2009 Dodge Journey

The Office of Defects Investigation (ODI) opened PE23-008 on May 1, 2023 to investigate an incident involving a 2009 Dodge Journey alleging occupant entrapment during a vehicle fire that resulted in a fatality. During the investigation, ODI collected information from the manufacturer and involved parties to confirm or refute the defect allegation. ODI has determined that additional reports of vehicle entrapment exist for other model year Dodge Journey vehicles. ODI continues to explore the cause of the thermal event and its potential effect on the actuation of the door locks. ODI also continues to explore other potential causes for door lock malfunction. ODI has determined that an upgrade to an Engineering Analysis (EA) is necessary to continue the review of the investigative material and to assess the risk to motor vehicle safety . To review the ODI report cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.

The Office of Defects Investigation (ODI) opened PE23008 on May 1, 2023 to investigate an incident involving a 2009 Dodge Journey alleging occupant entrapment during a vehicle fire that resulted in a fatality.  During this investigation, ODI collected information and evidence related to the defect allegation and incident, from the manufacturer and involved parties. The information and evidence collected in this initial phase was insufficient to make a defect determination. ODI has upgraded this investigation to an Engineering Analysis (EA24003) to develop a more comprehensive understanding of whether a potential safety defect exists. To review the ODI report cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.

In a letter dated August 21, 2014, the Center for Auto Safety (CAS) petitioned the National Highway Traffic Safety Administration (NHTSA) to initiate a defect investigation of alleged failures associated with the Totally Integrated Power Module (TIPM) installed in Chrysler SUV?s, trucks, and vans beginning in the 2007 model year. The petitioner alleges that TIPM defects may result in engine stall, airbag non-deployment, failure of fuel pump shutoff resulting in unintended acceleration, fire, and other symptoms. On September 25, 2014, the Office of Defects Investigation (ODI) opened DP14-004 to evaluate the petition for a grant or deny decision. ODI analyzed complaint data provided by CAS as well as complaints submitted to ODI from consumers. In total, there were 296 complaints submitted by the petitioner in the original petition and five supplements, including 271 complaints related to the subject vehicles equipped with TIPM-7. Approximately 3 percent of CAS complaints are related to vehicles equipped with TIPM-6 and ODI?s review of these complaints did not identify any safety defect trends. ODI conducted a detailed review of complaints narratives submitted by CAS and consumers including careful analysis of vehicle repair histories, warranty claims obtained from the manufacturer and any available Customer Assistance Inquiry reports (CAIR). Analysis of the field data indicated that MY2011-2013 Jeep Grand Cherokee and Dodge Durango vehicles exhibited significantly higher complaint rates related to fuel pump relay (FPR) failures than other subject vehicles. In a September 3, 2014 letter to NHTSA, Chrysler submitted a Defect Information Report (DIR) identifying a defect in the FPR within the TIPM-7 which can result in a no start or stall condition in approximately 188,723 model year (MY) 2011 Jeep Grand Cherokee (WK) and Dodge Durango (WD) vehicles manufactured from January 5, 2010 through July 20, 2011 (14V-530).In a February 24, 2015 letter, Chrysler submitted a second DIR expanding the scope of the FPR defect condition to include an additional 338,216 MY 2012 through 2013 Jeep Grand Cherokee vehicles manufactured from September 17, 2010 through August 19, 2013 and MY 2012 through 2013 Dodge Durango vehicles manufactured from January 18, 2011 through August 19, 2013 (15V-115).ODI analysis of the CAS allegations of TIPM defects resulting in stall while driving, airbag non-deployment, unintended acceleration, fire and other faults identified a single defect condition related to 1 of over 60 different circuits in the TIPM assembly. The most common effect of this defect condition, related to the fuel pump relay, was a no-start concern, but it could also result in stall while driving (76 complaints). No valid evidence was presented in support of claims related to airbag non-deployment, unintended acceleration or fire resulting from TIPM faults and these claims were found to be wholly without merit based on review of the field data and design of the relevant systems and components.Except insofar as the petitioner's contentions relate to the defect condition addressed by the Chrysler recalls, the factual bases of the petitioner's contentions that any further investigation is necessary are unsupported. In our view, additional investigation is unlikely to result in a finding that a defect related to motor vehicle safety exists or a NHTSA order for the notification and remedy of a safety-related defect as alleged by the petitioner at the conclusion of the requested investigation. Therefore, in view of the need to allocate and prioritize NHTSA's limited resources to best accomplish the agency's safety mission, the petition is den

In March 2011 Chrysler submitted a defect information report for NHTSA Recall No. 11V139 declaring a defect condition that could cause the ignition key to inadvertently move from the RUN to the ACC position on model year (MY) 2010 Dodge Journey, Grand Caravan, and Chrysler Town and Country.The report identified engine stalling as the defect consequence and cited customer complaints and warranty claims, as well as two rear-end collisions, as leading to the recall action.Chrysler determined that a defective WIN module, which is effectively the equivalent of the ignition switch, was the cause of the inadvertent key rotation, and that a new design WIN module would be installed as a remedy.In Spring 2014 ODI conducted outreach to major light vehicle manufacturers regarding ignition key position and its effect on air bag system availability.The outreach was conducted in connection with NHTSA Recall No. 14V047, a recent recall involving inadvertent ignition key rotation and subsequent air bag disablement in certain GM products.During discussions held in April 2014, Chrysler advised ODI that Chrysler air bag systems of this vintage, including the subject vehicles, revert to energy reserve when the ignition key moves to the ACC or OFF position, and that under energy reserve the air bags would only be available for a short period, approximately two tenths of a second (ODI notes this consequence was not identified in the 11V139 recall report).A review of the ODI consumer database conducted after the April 2014 discussions identified complaints alleging that MY 2008-2009 vehicles may have a similar defect as the MY 2010 vehicles, and that some MY 2010 consumers reported experiencing ignition key position concerns after the 11V139 recall remedy was applied.Accordingly this investigation was opened.In response to ODI?s information request letter, Chrysler reported that MY 2008-2009 subject vehicles used the same design WIN module as the recalled vehicles, and also identified 66 consumer reports and one non-injury crash incident potentially related to inadvertent ignition key rotation.Chrysler?s review of the MY 2010 remedy used in 11V139, which involved installation of a Trim Ring as opposed to replacement of the WIN module, showed the remedy did not adequately address ignition key position concerns, and in some use-cases could cause other systems to operate improperly (radio, instrument panel lighting, HVAC fan motor, etc.).Chrysler subsequently filed multiple defect information reports to 1) add the MY 2008-2009 Dodge Grand Caravan and Chrysler Town and Country, and the MY 2009 Dodge Journey to the original recall scope, and 2) stating that the complete WIN module would be replaced with a new design component in all recalled vehicles (including those that had the Trim Ring installed during 11V139).Chrysler?s report also advises of constrained remedy parts availability, see NHTSA Recall No. 14V373 for further details.Accordingly, the investigation is closed based on the recall action Chrysler is undertaking.The ODI reports cited above can be reviewed online at http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers: 10584873, 10583399, 10573295, 10566365, 10546805, 10513060, 10509284, 10503121, 10496599, 10475027, 10456099, 10450629, 10443680, 10422766, 10410447, 10409269, 10402947, 10402751, 10402660, 10396943, 10394957, 10356632, 10315972

The contact owns a 2009 Dodge Journey. The contact stated that the vehicle failed to start. The vehicle was towed to the dealer, where it was diagnosed, and it was determined that the Totally Integrated Power Module (TIPM) had failed and needed to be replaced. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 160,000.

NHTSA ID

11731127

Incident

Dec 14, 2025

Mileage

160,000 mi

Power steering hose ruptured after a few days of snow and ice. I went to drive to the store but was unable to turn out of the driveway due to no power steering. I done some research to where I found out there was a recall for this same issue but evidently my VIN # isn't included in this recall as while as many others I have read about online. I think this needs to be looked into.

NHTSA ID

11715663

Incident

Jan 31, 2026

The contact owns a 2009 Dodge Journey. The contact stated that while reversing in cold weather, the vehicle lost power steering functionality. Upon inspection, the contact became aware that the power steering hose was leaking fluid and had detached. There were no warning lights illuminated. The contact related the failure to NHTSA Campaign Number: 16V273000 (Steering). The vehicle was towed to the local dealer, and the contact was informed that the VIN was not associated with the recall. The vehicle was not diagnosed or repaired. The manufacturer was contacted and confirmed that the VIN was not included in the recall. The approximate failure mileage was 77,000.

NHTSA ID

11714906

Incident

Jan 30, 2026

Mileage

77,000 mi

Car doesnt start all the time when it does it ends up shutting off. it shuts off while driving, also cuts in and out while driving.

NHTSA ID

11699592

Incident

Nov 13, 2025

The steering locked up could not turn or straighten car out. All electrical things lights air conditioning gas light just went haywire and is still not working. The shifting system I guess is what u call it started slipping out of gear like going into natural or first gear and nothing else. Several cars had to serve to keep from getting hit at 70+ miles an hour and I had no control other than to hit the break on the freeway and pray. Accordingly to the Bob site there's so many problems I know the ones I've had I just didn't know I could let any one know that mattered. I've reported it today. The first time it slipped out of gear I thought maybe it was something I may have done as far as the electric it was Little things like AC works as it pleases airbags light up tire pressure ECT the gas light no longer moves stays on E unknown to exact dates

NHTSA ID

11694469

Incident

Oct 19, 2025

I have issues starting it. New starter, new battery and it just dies. Luckily I was parked when it died. I have children, if it dies while driving I could be in a serious car crash with my children in the car. I do not want to die, I love my car but I do not want to be put in danger because of this type of issue. I also do not want to be stranded somewhere. PLEASE HELP.

NHTSA ID

11682538

Incident

Aug 23, 2025

The Carbondale Fire Department was dispatched to a vehicle fire In the parking lot behind the above-listed address. Fire personnel arrived and found a 2009 Dodge Journey with an engine compartment fire. Fire personnel used tank water and a pre-connected 1 3/4 In. hose line to extinguish the fire. There were no exposures or damage to other property. Upon completing the extinguishment, an origin and cause investigation was conducted, which Included, but was not limited to, scene examination, documentation, and interviews. The owner of the vehicle stated the following: He purchased the vehicle new. He has liability Insurance only through Allstate. This Is not his primary vehicle. He does his own service. No known electrical Issues, and there were no warning lights on the vehicle before the fire. The vehicle has approximately 160,000 miles on It The only known issue with the vehicle was a power steering issue. Before the discovery of the fire, the owner had pulled into a gas station across town to add power steering fluid. Upon leaving the gas station, the owner reported that within a few blocks, he began seeing black smoke coming from under the hood, and there was an odd odor to the smoke. (Review of Oty Video cameras confirmed this account) He pulled in the parking lot at the above-listed address and accessed the engine compartment to find fire on the power steering reservoir, the plastic engine cover, and the cooling fan. He attempted to extinguish the fire with a soda he had and then attempted to retrieve water from a nearby building. Upon returning with water, the fire was too large to extinguish. The scene examination revealed an engine compartment fire that had transitioned Into the passenger compartment during the failure of the front windshield. The hood of the vehicle had completely melted away during the fire. Fire patterns in the engine compartment were consistent with the owners account of the fire. The fire was determined to be unintentional, with the

NHTSA ID

11666519

Incident

Jun 9, 2025

On [XXX] around [XXX] I was driving 25mph in Alameda CA, and about two minutes into the ride, the airbag warning light came on. My fiance was in the passenger seat and our dog was in the back. About 15 minutes into the drive, my side airbags deployed without any collision or even bump in the road. I carefully and swiftly turned onto a side street and pulled over. My fiancé and I got out of the car, and as we took our dog out of the back seat, the primary airbags (steering wheel and passenger seat) deployed, and shattered the windshield. The dashboard was cracked as a result of the primary bags deploying. My fiancé's arm was bruised from the side airbag deploying (photo evidence taken). We called the police and they came to document the incident and confirmed that there was no collision (police report included). Vehicle was then towed home and is available for inspection. We've tried calling the dealership that the car was purchased, but it seems to be out of business. 1. Component that malfunctioned: Airbag and Indicator lights; available for inspection 2. Safety: This incident easily could've led us to crash teh vehicle and harm ourselves and others in the process, and much more seriously hurt us if we did not evacuate the car. My fiancé's arm is bruised. 3. No so far, we cannot get a hold of a dealer since ours was closed - but welcome an investigation 4. Yes, by police. The police report #[XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ID

11641187

Incident

Jan 21, 2025

LAMP - DOME

LAMP - DOME

LAMP - DOME

ACTUATOR - A/C AND HEATER

ACTUATOR - A/C AND HEATER

Connector kit Before ordering this connector repair kit 68018957A$, check it in the Mopar Connector Repair Kit Website to confirm part number and applicability. There is an error with the wiring diagrams in Service Library that is causing the incorrect repair kit part number to populate. Please use the Mopar Connector Repair Kit Website until this issue is resolved.