2003 Ford Explorer Transmission Problems

TL* THE CONTACT OWNS A 2003 FORD EXPLORER. THE CONTACT STATED THAT WHILE RESTARTING THE VEHICLE, THE GEAR SHIFTER DETACHED FROM THE STEERING WHEEL. THE VEHICLE WAS TOWED TO AN AUTHORIZED DEALER WHERE IT WAS DIAGNOSED WITH A FAILURE TO THE STEERING COLUMN THAT NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND THE CURRENT MILEAGE WAS 75,900. ..UPDATED 04/11/12 *BF THE CONSUMER STATED WHEN HE PUT THE VEHICLE IN REVERSE, THE ENTIRE GEAR SHIFT CAME OUT IN HIS HAND. LEAVING THE VEHICLE IN REVERSE. HE WAS ABLE TO TURN THE IGNITION SWITCH OFF. A CAST IRON BRACKET WAS COMPLETELY BROKEN OFF IN THE STEERING COLUMN. UPDATED 05/31/12

NHTSA ID

10451623

Incident

Mar 13, 2012

Mileage

75,900 mi

I WENT TO LEAVE FOR WORK ONE MORNING & I NOTICED THE REAR PANEL WAS CRACKED. IT WASN'T LIKE THAT THE NIGHT BEFORE, SO IT LITERALLY HAPPENED OVERNIGHT. MY MECHANIC SAID IT WAS COSMETIC & COMMON PROBLEM WITH THESE TRUCKS. I WAS TOLD THE WINDOW WOULD BE FINE, BUT THERE IS A CHANCE OF THE PANEL PIECE FALLING OFF. I HAVEN'T HAD IT FIXED YET DUE TO THE EXPENSE, BUT I AM AFRAID A PIECE MAY FALL OFF WHILE DRIVING WHICH COULD INJURE SOMEONE. TO ADD INSULT TO INJURY, A WEEK LATER, MY TRANSMISSION STARTED SLIPPING & THE O/D LIGHT WAS FLASHING. I HAD IT TOWED & SURE ENOUGH, IT HAD TO BE REBUILT. IT ALSO NEEDED A NEW HUB BEARING AND BOTH FRONT BALL JOINTS HAD TO BE REPLACED. *KB

NHTSA ID

10437913

Incident

Nov 24, 2011

TL* THE CONTACT OWNS A 2003 FORD EXPLORER EDDIE BAUER EDITION. THE CONTACT WAS DRIVING 30 MPH WHEN THE OVERDRIVE WARNING LIGHT ILLUMINATED AND THE VEHICLE BECAME HARD TO SHIFT. THE VEHICLE WAS TAKEN TO THE DEALER FOR DIAGNOSTIC TESTING WHERE IT WAS DIAGNOSED THAT THE OVERDRIVE BAND WAS FRACTURED AND POSSIBLY HAD CAUSED DAMAGE TO THE TORQUE CONVERTER. THE MANUFACTURER WAS CONTACTED BUT THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 34,029 AND THE CURRENT MILEAGE WAS 64,846. UPDATED 11/22/11*LJ THE CONSUMER STATED THE SHIFTING WAS ERRATIC AT STEADY SPEEDS, THERE WAS A HARD BANG WHEN SHIFTING. THE PCM WAS REPROGRAMMED. THERE WAS A CLUNK NOISE WHEN COMING TO A STOP. THE DEALER REPLACED THE TRANSMISSION FLUID. THE OVERDRIVE LIGHT ILLUMINATED AND 95% OF THE TIME, THE VEHICLE WOULD NOT SHIFT OUT OF 1ST GEAR. UPDATED 03/12/12

NHTSA ID

10424147

Incident

Aug 24, 2011

Mileage

34,029 mi

TRANSMISSION FAILURE....O/D LIGHT FLASHES AND SERVICE ENGINE LIGHT STAYS ON. *TR

NHTSA ID

10422697

Incident

Jul 24, 2011

Mileage

105,000 mi

THE TRANSMISSION ON MY 2003 FORD EXPLORER IS GONE. *KB

NHTSA ID

10419681

Incident

Aug 10, 2011

Mileage

146,000 mi

O/D LIGHT SPONTANEOUSLY CAME ON. CAN NOT BE TURNED OFF. TRANSMISSION TAKES OFF SLOW. FIRST GEAR SLAMS INTO SECOND, WITH SLOW TAKEOFF CAUSES CARS BEHIND ME TO STOP SHORT BECAUSE MY TAKEOFF IS VERY SLOW. *TR

NHTSA ID

10419427

Incident

Jun 25, 2011

Mileage

55 mi

MY 2003 FORD EXPLORER HAD A "THUNK" NOISE FROM DAY ONE. FORD DEALERSHIP "COULD NOT DUPLICATE" THE COMPLAINT EVEN THOUGH I TOOK IT BACK MULTIPLE TIMES. HAD TO REPLACE THE TORQUE CONVERTER AT 70K MILES AND NOW AT 135K MILES THE WHOLE TRANSMISSION AND ANOTHER TORQUE CONVERTER FOR RATTLING AGAIN. OD/OFF BLINKING LIGHT AND CHECK TRANSMISSION NOTICE CAME ON WITH ERRATIC SHIFTING AND LOSS OF 2ND AND 5TH GEARS. REPLACEMENT OF TRANS ELIMINATED "THUNK" AND MY $4600. SIMILAR COMPLAINTS WITHOUT ANY ACKNOWLEDGEMENT OF FAULTY MATERIALS OR ENGINEERING BY FORD HAS PLAGUED HUNDREDS IF NOT THOUSANDS OF EXPLORER OWNERS. WHERE IS THE EXPECTED INVESTIGATION OF THESE PROBLEMS? WHY DO WE HAVE TO WAIT UNTIL ACCIDENTS OR INJURY TO HAVE FAULTY AUTOS RECALLED? WHY ARE SPARK PLUGS EJECTED MORE OF A SAFETY CONCERN THAN TRANSMISSIONS THAT LEAVE DRIVERS WITHOUT PROPER MOVING CAPABILITY ON THE HIGHWAY? WHERE IS THE RECALL FOR THESE UNITS? *KB

NHTSA ID

10413349

Incident

Jun 30, 2011

Mileage

135,000 mi

THE TRANSMISSION ON OUR 2003 FORD EXPLORER HAD TO BE REPLACED. IT COULD HAVE LEFT US STRANDED ON THE ROAD. FORD KNEW OF THIS PROBLEM WITH THE TRANSMISSIONS ON THE 2003-2004 EXPLORERS. I THINK THEY SHOULD MAKE AN ADJUSTMENT ON THE COST OF THE REPAIRS. TRANSMISSION ARE SUPPOSED TO LAST LONGER THAN 71,000 MILES. WE DID NOT MISTREAT THIS VEHICLE IN ANY WAY. *TR

NHTSA ID

10407100

Incident

Mar 30, 2011

Mileage

71,000 mi

TL*THE CONTACT OWNS A 2003 FORD EXPLORER. THE CONTACT STATED WHILE DRIVING APPROXIMATELY 35 MPH THE OVER DRIVE LIGHT BEGAN ILLUMINATING ON THE INSTRUMENT PANEL AND THE VEHICLE BEGAN TO SHIFT INTO A HIGHER GEAR. THE CONTACT TURNED THE VEHICLE OFF AND UPON RESTARTING IT, THE VEHICLE BEGAN TO FUNCTION NORMALLY. AFTER DRIVING FOR A FEW MILES, THE FAILURE RECURRED. THE VEHICLE WAS NOT TAKEN TO A DEALER TO HAVE THE FAILURE DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 110,000 AND THE CURRENT MILEAGE WAS 111,000.

NHTSA ID

10401403

Incident

May 15, 2011

Mileage

110,000 mi

TL*THE CONTACT OWNS A 2003 FORD EXPLORER. THE CONTACT STATED THAT THE DOOR AJAR LIGHT ILLUMINATED FREQUENTLY AND THE DOME LIGHT STAYED ILLUMINATED EVEN WHEN THE DOORS WERE CLOSED. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER FOR A MANUFACTURERS RECALL AND THE DEALER STATED THAT THE REPAIR HAD PREVIOUSLY BEEN PERFORMED. THE VEHICLE WAS NOT REPAIRED. THE CONTACT STATED THAT THE VEHICLE HESITATED INTERMITTENTLY. THE VEHICLE HAD NOT BEEN INSPECTED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE CURRENT MILEAGE WAS APPROXIMATELY 72,000. THE FAILURE MILEAGE WAS APPROXIMATELY 49,000.

NHTSA ID

10401153

Incident

Apr 18, 2007

Mileage

48,065 mi

MY 2003 FORD EXPLORER WAS PARKED IN MY DRIVEWAY AND IT SOMEHOW ROLLED DOWN APPROX 150 FEET AND SMASHED INTO A TREE. THERE WAS NO ONE IN THE VEHICLE IT WAS PARKED AND THE KEYS WERE IN THE HOUSE. I IMMEDIATELY CALLED MY INSURANCE (STATE FARM) AND THEY HAD ME CALL A COLLISION GARAGE TO COME OUT AND THEY CAME WITHIN THE HOUR. THEY HAVE STATED THAT THE VEHICLE IS A TOTAL LOSS. THE NEXT MORNING I CALLED FORD AND THEY DISREGARDED ANYTHING I SAID AND SAID MY INSURANCE SHOULD TAKE CARE OF IT. I AM STILL PAYING ON A LOAN FOR THIS CAR AND I DO HAVE FULL COVERAGE BUT I AM NOW WITHOUT A VEHICLE AND I AM SCARED TO THINK OF WHAT MIGHT OF HAPPENED IF MY DAUGHTERS WOULD OF BEEN PLAYING IN THE BACKYARD. *TR

NHTSA ID

10399398

Incident

May 3, 2011

Mileage

117,500 mi

VEHICLE TRANSMISSION SLIPS OUT OF GEAR AND SOMETIMES WONT ENGAGE. FREQUENTLY OCCURS AT STOP/START MOVEMENTS. OCURRS IN FORWARD AND REVERSE. "O/D OFF" LIGHT IS FREQUENTLY DISPLAYED. UNSAFE TO DRIVE ANYWHERE!!! *TR

NHTSA ID

10398071

Incident

Apr 2, 2011

Mileage

91,000 mi

TRANSMISSION PROBLEMS STARTED AROUND 100K MILES; HIGH RPM SHIFTING BETWEEN 1ST AND 2ND GEAR WITH SUBSEQUENT FLASHING O/D LIGHT. MANY TIMES TRANSMISSION WILL "CLUNK" INTO GEAR EITHER FROM GOING INTO REVERSE, STOPPING COMPLETELY, THEN SHIFTING INTO DRIVE AND/OR WHEN PUTTING IN REVERSE OR DRIVE. APPEARS THIS IS A COMMON PROBLEM FOR MY MODEL YEAR EXPLORER (03) AND SAME CODE MANY OTHERS RECEIVE (P0775) WHICH REALLY DOES NOT DESCRIBE THE PROBLEM OR LEAD A NOT SO MECHANICAL INCLINED PERSON TO TRY AND TROUBLESHOOT/BUY PARTS TO FIX. I'M CAREER MILITARY MAN W/FAMILY AND MY TRUCK IS PAID OFF NEXT MONTH--OWNED 5 YEARS AND REALLY SUCKS TO HAVE TO POSSIBLY DUMP $3K INTO A TRUCK THAT FORD HAS KNOWN CONTAINED ISSUES WITH THE 5R55W TRANSMISSION. *TR

NHTSA ID

10398051

Incident

Nov 15, 2010

Mileage

100,000 mi

I HAVE A 2003 FORD EXPLORER AND MY O/D LIGHT KEEPS FLASHING I TOOK IT TO THE DEALER TO GET IT CHECKED AND THEY SAID I NEED A NEW TRANSMISSION BECAUSE I HAVE NO 2ND OR 5TH GEAR THEY ALSO SAID THIS IS A COMMON PROBLEM WITH THAT YEAR. THEY SAID THE SHIFT SEALNOID WENT OUT SO NOW I CANT DRIVE MY TRUCK TELL I CAN AFFORD 3400 DOLLARS TO GET IT FIXED SO THAT HAS MADE IT HARDER FOR ME TO GET TO WORK AND TO GET MY FAMILY WHERE THEY NEED TO BE. *TR

NHTSA ID

10395317

Incident

Apr 2, 2011

Mileage

131,500 mi

TRANSMISSION WENT OUT. *TR

NHTSA ID

10393791

Incident

Mar 15, 2011

Mileage

100,000 mi

TL* THE CONTACT OWNS A 2003 FORD EXPLORER. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 40 MPH, THE VEHICLE BEGAN TO DECELERATE INDEPENDENTLY WITH THE ILLUMINATION OF SEVERAL WARNING LIGHTS. THE FAILURE WOULD RECUR INTERMITTENTLY AND THE EITHER THE VEHICLE WOULD RESTART IMMEDIATELY OR THE VEHICLE WOULD BE TOWED. THE VEHICLE WAS INSPECTED BY AN INDEPENDENT MECHANIC AND THEY ADVISED HER THAT THE TRANSMISSION WOULD NEED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS CONTACTED AND OFFERED NO ASSISTANCE. THE FAILURE MILEAGE WAS APPROXIMATELY 67,000. THE VIN WAS UNAVAILABLE.

NHTSA ID

10392882

Incident

Jul 25, 2009

Mileage

67,000 mi

I OWN A 2003 FORD EXPLORER, I HAVE OWNED IT FOR ALMOST 5 YEARS AND TOOK CARE OF IT. I ALSO PAID ALOT OF MONEY FOR IT AND AFTER ABOUT THREE YEARS OUT OF NOWHERE MY O/D LIGHT STARTED BLINKING AND MY CAR STARTED SHIFTING WRONG. I HAD THE SOLENOID ON TRANNY REPLACED SOON AS I PUT IT IN 4WHEEL DRIVE MY O/D LIGHT STARTED BLINKING AGAIN AND SHIFTING WRONG. THIS IS MAKING THE CAR ACCELERATE TO MUCH AT TIMES AND ALMOST NOT WANTING TO SHIFT OTHERS.SO WHILE WAITING THINKING I NEED A NEW TRANSMISSION MY ENGINE LIGHT COMES ON FOLLOWED BY A LIGHT TICKING NOISE, THAT GOT LOUDER AND LOUDER OVER ABOUT A MONTH.SO THE CAR WAS TAKEN TO THE DEALERSHIP AN PUT ON A COMPUTER THEY SAID I SHOULD JUNK IT, YES ITS 5 YEARS OLD BUT I BOUGHT MY CAR FROM THEIR AND I PAID ALOT FOR IT.SO NO ONE KNOWS EXACTLY WHAT'S WRONG WITH IT I MYSELF BELIEVE BUT FORD.I BEEN TOLD I NEED A NEW TRANSMISSION AND MY TIMING CHAIN IS BAD ON THE ENGINE.THE CAR STILL RUNS ALTHOUGH I WONT DRIVE IT COMPLETELY UNSAFE. ITS A NICE LOOKING CAR BUT I SEEN ALOT OF PEOPLE WITH THIS SAME PROBLEM WITH THE SAME YEAR MAKE AND MODEL HOW IS THAT AND ITS DANGEROUS? ME AND MY DAUGHTER WRECKED AFTER SUDDEN ACCELERATION THANKFULLY THE AIRBAGS DEPLOYED AND BURNT HER BUT WE WERE BOTH FINE OTHERWISE. I JUST NOW THIS IS DANGEROUS,FORD KNOWS ABOUT IT AND WHY IT HAPPENED AND HOW TO FIX IT. *TR

NHTSA ID

10392327

Incident

Mar 15, 2008

Mileage

85,000 mi

WELL THIS WILL BE THE 2ND TRANSMISSION FOR MY 2003 FORD EXPLORER, THE FIRST WAS AT 88700 MILES ABOUT 4 YEARS AGO. IT TOOK THE DEALERSHIP ALMOST 2 WEEKS TO FIGURE OUT WHAT WAS WRONG. THEN 2 WEEKS AFTER THAT HEARD A LOUD PING WHILE DRIVING HOME, AT 9:00 AT NIGHT, TOOK IN TO DEALER AND THE DRIVE SHAFT HAD WATER IN IT. NOW I AM THE ORIGINAL OWNER, TRUCK HAS NEVER BEEN OFF ROAD, NEVER TOWED ANYTHING, HIGHWAY MILES. SO, I FIX ALL THAT( ABOUT $3,000.00 IN ONE MONTH) NOW THIS PAST WEEKEND COMING HOME ON THE INTERSTATE TRUCK GIVES A LARGE SHUDDER 3 TIMES, I ALMOST GET RUN OVER BY A TOUR BUS BECAUSE TRUCK IS GETTING READY TO DIE. LIMP HOME CAN'T DRIVE OVER 60 MILES AN HOUR, WENT BACK ROADS HOME, DID NOT LIKE GOING UP SMALL HILLS. WHEN 1 MILE FROM HOME O/D OFF LIGHT CAME ON AND TRANSMISSION STARTED ACTING BAD. PULLED INTO DRIVEWAY, BARELY. NOW I'M PISSED BECAUSE HERE I GO AGAIN POURING OUT MONEY TO FIX AND ALMOST GOT HIT ON INTERSTATE. *TR

NHTSA ID

10390232

Incident

Mar 12, 2011

Mileage

200,000 mi

I RECENTLY ENCOUNTERED PROBLEMS WITH MY VEHICLE'S ACCELERATION. THE VEHICLE THEN BEGAN TO BUCK, MAKE LOUD NOISES, THE CHECK ENGINE LIGHT CAME ON AND THEN THE O/D LIGHT BEGAN TO FLASH. I TOOK MY VEHICLE TO THE DEALER TO HAVE A DIAGNOSTICS TEST PERFORMED WHICH DETERMINED THAT MY TRANSMISSION NEEDED TO BE REPLACED. THE VEHICLE THAT I AM REFERENCING IS A 2003 FORD EXPLORER WITH 73,859 MILES (AT THE TIME OF THE DIAGNOSIS). I DID RESEARCH WHICH REVEALED THAT THIS HAS BEEN A COMMON ISSUE WITH 2003 FORD EXPLORERS WITH APPROXIMATELY THE SAME NUMBER OF MILES. I DID GET THE TRANSMISSION REPLACED IN MY VEHICLE, HOWEVER THE COMPLAINT IS THAT THESE VEHICLES ARE REQUIRING TRANSMISSION REPLACEMENTS AT SUCH LOW MILES. WITH ALL OF THE COMPLAINTS INVOLVING THIS ISSUE, IT SEEMS TO WARRANT AN INVESTIGATION INTO THE MATTER........PLEASE INVESTIGATE. *TR

NHTSA ID

10384841

Incident

Jan 24, 2011

Mileage

73,859 mi

TL* THE CONTACT OWNS A 2003 FORD EXPLORER. THE CONTACT WAS TRAVELING 45 MPH WHEN THE OVER DRIVE WARNING LIGHT ILLUMINATED AND THE TRANSMISSION FAILED. THE CONTACT TOOK THE VEHICLE TO THE DEALER AND WAS TOLD THAT THE TORQUE CONVERTER, SERVO PACK AND CLUTCH WOULD NEED REPLACING. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 100,000.

NHTSA ID

10384528

Incident

Feb 13, 2011

Mileage

100,000 mi

TL*THE CONTACT OWNS A 2003 FORD EXPLORER. WHILE DRIVING APPROXIMATELY 35 MPH, THE OVER-DRIVE AND ENGINE SERVICE WARNING INDICATORS ILLUMINATED. THE WARNING INDICATORS REMAINED ILLUMINATED UNTIL THE ENGINE WAS TURNED OFF. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER WHERE A DIAGNOSTIC TEST WAS PERFORMED WHICH DETECTED THAT THE GEAR RATIO AND PRESSURE CONTROL SOLENOID WERE DEFECTIVE WITHIN THE TRANSMISSION. THE CONTACT WAS AWAITING THE PARTS FOR THE VEHICLE TO BE REPAIRED. THE FAILURE MILEAGE WAS 94,583. UPDATED 03/31/11*LJ UPDATED 04/05/11

NHTSA ID

10384287

Incident

Feb 16, 2011

Mileage

94,583 mi

THE TRANSMISSION WENT OUT SEVERAL MONTHS AFTER THE WARRANTY EXPIRED AND THE COMPANY DID NOTHING TO ADDRESS THIS...THE CAR WAS ONLY 5 YEARS OLD WHEN THIS HAPPENED AND WE HAD TO GET A NEW TRANSMISSION. *TR

NHTSA ID

10383329

Incident

Nov 15, 2008

I WAS DRIVING MY 2003 FORD EXPLORER XLT V6 4.0L ON I40W, WHEN ALL OF A SUDDEN THE VEHICLE BEGAN TO DECELERATE WHILE THE RPMS WERE CONSTANTLY GOING UP. THIS PUT ME IN THE INTERSTATE WITH NO POWER AS THE GEARS WEREN'T SHIFTING. I TOOK IT TO MY LOCAL FORD DEALERSHIP AND THEY PUT IT ON THE DIAGNOSTIC MACHINE AND TOLD ME THEY REALLY DIDN'T KNOW WHAT WAS WRONG WITH IT AND THAT THEY WOULD HAVE TO BREAK THE TRANSMISSION DOWN IN ORDER TO KNOW FOR SURE. I SEARCHED ONLINE FOR ANY COMMON TRANSMISSION PROBLEMS AND CAME ACROSS A SITE WHERE PEOPLE WITH VEHICLES JUST LIKE MINE HAVING THE SAME EXACT PROBLEM. AS OF NOW I'M STILL WAITING ON FORD TO LET ME KNOW WHAT'S GOING ON WITH MY TRUCK, BUT WITH HUNDREDS OF OTHER PEOPLE HAVING THE SAME PROBLEM I SEE NO REASON FOR THEM NOT KNOW WHAT THE PROBLEM IS AS WELL AS HAVE A RECALL ON THE VEHICLE TO FIX THE PROBLEM. *TR

NHTSA ID

10383326

Incident

Feb 15, 2011

Mileage

120,000 mi

NO SECOND GEAR. *TR

NHTSA ID

10381658

Incident

Mar 22, 2010

Mileage

60,356 mi

LIKE EVERY OTHER DAY, I STARTED THE SUV A FEW MINUTES BEFORE I HAD TO LEAVE TO LET IT WARM UP BECAUSE NY IS COLD, AND THEN LEFT TO RUN SOME ERRANDS. I REALIZED RIGHT AWAY THAT THE TRUCK SOUNDED A LITTLE FUNNY WHEN ACCELERATING, SO THE RADIO WENT OFF SO I COULD LISTEN. I FOUND THAT WHEN SHIFTING FROM FIRST TO SECOND, IN THIS AUTOMATIC VEHICLE, THE OVERDRIVE WAS KICKING ON PREMATURELY. THEN THE O/D LIGHT STARTED FLASHING. I CAME HOME AND STARTED RESEARCHING IT AND FOUND HUNDREDS OF COMPLAINTS, SO HERE I AM, IN THE SAME BOAT AS EVERYONE ELSE, ABOUT TO LOOK UP NUMBERS TO TRANSMISSION SPECIALISTS BECAUSE THE DEALER IS DEFINITELY NOT GOING TO MAKE ANY MONEY OFF OF MY WITH THIS ONE. *TR

NHTSA ID

10380183

Incident

Feb 1, 2011

Mileage

102,000 mi