1999 Ford F-250 Powertrain (other) Problems

TL* THE CONTACT OWNS A 1999 FORD F-250. AFTER THE VEHICLE WAS PLACED INTO THE PARK POSITION, IT INDEPENDENTLY ROLLED BACKWARDS WITHOUT WARNING. THE PASSENGER WAS ABLE TO STOP THE VEHICLE. THE CONTACT DISCOVERED THAT THE VEHICLE INADVERTENTLY SWITCHED INTO THE REVERSE POSITION. AS A RESULT, THE CONTACT WAS KNOCKED DOWN AND SUSTAINED INJURIES THAT REQUIRED MEDICAL ATTENTION. A POLICE REPORT WAS FILED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 245,000. ....UPDATED 07/05/16 *BF THE CONSUMER STATED HE EXITED THE VEHICLE AND WALKED TO THE REAR OF THE VEHICLE. THE VEHICLE SOMEHOW WENT INTO REVERSE, WHILE THE DOOR WAS STILL OPEN. UPDATED 07/21/16.*JB

NHTSA ID

10864577

Incident

Jan 15, 2016

Mileage

245,000 mi

1999 FORD F-250 WITH TRANSMISSION PROBLEMS. CONSUMER HAD THIS PROBLEM REPAIRED. SHE WAS THEN INFORMED THAT THERE WAS A TSB THAT SHE NEVER KNEW ABOUT. FORD IS REFUSING TO REIMBURSE HER FOR THE REPAIRS. *KB THE CONSUMER STATED THE MANUFACTURER WAS FULLY AWARE OF THE TRANSMISSION PROBLEM, BUT FAILED TO NOTIFY THEIR CUSTOMERS. THE PROBLEM WAS THE FLUID WOULD OVERHEAT DURING SEVERE DUTY AND WEAR OUT THE TORQUE CONVERTER, WHICH RESULTED IN THE RADIATOR, COOLER LINES AND HOSES FOR THE TRANSMISSION TO BE REPLACED. THE STABILIZER BAR LINK AND BATTERY WERE REPLACED. *JB

NHTSA ID

10207129

Incident

Oct 1, 2007

PROBLEMS WITH BRAKE EQUIPMENT/ VEHICLE SHOOK VIOLENTLY WHEN BRAKES WERE APPLIED. *MR THE VEHICLE HAD BEEN TO THE DEALER FIVE TIMES, AND EACH TIME THE CONSUMER WAS INFORMED THE PROBLEM WAS RESOLVED. AFTER THE SECOND REPAIR, THE WARRANTY HAD EXPIRED SO THE CONSUMER HAD TO PAY FOR THE REPAIRS. FINALLY, THE CONSUMER TOOK THE VEHICLE TO HIS PERSONAL MECHANIC WHO STATED THE PROBLEMS THE VEHICLE EXPERIENCED WAS CAUSED BY A FRONT SEAL LEAKAGE ON THE RIGHT AXLE. IN ADDITION, THE MECHANIC STATED WHEN THE GREASE LEAKED ONTO THE ROTOR, IT BECAME HOT AND WARPED THE ROTOR WHICH CAUSED THE VIBRATION. CONSUMER WANTED NEW ROTORS, CALIPERS, AND SEALS ON BOTH FRONT WHEELS AT NO COST TO HIM. HE ALSO WANTED TO BE REIMBURSED FOR THE THREE OUT OF POCKET REPAIRS. *PH *JB

NHTSA ID

10022276

Mileage

25,000 mi

AXEL ASSEMBLY APPEARS TO HAVE BEEN DEVOID OF LUBRICANT SINCE MANUFACTURING. *AK

NHTSA ID

763454

Incident

Jun 6, 2002

WHILE REPLACING FRONT ROTORS, CONSUMER NOTICED THAT FRONT AXLE WAS INCORRECT FOR THIS VEHICLE AS LISTED IN PARTS OF CATALOG. FORD HAS BEEN NOTIFIED.*AK *JB

NHTSA ID

8003699

Incident

Feb 1, 2002

AT 20,000 MILES ONGOING PROBLEM WITH LOSS OF POWER AFTER 1/2 HOURS OF RUNNING AND STALLING OUT WHEN APPLYING ACCELERATOR PEDAL FROM A STOP POSITION. VEHICLE BEEN IN DEALER SHOP ON FIVE OCCASIONS, AND PROBELEM STILL REOCCURRING. *AK DEALER HAS REPLACED THE FUEL PUMP, AIR FLOW SENSOR, MASS AIR FLOW SENSOR, AND THE O2 SENSORS, SOME OF THESE HAVE BEEN REPLACED MORE THAN ONCE AND VEHICLE CONTINUES TO LOSE POWER AND STALL. DOOR AJAR LIGHT ILLUMINATED, DEALER ORDERED LEFT DOOR JAM SWITCH. FUEL GAUGE READS FULL WHEN IT IS NOT, DEALER REPLACED FUEL SENDER. CONSUMER STATES PASSENGER FRONT RIM IS WARPED. SHIFTER HANDLE BEZEL KEEPS POPPING OFF, TRANSMISSION WOULD NOT GO INTO ALL GEARS, WHEN BACKING IN REVERSE, THER IS A SQUEALING NOISE. LEFT DOOR CYLINDER REPLACED. ABS LIGHT ILLUMINATED WHEN GOING IN REVERSE. AIR CONDITIONER DOES NOT GET COLD. *SLC

NHTSA ID

891723

Incident

Nov 15, 1998

WHILE COMING OFF A RAMP ONTO FREEWAY AT 30 MPH VEHICLE COMPLETELY SHUT DOWN, CAUSING LOSS OF POWER BRAKES AND STEERING CONTROL. AFTER GAINING CONTROL OF THE VEHICLE , VEHICLE RESTARTED, BUT DRIVELINE WOULD NOT ENGAGE. CAUSE HAS NOT BEEN DETERMINED. NO COLLISION OR INJURIES OCCURRED. PLEASE GIVE ANY FURTHER DETAILS.*AK

NHTSA ID

890325

WHILE COMIMG OFF A RAMP ONTO THE FREEWAY AT 30 MPH VEHICLE COMPLETELY SHUT DOWN, CAUSING LOSS OF POWER BRAKES AND STEERING CONTROL AFTER GAINING CONTROL OF VEHICLE, VEHICLE RESTARTED, BUT DRIVELINE WOULD NOT ENGAGE. PLEASE GIVE ANY FURTHER DETAILS.*AK

NHTSA ID

890321

THERE WAS VIBRATION IN VEHICLE WHEN TRAVELING BETWEEN 35 AND 50 MPH. DEALERSHIP EXAMINED VEHICLE AND DETERMINED THAT ENTIRE DRIVELINE NEEDED TO BE REPLACED BECAUSE COMPONENT WAS WARPED. *AK

NHTSA ID

887926

Incident

Oct 27, 1999

NO SUMMARY LISTED FOR ABOVE VEHICLE. *AK

NHTSA ID

744474

Incident

Apr 2, 2001

FRONT DIFFERENTIAL BROKE WHILE DRIVING WHICH CAUSED VEHICLE TO STALL ABRUPTLY. IF OCCUPANT WAS NOT RESTRAINT HE MAY HAVE FLOWN OUT OF WINDOW. MANUFACTURER SAID IT WAS NOT A MANUFACTURER'S DEFECT, AND WON'T ASSIST CONSUMER. PLEASE PROVIDE FURTHER INFORMATION. *AK

NHTSA ID

877128

Incident

Nov 20, 2000

TRUCK HAS BEEN TO DEALER SEVERAL TIMES FOR VIBRATION IN DRIVE TRAIN. THEY HAENT BEEN ABLE TO REMEDY THIS PROBLEM AT ALL. ALSO THE COIL ON THE #4 CYLINDER HAS GONE OUT TWICE . THE VIBRATIONS HAVE US WORRIED ABOUT THE SAFETY OF THIS VEHICLE

NHTSA ID

732350

Incident

Mar 13, 1999

FRONT HUB WOULD NOT HOLD VACUUM CAUSING 4 WHEEL DRIVE NOT TO ENGAGE EVEN THOUGH THE 4 WHEEL DRIVE LIGHT IS ILLUMINATED. THIS CAUSED THE TRUCK TO LOOSE CONTROL AND HIT A TREE. NLM

NHTSA ID

551063

WHEN I PUT MY TRUCK INTO GEAR AND INITIALLY START OUT THERE WAS KNOCKING AND CLUNKING COMING FROM UNDER THE RIGHT (PASSENGER SIDE) FLOOR BOARDS. CLUNKING SEEMED SIMILAR TO BAD U-JOINTS WHEN TORQUE IS PUT ON THEM. CLUNKING COULD BE FELT ON FLOOR. I HAD IN TO DEALER NUMEROUS TIMES BEFORE THEY WERE ABLE TO FEEL AND HEAR CLUNKING. THE KNOCKING AND CLUNKING IS MORE PREVELANT IN WARM WEATHER. NOW I AM TOLD BY DEALER ( PLACE MOTOR, 19 THOMPSON ROAD-ROUTE 193,WEBSTER, MA,01570, PH.#5089438010) THAT THIS IS "UNDER INVESTIGATION" BY FORD MOTOR CO. I ASKED WHAT MY OPTIONS WERE BECAUSE I DON'T LIKE DRIVING A NEW VEHICLE AROUND WITH THE CLUNKING AND NOTHING BEING DONE. AT THIS POINT THERE WAS NOTHING THEY COULD DO AND THAT THESE PROBLEMS HAPPEN AND IT TAKES TIME TO FIND THEM. I WASN'T HAPPY WITH THE WAIT UNTIL IT FALLS OFF ATTITUDE I GOT, NOT NECESSARILY FROM THE DEALER BUT FROM FORD. THIS IS THE SECOND NEW VEHICLE WE HAVE PURCHASED FROM FORD THAT HAS HAD THE "UNDER INVESTIGATION" LABEL PUT ON IT. I HAD A 1997 FORD EXPEDITION THAT, ON COLD START UPS, HAD A TWO TO THREE MINUTE ENGINE RAPPING NOISE THAT WAS ALSO "UNDER INVESTIGATION". IT SOUNDED AS IF NO OIL WAS GETTING IN THE ENGINE FOR THE LONGEST TIME. THIS PROBLEM TURNED US OFF FROM BUYING OUT OUR VEHICLE FROM ITS LEASE PROGRAM. 2 FOR 2 DOES NOT MAKE ME VERY KEEN ON FORD QUALITY OR ITS CUSTOMER SATISFACTION, ESPECIALLY ON $30,000. TO $40,000. VEHICLES *AK.

NHTSA ID

716420

Incident

Jun 1, 1999

DRIVING DOWN A DRY ROAD WITH THE 4 -WHEEL DRIVE AND UPON MAKING A SHARP LEFT OR RIGHT TURN THE FRONT WHEEL HUBS WILL LOCK UP. CONTACTED DEALER CLAIMS THIS IS ORMAL. *AK

NHTSA ID

851433

Incident

Jun 15, 1999

THE VEHICLE WOULD NOT SHIFT OUT OF LOW GEAR ,AND THE SPEEDOMETER WOULD NOT FUNCTION. THE DEALER HAS INSPECTED VEHICLE . *AK

NHTSA ID

844908

Incident

Aug 8, 1999

VEHICLE'S CAPACITY OF THE WEIGHT RATING IS WRONGFULLY MISPRINTED AT 4900,BUT SHOULD READ AT 6000+. DEALER/MFR. NOTIFIED, AND REFUSED TO MAKE CORRECTION. CONSUMER WOULD LIKE TO KNOW WHAT CAN BE DONE? *AK *SB

NHTSA ID

831786

Incident

Oct 1, 1998