Interior & seats
Filed Jun 1, 2026
The contact owns a 2016 Dodge Grand Caravan. The contact stated that the passenger's sliding door had failed to lock as intended, and the driver's side sliding door had failed to open as intended. The dealer was notified of the failure, but the vehicle was not diagnosed or repaired. The manufacturer was not contacted. The failure mileage was approximately 120,000.
- NHTSA ID
- 11741351
- Incident
- Jun 1, 2023
- Mileage
- 120,000 mi
Interior & seats
Filed Apr 1, 2026
The contact’s father owns a 2016 Dodge Grand Caravan. The contact stated that the rear sliding doors unexpectedly opened while the vehicle was parked and idling, or while driving at various speeds. The driver pulled over to the side of the road and manually closed the door. The contact researched online and became aware of an extended warranty for the failure; however, the VIN was not included. The vehicle was not taken to the dealer, and the vehicle was not diagnosed or repaired. The manufacturer was made aware of the failure and confirmed that the VIN was not under recall or an extended warranty. The manufacturer referred the contact to the NHTSA Hotline to report the failure. The failure mileage was approximately 54,000.
- NHTSA ID
- 11728442
- Incident
- Apr 1, 2023
- Mileage
- 54,000 mi
EngineInterior & seatsPowertrain (other)
Filed Mar 25, 2026
1) At D/S Stow and Go seat malfunctioned and was repaired by CarMax Service Center Jan 2023 - 2) Around 97,000 so - Engine started ticking on or about JUL/SEP 2023, enstate Lloyds Automotive in Spokane Valley replaced out engine due to manufacture defect in Oct 2023. 3) At 103,672mi - P/S stow and Go seat was repaired for same issues as D/S stow & Go Seat by Lloyds Automotive Oct 2023 when engine was replaced out. 4) Around 116,000mi the Transmission was flushed when I got the oil changed because I noticed jerking shifting at times, this was Aug 2024 there was no check engine or diag faults. 5) Around 132,720 Fell under CXLHX982 / CXLHX981 Actuator Sliding Door D/S & P both repaired and Transmissioned serviced again because my van started stalling out at stops and the jerking happened again no check engine or diag faults 6) Around 138,000 - D/S Sliding door hatch pin repair by Coos Bay Area Dodge. On 24Mar2026 - Around 142,000mi my transmission overheat warning came on and my van would not go any faster than 45 to 50mi, the RPMs went from 1.5 to 4 to 5 then 7 and back down, I immediately pulled over and sat for about 40min turned my van back on there was no overheat warning so I drove around 50mi per hour in the emergency lane to the next exit which was Hood River, Or and trailer towed my van from Hood River, Or to AAMCO, North Spokane Wa for transmission service. - I believe my vehicle 2016 Dodge Grand Caravan R/T model - transmission was built with some underlying transmission serious safety defects and should have been recalled and a part of Part 573 Safety Recall Report 16V-461. My vehicle malfunctioning could have caused an accident if not for my quick thinking that day and keeping my vehicle maintained at a high standard. I do keep all my service records.
- NHTSA ID
- 11727028
- Incident
- Mar 24, 2026
Interior & seats
Filed Dec 30, 2025
The contact owns a 2016 Dodge Grand Caravan. The contact stated that while the vehicle was parked, the contact noticed that there was an unusually loud buzzing sound coming from the front driver's side door. The contact stated that the failure occurred while the key was in the ignition switch. In addition, the rear door failed to latch and to close securely. The contact stated that the failure initially occurred intermittently but had become persistent. The dealer was made aware of the failure; however, the contact was informed that there were no open recalls associated with the VIN. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The contact referenced an unknown recall. The manufacturer was not made aware of the failure. The failure mileage was approximately 74,000.
- NHTSA ID
- 11707767
- Incident
- Nov 30, 2025
- Mileage
- 74,000 mi
Interior & seats
Filed Jul 25, 2025
I was waiting at a red light when I was violently hit in the back of my head which caused some disorinetation and pain. I asked my wife to tell me what happened ( I thought we might have been rear-ended) but she said my headrest had broken open. While after a web search I now understand what the purpose of this "safety feature" is, had I been driving on a highway or going through a curve, the result might have been different.
- NHTSA ID
- 11676102
- Incident
- Jul 25, 2025
Interior & seats
Filed Jun 26, 2025
The headrest on the driver seat ejected while I was driving. The headrest is unable to go back into the correct position. It looks as if a plastic piece has failed inside the headrest. No accident occurred when the headrest failed. The drivers neck was hurt during the incident. Driver almost lost control of the vehicle
- NHTSA ID
- 11669411
- Incident
- Jun 26, 2025
Interior & seats
Filed Oct 12, 2024
Closed the driver side sliding door and the headrest on the driver seat exploded open. Car was not in motion. Door shut and head rest adjacent to it just popped apart and hit the head of the person in the driver seat.
- NHTSA ID
- 11619461
- Incident
- Oct 12, 2024
Interior & seats
Filed Apr 13, 2024
the head rest deployed without being in an accident and now cannot be re-assembled. This is a recurrent problem with Chrysler vehicles including the Grand Caravan.
- NHTSA ID
- 11582783
- Incident
- Apr 13, 2024
Interior & seats
Filed Jul 25, 2023
Passenger side active headrest deployed on its own while driving. No accident or collision involved. 16 year old son was seated in the passenger side seat when the headrest deployed on its own. Luckily no injury to my son. Want to report this issue to prevent any possible injuries that may arise due to malfunction deployment of active headrest. Researched online and discovered that this is an ongoing issue with Chrysler/Dodge vehicles and is not covered under warranty. Will have to search for a used replacement part since dealership cost for repair is too costly.
- NHTSA ID
- 11534310
- Incident
- Jul 22, 2023
Interior & seats
Filed Jul 7, 2023
The driver's seat headrest active head restraint randomly deployed as I was exiting the vehicle. The plastic retainers had broke off allowing the headrest to deploy and it cannot be reset. If this had occurred while driving, the headrest could have struck me in the back of the head possibly causing injury or could have lead to an accident.
- NHTSA ID
- 11530852
- Incident
- Jul 5, 2023
Interior & seats
Filed Apr 28, 2023
The passenger side head rest "deployed" while sitting still at the gas pump. My great niece was reclined and when she raised the seat back up, it popped out and hit her in the back of the head.
- NHTSA ID
- 11519539
- Incident
- Apr 28, 2023
Interior & seats
Filed Nov 16, 2022
A few months ago, the passenger seat headrest safety system deployed with no warning while the vehicle was parked/off. No warning systems were triggered on the vehicle. I can see that inside the headrest, the light plastic frame which retains the metal pin has cracked, probably just from the pressure of the springs over time. As a result the metal pin broke free from the plastic frame. The actual release triggers have not released. I haven't had anyone look at it, but many reports online say dealers are charging $600 to fix it. The springs are very powerful—I'm glad no one was in the seat when it happened.
- NHTSA ID
- 11493871
- Incident
- May 1, 2022
Interior & seats
Filed Sep 16, 2022
The headrest on my vehicle on the driver seat deployed while in use for no apparent reason.
- NHTSA ID
- 11484772
- Incident
- Sep 14, 2022
Interior & seats
Filed Sep 6, 2022
The contact owns a 2016 Dodge Grand Caravan. The contact stated that the driver’s side sliding door was locked and could not be opened from inside or outside the vehicle. Additionally, the door would not open while using the key fob. The cause of the failure was not determined. The manufacturer and local dealer was not contacted regarding the failure. The failure mileage was 128,359.
- NHTSA ID
- 11483055
- Incident
- Sep 5, 2022
- Mileage
- 128,359 mi
Interior & seats
Filed Oct 18, 2021
The contact owns a 2016 Dodge Grand Caravan. The contact stated that the driver’s side sliding door had become defective and could not be opened from either the inside or the outside. Neither the dealer nor the manufacturer was notified of the failure. The vehicle had yet to be repaired. The failure mileage was approximately 110,000.
- NHTSA ID
- 11437220
- Incident
- Jul 1, 2021
- Mileage
- 110,000 mi
AirbagsInterior & seats
Filed Oct 9, 2021
The driver's side headrest has deployed on it's own while parked in a driveway and turned off. After inspection, the plastic brackets that retain the metal pin that is supposed to secure the headrest broke apart and released the headrest into a deployed position. This is a design flaw that should be recalled before someone becomes injured. The headrest is under a spring loaded force that the plastic was not engineered to restrain.
- NHTSA ID
- 11436181
- Incident
- Oct 9, 2021
Interior & seats
Filed Aug 3, 2021
Both sliding doors will not unlock. Passengers have to exit either through the front passenger door, through the rear hatch or climb out the sliding door windows. This is a safety issue in an emergency. The driver side sliding door had the problem several months ago. The passenger side sliding door developed the problem today.
- NHTSA ID
- 11427544
- Incident
- Aug 3, 2021
Body & structureInterior & seats
Filed Jul 14, 2021
The contact owns a 2016 Dodge Grand Caravan. The contact stated that the rear passenger’s side door failed to open. The contact took the vehicle to the local dealer, where it was diagnosed with needing the rear passenger’s side door actuator to be replaced. The vehicle was repaired. The contact stated a year later, the rear driver’s side door failed to open. The contact took the vehicle back to the local dealer, where it was diagnosed with needing the rear driver’s side door actuator to be replaced. The vehicle was repaired. The manufacturer had not been informed of the failure. The failure mileage was approximately 30,000.
- NHTSA ID
- 11424749
- Incident
- Jan 1, 2017
- Mileage
- 30,000 mi
Interior & seats
Filed Jun 21, 2021
The contact owns a 2016 Dodge Grand Caravan. The contact stated upon exiting the vehicle, the driver-side rear sliding door would not unlock and open. The contact stated no warning light was illuminated. The vehicle was taken to an independent mechanic where it was diagnosed with the door actuator needing to be replaced. The vehicle was not repaired. The manufacturer had not been informed of the failure. The failure mileage was approximately 56,000.
- NHTSA ID
- 11421634
- Incident
- Feb 15, 2021
- Mileage
- 56,000 mi
Interior & seats
Filed Apr 10, 2021
THE FRONT PASSENGER HEADREST POPPED FORWARD WHILE ADJUSTING THE SEAT TO LOAD EQUIPMENT IN THE REAR FLOORBOARD COMPARTMENT. THE PLASTIC ASSEMBLY THAT HOLDS THE METAL PIN WHICH IS USED TO KEEP THE HEADREST IN ITS NORMAL POSITION HAD BROKEN. THIS IS APPARENTLY A COMMON PROBLEM ACCORDING TO INTERNET RESEARCH BUT NO RECALL HAS BEEN ISSUED. THE VEHICLE WAS STATIONARY IN MY DRIVEWAY AND NOT RUNNING.
- NHTSA ID
- 11407439
- Incident
- May 18, 2019
- Mileage
- 79,000 mi
Interior & seats
Filed Feb 23, 2021
TL* THE CONTACT OWNS A 2016 DODGE GRAND CARAVAN. THE CONTACT STATED THAT THE DRIVER'S SIDE SLIDING DOOR FAILED TO UNLATCH OR OPEN AS DESIGNED. THE CONTACT HAD NOT TAKEN THE VEHICLE TO A DEALER NOR AN INDEPENDENT MECHANIC TO BE DIAGNOSED NOR REPAIRED. NEITHER THE MANUFACTURER NOR THE DEALER WERE MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 120,000.*DT*JB THE CONSUMER STATED THE VEHICLE WAS TAKEN TO THE DEALER AND IT WAS DETERMINED THE ACTUATOR FAILED. THE MANUFACTURER WAS CONTACTED AND DID NOT OFFER ANY ASSISTANCE DUE TO THE VEHICLE BEING OUT OF WARRANTY. THE DEALER EXPLAINED THE PASSENGER SIDE WOULD FAIL SOON. *JS
- NHTSA ID
- 11397501
- Incident
- Feb 2, 2021
- Mileage
- 120,000 mi
ElectricalInterior & seats
Filed Feb 18, 2021
MY TRANSMISSION IS GOING OUT CAR GOES INTO 5 RPM WHEN ONLY GOING 30-40 MPH BACK SEATS DON'T UNLOCK TO FOLD AWAY BACK SLIDING DOORS DON'T LOCK EVEN AFTER ALARM IS ACTIVATED AND HAVE HAD A BRAKE IN
- NHTSA ID
- 11396730
- Incident
- Feb 1, 2019
AirbagsInterior & seats
Filed Dec 13, 2020
THE DRIVER'S SIDE HEADREST HAS DEPLOYED ON IT'S OWN WHILE PARKED IN A DRIVEWAY AND TURNED OFF. AFTER INSPECTION, THE PLASTIC BRACKETS THAT RETAIN THE METAL PIN THAT IS SUPPOSED TO SECURE THE HEADREST BROKE APART AND RELEASED THE HEADREST INTO A DEPLOYED POSITION. THIS IS A DESIGN FLAW THAT SHOULD BE RECALLED BEFORE SOMEONE BECOMES INJURED. THE HEADREST IS UNDER A SPRING LOADED FORCE THAT THE PLASTIC WAS NOT ENGINEERED TO RESTRAIN.
- NHTSA ID
- 11383209
- Incident
- Dec 12, 2020
- Mileage
- 52,000 mi
Fuel systemInterior & seatsPowertrain (other)
Filed Sep 1, 2020
IF THE TRANSMISSION LOSES HYDRAULIC PRESSURE, THE VEHICLE MAY LOSE MOTIVE POWER, INCREASING THE RISK OF A CRASH.
- NHTSA ID
- 11352677
- Incident
- Aug 26, 2020
- Mileage
- 10,000 mi
Body & structureInterior & seats
Filed Jul 2, 2020
TL* THE CONTACT OWNS A 2016 DODGE GRAND CARAVAN. THE CONTACT STATED THAT THE DRIVER'S SIDE SLIDING DOOR CEASED IN THE CLOSED/LOCKED POSITION. THE CONTACT WAS UNABLE TO UNLOCK THE DOOR. THE VEHICLE WAS TAKEN TO REEDMAN TOLL CHRYSLER DODGE JEEP RAM OF SPRINGFIELD (770 BALTIMORE PIKE, SPRINGFIELD, PA 19064, (610) 544-5300) HOWEVER, WAS NOT DIAGNOSED NOR REPAIRED. THE MANUFACTURER WAS NOT CONTACTED. THE FAILURE MILEAGE WAS 70,000.
- NHTSA ID
- 11337130
- Incident
- Nov 1, 2019
- Mileage
- 70,000 mi
Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.