1993 Eagle Vision

ON SEPTEMBER 5, 2004, MR. ROBERT GALENTY OF ISELIN, NJ, PETITIONED THE AGENCY TO CONDUCT DEFECT INVESTIGATIONS OF CERTAIN MODEL YEAR (MY) 1993-1997 VEHICLES PRODUCED BY DAIMLERCHRYSLER CORPORATION.HIS PETITION IDENTIFIED THREE ISSUES OF CONCERN: 1) FUEL LEAKING FROM THE FUEL INJECTOR RAILS; 2) BRAKE FLUID CONTAMINATION RESULTING IN BRAKE FAILURE; AND 3) SUSCEPTIBILITY OF THE VEHICLE FRAME TO DAMAGE WHILE THE VEHICLE IS BEING TOWED.MR. GALANTY ALLEGED THAT HIS 1996 DODGE INTREPID HAD EACH OF THESE THREE PROBLEMS.CONCERNING FUEL RAIL LEAKAGE, DAIMLERCHRYSLER COMMENCED A RECALL (98V-184) OF APPROXIMATELY 722,600 VEHICLES TO ADDRESS ENGINE FUEL RAIL LEAKS THAT COULD LEAD TO A FIRE, INCLUDING THOSE VEHICLES CITED IN THE PETITION AND THE PETITIONER'S 1996 DODGE INTREPID.ON OCTOBER 7, 1998, NHTSA OPENED A RECALL QUERY INVESTIGATION (RQ98-018) TO EVALUATE THE ADEQUACY OF THE RECALL REMEDY.THAT INVESTIGATION WAS CLOSED ON JULY 8, 2002 WITHOUT REQUIRING FURTHER ACTION BY DAIMLERCHRYSLER.VERY RECENTLY, ON JUNE 9, 2004, NHTSA DENIED A PETITION (RP04-001) TO REOPEN RQ98-018 AFTER FINDING THAT THERE WAS NO NEW INFORMATION THAT WOULD INDICATE ANY BASIS FOR REOPENING IT.THIS IS STILL THE CURRENT POSITION OF NHTSA ON THIS ISSUE.CONCERNING BRAKE FLUID CONTAMINATION AND FRAME ALIGNMENT, A REVIEW OF NHTSA'S DATABASE SHOWS NO OTHER COMPLAINTS ON EITHER ONE OF THESE ISSUES ON THE VEHICLES CITED IN THE PETITION.

THE MANUFACTURER REPORTS ABOVE ARE BASED ON DAIMLERCHRYSLER?S (DC) ANALYSIS OF MODEL YEAR (MY) 1998 (POPULATION = 356,384) AND 1999 (POPULATION = 486,948) JA, JX AND LH FAMILY SUBJECT VEHICLE DATA (EARLIER MYS EXCLUDED).THE POPULATION NUMBER INCLUDES ALL MYS.THE PRECISE NUMBER OF DUPLICATES BETWEEN ODI AND DC REPORTS CANNOT BE DETERMINED DUE TO MISSING OR INCOMPLETE INFORMATION.THE FATALITY INCIDENT INVOLVED AN ELDERLY PERSON WHO ATTEMPTED TO STOP A ROLL AWAY VEHICLE AND RECEIVED FATAL INJURIES.ODI ALSO GATHERED INFORMATION ON MY 1997-99 PROWLER VEHICLES IN THIS INVESTIGATION. THE PROWLER VEHICLES WERE MANUFACTURED WITH A DIFFERENT DESIGN SHIFTER MECHANISM (THE SHIFT LEVER IS SHORTER).THERE ARE NO COMPLAINTS OF PROWLER INTERLOCK FAILURE IN ODI?S DATABASE, AND DC HAS RECEIVED NO REPORTS EITHER.THE PROWLER IS EXCLUDED FROM THE RECALL SCOPE.THE INVESTIGATION INVOLVED A CONDITION WHERE THE INTERLOCK SYSTEM COULD FAIL (OR BE MADE INOPERATIVE BY THE OPERATOR) DURING VEHICLE USE, POSSIBLY INADVERTENTLY.THE INTERLOCK SYSTEM IS REQUIRED UNDER FMVSS 114.WITH THE TRANSMISSION IN THE PARK POSITION AND THE IGNITION KEY OFF, THE COMBINED ACTION OF PRESSING THE SHIFT BUTTON AND PULLING THE SHIFT LEVER REARWARD MAY RESULT IN THE OPERATOR OVERCOMING THE INTERLOCK SYSTEM AND CAUSE THE MECHANICAL LINKAGE OF THE SYSTEM TO DISCONNECT.WHEN THIS OCCURS, THERE IS NO OVERT INDICATION TO AN OPERATOR THAT THE SYSTEM IS DEFEATED, AND AN INCREASED RISK OF VEHICLE ROLL-AWAY EXISTS.UNDER RECALL 04V021, DC WILL REPLACE DAMAGED SHIFT MECHANISMS, AND WILL INSTALL ON ALL VEHICLES A DEVICE WHICH INHIBITS THE OPERATOR?S ABILITY TO OVERCOME THE INTERLOCK AND DEFEAT THE SYSTEM.BEGINNING WITH MY 2000, DC INCORPORATED A BRAKE AND TRANSMISSION SHIFTER INTERLOCK (BTSI) SYSTEM INTO THE SUBJECT VEHICLES.INTRODUCTION OF BTSI INVOLVED DESIGN CHANGES TO THE SHIFT MECHANISM, ONE OF WHICH RESULTED IN REDUCED MECHANICAL ADVANTAGE (RMA) OF THE SHIFT BUTTON.THE RMA SHIFTER REQUIRES INCREASED FORCES TO OVERCOME THE INTERLOCK SYSTEM, MAKING THE SHIFTER LESS SUSCEPTIBLE TO DAMAGE.

MR. LARRY A. SACKEY SUBMITTED A PETITION TO THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) BY LETTER DATED APRIL 18, 2003, REQUESTING THAT NHTSAFURTHER INVESTIGATE THE DEFECTIVE COLLAPSIBLE STEERING SHAFT SYSTEM ON 1987-1995 VEHICLES MANUFACTURED BY THE DAIMLERCHRYSLER CORPORATION.IN PART BECAUSE OF 49 CFR ? 30120(G), NHTSA HAS DECIDED TO LIMIT THE SCOPE OF THE PETITION VEHICLES TO 1993-1995 MODELS, EXCLUDING THE 1993 JEEP GRAND CHEROKEE AND 1994-1995 DODGE RAM SERIES TRUCKS THAT WERE RECALLED (93V210 & 96V230) FOR STEERING COLUMN FAILURE.IF THE ANALYSIS OF THESE VEHICLES HAD IDENTIFIED A POTENTIAL PROBLEM, THE SCOPE COULD HAVE BEEN EXPANDED IN AN INVESTIGATION.A REVIEW OF ODI'S DATA BASE SHOWS NO RECENT COMPLAINTS AND A LACK OF A COMPLAINT TREND CONCERNING THE SUBJECT ISSUE ON THE SUBJECT VEHICLES AS A WHOLE OR BY INDIVIDUAL MODELS.THEREFORE, THE PETITION IS DENIED.FOR DETAILS, SEE FEDERAL REGISTER NOTICE VOLUME 68, NO. 130, JULY 8, 2003.

THE ENGINE CUTS OFF FOR A FEW SECONDS WHILE DRIVING AT HIGH SPEEDS (60 MPH). THE VEHICLE LURCHES AS A RESULT. LUCKILY, THE ENGINE STARTS UP AGAIN WITHOUT NEEDING TO CRANK AND THE VEHICLE PROCEEDS. ON ONE OCCASION, WHEN DRIVING AT SLOWER SPEED (25 MPH), THE VEHICLE STALLED. I LOST THE POWER STEERING, AND HAD TO STOP AND RESTART THE IGNITION USING THE KEY. *JB

NHTSA ID

10158686

Incident

Apr 2, 2006

DT: CONSUMER OWNS A 1993 EAGLE VISION. CONSUMER RECEIVED RECALL 99V215000 ABOUT A YEAR AGO CONCERNING LOWER CONTROL ARM. HE TOOK VEHICLE TO DEALER TO GET REPAIRS DONE . DEALER DID NOT DO ANYTHING TO VEHICLE AND CHARGED HIM $1020 FOR REPAIRS. HE TOOK VEHICLE TO ANOTHER DEALER ON AUGUST 3, 2005 BECAUSE IT STARTED SHAKING AGAIN. THEY DID NOT DO ANY REPAIRS. HE CONTACTED THE MANUFACTURER, AND WAS TOLD TO TAKE VEHICLE BACK TO DEALER. *AK *JB

NHTSA ID

10132143

Incident

Aug 3, 2005

CAMPAIGNS 98V184000 AND 98V130000 CONCERN FUEL LEAKAGE ON THE 1993 EAGLE VISION. ON MAY 13, 1999 THE O RINGS WERE REPLACED ON MY EAGLE BY THE PREVIOUS OWNER. ON MARCH 31, 2000, AFTER PURCHASING THE CAR I HAD TO TAKE MY CARE IN TO A GARAGE DUE TO THE STRONG SMELL OF GASOLINE. THE REPAIR SHOP FOUND A GAS LEAK. THEY REPLACED THE FUEL RAIL GASKET WHICH COST A TOTAL OF $214.02. I BELIEVE THE CAUSE OF THIS PROBLEM WAS CAUSED BY THE LEAKAGE OF THE O RINGS. THE REPLACEMENT OF THE FUEL RAIL GASKET SHOULD BE COVERED UNDER CAMPAIGN NO. 98V130000. I AM REQUESTING REIMBURSEMENT FOR THE $214.02. ALSO, I WOULD LIKE TO KNOW IF THERE IS ANYTHING ALSE I SHOULD DO TO MAKE THE CAR SAFER SUCH AS HAVING THE ENGINE FUEL RAIL REPLACED, WHICH IT APPEARS WASN'T DONE WHEN THE O RINGS WERE REPLACED BY THE PREVIOUS OWNER.

NHTSA ID

10121668

Incident

Mar 31, 2000

Mileage

65,785 mi

THE DRIVER'S SIDE FRONT SEAT BACK WOULDN'T STAY IN THE UPRIGHT POSITION. IT KEPT FALLING BACK DOWN. PLEASE PROVIDE ANY FURTHER INFORMATION. *PH *TC

NHTSA ID

10032419

Incident

Mar 1, 2005

Mileage

119,000 mi

THE CONSUMER HAD AN ON GOING CONCERN THAT EVERY YEAR WHEN ROTATING THE FRONT TIRES, A BROKEN STUD HAS TO BE REPLACED. DEALER WAS CONTACTED. *JB ...NOT JUST WHEN ROTATIN GTIRES. NEARLY EVERY TIME THAT FRON TTIRES ARE REMOVED, A STUD BREAKS OFF. I M SURE TO INFORM THE SERVIC EPROVIDER NOT TO USE AN AIR WRENCH AND TO HAND TORQUE THE LUG NUTS. *AK

NHTSA ID

10096866

Incident

Jun 12, 1996

Mileage

30,000 mi

AMENDMENT TO NHTSA ODI COMPLAINT NUMBER 10066149. FUEL RAIL/INJECTION SYSTEM FUEL LINE O-RING LEAK. REFERENCE NHTSA 98V184000/CHRYSLER RECALL 790. 1) 1 INCIDENT OF RECALL NOTICE AND ATTEMPTED RECALL SERVICE. AFTER RECALL SERVICE PERFORMED ON MARCH 18 1999 THERE WERE 2 INCIDENTS OF FUEL RAIL/O-RING LEAK CONFIRMED AS FOLLOWS: 2) RIGHT (PASSENGER) SIDE FUEL RAIL CRACKED AND LEAKED (OCTOBER 17 2002) 3) LEFT (DRIVER) SIDE FUEL INLET LINE O-RING FAILED AND LEAKED (APRIL 13 2004). CUSTOMER WAS MADE TO PAY FOR REPAIRS OF 3RD INCIDENT FOR $583.00 TO REPLACE ENTIRE FUEL RAIL ASSEMBLY CHRYSLER PART NUMBER 5015231AA. INSPECTION OF PARTS RETURNED TO CUSTOMER SHOW THAT FUEL INLET O-RING IS DEFECTIVE (HARDENED AND SHRUNKEN) AND IS BLACK IN COLOR (RECALL REPLACEMENT O-RING IS SUPPOSED TO BE BLUE IN COLOR). IT HAS BEEN CONFIRMED THAT 2ND INCIDENT OF FUEL LEAK WAS DUE TO RECALL SERVICE REPAIR OF MARCH 18 1999 NOT PROPERLY PERFORMED AS FUEL INLET O-RING WAS NEVER REPLACED (VILLAGE MOTORS CHELSEA MI-MECHANIC MISTAKE). IT SHOULD ALSO BE NOTED THAT RECALL SERVICE PROCEDURE TO "REINFORCE RIGHT (PASSENGER) SIDE FUEL RAIL DID NOT PREVENT FUEL LEAK INCIDENT OF OCTOBER 17 2002. CUSTOMER IS SEEKING REIMBURSEMENT FOR $583.00 FROM CHRYSLER DUE TO IMPROPER RECALL SERVICE OF DEFECTIVE O-RING. NHTSA ASSISTANCE WOULD BE APPRECIATED.

NHTSA ID

10066549

Incident

Apr 13, 2004

Mileage

148,650 mi

FUEL WAS LEAKING FROM THE FUEL RAIL. CONSUMER HAD VEHICLE TOWED TO THE DEALERSHIP. VEHICLE CAUGHT ON FIRE WHILE BEING TOWED TO THE DEALERSHIP, AND DEALERSHIP REFUSED TO HONOR THE FUEL LEAKAGE RECALL 98V184000 BECAUSE OF THE FIRE. VEHICLE HAD BEEN AT THE DEALERSHIP FOR A MONTH. *AK

NHTSA ID

10067390

Incident

Mar 15, 2004

Mileage

150,000 mi

FUEL RAIL/INJECTION SYSTEM LEAK. REFERENCE NHTSA 98V184000 AND CHRYSLER RECALL NUMBER 790. 3 INCIDENTS OF FUEL SYSTEM LEAK DUE TO DEFECTIVE FUEL RAIL SYSTEM LEAK. NHTSA 98V184000/CHRYSLER RECALL 790 IS FOR SUPPOSEDLY FIXING RIGHT (PASSENGER) SIDE INJECTION RAIL BUT FAILS TO ACKNOWLEDGE AND ADDRESS FIXING LEFT (DRIVER) SIDE FUEL INJECTION RAIL WHICH HAS SAME PROBLEM. NOTE: ROOT CAUSE OF FUEL LEAK IS THAT THE FUEL INJECTION RAIL IS MADE OF A PLASTIC WHICH EVENTUALLY SHRINKS OR CRACKS.

NHTSA ID

10066149

Incident

Apr 13, 2004

Mileage

148,700 mi

Valve Body. These may cause over drive cycling.

FLASH PROGRAMMING FAILURE RECOVERY. *SLC

SUBJECT REGARDING LOW OR NO CABIN HEAD, ENGINE COOLING SYSTEM SYSTEM FILL PROCEDURE. *TT

SUBJECT REGARDING CAMSHAFT / BEARING SERVICE. *TT

SUBJECT REGARDING AIRBAG / CLOCK SPRING SERVICE FOR VARIOUS MODELS INCLUDING 2002 MODEL YEAR JEEP LIBERTY. *TT

SOME OWNERS MAY EXPERIENCE LOOSE FEEL OR CLUNK IN THE STEERING WHEEL AS THE WHEEL IS MOVED FROM SIDE TO SIDE. *TT