2001 Ford Explorer Sport Trac

ON SEPTEMBER 6, 2005, ODI RECEIVED A PETITION REQUESTING THAT THE AGENCY INVESTIGATE ALLEGATIONS OF ENGINE SPARK PLUG EJECTION IN CERTAIN MODEL YEAR 1997 THROUGH 2004 FORD VEHICLES WITH TRITON V-8 AND V-10 ENGINES.ODI RECEIVED A TOTAL OF 474 NON-DUPLICATIVE COMPLAINTS ON THE SUBJECT VEHICLES WHERE THE COMPLAINANT, OR THE DEALER REPAIRING THE VEHICLE, REPORTED THAT A SPARK PLUG DETACHED FROM THE CYLINDER AND/OR EJECTED FROM THE ENGINE.AS OF DECEMBER 8, 2005, ODI IS NOT AWARE OF ANY ALLEGATIONS WHERE THE ALLEGED DEFECT RESULTED IN A LOSS OF VEHICLE CONTROL, A CRASH, AN INJURY, OR A FATALITY IN ANY OF THE 10,319,810 SUBJECT VEHICLES.IN ADDITION, ODI IS AWARE OF ONLY TWO INCIDENTS WHERE THE VEHICLE STALLED WITHOUT RESTART.INFORMATION CONTAINED IN THE ODI CONSUMER COMPLAINTS AND OBTAINED FROM 72 TELEPHONE INTERVIEWS WITH COMPLAINANTS SHOWED THE FOLLOWING:(1) 99% OF THE COMPLAINTS WERE ON MY 1997 TO 2002 SUBJECT VEHICLES.(2) MOST THE COMPLAINANTS REPORTED HEARING A LOUD POP WHILE DRIVING OR UPON STARTING UP THE VEHICLE FOLLOWED BY A LOUD, REPETITIVE CLICKING OR POPPING SOUND.(3) MANY OF THE COMPLAINANTS REPORTED THAT THE POPPING SOUND WAS ACCOMPANIED BY SOME LOSS OF VEHICLE POWER; HOWEVER, IN 99% OF THE INCIDENTS REPORTED, THE VEHICLE DID NOT STALL.IN THE VERY FEW INCIDENTS WHERE THE VEHICLE DID STALL, MOST VEHICLES COULD BE RESTARTED.(4) ONLY A SMALL PERCENTAGE OF THE COMPLAINANTS CITED THAT THEY SMELLED GAS OR A SLIGHT BURNING SMELL WHEN THE INCIDENT OCCURRED.(5) IN ALL BUT A VERY FEW INCIDENTS, VEHICLE DAMAGE WAS LIMITED TO THE ENGINE.IN ONE INCIDENT, THE COMPLAINT REPORTED THAT THE FUEL RAIL WAS DAMAGED AND REPLACED AFTER ONE OF THE SPARK PLUGS EJECTED FROM THE ENGINE; HOWEVER, THE COMPLAINANT REPORTED THAT THE DAMAGE DID NOT RESULT IN ANY TYPE OF FUEL LEAK OR FIRE.IN ANOTHER INCIDENT, THE ONLY INCIDENT WHERE A FIRE WAS ALLEGED, THE COMPLAINANT REPORTED THAT NO FLUID LEAK WAS OBSERVED, BUT THAT A FIRE RESULTED AFTER THE SPARK PLUG HAD EJECTED FROM THE ENGINE AND HE HAD RESTARTED THE VEHICLE AND DRIVEN TO ANOTHER LOCATION.NONE OF THE COMPLAINANTS REPORTED ANY DAMAGE TO THE VEHICLE HOOD.(6) ONLY TWO COMPLAINANTS REPORTED THAT THEY OBSERVED WHAT APPEARED TO BE SOME DROPS OF FUEL COMING FROM THE CYLINDER WHERE THE SPARK PLUG HAD FAILED OR ON THE SPARK PLUG ITSELF; HOWEVER, EACH OF THESE COMPLAINANTS REPORTED THAT THERE WAS NO SMOKE OR FLAMES AS A RESULT OF HIS INCIDENT.AS THE PETITIONER NOTED, AND ODI?S ANALYSIS SHOWED, IT IS POSSIBLE FOR A SPARK PLUG TO DETACH FROM THE ENGINE CYLINDER THREADS IN THE SUBJECT VEHICLES.HOWEVER, ODI?S ANALYSIS OF 474 COMPLAINTS DESCRIBING SUCH INCIDENTS FOUND ONLY A VERY FEW ALLEGED ANY SAFETY-RELATED CONSEQUENCES.NONE OF THESE SHOWED ANY EVIDENCE OF A SERIOUS SAFETY CONSEQUENCE.GIVEN THE LARGE POPULATION AND RELATIVELY LONG EXPOSURE TIME OF THE SUBJECT VEHICLES, THE COMPLAINT ANALYSIS INDICATES THAT THE RISK TO MOTOR VEHICLE SAFETY FROM THE ALLEGED DEFECT IS VERY LOW.IN VIEW OF THE FOREGOING, IT IS UNLIKELY THAT NHTSA WOULD ISSUE AN ORDER FOR THE NOTIFICATION AND REMEDY OF THE ALLEGED DEFECT AT THE CONCLUSION OF THE INVESTIGATION REQUESTED IN THE PETITION.THEREFORE, IN VIEW OF THE NEED TO ALLOCATE AND PRIORITIZE NHTSA?S LIMITED RESOURCES TO BEST ACCOMPLISH THE AGENCY?S SAFETY MISSION, THE PETITION IS DENIED.

BY LETTER DATED AUGUST 4, 2003, FORD NOTIFIED THE AGENCY THAT IT IS CONDUCTING A VOLUNTARY SAFETY RECALL (NHTSA RECALL NO. 03V281) INVOLVING CERTAIN MODEL YEAR (MY) 1998-2001 FORD EXPLORER / MERCURY MOUNTAINEER 4-DOOR, MY 1998-2000 FORD EXPLORER 2-DOOR AND MY 2001-2002 FORD EXPLORER SPORT AND SPORT TRAC VEHICLES EQUIPPED WITH HIGH BACK SEATS.COMPLAINTS ALLEGE THAT THE DRIVER'S SEAT BACK RECLINED WITHOUT WARNING.A BOLT BETWEEN THE UPPER SEAT RECLINER ATTACHMENT AND THE SEAT BACK FRAME MAY FRACTURE.FORD WILL REPLACE THE BOLT THAT ATTACHES THE SEAT RECLINER MECHANISM TO THE SEAT BACK FRAME ON THE DRIVER SIDE SEAT.BASED ON FORD'S SAFETY RECALL ACTION, THIS INVESTIGATION IS CLOSED.

I was driving and the lights on the vehicle went out I thought it was the bulbs but no lights were working I adjusted steering wheel to look to see fuse box and all lights came back on there is an electrical short somewhere then I went to start the truck and it made a funny sound and then I lost all power and truck wouldn't start then the alarm kept going off and I could turn off even with the remote or the chipped key. And the truck won't start. Also when you change gears the indicator to show what gear you are in dosent move . This truck has electrical issues and is not safe for drivers to lose all power like this and basically its something ford should be responsible for fixing because it's a defect in the electrical system also the AC compressor dosent work

NHTSA ID

11538547

Incident

Feb 2, 2023

TRANSMISSION NOT WORKING

NHTSA ID

11253967

Incident

Nov 10, 2018

Mileage

127,854 mi

CAR TAKES ABOUT 3 TO 5 TRIES TO START. I REPLACED GAS PUMP, PLUGS, CABLES, TEMP SENSOR, STILL TAKES LONG TO START.O/D OFF LIGHT STARTED FLASHING, AND NOW IT HAS A ROUGH GEAR CHANGE I BELIEVE FROM 2ND TO 3RD

NHTSA ID

11096662

Incident

May 1, 2018

Mileage

136,000 mi

TL* THE CONTACT OWNS A 2001 FORD EXPLORER SPORT TRAC. THE CONTACT STATED THAT THE VEHICLE STALLED WHILE DRIVING VARIOUS SPEEDS. THE FAILURE OCCURRED WITHOUT WARNING. THE VEHICLE WAS MANUALLY RESTARTED AND OPERATED AS INTENDED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED AS A TRANSMISSION MALFUNCTION. THE DEALER WAS NOT NOTIFIED OF THE FAILURE. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND TRANSFERRED THE CONTACT TO NHTSA. THE FAILURE MILEAGE WAS APPROXIMATELY 186,000.

NHTSA ID

11075183

Incident

Feb 27, 2016

Mileage

186,000 mi

TL* THE CONTACT OWNS A 2001 FORD EXPLORER SPORT TRAC. THE CONTACT STATED THAT THE VEHICLE RANDOMLY FAILED TO START UPON TURNING THE KEY NUMEROUS TIMES. THE DEALER (PEGUES-HURST FORD, 200 TX-63 SPUR, LONGVIEW, TX 75601, (903) 758-6211) WAS CONTACTED AND INDICATED THAT THEY WOULD NEED TO DETERMINE IF THEY COULD REPLICATE AND DIAGNOSE THE FAILURE. THE CONTACT WAS ADVISED TO SCHEDULE AN APPOINTMENT WITH THE DEALER. THE VEHICLE WAS NOT DIAGNOSED. THE MANUFACTURER ISSUED 12 TECHNICAL SERVICE BULLETINS (TSBS) FOR THE ELECTRICAL SYSTEM, 52 TSBS FOR THE ENGINE, AND 3 TSBS FOR THE FUEL SYSTEM GASOLINE, BUT THE CONTACT WAS UNCERTAIN AS TO WHICH PART CAUSED THE FAILURE. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 170,000.

NHTSA ID

11052185

Incident

Nov 14, 2016

Mileage

170,000 mi

VEHICLE RUNNING IN PARK WHILE DRIVER GATHERED BOXES TO PLACE IN BED OF TRUCK. DRIVE TRAIN ENGAGED SENDING DRIVERLESS VEHICLE DOWN ROAD, ACROSS INTERSECTION AND INTO BRICK WALL. WITNESS TO IMPACT RAN TO VEHICLE THINKING TO CHECK ON DRIVER. UPON OPENING DOOR, NOTED NO DRIVER AND STATED SHIFTER STILL INDICATED VEHICLE WAS IN PARK.

NHTSA ID

11010899

Incident

Jul 13, 2017

Mileage

235,000 mi

I HAD AN ACCIDENT I JANUARY 2016 AND MY AIRBAG DID NOT DEPLOY CAUSE ME DAMAGE TO MY NECK AND BOTH SHOULDER. DOCTORS SAY I NEED SURGERY ON ROTATOR CUFFS. IF AIRBAGS HAD DEPLOYED I WOULD NOT HAVE BEEN THRUST FORWARD. I GRABBED STEERING WHEEL TO BRACE MYSELF AND WAS THRUST FORWARD THERE FOR DAMAGE BOTH ROTATOR CUFFS IN MY SHOULDER AND HURTING MY NECK ALSO. I HAVE SEEN MANY OTHER TRUCKS OF MY MAKE THAT AIR BAGS HAVE NOT DEPLOYED AND PEOPLE GETTING HURT. I DO NOT UNDERSTAND WHY THEY DID NOT DEPLOY. . WHY ARE THERE NOT RECALLS ON THIS AIR BAGS. THANK YOU. [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).'*JB

NHTSA ID

10984456

Incident

Jan 3, 2016

DRIVING ON FREEWAY FRONT DRIVER WHEEL FELL OFF CAUSING TRUCK TO ROLL OVER. NO AIR BAG WAS INFLATED. WAS TOLD THE PIN THAT HOLDS THE TIRE ON CAME OUT. TRUCK WAS TOTALLED AND HIT 2OTHER CARS WHILE ROLLING.

NHTSA ID

10969825

Incident

Feb 6, 2017

Mileage

107,000 mi

STEERING SHUDDER DURING LOW SPEED MANEUVERS - 4.0L ENGINE. *TT

SAFETY BELT RETRACTION SPEED. *TT

FRONT AXLE LEAKS FLUID FROM VENT TUBE - VEHICLES EQUIPPED WITH 4X4 OR AWD. *TT

MOAN/VIBRATION DURING AIR CONDITIONING OPERATION. *TT

REVISED PROCEDURE FOR ADJUSTING ALIGNMENT ON ALL SUSPENSIONS - NEW RIGHT HAND UPPER CONTROL ARM DESIGN FOR TORSION BAR FRONT SUSPENSIONS. *TT

GENERAL (PCM) POWER TRAIN CONTROL MODULE PROGRAMMING PROCEDURES. *TT