2008 Ford F-250 Sd Brakes Problems

TL* THE CONTACT OWNS A 2008 FORD F-250 SD. THE CONTACT STATED THAT THE STEERING WHEEL LOCKED SEVERAL TIMES AND THE BRAKES HAD TO BE APPLIED EACH TIME WHILE MAKING A TURN. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO WAS UNABLE TO REPLICATE AND DIAGNOSE THE FAILURE. THE DEALER REPLACED THE POWER STEERING FLUID AND BRAKE FLUID, BUT WERE ALSO UNABLE TO DIAGNOSE THE FAILURE. THE MANUFACTURER WAS NOTIFIED. THE APPROXIMATE FAILURE MILEAGE WAS 120,000.

NHTSA ID

10954457

Incident

Nov 1, 2016

Mileage

120,000 mi

TL* THE CONTACT OWNS A 2008 FORD F-250 SD. AFTER THE BRAKE PEDAL WAS DEPRESSED, IT SUNK TO THE FLOORBOARD AND FAILED TO OPERATE. THE CONTACT WAS ABLE TO STOP THE VEHICLE BY USING THE ELECTRIC BRAKE FROM A TRAILER BEING TOWED BY THE VEHICLE. THE FAILURE OCCURRED WITHOUT WARNING. THE VEHICLE WAS TOWED TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE CRUISE CONTROL BRAKE RELEASE SWITCH FAILED AND NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 51,000. UPDATED 09/22/16*LJ UPDATED 10/6/2017*JS

NHTSA ID

10893155

Incident

Jul 30, 2016

Mileage

51,000 mi

I WAS DRIVING MY FORD 250 ON A SLICK ROAD WHEN A PICK UP STOPPED SHORT IN FRONT OF ME. I WAS UNABLE TO STOP IN TIME HITTING THE REAR END OF THE PICK UP APPROXIMATELY 20-30 MPH. MY AIR BAGS DID NOT DEPLOY AND THE SEAT BELT ALLOWED ME TO SLIDE UNDER THE BELT CAUSING MY KNEES TO HIT THE DASH. OTHER THEN GOOD BRUISES AND MILD SORENESS I WAS FINE. THE OTHER PERSON WAS FINE AS WELL. MY SEAT BELT DID NOT ENGAGE AND I AM WONDERING WHY MY AIRBAGS DID NOT DEPLOY. THE GRILL AND RADIATOR WERE DAMAGED?

NHTSA ID

10763419

Incident

Sep 4, 2015

Mileage

40,000 mi

WAS TOLD BY DEALER, REAR CALIPER WAS DRAGGING, I REPLACED REAR BRAKES AND IN THE PROCESS NOTICED BOTH BACK CALIPERS WERE DEFECTIVE AT 62000 MILES. ONE PISTON ON ONE SIDE WAS ATTACHED TO THE PAD AND CRACKED IN HALF. THE OTHER SIDE, BOTH PISTONS WERE BROKEN. AT SUCH A SHORT MILEAGE INTERVAL, CALIPERS SHOULD NOT BE DEFECTIVE AND DRAGGING ON THE ROTORS. *TR

NHTSA ID

10703992

Incident

Sep 10, 2014

Mileage

62,021 mi

TL* THE CONTACT OWNS A 2008 FORD F-250 SD. THE CONTACT WAS ENTERING A PARKING LOT AT APPROXIMATELY 5 MPH WHEN THE BRAKES SEIZED. THE VEHICLE WAS TAKEN TO A DEALER AND AN INDEPENDENT MECHANIC FOR INSPECTION, HOWEVER NO RESULTS WERE FOUND FOR THE FAILURE. THE BRAKES WERE REBUILT, REPLACED, DISSEMBLED AND CLEANED, HOWEVER THE FAILURE RECURRED. THE VEHICLE WAS NOT FURTHER REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE ISSUE. THE APPROXIMATE FAILURE MILEAGE WAS 10,000.

NHTSA ID

10560018

Incident

Sep 15, 2007

Mileage

10,000 mi

AFTER APPOX. ONE HOUR AT 65 MPH ON CRUISE CONTROL I DISENGAGED THE CRUISE CONTROL , COASTING TO A SPEED OF ABOUT 25 MPH OR LESS TO MAKE A UPCOMING LEFT TURN. AS I STARTED TO TURN I PRESSED ON THE BRAKE AND FOUND IT WAS WITHOUT ASSIST, AND THE SAME WAS TRUE FOR THE STEERING. I APPLIED AS MUCH PRESSURE AS I COULD TO BOTH THE BRAKE PEDAL AND THE STEERING WHEEL AND FORTUNATELY MADE THE TURN WITH OUT INCIDENT. I TAPPED THE FUEL PEDAL AND BOTH THE BRAKES AND STEERING ASSIST RETURNED TO NORMAL. I'VE HAD THE PROBLEM BEFORE WITH LOSS OF BRAKES BUT HAVE ALWAYS BEEN GOING STRAIGHT. I REPORT THIS TO THE DEALERSHIP BUT SINCE THE VEHICLE DOESN'T SHOW A ERROR CODE THEY CAN'T FIX IT! AT LEAST IF I DIE IN A CRASH THIS WILL BE MY RECORD. I WILL REPORT THE TRUCK AGAIN TO THE DEALER BUT THEY WONT FIX IT. I HAVE SEEN THAT OTHERS ARE EXPERIENCING ALSO. I WON'T LET MY WIFE DRIVE THE TRUCK IT IS NOT SAFE!!! THIS IS A DESIGN FLAW THE SYSTEM IS DRAWING FLUID FOR BOTH THE BRAKES AND STEERING FROM THE POWERSTEERING PUMP, ALSO I BELIEVE FROM WHAT I HAVE READ THE FLUID TRAVELS THRU A SCREEN(FILTER) WHICH CAN PLUG STARVING THE SYSTEM OF FLUID NEEDED TO PROPERLY OPERATE THE STEERING AND BRAKES. *TR

NHTSA ID

10551058

Incident

Sep 24, 2013

Mileage

92,000 mi

TL* THE CONTACT OWNS A 2008 FORD F-250 SD. THE CONTACT STATED THAT ALL FOUR TIRES SEIZED. IN ADDITION, THE VEHICLE PERFORMED AS IF THE BRAKE PEDAL WAS CONSTANTLY BEING DEPRESSED WHILE DRIVING. THE VEHICLE WAS TAKEN TO DEALER FOR DIAGNOSTIC TESTING, WHO CONFIRMED THAT THE BRAKES HAD SEIZED. THE DEALER LUBRICATED THE BRAKES WITH HEAVY GREASE AND REPLACED BOTH THE BRAKE PADS AND CALIPERS. THE FAILURE RECURRED. THE FAILURE WAS REPORTED TO THE MANUFACTURER. THE FAILURE MILEAGE WAS 18,000. THE CURRENT MILEAGE WAS 22,000. THE VIN WAS NOT AVAILABLE.

NHTSA ID

10515211

Incident

Mar 1, 2011

Mileage

18,000 mi

I WAS ON MY WAY TO THE BUILDING SUPPLY WITH THE TRUCK. I WAS TOWING A SMALL UTILITY TRAILER. AS I APPROACHED A FAIRLY SHARP CURVE I APPLIED THE BRAKES AND THE PEDAL WENT TO THE FLOOR. THE TRUCK BRAKES WERE GONE WITHOUT WARNING. THE TRAILER BRAKES LOCKED AND SLOWED THE VEHICLE ENOUGH TO GET SAFELY THROUGH THE TURN. I RELIED ON THE TRAILER BRAKES AND THE TRANSMISSION TO COMPLETE THE TRIP AND GET THE VEHICLE SAFELY HOME. WHEN I GOT HOME I CALLED THE DEALER AND HAD THE TRUCK TOWED THERE FOR REPAIR. THE DEALER SAID THAT THE FAILURE WAS DUE TO BADLY WORN BRAKE PADS CAUSING THE CALIPERS TO OVEREXTEND AND A CALIPER PISTON SEAL HAD FAILED. PADS ON ALL 4 WHEELS WERE BADLY WORN. IT WAS THE LEFT REAR CALIPER THAT FAILED. I DO NOT UNDERSTAND HOW THE BRAKES CAN BE THIS BADLY WORN AFTER ONLY 21,000 MILES.

NHTSA ID

10485463

Incident

Nov 9, 2012

Mileage

21,000 mi

AFTER A 10 MILE TRIP , GOT TO MY HOME AND REAR DRIVER BRAKE WAS SMOKING. I HAD CONTINUALLY COMPLAINED TO LOCAL FORD DEALERSHIP ABOUT EXCESSIVE HEAT I.E. YOU COULD HEAR CRACKLING AFTER PARKING THE VEHICLE. I BOUGHT A CENTEC HAND LASER HEAT TEMPERATURE LCD GUN AND DEMONSTRATED TO THE FORD SERVICE MANAGER THAT ALL DISCS HAD EXCESSIVE HEAT. THEY CLAIMED THEY SERVICED THE BRAKES. CONTINUALLY BLAMED THE NEW YORK WINTER AND SALT. SINCE I GOT MY LAST SERVICE SATISFACTION SURVEY SHORTLY AFTER THIS SMOKING INCIDENT, I WROTE THAT FORD SHOULD RECALL THESE TRUCKS FOR THIS PROBLEM SINCE THE DEALERSHIPS EITHER CANNOT FIX THE PROBLEM OR WAIT TILL THE WARRANTY IS UP(IS FORD ITSELF COVERING UP?) I REPLACED THE CALIPER MYSELF IN MY YARD SINCE I FELT IT WAS UNSAFE. THE PISTONS IN THESE CALIPERS FREEZE UP DUE TO A MANUFACTURER DEFECT. *TR

NHTSA ID

10478567

Incident

Aug 22, 2011

Mileage

26,000 mi

SLOWING DOWN TO EXIT HIGHWAY AND LOST ALL POWER STEERING AND POWER BRAKES AS IF THE TRUCK SHUT OFF, BUT IT WAS STILL RUNNING. *JS

NHTSA ID

10455488

Incident

Feb 22, 2012

Mileage

55,000 mi

TL* THE CONTACT OWNS A 2008 FORD F-250 SD. THE CONTACT WAS DRIVING 70 MPH WHEN SMOKE EMITTED FROM THE REAR DRIVER SIDE WHEEL. THE VEHICLE WAS TAKEN TO THE DEALER WHO DIAGNOSED THAT THE BRAKE CALIPERS WERE DEFECTIVE AND CAUSED THE BRAKE SYSTEM TO OVERHEAT. AS A RESULT, THE BRAKE ASSEMBLY HAD TO BE REPLACED. THE CONTACT MENTIONED HE HAD TO REPLACE THE BRAKE ASSEMBLY A TOTAL OF THREE TIMES. THE MANUFACTURER WAS NOT MADE AWARE OF THE RECURRING PROBLEM. THE FAILURE MILEAGE WAS 40,000 AND CURRENT MILEAGE WAS 50,000. UPDATED 10/5/11 *CN UPDATED 10/24/11

NHTSA ID

10420916

Incident

Aug 19, 2011

Mileage

40,000 mi

EVERYTIME I GET ON THE BRAKES HARD THE STEERING QUITS, CANNOT STEER 2008 F250, DIESEL, HARD ON BRAKES STEERING LOCKS IN DIRECTION YOU ARE GOING, HAPPENS EVERYTIME WITHOUT FAIL. *TR

NHTSA ID

10380906

Incident

Dec 10, 2010

Mileage

115,000 mi

IN APRIL 2010, MY 2008 FORD F-250 SUPER DUTY'S RIGHT FRONT BRAKE CALIPER FROZE, CAUSING THE BRAKES TO HEAT UP AND BEGIN SMOKING. THE FORD DEALERSHIP CLAIMED TO FIX THE PROBLEM IN APRIL, BUT IN JULY, THE SAME THING HAPPENED TO THE FRONT DRIVERS SIDE BRAKE (SMOKE BEGAN BILLOWING FROM THE WHEEL ON THE HIGHWAY). UPON INSPECTION, THE FORD MECHANIC FOUND ALL FOUR BRAKES ON THE TRUCK SEIZED, INCLUDING THE FRONT PASSENGER SIDE BRAKE AGAIN. THE MECHANIC STATED THAT HE SEES THE PROBLEM ALL THE TIME ON THE SUPER DUTY TRUCKS, BUT FORD MOTOR COMPANY REFUSED TO ACKNOWLEDGE THAT THERE IS A PROBLEM WITH THE BRAKE DESIGN ON ITS TRUCKS. SO FAR, THE BRAKES ON MY TRUCK HAVE SEIZED TWICE WITHIN A THREE MONTH SPAN, AND THE DEALERSHIP MORE OR LESS ASSURED ME IT WOULD HAPPEN AGAIN, AND THAT I WOULD NEED TO TAKE MY VEHICLE IN FOR AN EXPENSIVE BRAKE OVERHAUL EVERY TIME IT OCCURS. THIS FAULTY DESIGN NOT ONLY PRESENTS A FINANCIAL BURDEN BECAUSE OF COSTLY REPAIRS, BUT ALSO PUTS MY LIFE, AND MY FAMILY'S LIVES, AT RISK EVERY TIME I DRIVE THIS VEHICLE. *TR

NHTSA ID

10350028

Incident

Jul 2, 2010

Mileage

10,292 mi

TL* THE CONTACT OWNS A 2008 FORD F250 SD. THE CONTACT WAS REVERSING IN HER DRIVEWAY AND DEPRESSED THE BRAKE PEDAL AS IT FELL MUCH FARTHER INTO THE FLOORBOARD THAN USUAL. THE BRAKES DID NOT ENGAGE AND THE CONTACT UTILIZED THE EMERGENCY BRAKE TO STOP THE VEHICLE. THE VEHICLE WAS THEN TOWED TO AN AUTHORIZED DEALER WHERE IT WAS DISCOVERED THAT BRAKE FLUID WAS LEAKING. THE LEAK WAS CAUSED BY A FRACTURED CALIPER AND PISTONS. THE CALIPER AND PISTONS WERE REPLACED AS WELL AS BRAKE PADS AND ROTORS. THE MANUFACTURER WAS NOT CONTACTED. THE VIN WAS NOT AVAILABLE. THE FAILURE MILEAGE AND CURRENT MILEAGES WERE 33,000.

NHTSA ID

10347015

Incident

Aug 1, 2010

Mileage

33,000 mi

2008 FORD F250 CREW! WHERE DO I BEGIN? I'VE HAD THIS TRUCK IN MORE TIMES THAN I CAN COUNT! MOST RECENTLY FOR POWER STEERING ISSUES! I'M HAVING IT WORKED ON FOR THE THIRD TIME TODAY! ALONG WITH ANOTHER PROBLEM WITH THE FRONT DRIVE SHAFTS, WHICH IT HAS BEEN IN AT LEAST TWO OTHER TIMES FOR! THE POWER STEERING DOESN'T WORK AT LOWER SPEEDS WHEN TRYING TO MANEUVER AROUND OR EVEN WHEN TRYING TO TURN AROUND! YOU LITERALLY HAVE TO CRANK AS HARD AS YOU CAN TO GET IT TO TURN AND BEING A FAIRLY FIT 28 YEAR OLD CONSTRUCTION WORKER I SHOULDN'T HAVE TO WORK THAT HARD TO TURN THE WHEEL ON A TRUCK THAT HAS POWER STEERING! I JUST ABOUT RAMMED A LIGHT POLE WHILE OUT PLOWING AT ABOUT 15 MILES AN HOUR WITH MY 2 YEAR OLD RIDING IN THE BACK! THIS OF COURSE WAS BEFORE I HAD IT IN THE LAST TIME AND IT IS A LITTLE BETTER BUT THE PROBLEM PERSISTS AND I DON'T WANT TO BE DRIVING THIS TRUCK TRYING TO GET ONTO A ROADWAY WITH ANY OF MY FOUR CHILDREN WHEN IT DECIDES TO ACT UP AND GET HIT BY A MACK TRUCK! I HOPE SOMETHING CAN BE DONE WITH THIS AND HOPE TO HEAR BACK! THANK YOU!!! *TR

NHTSA ID

10262866

Incident

Feb 14, 2009

Mileage

30,000 mi

ON SEVERAL OCCASIONS WHILE APPLYING FOOT BRAKE PEDAL, FOOT ALSO DEPRESSES GAS PEDAL. THIS OCCURS MOSTLY WHEN HAVING TO STOP QUICKLY. CONDITION INCREASES STOPPING DISTANCE. CONDITION IS BAD WITH A STANDARD TRANSMISSION AND MUCH MORE SO WITH AN AUTOMATIC TRANSMISSION. SELLING DEALER AND ANOTHER DEALER IN TEXAS SAID THERE IS NO ADJUSTMENT. IN MY OPINION THERE IS A DESIGN PROBLEM THAT NEEDS TO BE CORRECTED. THIS IS A SAFETY HAZARD. *TR

NHTSA ID

10239694

Incident

Nov 15, 2007

Mileage

1,000 mi

TL*THE CONTACT OWNS A 2008 FORD F-250 SD. WHILE DRIVING 50 MPH, THE INSTRUMENT CLUSTER, TRACTION CONTROL SYSTEM, CRUISE CONTROL, AND AIR CONDITIONING FAILED. ALL OF THE GAUGES DISPLAYED ZERO. THE VEHICLE WOULD OPERATE, BUT NOTHING WOULD DISPLAY ON THE INSTRUMENT PANEL. THE VEHICLE WOULD ALSO STUTTER AND THEN THE GAUGES WOULD FUNCTION PROPERLY. THE VEHICLE HAS BEEN AT THE DEALER FOR TWO WEEKS AND THEY INFORMED THE CONTACT THAT THE INSTRUMENT CLUSTER WAS FAULTY AND WOULD BE REPLACED UNDER WARRANTY. THE CURRENT MILEAGE WAS 1,000 AND FAILURE MILEAGE WAS 10.

NHTSA ID

10219699

Incident

Feb 12, 2008

Mileage

10 mi

WHILE DRIVING APPLIED BRAKES FOR UPCOMING STOP LIGHT AND REAR BRAKES LOCKED UP CAUSING THE REAREND OF THE TRUCK TO HOP VIOLENTLY. TOOK TRUCK TO FORD DEALER AND THEY SAID THEY COULD FIND NOTHING WRONG. *TR

NHTSA ID

10214752

Incident

Dec 24, 2007

Mileage

4,700 mi