RoadVitals

2011 E-One Quest

Recalls, owner-reported complaints, investigations and safety data

Owner complaintsComplaints are reports submitted to NHTSA by owners and drivers. NHTSA does not verify most reports before publishing them, and a complaint does not establish that a defect exists. Volume is influenced by how many of a vehicle were sold, how long it has been on the road, and how much attention an issue has received.
0
Safety recallsA safety recall is issued when a manufacturer or NHTSA determines that a vehicle has a safety-related defect or does not comply with a federal motor vehicle safety standard. Recall repairs are free. Whether a specific vehicle is covered depends on its VIN — a recall listed for a model year does not necessarily apply to every vehicle of that year.
2
Latest Dec 1, 2011
InvestigationsNHTSA opens an investigation to examine whether a safety defect may exist. An open investigation is not a determination that a defect exists, and many investigations close without a recall. Investigations can, however, lead to one.
0
Crash or fire reportedComplaints whose submitter recorded that a crash or a fire occurred. These are the reporter's own answers on the NHTSA form, not verified findings.
0

Overview

Our database contains no NHTSA owner-reported complaints for the 2011 E-One Quest. 2 safety recalls have been issued covering this model year; and 3 manufacturer communications are on file.

Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.

Safety recalls

2 campaigns cover this model year

Recalls apply to specific vehicles, not to every vehicle of a model year. Check your VIN with NHTSA or your manufacturer's dealer to confirm whether a recall affects your vehicle.

Check a VIN on NHTSA.gov
11V564000

ELECTRONIC STABILITY CONTROL (ESC)

Dec 1, 2011
220 units potentially affected
The defect: E-ONE IS RECALLING CERTAIN MODEL YEAR 2008 THROUGH 2011 CYCLONE II, TYPHOON, AND QUEST VEHICLES MANUFACTURED FROM MAY 1, 2008, THROUGH NOVEMBER 28, 2011, AND EQUIPPED WITH MERITOR WABCO ELECTRONIC STABILITY CONTROL (ESC) MODULES. UNDER CERTAIN ROAD AND DRIVING CONDITIONS, VEHICLE BODY ROLL AND ROAD INCLINATION CHARACTERISTICS MAY ADVERSELY AFFECT THE SLIP ANGLE CALCULATION OF THE ELECTRONIC STABILITY CONTROL (ESC) SYSTEM. THIS MIGHT CAUSE THE ESC TO PERCEIVE AN OVER STEERING SITUATION AND THEREFORE APPLY THE OUTER WHEEL BRAKE ON THE FRONT AXLE UNTIL THE VEHICLE IS PERCEIVED TO BE STABLE.
The risk: IF THE DRIVER IS SLOW TO REACT DURING THIS ESC INTERVENTION, THE VEHICLE MAY DEVIATE FROM THE INTENDED LINE OF TRAVEL, INCREASING THE RISK OF A CRASH.
The remedy: E-ONE WILL NOTIFY OWNERS AND IS WORKING WITH MERITOR WABCO TO REPLACE THE CONTROL MODULE FREE OF CHARGE. THE SAFETY RECALL BEGAN ON DECEMBER 16, 2011. OWNERS MAY CONTACT E-ONE CUSTOMER SERVICE AT 1-800-627-5050 OR MERITOR ON TRACK CUSTOMER SERVICE AT 1-866-668-7221.
E-ONE, INC.View on NHTSA.gov
11V443000

ENGINE AND ENGINE COOLING

Aug 17, 2011
33 units potentially affected
The defect: E-ONE IS RECALLING CERTAIN MODEL YEAR 2010 AND 2011 TYPHOON AND CYCLONE II AND MODEL YEAR 2011 TRADITION AND QUEST FIRE FIGHTING CHASSIS MANUFACTURED FROM NOVEMBER 24, 2010, THROUGH JULY 13, 2011, EQUIPPED WITH A CUMMINS ISB, ISL, ISC, or ISX DIESEL ENGINE. THE V-BAND CLAMP ASSEMBLY, PART NUMBERS Q187684, Q187685, AND Q187686, USED TO CONNECT THE INLET AND OUTLET CONE SECTIONS TO THE DIESEL OXIDATION CATALYST (DOC)/DIESEL PARTICULATE FILTER (DPF) INCLUDE A T-BOLT WHICH CAN FRACTURE AND FAIL WHEN SUBJECTED TO STRESS OR LOAD. A FRACTURE OR FAILURE OF THE T-BOLT MAY CAUSE THE CLAMP TO LOOSEN AND THE INLET OR OUTLET SECTIONS ATTACHED TO THE DOC/DPF HOUSING TO DISCONNECT.
The risk: THIS COULD RESULT IN ASPHYXIATION OR CARBON MONOXIDE POISONING. THE HEAT BUILD UP FROM THE EXHAUST CAN ALSO RESULT IN A FIRE. IF BOTH CLAMPS FAIL, THERE IS A RISK IN SOME APPLICATIONS THAT THE DOC/DPF HOUSING MAY DETACH COMPLETELY, CREATING A ROAD HAZARD.
The remedy: E-ONE IS WORKING WITH CUMMINS TO IDENTIFY AND NOTIFY OWNERS OF THE RECALL CAMPAIGN. REPAIRS WILL BE PERFORMED BY AUTHORIZED CUMMINS DEALERS FREE OF CHARGE. THE SAFETY RECALL BEGAN ON OCTOBER 10, 2011. OWNERS MAY CONTACT CUMMINS AT 1-812-377-5000 OR E-ONE AT 1-352-861-3223.
E-ONE, INC.Manufacturer number 4ENView on NHTSA.gov

Recent owner complaints

Reports submitted to NHTSA, shown in the owner's own words

No owner complaints recorded for this model year

Either none have been filed with NHTSA, or this vehicle is too new for reports to have accumulated.

Manufacturer communications

A bulletin sent by a manufacturer to its dealers. Not a recall, and repairs are not necessarily free.

MIC-EONE030320

EQUIPMENT

E-ONE, Inc. TSB report for the month of February 2020.

2018-1047

ELECTRICAL SYSTEM:WIRING

During a routine truck delivery inspection a malfunction of the air flow restriction indicator light was detected. Our investigation determined that the malfunction was introduced in 2007 with the launch of the new ISSPRO gauge cluster. The new dash gauge cluster changed the requirement for air flow sensor signal from active high to active low. This malfunction went unnoticed until now due to our published air filter routine maintenance requirements and the air filter?s longevity. Revised units affected by year.

TSB2018-1043

ELECTRICAL SYSTEM; EXTERIOR LIGHTING:TURN SIGNAL

During a routine truck delivery inspection a malfunction of the air flow restriction indicator light was detected. Our investigation determined that the malfunction was introduced in 2010 with the launch of the new ISSPRO gauge cluster. The new dash gauge cluster changed the requirement for air flow sensor signal from active high to active low. This malfunction went unnoticed until now due to our published air filter routine maintenance requirements and the air filter?s longevity.

Manufacturers file copies of the bulletins they send to dealers with NHTSA. These often describe diagnostic or repair procedures for a known condition. They are not recalls: repairs described in a bulletin are usually only free if the vehicle is still under warranty or the manufacturer has extended coverage.

Compare model years

Complaint and recall counts across every year of this model

E-One Quest by model year
YearComplaintsRecallsInvestigationsIssue Index
2017030—
2016050—
2015050—
2014060—
2013040—
2011Viewing020—
2010010—
2009020—
2008020—

Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers. Older model years have had longer for reports to accumulate.