1996 Ford F-250 Owner Complaints

Cruise control switch began smoking, disconnected it and took it to Awesome Ford of Chehalis, WA for recall service sometime in June or July. Service tech found that brake fluid had wicked its way up electrical harness into cruise control servo, necessitating replacement in order to complete recall service. FoMoCo has been unable/unwilling to replace cruise control servo and is instead requiring that I pull one from a wrecking yard in order to complete recall service.

NHTSA ID

11543544

Incident

Sep 5, 2023

A MALFUNCTIONING CHECK VALVE WITHIN THE FUEL PUMP ASSEMBLY CAUSES A PORTION OF THE UNUSED FUEL FROM ONE TANK TO BE RETURNED TO THE SECOND TANK. WHEN THIS OCCURS, THE CAPACITY OF THE SECOND TANK CAN BE EXCEEDED, CAUSING FUEL SPILLAGE. ABOUT 5 GALLONS OF FUEL SPILLED OUT OF FILL TUBE.

NHTSA ID

11469663

Incident

May 30, 2022

FUEL RUNNING OUT FOUNT TANK IN DRIVEWAY WITH SELECTOR ON REAR TANK

NHTSA ID

11196563

Incident

Apr 10, 2019

Mileage

17,068 mi

EXCESS FUEL FROM REAR TANK IS RETURNED TO FRONT TANK CAUSING FUEL OVERFILL AND FUEL LEAK.

NHTSA ID

11024911

Incident

Sep 20, 2017

Mileage

125,000 mi

FRONT FUEL TANK STOPPED WORKING. VEHICLE RUNS USING REAR FUEL TANK. IF I TAKE OFF THE FRONT TANK FUEL CAP, GAS POURS OUT SOMETIMES SPRAYS ( ABOUT 8 OUNCES OR SO) . FRONT FUEL TANK SEEMS TO BECOME PRESSURIZED. THIS CAN HAPPEN EVERY TIME YOU DRIVE IT ( IF YOU REMOVE THE FRONT CAP). IN MY OPINION THIS IS A DEFINITE SAFETY HAZARD THAT NEEDS TO BE ADDRESSED. I DID SOME SEARCHES ON THE INTERNET AND THIS PROBLEM IS QUITE COMMON. BIG FIRE HAZARD.

NHTSA ID

10837715

Incident

Jan 2, 2016

Mileage

231,000 mi

TL* THE CONTACT OWNS A 1996 FORD F-250 EQUIPPED WITH UNIROYAL LAREDO TIRES, SIZE: 265/75R16 (NA). WHILE MAKING A RIGHT TURN AT APPROXIMATELY 50 MPH, THE FRONT PASSENGER SIDE TIRE RUPTURED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS CONFIRMED THAT THE TREAD SEPARATED AND THE TIRE NEEDED TO BE REPLACED. THE TIRE WAS REPLACED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE VEHICLE FAILURE MILEAGE WAS 185,000 AND THE TIRE FAILURE MILEAGE WAS 15,000. THE DOT NUMBER WAS UNAVAILABLE.

NHTSA ID

10794901

Incident

Jul 10, 2015

Mileage

185,000 mi

FUEL SPILLS FROM REAR TANK WHEN FUELING FRONT TANK. ENGINE SPUTTERS AND QUITS WHILE RUNNING DUE TO FUEL PRESSURE FAILURE..

NHTSA ID

10766371

Incident

Mar 25, 2015

Mileage

170,000 mi

THIS IS NOT A COMPLAINT BUT TO LET EVERYONE KNOW WHAT I HAVE FOUND TO BE PART OF THE PROBLEM ON THE STEERING NOT RETURNING AFTER A TURN. THE STEERING COLUMN BEARING IN THE TOP OF THE COLUMN IS BAD. I HAVE HAD TO REPLACE AT LEAST 20 OF THESE FOR THIS COMPLAINT AND FIXED THE PROBLEM. THE LOCKING OF THE STEERING WHEN BREAKING IS A HYDROBOOST PROBLEM NOT A STEERING PROBLEM. FORD NEED TO RESEARCH THIS AND CORRECT IT BEFORE THERE IS A DEATH BECAUSE OF IT. *TR

NHTSA ID

10668218

Incident

Dec 25, 2014

Mileage

300,000 mi

TL* THE CONTACT OWNS A 1996 FORD F250. THE CONTACT STATED THE VEHICLE WAS OFF AND THE KEY WAS OUT OF THE IGNITION WHEN THE VEHICLE CAUGHT ON FIRE. THE FIRE DEPARTMENT WAS CALLED TO EXTINGUISH THE FIRE WHO STATED THAT THE FIRE STARTED UNDER THE HOOD FROM A WIRE. THE VEHICLE WAS DESTROYED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS UNAVAILABLE.

NHTSA ID

10648731

Incident

Oct 16, 2014

TL* THE CONTACT OWNS A 1996 FORD F-250. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 70 MPH, THE DRIVERS SEAT RECLINED INDEPENDENTLY. THE CONTACT WAS A LICENSED MECHANIC WHO STATED THAT THE BOLTS THAT HOLD THE SEAT UPRIGHT WERE BROKEN. THE MANUFACTURER WAS NOT NOTIFIED OF THE DEFECT. THE APPROXIMATE FAILURE MILEAGE WAS 110,000.

NHTSA ID

10593652

Incident

May 22, 2014

Mileage

110,000 mi

TL* THE CONTACT OWNS A 1996 FORD F-250. THE CONTACT STATED THAT HE WAS REPLACING THE GLOW PLUGS WHEN THE VEHICLE SUDDENLY CAUGHT ON FIRE. THE CONTACT WAS ABLE TO EXTINGUISH THE FIRE. THE MANUFACTURER WAS CONTACTED AND THE CONTACT REFERENCED NHTSA CAMPAIGN NUMBER: 06V286000 (VEHICLE SPEED CONTROL). THE CONTACT LATER RECEIVED A CALL FROM THE MANUFACTURER'S LEGAL TEAM, WHO ADVISED THAT THE FIRE WAS NOT RELATED TO THE RECALL. THE CONTACT STATED THAT THE MANUFACTURER NEVER INSPECTED THE VEHICLE TO MAKE THAT DETERMINATION. THE VEHICLE WAS REPAIRED. THE FAILURE MILEAGE WAS 200,000.

NHTSA ID

10584057

Incident

Apr 21, 2010

Mileage

200,000 mi

TL* THE CONTACT OWNS A 1996 FORD F-250. THE CONTACT STATED THAT THE VEHICLE WAS SITTING IN A RESIDENTIAL DRIVE WAY WHEN IT CAUGHT ON FIRE. THE FIRE DEPARTMENT EXTINGUISHED THE FIRE AND DETERMINED THAT THE SPEED CONTROL DEACTIVATION SWITCH WAS THE CULPRIT. THE VEHICLE WAS DESTROYED. THE CONTACT SPOKE WITH THE MANUFACTURER IN REGARD TO NHTSA CAMPAIGN ID NUMBER: 06V286000 (VEHICLE SPEED CONTROL), BUT WAS TOLD THAT THE VEHICLE WAS NOT INCLUDED IN THE RECALL. THE FAILURE AND THE CURRENT MILEAGES WERE 150,000. *TR

NHTSA ID

10522089

Incident

Jun 26, 2013

Mileage

150,000 mi

TL* THE CONTACT OWNS A 1996 FORD F-250. THE CONTACT STATED THAT THE CROSS MEMBER, WHICH HELD THE REAR OF THE FUEL TANK WAS CORRODED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE CONTACT REFERENCED NHTSA CAMPAIGN ID NUMBER: 96V146000 (STRUCTURE) THAT BUT WAS ADVISED BY THE MANUFACTURER THAT THE VIN WAS NOT INCLUDED IN THE RECALL. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 96,000. *TR

NHTSA ID

10499660

Incident

Feb 15, 2013

Mileage

96,000 mi

TWO OUT OF FOUR KUMHO TIRES HAVE FAILED WITH A THIRD ONE ON ADVISEMENT IN POOR CONDITION. ONE TIRE SEPARATED IN HIGHWAY TRAFFIC AT HIGHWAY VELOCITY. EXTENSIVE DAMAGE TO VEHICLE, BODY AND FUEL SYSTEM. VERBALLY AND IN WRITING I ASKED FOR AN INVESTIGATION INTO THIS MATTER WITH NO ACTION BEING TAKEN. I HAVE MAINTENANCE LOGS, RECEIPTS, PICTURES, ESTIMATES AND ALL EMAIL CORRESPONDENCES FOR YOUR REVIEW. *TR ON SEPTEMBER 10, 2010, UPON A VISUAL INSPECTION, THE CONSUMER NOTICED THE RIGHT REAR TIRE WAS GETTING READY TO SEPARATE. SO, HE REPLACED IT WITH ONLY 15, 979 MILES ON THE VEHICLE. ON SEPTEMBER 25, 2012, THE LEFT REAR TIRE SEPARATED AT HIGHWAY SPEED WITH 22,642.6 MILES ON THE TIRE, THE APPROXIMATE TREAD WAS 7/32. UPDATED IVOQ 11/19/12

NHTSA ID

10481090

Incident

Sep 9, 2010

Mileage

126,881 mi

TL* THE CONTACT OWNS A 1996 FORD F-250 DIESEL. THE CONTACT STATED THAT WHILE DRIVING, AN ODOR OF BURNING PLASTIC BURNING WAS EMITTED INTO THE VEHICLE. THE VEHICLE WAS TAKEN TO A LOCAL MECHANIC WHO DIAGNOSED THAT THE CRUISE CONTROL BURNED A HOLE IN THE BRAKE FLUID RESERVOIR. AS A RESULT, THE CRUISE CONTROL LINES AND THE BRAKE FLUID NEEDED TO BE REPLACED. IN ADDITION, THE BRAKES WERE NOT RESPONDING PROPERLY. THE VEHICLE WAS THEN TAKEN TO THE DEALER WHO DIAGNOSED THAT THE BRAKE BOOSTER NEEDED TO BE REPLACED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 183,628 AND THE CURRENT MILEAGE WAS 186,000.

NHTSA ID

10432898

Incident

Aug 7, 2011

Mileage

183,628 mi

TL*THE CONTACT OWNS A 1996 FORD F250 DIESEL. THE CONTACT STATED THE STEERING COLUMN BECAME VERY LOOSE WHILE DRIVING. THE VEHICLE WAS NOT TAKEN TO THE DEALER FOR DIAGNOSTIC TESTING. THE FAILURE MILEAGE WAS 77,600.

NHTSA ID

10399114

Incident

Apr 8, 2011

Mileage

77,600 mi

TL* THE CONTACT OWNS A 1996 FORD F250 DIESEL. THE CONTACT WAS ENTERING A RESIDENTIAL PARKING GARAGE WHEN THE STEERING WHEEL COMPLETELY FRACTURED FROM THE VEHICLE. THE CONTACT WAS ABLE TO MAINTAIN CONTROL OF THE VEHICLE AND ENGAGED THE EMERGENCY BRAKE TO BRING IT TO A STOP. THE VEHICLE WAS TOWED TO A LOCAL REPAIR SHOP WHERE THE MECHANIC DIAGNOSED THE FAILURE AS A WEAK STEERING COLUMN WHICH WOULD REQUIRE REPLACING. THE MANUFACTURER WAS CONTACTED AND OFFERED NO ASSISTANCE. THE VEHICLE WAS REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 263,000.

NHTSA ID

10386991

Incident

Feb 22, 2011

Mileage

263,000 mi

1996 FORD, F250, 7.3 LITER DIESEL: HIGH PRESSURE POWER STEERING HOSE FAILED AT CONNECTION TO THE POWER STEERING PUMP. THE FAILURE OCCURRED WHEN BACKING OUT OF A PARKING SPACE. THE CAUSE OF THE FAILURE IS DUE TO FAILURE OF AN INTERNAL PLASTIC COMPONENT THAT CONNECTS THE TUBING TO THE CONNECTING NUT/FITTING. REPLACED WITH A FABRICATED HYDRAULIC HOSE THAT DID NOT HAVE ANY INTERNAL PLASTIC COMPONENTS. *TR

NHTSA ID

10366654

Incident

Nov 17, 2010

Mileage

80,280 mi

TL* THE CONTACT OWNS A 1996 FORD F-250. THE CONTACT STATED THAT WHILE THE VEHICLE WAS PARKED NEXT TO THE GARAGE THE VEHICLE IGNITED INTO FLAMES. THE VEHICLE BURNED DOWN THE ENTIRE GARAGE AND DID PARTIAL FIRE DAMAGE TO THE HOUSE. THE CONTACT HAS NOT CALLED THE MANUFACTURER REGARDING THE FIRE. THE CONTACT NOTICE NUMEROUS COMPLAINTS REGARDING FIRES FOR THIS YEAR MAKE AND MODEL. THE CONTACT HAD THE VEHICLE REPAIRED UNDER A MANUFACTURERS RECALL YEARS PRIOR TO THE FAILURE FOR THE CRUISE CONTROL WHERE THE DEALER REPLACED A WIRING HARNESS THAT COULD CAUSE A FIRE. THE CONTACT STATED SOMEONE COULD HAVE LOST THEIR LIFE DUE TO THE FIRE. THE FAILURE MILEAGE WAS 158,000.

NHTSA ID

10365720

Incident

Oct 9, 2010

Mileage

158,000 mi

TL* THE CONTACT OWNS A 1996 FORD F250. HIS VEHICLE CAUGHT ON FIRE WHILE HE WAS MAKING REPAIRS TO THE ENGINE. THE FIRE SPREAD TO THE WIRING HARNESS AND BURNED THE HIGH PRESSURE OIL LINE. HE HAD TO DISCONNECT THE BATTERIES. THE FORD MANUFACTURER WAS NOTIFIED OF THE FAILURE. FORDS LEGAL DEPARTMENT SENT A LETTER DENYING RESPONSIBILITY , BECAUSE THE VEHICLE WAS NOT REPAIRED BY A FORD DEALER. THE FAILURE MILEAGE WAS 210,000.

NHTSA ID

10295252

Incident

Nov 5, 2009

Mileage

210,000 mi

A MALFUNCTIONING CHECK VALVE WITHIN THE FUEL PUMP ASSEMBLY CAUSES A PORTION OF THE UNUSED FUEL FROM ONE TANK TO BE RETURNED TO THE SECOND TANK. WHEN THIS OCCURS, THE CAPACITY OF THE SECOND TANK CAN BE EXCEEDED, CAUSING FUEL SPILLAGE. *TR

NHTSA ID

10289346

Incident

Oct 20, 2009

Mileage

176,489 mi

FORD F250 1996 BRAKE CYLINDER LEAK FIRE. *TR

NHTSA ID

10285108

Incident

Sep 5, 2009

Mileage

141,000 mi

TL* THE CONTACT OWNS A 1996 FORD F250. THE CONTACT STATED THAT DURING DECELERATION, SHIFTING INTO REVERSE, OR WHILE IN IDLE THE VEHICLE INTERMITTENTLY STALLED. THE MANUFACTURER WAS NOTIFIED IN REFERENCE TO RECALL# 07V553000, ENGINE AND ENGINE COOLING, ENGINE, DIESEL WHO CONFIRMED THAT HIS VIN WAS EXCLUDED. NO REPAIRS HAVE BEEN MADE. THE VEHICLE IDENTIFICATION NUMBER WAS UNAVAILABLE. THE FAILURE MILEAGE WAS 360,000 AND THE CURRENT MILEAGE WAS UNKNOWN. UPDATED 10/06/09 *BF UPDATED 10/08/09

NHTSA ID

10283633

Incident

Sep 1, 2008

Mileage

360,000 mi

I HAVE A 1996 FORD F250 7.3 LITER DIESEL TRUCK. IT STALLS ON OCCASION AT LOW SPEEDS WHICH I FEEL IS A SAFETY ISSUE. I FOUND OUT THAT FORD HAD A RECALL ON 1997 AND NEWER TRUCKS BECAUSE OF THE CAM POSITION SENSOR. EVERYTHING I COULD FIND OUT ABOUT MY PROBLEM IS THE SAME. THE CPS UNIT CAUSES THIS PROBLEM. I FEEL FORD SHOULD REPLACE MY CPS UNIT AS WELL. *TR

NHTSA ID

10246189

Incident

Sep 15, 2008

Mileage

100,000 mi

TL*THE CONTACT OWNS A 1996 FORD F250. THE CONTACT STATED THAT THE CAM POSITION SENSOR FAILED WITHOUT WARNING AND THE MOTOR FAILED AS WELL. THE SENSOR IS LOCATED ON THE LOWER FRONT END OF THE MOTOR OF THE VEHICLE. THE CONTACT STATED THAT THE VEHICLE WOULD SHUT OFF WITHOUT WARNING WHILE DRIVING VARIOUS SPEEDS. HE CALLED THE FORD MANUFACTURER AND THEY STATED THAT THEY HAVE BEEN AWARE OF THE ISSUE SINCE 1996, BUT HAS DONE NOTHING TO CORRECT THE FAILURE. THE FAILURE MILEAGE WAS 102,000. UPDATE 09/10/08 *CW THE CAM SHAFT POSITION SENSOR WAS THE CAUSE OF THE ENGINE STALLING. UPDATED 09/16/08 *JB

NHTSA ID

10234866

Incident

Jul 18, 2006

Mileage

102,000 mi