2008 Ford F-250 Sd Engine Problems

HAVE HAD NUMEROUS PROBLEMS WITH THE COOLING SYSTEM ON THIS VEHICLE. HAD THE AIR CHARGE COOLER REPLACED UNDER WARRANTY AT AROUND 70,000 MILES. THE RADIATOR WAS LEAKING AS WELL BUT DEALER REFUSED TO REPLACE IT AND WANTED 1400.00 TO REPLACE. WAS LOSING COOLANT AT A RATE OF ABOUT 1 GALLON A WEEK GOING THRU THE AIR CHARGE COOLER AND OUT THE EXHAUST. AT 89,000 MILES I HAD TO PAY $1947.00 TO REPLACE BOTH THE VERTICAL AND HORIZONAL EGR COOLERS. AGAIN, DUMPING A GALLON OF COOLANT INTO THE EXHAUST SYSTEM A WEEK CAUSING SEVER SMOKING AND POLLUTANTS. THIS IS A SERIOUS PROBLEM THAT THOUSANDS OR PROBABLY MILLIONS OF F-250 AND OTHERS WITH THE 6.4L DIESEL ENGINE. FORD REFUSED TO DO THE RIGHT THING AND DO A TOTAL RECALL ON THESE ILL DESIGNED TRUCKS. I CANNOT BELIEVE THEY HAVE BEEN ALLOWED TO GET AWAY WITH TURNING THEIR HEAD ON THIS DESIGN FLAW AND NOT MADE TO CORRECT THE AIR CHARGED COOLERS, PLASTIC RADIATORS AND THE EGR COOLERS.

NHTSA ID

11242558

Incident

Dec 3, 2012

TL* THE CONTACT OWNS A 2008 FORD F-250 SD. WHILE DRIVING, THE ENGINE FAILED TO RESPOND. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT THE ENGINE NEEDED TO BE REPLACED DUE TO A CRACK IN THE NUMBER EIGHT CYLINDER WALL. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTUER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 125,000.

NHTSA ID

10904538

Incident

Sep 7, 2016

Mileage

125,000 mi

I WAS BACKING UP IN THE PARKING AREA OF MY HOUSE IN MY 2008 F250 (DIESEL), AND APPLIED THE BRAKES TO STOP AND CHANGE DIRECTION. AS I STARTED BRAKING, THE ENGINE STARTED ACCELERATING, EVEN THOUGH I WAS APPLYING THE BRAKES. THE VEHICLE KEPT MOVING BACKWARD, AND I HAD TO STAND ON THE BRAKES AND SHIFT INTO NEUTRAL TO GET IT TO STOP MOVING BACKWARD. AFTER A FEW SECONDS THE PROBLEM STOPPED. I THEN CONTINUED ON MY WAY. THE VEHICLE HAD 37,060 MILES.

NHTSA ID

10822686

Incident

Jan 26, 2016

Mileage

37,060 mi

WE PURCHASED THIS 2008 FORD F-250 SUPER DUTY NEW AT THE FORD STORE IN SAN LEANDRO, CA ON JULY 21, 2007 AND CONTINUE TO BE THE ORIGINAL OWNERS. THIS VEHICLE IS EQUIPPED WITH A 6.4 TURBO-DIESEL ENGINE. THIS VEHICLE IS SUBJECT TO TSB 07-26-2 (WIRING HARNESS DEFECT ON HPFP) ISSUED AUGUST 2007. ON THE MORNING OF MARCH 27, 2015, WHILE ACCELERATING ONTO A FREEWAY AND AT AN APPROXIMATE SPEED OF 50 MPH, THE ENGINE SHUT DOWN WITHOUT ANY WARNING. I LOST ALL ACCELERATION AND THE ENGINE DIED. BRAKING AND STEERING WERE ALSO DIMINISHED. I GOT LUCKY AND WAS ABLE TO AVOID A COLLISION AND COAST TO THE SIDE OF THE ROAD WHERE THE VEHICLE WOULD NOT RESTART. THE VEHICLE WAS TOWED TO A LOCAL REPAIR SHOP (BUD ADAMS - CASTRO VALLEY, CA; BAR#:228593 CAL#:66801). DIAGNOSIS REVEALED A SHORT IN THE WIRING OF THE HIGH PRESSURE FUEL PUMP GASKET WIRING HARNESS (THE SUBJECT OF TSB 07-26-2 WHEREIN FORD RECOGNIZED ON OR ABOUT AUGUST OF 2007 A PROBLEM WITH UNPROTECTED WIRING WITHIN THE HPFP WIRING HARNESS). REPAIRS WERE EXTREMELY COSTLY ($3,791.89 REDUCED TO $2,591.89) BUT MORE IMPORTANTLY THIS INSTANTANEOUS FAILURE WITHOUT WARNING IS GOING TO CAUSE AN ACCIDENT, INJURY OR DEATH; IT IS ONLY A MATTER OF TIME. I GOT LUCKY. I SEE OTHER COMPLAINANTS WHO HAD HOURS STUCK IN THE DESERT, SOMEONE WITH A LOAD OF CATTLE STUCK WITHOUT WARNING, THE LIST GOES ON. IN EACH REPORTED INSTANCE THE OPERATOR DESCRIBED AN IMMEDIATE LOSS OF POWER PLANT WITH NO WARNING. I URGE THE NTSB TO INVESTIGATE THESE UNPLANNED SHUT DOWNS OF THIS VEHICLE'S POWER PLANT. UNDER CERTAIN CIRCUMSTANCES THIS MAY LEAD TO LOSS OF CONTROL OF THE VEHICLE, COLLISION, INJURY AND POSSIBLY DEATH. FORD HAS KNOWN ABOUT THIS ISSUE SINCE AUGUST OF 2007 YET HAS NOT ISSUED A RECALL. SOME MAY SAY THIS IS DUE TO THE LARGE COSTS INVOLVED TO REMOVE AND REPLACE THE HPFP GASKET AND WIRING HARNESS (IN PART INVOLVING THE REMOVAL OF THE VEHICLE'S CAB). *TR

NHTSA ID

10704582

Incident

Mar 27, 2015

Mileage

80,121 mi

TL* THE CONTACT OWNS A 2008 FORD F-250 SUPER DUTY. WHILE DRIVING 65 MPH, THE STEERING FAILED AS A LOUD ABNORMAL POP SOUND EMITTED FROM THE ENGINE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE ISSUE. THE APPROXIMATE FAILURE MILEAGE WAS 130,000. THE VIN WAS UNAVAILABLE. UPDATED 12/2/14*CN THE CONSUMER STATED THE BOLTS HOLDING THE STEERING BOX ON THE FRAME SHEARED OFF. UPDATED 01/08/15

NHTSA ID

10650840

Incident

Oct 27, 2014

Mileage

130,000 mi

2008 FORD F 250 SUPER DUTY DIESEL 6.4 ENGINE - ENGINE QUIT RUNNING WITH NO WARNING, WOULD NOT RESTART. WAS IN THE MIDDLE OF A LONG BRIDGE OVER THE MISSISSIPPI RIVER. THIS WAS A MAJOR INCONVENIENCE. HAD TO BE TOWED TO DEALER. TSB 07-26-2 WAS PERFORMED TO FIX THE KNOWN PROBLEM OF AN UNPROTECTED WIRE IN THE HIGH PRESSURE FUEL PUMP GASKET CHAFFING THROUGH. THIS WAS AN EXPENSIVE REPAIR SINCE THE CAB HAD TO BE REMOVED. A REVISED GASKET WITH PROTECTED WIRE WAS INSTALLED. LUCKILY I WAS NOT TOWING OUR 5TH WHEEL AT THE TIME. THIS IS A SERIOUS SAFETY RISK. FORD SHOULD RECALL AND COVER THE EXPENSE TO REPAIR AS THIS WAS A KNOWN DESIGN FLAW. *TR

NHTSA ID

10626903

Incident

Oct 7, 2013

Mileage

30,000 mi

2008 FORD F-250 SD DIESEL NO WARNING DRIVING 55 ON THE FREEWAY TOWING A TRAILER THE TRUCK SHUTS DOWN NO POWER. THIS IS THE 3RD TIME THIS TRUCK HAS SHUT DOWN ON THE FREEWAY WITH NO WARNING. HOW CAN FORD SELL THEIR CUSTOMERS A TRUCK AS WHAT ONE OTHER PERSON STATES: A $55,000.00 TRUCK THAT IS ADVERTISED TO BE SUPER DUTY AND SHOULD LAST 400000 TO 500000 MILES WITH ONLY MINER ENGINE REPAIRS, THIS SHOULD NOT BE HAPPENING. FORD KNOWS FOR A FACT THAT THEY HAVE A FAULTY MOTOR AND FAULTY INTERNAL PARTS ON ALL THE 2008 THRU 2010 6.4 L DIESEL MOTORS. THAT'S WHY THEY DESIGNED A NEW MOTOR AND ARE SUING NAVISTAR THE ENGINE DESIGNER. NOW YOU CAN GO ALL OVER THE INTERNET AND FIND THOUSANDS OF CUSTOMERS WITH THE SAME PROBLEMS AND MORE. THIS IS OUR SECOND TIME TO ENTER A COMPLAINT IN THE NHTSA (#10435125) DOES ANYTHING HAPPEN WITH THIS INFORMATION? *TR

NHTSA ID

10520802

Incident

Jun 15, 2013

Mileage

160,000 mi

ON NUMEROUS OCCASIONS MY 08 FORD F250 6.4 HAS HAD EXCESSIVE BLUISH WHITE SMOKE FROM THE EXHAUST WHILE DRIVING AND LASTS AROUND 20 SECONDS. DEALER WAS NOTIFIED AND SITUATION MET ALL CRITERIA OUTLINED IN TSB 11-2-2. CAC WAS REPLACED. HOWEVER, VEHICLE STILL INTERMITTENTLY HAS SAME PROBLEM. ON ONE OCCURRENCE THE SMOKE WAS SO EXCESSIVE THAT A MOTORCYCLE TRAVELING BEHIND ME ALMOST RAN OFF THE ROAD DUE TO VISIBILITY. FORD STATES THAT THIS IS NORMAL.

NHTSA ID

10512134

Incident

Jan 16, 2013

Mileage

55,666 mi

ON 2 OCT 2008, RADIATOR WAS DISCOVERED TO BE CRACKED AND LEAKING AT LEFT LOWER CORNER AT 6,240 MILES AND WAS REPLACED BY FORD UNDER 3YR/36000 WARRANTY. FORD INSTALLED DEGAS BOTTLE "T" FITTING TO ELIMINATE ANY FURTHER RADIATOR FAILURE. ON 12 MAR 2012, RADIATOR WAS DISCOVERED TO BE CRACKED AND LEAKING FROM LEFT LOWER CORNER AT 47,895 MILES. FORD SAID FAILURE WAS CAUSED DUE TO AN HYPER-EXTENDED THERMOSTAT. FORD REPLACED THERMOSTAT UNDER WARRANTY BUT WOULD NOT COVER RADIATOR UNDER WARRANTY. RADIATOR WAS REPLACED BY NON-FORD MECHANIC. ON 25 APR 2013 RADIATOR WAS DISCOVERED TO BE CRACKED AND LEAKING FROM RIGHT SIDE SEAM AT 58,520 MILES. FORD WAS CONTACTED AND OFFERED NO HELP OUTSIDE OF WARRANTY. RADIATOR WAS REPLACED BY NON-FORD MECHANIC OUTSIDE OF WARRANTY. IT DOESN'T TAKE A ROCKET SCIENTIST TO KNOW THERE IS SOMETHING SERIOUSLY WRONG WITH THE 08 F250 6.4 COOLING SYSTEMS THAT FORD FAILS TO TAKE RESPONSIBILITY FOR. I TOW A 35FT 5TH WHEEL SEVERAL TIMES A YEAR AND MY BIGGEST FEAR IS THE RADIATOR GOING OUT WHILE TOWING. IF THE RADIATOR BLEW AND THE TRUCK WENT INTO "REDUCED POWER" MODE, THERE IS A GREAT POSSIBILITY THAT A LIFE THREATENING INCIDENT COULD OCCUR, ESPECIALLY WHILE TOWING ON A STEP INCLINE. I HOPE FORD FIGURES THIS OUT SOON BEFORE SOMEONE GETS HURT.

NHTSA ID

10512136

Incident

Oct 2, 2008

Mileage

6,240 mi

CPSC# I1310184A. 2008 FORD F-250. CONSUMER STATED THAT HE HAS HAD NUMEROUS PROBLEMS WITH THE COOLING SYSTEM. STATED THE RADIATOR WAS LEAKING ALSO. *LN THE CONSUMER STATED HE WAS LOOSING A GALLON OF COOLANT A WEEK. IT WAS GOING THROUGH THE AIR CHARGE AND OUT THE EXHAUST. AT 89,000 MILES, HE HAD TO PAY $ 1947.00 TO REPLACE BOTH THE VERTICAL AND HORIZONTAL EGR COOLERS. AGAIN, DUMPING A GALLON OF COOLANT INTO THE EXHAUST SYSTEM A WEEK WHICH CAUSED SEVERE SMOKING.

NHTSA ID

10508006

Incident

Dec 3, 2012

TL* THE CONTACT OWNS A 2008 FORD F-250 SD. THE CONTACT STATED THAT WHILE DRIVING AT VARIOUS SPEEDS HE NOTICED THAT WHITE SMOKE WOULD EMIT FROM THE EXHAUST SYSTEM. THE CONTACT STATED THAT THE EXHAUST SYSTEM WAS EQUIPPED WITH A SELF-CLEANING FUNCTION HOWEVER, THE WHITE SMOKE STILL EMITTED AFTER THE FUNCTION WAS COMPLETED. THE VEHICLE WAS NOT TAKEN TO THE DEALER OR AN INDEPENDENT MECHANIC. THE MANUFACTURER WAS CONTACTED AND THEY OFFERED NO ASSISTANCE. THE FAILURE MILEAGE WAS APPROXIMATELY 179,000. THE CURRENT MILEAGE WAS APPROXIMATELY 180,000. THE VIN WAS UNAVAILABLE. *TR

NHTSA ID

10505223

Incident

Feb 1, 2013

Mileage

179,000 mi

EXHAUST LEAK FROM BEHIND THE TURBO. EXHAUST ENTERS THE INSIDE OF THE CAB. SEEMS TO BE A COMMON PROBLEM. EXPENSIVE TO FIX. MUST REMOVE CAB FROM FRAME TO REPAIR. HAZARDOUS FUMES ENTER VEHICLE CAUSING HEADACHES. DEALER IS ACTING LIKE THIS IS RARE BUT IN SEARCHING THE WEB I HAVE SEEN NUMEROUS COMPLAINTS OF THE SAME PROBLEM I AM HAVING. *TR ## VIN FAILED ##

NHTSA ID

10490351

Incident

Nov 21, 2012

Mileage

107,000 mi

TL* THE CONTACT OWNS A 2008 FORD F-250 SD. WHILE DRIVING APPROXIMATELY 50 MPH, THE TURBO ENGINE STALLED WITH AN ILLUMINATION OF A WARNING INDICATOR. THE VEHICLE BEGAN TO PERFORM ROUGHLY WITH SMOKE AND FLAMES EMITTING FROM THE EXHAUST. WHEN THE ENGINE WAS TURNED OFF THE FLAMES WERE NO LONGER VISIBLE. THE VEHICLE WAS TOWED TO AN AUTHORIZED DEALER WHO STATED THE TURBO CHARGER WOULD NEED TO BE REPLACED AND INCLUDING OTHER DEFECTIVE PARTS. THE FAILURE WAS RELATED TO THE RECALL ASSOCIATED WITH NHTSA CAMPAIGN ID NUMBER 07V139000 (POWER TRAIN: AUTOMATIC TRANSMISSION: CONTROL MODULE (TCM, PCM)). THE CONTACT EXPERIENCED THE IDENTICAL DEFECT AS STATED IN THE RECALL. THE MANUFACTURER WAS NOTIFIED AND THEY INFORMED THE CONTACT THAT THE VIN WAS NOT INCLUDED IN THE RECALL. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 70,000. UPDATED 11/01/12*LJ

NHTSA ID

10475851

Incident

Jul 11, 2012

Mileage

70,000 mi

I NOTICED THAT SOMETHING WAS DRIPPING FROM THE FRONT END OF MY TRUCK AND SUSPECTED THAT THE RADIATOR WAS LEAKING. I TOOK IT TO THE DEALERSHIP TO DIAGNOSE THE PROBLEM. I ALSO GAVE THEM SEVERAL TSBSS CONCERNING THE RADIATOR LEAK TO MAKE THEM AWARE THAT THIS IS A KNOWN PROBLEM TO FORD. OBVIOUSLY THEY CALLED ME BACK AND SAID THAT THE ENTIRE COOLING SYSTEM (RADIATOR, HOSES AND DEGAS BOTTLE) NEEDED REPLACEMENT, IT WASN'T UNDER WARRANTY AND I WOULD NEED TO PAY $1,776. I ONLY HAVE 39K MILES ON IT AND I NEVER THOUGHT THAT I WOULD BE REPLACING A RADIATOR THIS SOON. I HAVE ALWAYS BABIED THIS TRUCK AND MAINTAINED IT REGULARLY. I FEEL THAT FORD KNEW ABOUT THIS DESIGN FLAW AND SHOULD BE HELD ACCOUNTABLE FOR THE COSTS INCURRED BY ME TO REPAIR THE PROBLEM. WHO IS TO SAY THAT THIS MAY NOT OCCUR AGAIN DOWN THE ROAD? I HAVE READ THAT IT IS NOT UNCOMMON FOR TRUCKS NEEDING SEVERAL REPLACEMENT RADIATORS. IT'S CONCERNING TO ME THAT FORD CAN GET AWAY WITH THIS KIND OF DESIGN FLAW (OR SCAM) WITHOUT ANY REPERCUSSION FROM OUR GOVERNMENT. *TR

NHTSA ID

10464620

Incident

Jul 2, 2012

Mileage

39,000 mi

LIFTERS AND CAM HAVE FAILED. AND HAS TRASHED THE MOTOR. HAVE ASKED FOR HELP FROM FORD AND THEY HAVE DENIED CLAIM. THE PROBLEM WITH THIS IS THAT $55,000.00 TRUCK THAT IS ADVERTISED TO BE SUPER DUTY AND SHOULD LAST 400000 TO 500000 MILES WITH ONLY MINER ENGINE REPAIRS, THIS SHOULD NOT BE HAPPENING. FORD KNOWS FOR A FACT THAT THEY HAVE A FAULTY MOTOR AND FAULTY INTERNAL PARTS ON ALL THE 2008 THRU 2010 6.4 L DIESEL MOTORS. THAT'S WHY THEY DESIGNED A NEW MOTOR AND ARE SUING NAVISTAR THE ENGINE DESIGNER. NOW YOU CAN GO ALL OVER THE INTERNET AND FIND THOUSANDS OF CUSTOMERS WITH THE SAME PROBLEMS AND MORE. FORD KNOWS THAT THE LIFTERS WILL FAIL AT SOME PREMATURE POINT, AND THE ROCKER ARMS WILL BREAK. ONE OF THE PROBLEMS IS THAT THERE IS SO MUCH BACK PRESSURE ON THE MOTOR DUE TOO THE PARTICULATE FILTER. THAT HAS EVEN BEEN RE-DEIGNED IN THERE NEW 6.7 MOTOR. WHY IS THERE NOT A RECALL ON THIS MOTOR OR SOME KIND OF MANDATORY RETROFIT OR FINANCIAL AID TO FIX THESE PROBLEMS. ON ANOTHER NOTE I HAVE ALL MOST HAD A LEAST 8 HEAD ON COLLISIONS FROM LOST POWER DUE TO THE EGR COOLERS FAILING OR THE PARTICULATE FILTER CLOGGING UP. THIS IS A COMMON PROBLEM WITH THIS ENGINE ALSO YOU CAN BE IN GREAT DANGER WHEN TRYING TO PASS SOMEONE. I HOPE TO HEAR FROM SOME ONE SOON.. THANK YOU IN THIS MATTER. HOW CAN FORD TURN THEIR BACKS ON LOYAL AMERICANS.......

NHTSA ID

10461797

Incident

May 10, 2012

Mileage

128,000 mi

1/1/10 ISN'T THE FIRST SMOG-OUT, BUT DEFINITELY THE WORST & MOST DANGEROUS. WHILE DECENDING FROM THE TOP OF THE MOUNTAIN IN GATLINBURG IN BUMPER TO BUMPER TRAFFIC WHERE IT TOOK 45-60 MINS TO GO 2 MILES, THE EXHAUST CLEANING WAS BLOWING SUFFOCATING AND BLINDING BLUE SMOKE CONTINUOUSLY. THEN GOING THROUGH TOWN WHERE PEOPLE ARE WALKING UP & DOWN BESIDE THE ROAD (STILL IN BUMPER TO BUMPER TRAFFIC) IT WAS STILL SMOGGING THE PEOPLE WALKING AND PEOPLE DRIVING BEHIND ME COULD NOT SEE. IF A MOTORCYCLE OR PERSON ENDED UP BESIDE US WHEN WE HAD TO STOP FOR TRAFFIC LIGHTS, THEY WOULD HAVE BEEN SEVERELY BURNED. IT CONTINUED TO CLEAN DOWN TO PIGEON FORGE FOR A TOTAL OF 1-1/2 TO 2 HOURS. FORD ENGINEER WAS SUPPOSED TO RECALIBRATE TO MAKE SURE IT DIDN'T CLEAN IF UNDER 35 MPH, BUT IT DOES IT ALL THE TIME, SOMETIMES DAY AFTER DAY FOR HOURS. *TR

NHTSA ID

10434350

Incident

Jan 2, 2010

Mileage

20,000 mi

LEAKING RADIATOR THAT IS A $1,200 REPAIR. *KB

NHTSA ID

10419802

Incident

Aug 5, 2011

Mileage

64,000 mi

I CAME HOME FROM WORK, SHUT MY VEHICLE OFF, CLIMBED OUT AND NOTICED THAT SOMETHING WAS DRIPPING FROM THE FRONT END. GOT UNDER AND FOUND THAT THE RADIATOR WAS LEAKING AND AT A PRETTY GOOD RATE. I CALLED THE DEALERSHIP TO ASK DETAILS ABOUT IT AND AGREED TO DROP IT OFF THE NEXT DAY. I HAD TO REFERENCE THEM TO A TSB 09-23-1 CONCERNING THE RADIATOR LEAK DUE TO A HYPER EXTENDED THERMOSTAT. A COUPLE OF DAYS LATER I GET A CALL AND WAS TOLD THAT THE THERMOSTAT "SEEMS" TO BE FINE AND THAT I WOULD HAVE TO BEAR THE COST OF THE RADIATOR REPLACEMENT AT $1400. FORD REPLACED THESE RADIATORS IN JOB 1 TRUCKS IF THEY WERE LEAKING AT THE TIME THE VENTURI TEE WAS BEING INSTALLED IN THE COOLING SYSTEM. I HAD THE RECALL DONE BUT IT WASN'T LEAKING AT THE TIME. I HAVE 37K MILES ON IT. I'VE NEVER OVER HEATED IT, OVER SPED IT AND I TAKE CARE OF MY VEHICLE. THE FORD DEALERSHIP IS TELLING ME THAT IF THEY REPLACED THE PARTS, SENT THEM TO FORD AND FORD FOUND THEY WERE STILL GOOD, I WOULD THEN GET BILLED BACK LATER. AS OF RIGHT NOW, I HAVE NOT HAD THEM CONTINUE WITH THE WORK ON THE TRUCK. THE MAIN REASON IS BECAUSE THAT IS A COSTLY REPAIR AND I FEEL THAT FORD SHOULD COVER THIS KNOWING IT'S A PROBLEM. THERE WAS A RECALL AS I STATED EARLIER, AND AT LEAST 2 TSB'S STATING THAT THEY KNOW IT'S A PROBLEM. IT'S DISAPPOINTING THAT FORD IS STICKING IT TO PEOPLE LIKE ME FOR A DEFECTIVE PART. IT'S CRACKED AND NO ONE CAN TELL ME HOW IT CRACKED. WHEN ASKED, THE SERVICE MANAGER STATED, "THAT'S THE MILLION DOLLAR QUESTION." WHAT MAKES THIS EVEN WORSE, I'M ACTIVE DUTY MILITARY AND AM PREPARING FOR A DUTY STATION MOVE IN AUGUST. I BOUGHT THE VEHICLE TO TOW MY RV AND FAMILY OF 5, NOT FOR IT TO BREAK AND NO APPARENT REASON FOR IT BESIDES THE DEFECTIVE PART THAT FORD KNOWS ABOUT. *TR

NHTSA ID

10408738

Incident

Jun 21, 2011

Mileage

37,064 mi

TL* THE CONTACT OWNS A 2008 FORD F250 SUPER DUTY. THE CONTACT STATED THAT THE VEHICLE WOULD LOSE POWER WHILE DRIVING UP AN INCLINE OR SPORADICALLY AT ANY SPEED. THE VEHICLE WAS TAKEN TO THE DEALER WHO PERFORMED A DIAGNOSTIC AND TEST DROVE THE VEHICLE, BUT WAS UNABLE TO DUPLICATE THE FAILURE. THE DEALER REPLACED THE EXHAUST SENSOR AND THE INSTRUMENT PANEL CLUSTER BUT THE FAILURE WAS NOT CORRECTED. THE MANUFACTURER WAS CONTACTED AND A CLAIM WAS FILED. THE FAILURE MILEAGE WAS 29,000 AND THE CURRENT MILEAGE WAS 33,000.

NHTSA ID

10407754

Incident

May 1, 2011

Mileage

29,000 mi

2008 FORD F250 DIESEL 6.4L RADIATOR LEAKS. FORD BLAMES THIS ON T-STATS AND VENTURI TEE'S BUT IT IS CLEARLY A MANUFACTURING DEFECT. THERE ARE SO MANY PEOPLE THAT HAVE HAD THIS PROBLEM. FORD CONTINUES TO BURY THEIR HEAD IN THE SAND. EITHER NHTSA NEEDS TO GET INVOLVED OR A CLASS ACTION LAWSUIT SHOULD BRING THIS TO THE FOREFRONT. *TR

NHTSA ID

10400575

Incident

Nov 10, 2010

Mileage

60,000 mi

RE-OCCURRING PROBLEM WITH MY 2008 FORD F-250. THE TRUCK UPON ACCELERATION SURGES AT 2800-3000 RPM'S AND BLOWS WHITE SMOKE OUT OF THE EXHAUST PIPE. THIS ONLY HAPPENS DURING HIGH HUMID, OR RAINY DAYS, OR WHILE THE TRUCK IS OPERATING IN A STEADY STATE OF DRIVING FOR SEVERAL HOURS. IF YOU PULL OFF THE FREEWAY, AND THEN TRY TO ACCELERATE ON THE ENTRANCE RAMP THE TRUCK STUMBLES AND LOOSES ACCELERATION. I HAVE HAD THE TRUCK IN THE DEALER SEVERAL TIMES TO TRY TO FIND THE PROBLEM, BUT THEY WERE NOT SUCCESSFUL. THERE ARE NO CODES BEING DISPLAYED IN THE COMPUTER. THIS IS GOING TO CAUSE SOMEBODY TO GET RUN OVER TRYING TO ENTER THE FREEWAYS. FORD IS NOT TRYING TO SOLVE THE PROBLEMS EITHER. *TR

NHTSA ID

10386577

Incident

Mar 5, 2011

Mileage

85,000 mi

NOTICED A COOLANT LEAK COMING OFF THE DRIVER SIDE FRAME RAIL UNDER THE HOOD. TOOK IT IN TO THE FORD DEALERSHIP AND THEY HAD TO REPLACE THE RADIATOR. $1,400 LATER THEY SAID IF I HAD A HYPER EXTENDED THERMOSTAT IT WOULD BE FREE AS THAT IS WHAT FORD BELIEVES IS CAUSING THE PROBLEM. WELL OBVIOUSLY ITS NOT WHAT IS CAUSING THE PROBLEM SINCE THERE ARE HUNDREDS OF PEOPLE WITH THE SAME PROBLEM.

NHTSA ID

10377310

Incident

Jan 6, 2011

Mileage

22,850 mi

RADIATOR COOLANT LEAK AT TANK SEAM. *TR

NHTSA ID

10375494

Incident

Nov 1, 2009

Mileage

62,500 mi

2008 FORD F-250. RADIATOR LEAKING. DEALER STATES TO FORD CUSTOMER SERVICE THAT THEY FOUND A LEAK IN APRIL OF 2010. THEY NEVER INFORMED ME OF IT HOWEVER. IN APRIL THE VEHICLE WAS STILL UNDER THE 36,000 MI. WARRANTY. I FIRST NOTICED THE LEAK AROUND THE LAST OF NOVEMBER 2010 AND BY THEN THE VEHICLE WAS AT 46,000 MI. AND OUT OF WARRANTY. MY DEALER TELLS ME THEY AND FORD ARE AWARE THAT THERE IS A PROBLEM WITH THESE RADIATORS BUT FORD HAS YET TO ISSUE A RECALL. DEALER WONT INCUR ANY OF THE COST FOR REPAIRS AND FORD WONT OFFER ANY ASSISTANCE EITHER. *TR

NHTSA ID

10374994

Incident

Nov 25, 2010

Mileage

46,000 mi

2008 F250 SUPER DUTY DIESEL EXPLODED (NEIGHBORS' DESCRIPTION) WHILE PARKED. WE HAD JUST RETURNED FROM TOWING A SKID LOADER BACK FROM A JOB SITE AND APPROXIMATELY HALF AN HOUR LATER, NEIGHBORS CALLED TO SAY THAT OUR TRUCK HAD EXPLODED. THE FIRE DEPT WAS ON THE SCENE WHEN WE ARRIVED AND THE VEHICLE APPEARS TO BE A TOTAL LOSS. WE HAD OWNED AND USED THE TRUCK FOR 9 DAYS AND IT HAD PERFORMED WITHOUT PROBLEM DURING THAT TIME WHICH INCLUDED A 400 MILE TRIP FROM THE POINT OF PURCHASE IN PA TO OUR HOME LOCATION IN COLUMBUS OH. NO DAMAGE TO PROPERTY OTHER THAN TO THE VEHICLE ITSELF. *TR

NHTSA ID

10370331

Incident

Dec 11, 2010

Mileage

191,550 mi