2017 Ford Expedition Fuel system Problems

We were out of town driving to a baseball tournament going 80 miles an hour when the car completely lost power and a wrench came up. My husband barely coasted us to a shoulder. The car would not reset or restart unless it was in park. Happens twice. Took it for code read they said it is a throttle body issue but that instead of check engine light it shuts the whole car down until reset. Very scary on the interstate. Could have easily been in a bad collision.

NHTSA ID

11606524

Incident

Aug 4, 2024

In 2022, around mileage of 67000, our SUV was climbing a steep road when it suddenly made a pop sound & went into limp mode with the wrench light showing and the engine sounding rough. It felt like no fuel was getting to the engine & the gas pedal was non-responsive. The RPMs didn't change when the gas pedal was pressed. The grade was so steep, we barely made it to the side of the road without rolling backwards into traffic behind us. After turning the engine off and sitting about 10 mins, we tried starting the engine again. The car seemed to have reset itself! It ran fine; the wrench light turned off, and the gas pedal was responsive again. (At the time, we were on vacation at the coast and had traveled from our home at about elevation 3500'. We had also recently had to buy gas from a small no name gas station, so we feared we may have gotten bad fuel). From there, we returned home without re-occurrence, and we used fuel cleaning additive to our Chevron fuel for the next 2 fill ups. Then, approximately 600 miles later on a flat grade, it happened again without the pop sound. We immediately went to our Ford dealer who found no error code but found our purge valve stuck open. They recommended we replace it, which we did, and we operated the vehicle for 2 years without re-occurrence and using only Chevron gas. Recently, it happened again! Luckily, we weren't on a steep grade this time or on the freeway, but if a car would have been behind us, we would have likely been rear ended, especially had we been on the freeway. Once again, we shut the engine off, and it reset with the wrench light disappearing, so no diagnostic code got thrown AGAIN! Based on many complaints, this appears to be a common problem. It's very dangerous as the car immediately losses power to a crawl no matter what speed you are traveling at the time. It seems to be the electronic throttle body in instances where the SUV can stay running, so a code can be obtained before it resets.

NHTSA ID

11601824

Incident

Jul 11, 2024

Electronic throttle body will go into a limp mode and has no power to accelerate. This happens while driving down the street or highway and you might have enough power to pull to side of the road or street and not get run over. I have seen other reports of this and Ford extended their warranty on some vehicles to 10 years or 150,000 miles. These are mainly the eco boost motors. My vehicle has 88,000 miles and is regularly serviced. One occurrence was on a road under construction with no place to pull over quickly when this happened.

NHTSA ID

11556291

Incident

Nov 21, 2023

While driving my children, my 2017 Ford Expedition lost power and went into 'limp' mode (wrench appears on the dash) along with an incredibly rough idle. This is at least the 3rd time that this has happened (twice before replacing the current throttle bottle) and now. This is incredibly dangerous as the vehicle loses power and leaves my family and I at the mercy of other drivers around us. It has happened on a 6 lane freeway, a 2 lane highway, and, most recently, on a city street. After a very quick search of the internet, it is no secret that there are throttle body problems with 2017 Ford Expeditions. Ford is responsible for manufacturing a vehicle that is safe and free of mechanical defects. While some problems do arise unexpectedly, it is ignorant of Ford to continue to put passengers in harms way until an injury or death happens when there is a known issue.

NHTSA ID

11545042

Incident

Sep 17, 2023

The contact owns a 2017 Ford Expedition. The contact stated that while driving at approximately 45 MPH, the vehicle lost motive power and decelerated before the vehicle stalled. During the failure the message "Check Owner’s Manual" was displayed. The vehicle was towed to the local dealer who diagnosed that the throttle body was faulty and needed to be replaced. The vehicle was not yet repaired. The manufacturer was notified of the failure and informed that the VIN was not included in the Manufacturer’s Extended Coverage for the throttle body failure. The failure mileage was 64,000.

NHTSA ID

11539770

Incident

Aug 19, 2023

Mileage

64,000 mi

Driving through a mile-long tunnel on an interstate highway (speed limit 55 mph), the vehicle ceased to respond to the gas pedal and would not accelerate or maintain speed. Attempted to shift gears but that produced no change - it was as if the transmission was stuck in neutral, but pushing the gas pedal did not increase the rpm. As we exited the tunnel at approximately 30 mph, the driver attempted to pull over and stop the vehicle, and found that the power assist for the brakes was not working, making stopping difficult - the driver had to push the brakes very hard, multiple times, to stop the car. We did contact 911 dispatch when we thought we were going to likely impede traffic, as the tunnel only had two lanes traveling the same direction. However, no intervention was required as we reached the end of the tunnel and were able to pull over before the call was completed. The vehicle was towed to a dealership and they diagnosed a fuel pump and/or fuel pump module problem, but have ceased to respond to our calls for the past 48 hours, so we have no further information. The check engine light turned on when the car was restarted, but then later turned off, without any repair work having been completed.

NHTSA ID

11532173

Incident

Jul 9, 2023

While travelling on highway uphill around 60 mph in heavy traffic, vehicle lost all power and went to idle. I had to maneuver 3 lanes to reach shoulder. Wrench icon showed on dash. Restarted engine and code cleared and had power again. It happened 4 more times over next 2 months then gave P2112 code. Research showed to replace throttle body which I did. Now doing some watchful waiting to see if it reoccurs. I believe this is a safety gap that requires a recall and a redesign of the logic to prevent the disabling the power train all the way back to idle.

NHTSA ID

11523404

Incident

May 23, 2023

while driving on the 58 freeway in the fast lane amongst semi trucks my expedition lost power and had no acceleration, i was forced to the left shoulder of the freeway putting my family and i in danger. while stopped i had no response from my gas peddle but the engine was still on and a wrench appeared on my dash lights. i turned off the car and when i restarted it the car worked again and the wrench was gone. very very very dangerous

NHTSA ID

11518697

Incident

Apr 20, 2023

Throttle body and motor assembly failed at only 33,000 miles. Vehicle suddenly lost power and wrench light immediately illuminated on the dash. Vehicle had to be towed to local Ford dealership for repair. This created a very dangerous situation as the vehicle was currently being operated on a congested interstate on-ramp entering the highway with a very narrow shoulder / emergency lane. A vehicle accident & fatality could have easily occurred given this dangerous situation. Unfortunately this throttle body mechanical failure is a very common issue across many Ford vehicle platforms and the NHTSA has done the American consumer a disservice by allowing Ford to continue repairing these vehicles only when the throttle body unit fails. Instead the NHSTA should be forcing Ford to pre-emptively recall these vehicles and replace the faulty throttle bodies before more unnecessary fatalities occur.

NHTSA ID

11467164

Incident

Jun 1, 2022

Vehicle will lose all power and acceleration. Must pull the vehicle over to the side of the road. Turn vehicle back on and it works fine. This happens intermittently but consistently keeps happening. Code from vehicle states Electronic Throttle Body Issue

NHTSA ID

11465530

Incident

May 1, 2022

While attempting to accelerate, was not able to. Vehicle lost all power. Had to pull over and turn vehicle off and then back on. Happened twice in about 15 minutes. This is the 3rd time in 2 years this has occurred. Brought into repair facility and the issue is the throttle body.

NHTSA ID

11463535

Incident

May 5, 2022

I was driving the vehicle and it suddenly lost all engine power. The car was still on and running but slowed down to idle speed and was almost rear ended. I was barely able to get it over to the side street where I turned it off and then back on. And it ran like usual and I drove it back home, I was only a mile away. After further research it seems this is a known issue with the throttle body on these vehicles.

NHTSA ID

11451554

Incident

Feb 11, 2022

Car stops accelerating at various speeds on numerous occasions, and cannot get vehicle to propel. No propulsion occurs. Must bring vehicle to complete stop, turn off, and turn back before it will accelerate. Large wrench appears on screen, but disappears after the car is restarted. Safety issue because you cannot maintain speed or accelerate, was almost rear-ended and created potential accident trying to pull vehicle over. Took two visits to the authorized dealer to diagnose the problem as their was no "code" apparent to dealer, and was almost rear ended in between those visits. Vehicle owner quickly googled problem and noticed that N. Carolina Consumers Council had successfully petitioned NHTSA for this issue on other Fords, but that recall appears not to have included these Expeditions. Dealer replaced the throttle body.

NHTSA ID

11423700

Incident

Jul 5, 2021

I WAS DRIVING THE SUV AND ALL OF A SUDDEN THE ENGINE SEEMED TO SHAKE, THE RPM'S WENT UP AND THE CAR WOULD NOT ACCELERATE. THIS WAS ON A BUSY ROAD AND THANK GOD I WAS ABLE TO PULL OVER SAFETY. THE SUV WAS NOT ABLE TO MOVE AND WAS TOWED TO THE FORD DEALER. I WAS TOLD THE THROTTLE BODY PHYSICALLY LOOKED GOOD BUT THE ELECTRONIC IN IT WAS DYSFUNCTIONAL AND IT WOULD NEED TO BE REPLACED. THE COST WAS 755.93. THIS IS 2017 FORD EXPEDITION. CRAZY AND UNSAFE, WHAT INTERESTING WAS THE SERVICE TECH ASKED IF I CLEARED THE CODE P2112 FROM THE OBC. I SAID NO I DON'T KNOW HOW TO DO THIS. HE TOLD ME THEN THE CAR CLEARED THE CODE SO MAYBE THAT WHY IT CAN HAPPEN OVER AND OVER AGAIN. THE WAS A HISTORY OF P2112 BUT NO ACTIVE CODE. INTERESTING - SAFETY PROBLEM

NHTSA ID

11413274

Incident

Apr 20, 2021

Mileage

79,830 mi

WHEN DRIVING AT DIFFERENT SPEEDS THE THROTTLE BODY RANDOMLY AND IMMEDIATELY CLOSES TO IDLE WITHOUT WARNING. THIS HAPPENED 4 TIMES BEFORE IT WAS REPLACED. IT HAS BEEN FINE SINCE.

NHTSA ID

11398192

Incident

Sep 10, 2020

Mileage

63,000 mi

I WAS DRIVING TO A SCHEDULED APPOINTMENT WITH OUR LOCAL FORD DEALERSHIP FOR ANOTHER ISSUE WHICH NEEDED CORRECTING WHEN ALL OF A SUDDEN THE VEHICLE WOULD NOT ACCELERATE. THE CARS ENGINE WAS STILL RUNNING BUT NO ACCELERATION. I MANAGED TO GET OFF THE ROAD, WITHOUT BEING HIT, AND CONTINUED TO THE DEALERSHIP. I LET THEM KNOW WHAT HAD HAPPENED BUT THEY BLAMED THE INCIDENT ON A BAD BATTERY AND I THOUGHT THE ISSUE WAS FIXED. THIS IS WHERE THE ISSUE BECOMES CATASTROPHIC IN MY OPINION. ON NOVEMBER 1, 2020 MY WIFE AND TWO FRIENDS WERE IN THE VEHICLE AND HEADING OUT OF TOWN. WE LIVE IN A MOUNTAINOUS PART OF ARIZONA. FORTUNATELY WE WERE ON A FAIRLY LEVEL STRETCH AND IN THE RIGHT LANE. THE VEHICLE'S ACCELERATOR AGAIN FAILED TO FUNCTION. WE PULLED OFF THE ROAD TO THE SHOULDER. TURNED OFF THE ENGINE, RESTARTED THE CAR AND TURNED AROUND AND WENT BACK HOME, ABOUT A 120 MILE DETOUR. WE CALLED THE DEALERSHIP TO HAVE THEM DO A DIAGNOSTIC. THEY DETERMINED IT TO BE A FAILED THROTTLE BODY SENSOR. THIS INCIDENT COULD HAVE TURNED OUT MUCH WORSE. HAD WE BEEN PASSING A TRUCK, CAUGHT IN THE LEFT LANE AND ON A STEEP GRADE WITH NO ACCELERATION, WHO KNOWS THE OUTCOME. I CONTACTED FORD FOR THEM TO REIMBURSE ME FOR THE COST OF THE THROTTLE BODY REPAIR/REPLACEMENT. THEY DID COVER THAT COST, BUT I ALSO ASKED THEM TO GIVE ME AN ASSURANCE THE REPLACEMENT PART WOULD NOT DO THE SAME FAILURE AFTER SO MANY MILES. BY THE WAY OUR VEHICLE ONLY HAD 55K MILES WHEN THIS HAPPENED. I HAVE SINCE LEARNED FROM THE DEALERSHIP THAT THIS FAILURE (BAD SENSOR) OCCURS WITH FREQUENCY IN SIMILAR VEHICLES. IF THE FAILURE OCCURRED IN THE SCENARIO I MENTIONED ABOVE, WHO WOULD KNOW IT WAS THE THROTTLE BODY SENSOR THAT FAILED, RATHER THAN A DRIVER ERROR. IT IS A FAILURE THAT COULD BE CATASTROPHIC, AND PROBABLY HAS BEEN WITHOUT CONSEQUENCES. I ASKED FORD WHY THIS WASN'T A RECALL ACTION, NO RESPONSE. WHERE IS THE NHTSA?

NHTSA ID

11389992

Incident

Oct 22, 2020

Mileage

55,000 mi

09-10-19 MY 2017 FORD EXPEDITION HAS SHUT DOWN MULTIPLE TIMES WHILE DRIVING DOWN THE ROAD. THE DASHBOARD LIGHTS GO BLACK AND ALL POWER IS LOST, ENGINE, POWER STEERING ETC. I HAD THE VEHICLE TOWED TO THE DEALER ON 09-08-19. WHILE IT WAS BEING TOWED, THE ENGINE COMPARTMENT CAUGHT ON FIRE AND THE TOW TRUCK DRIVER HAD TO PUT OUT THE FIRE WITH AN EXTINGUISHER. FORTUNATELY, I DECIDED TO HAVE THE VEHICLE TOWED AS THIS ENTIRE EXPERIENCE IS A LIFE SAFETY MATTER.

NHTSA ID

11254347

Incident

Sep 8, 2019

Mileage

27,000 mi

VEHICLE STARTED RUNNING ROUGH GOING UP A HIGHWAY ON RAMP, CHECK ENGINE LIGHT CAME ON, PULLED OVER AND SHUT OFF ENGINE. RESTARTED ENGINE AND IT CONTINUED TO RUN ROUGH. A COUPLE DAYS LATER THE VEHICLE STALLED WHILE ACCELERATING INTO AN INTERSECTION AND AGAIN THE CHECK ENGINE LIGHT CAME ON. THE ELECTRONIC THROTTLE BODY ETB ASSEMBLY HAS BEEN REPLACED BY THE DEALER. I FEEL THIS IS A SAFETY ISSUE, AND IT SHOULD BE COVERED UNDER A RECALL!

NHTSA ID

11234601

Incident

Jul 9, 2019

Mileage

36,850 mi

2017 FORD EXPEDITION. CAR WAS RUNNING NORMAL, CRUISING AT 45MPH ON CITY STREET, THEN UNEXPECTED LOSS OF THROTTLE, CAUSING IMMEDIATE DECELERATION. ACCELERATOR NO LONGER RESPONDING TO INPUT. WRENCH LIGHT CAME ON; HAD TO COAST TO A STOP WITH TRAFFIC COMING FAST BEHIND ME. SHUT OFF CAR AND RESTARTED IT, AND WAS ABLE TO DRIVE IT TO THE DEALERSHIP. DEALER REPLACED FAULTY ELECTRONIC THROTTLE BODY.

NHTSA ID

11093267

Incident

May 10, 2018

Mileage

57,000 mi

ON TWO SEPARATE OCCASIONS (10/22/17 AND 10/27/17) VEHICLE LOST POWER WHILE DRIVING ON FREEWAY, AND "CHECK SERVICE MANUAL" WARNING APPEARED ON DASH. VEHICLE HAD TO BE STOPPED ON FREEWAY AND THEN RESTARTED IN ORDER TO PROCEED. SERVICED BY DEALER; ELECTONIC THROTTLE BODY DETERMINED TO BE DEFECTIVE, AND REPLACED.

NHTSA ID

11040518

Incident

Oct 22, 2017

Mileage

19,000 mi