1999 Ford F-250 Problems

The Belt in the tire separated while driving. This caused a "Bubble" to form causing my truck to shake violently and required changing to the spare tire. If this happened on the highway I could have lost control and caused an accident. I took my truck to a tire installer who documented the above finding and noted the tire was properly inflated and there were no impact marks on the tread or sidewalls. I am currently working with the supplier but they are being unreasonable with the requirements to have it inspected. No other reps have been contacted at this time. No ( its a 24 year old truck, I don't have any tire related warning lamps) LT235/85 R16

TL THE CONTACT OWNS A 1999 FORD F-250 EQUIPPED TRAILERED TO 2019 FOREST RIVER EAST TO WEST TRAVEL TRAILER EQUIPPED WITH TBC BRAND LLC TIRES, TIRE LINE: TRAILER KING, TIRE SIZE: ST225/75R15, DOT NUMBER: 1ADB4HFT1). THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 60 MPH, THE PASSENGER'S SIDE FRONT TIRE EXPERIENCED A BLOWOUT. THE CONTACT PULLED OVER TO THE SIDE OF THE ROADWAY AND PLACED THE SPARE ONTO THE VEHICLE. THE CONTACT STATED THAT ABOUT 15 MINUTES LATER, APPROXIMATELY 10 MILES LATER, THE FRONT DRIVER'S SIDE TIRE ALSO EXPERIENCED A BLOWOUT. THE TIRES WERE REPLACED WITH NEW TIRES. THE CONTACT CONTACTED CAMPERS INN RV OF MACON - BYRON (125 PEACHTREE PKWY, BYRON, GA 31008, (478) 956-6111) AND WAS INFORMED BY THE DEALER THAT THE TIRES WERE NOT REPAIRABLE. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGES WERE 221,000 ON THE VEHICLE AND 1,000 ON THE TIRES ON THE CAMPER. THE VIN WAS NOT AVAILABLE.

TL* THE CONTACT OWNS A 1999 FORD F-250. THE CONTACT STATED THAT THE EMERGENCY BRAKE FAILED. THE VEHICLE WAS NOT DIAGNOSED NOR REPAIRED. THE MANUFACTURER WAS NOTIFIED. THE APPROXIMATE FAILURE MILEAGE WAS 160,000. UPDATED 05/24/16*LJ UPDATED 12/12/2017*JS

TL* THE CONTACT OWNS A 1999 FORD F 250. WHILE DRIVING APPROXIMATELY 5 MPH AND MAKING A LEFT TURN, THE BRAKE PEDAL WAS DEPRESSED BUT THE VEHICLE FAILED TO DECELERATE WITHOUT WARNING. THE CONTACT OBSERVED THAT THERE WAS FUEL LEAKING FROM THE REAR OF THE VEHICLE. THE VEHICLE WAS TOWED TO A DEALER WHERE IT WAS DIAGNOSED THAT THE BRAKE LINE WAS SEVERELY CORRODED AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND STATED THAT THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 11V385000 (FUEL SYSTEM, GASOLINE). THE FAILURE MILEAGE WAS APPROXIMATELY 180,000. UPDATED 11/23/15*LJ *CN

The contact owns a 1999 Ford F-250. The contact stated that the vehicle stalled while driving at various speeds. The contact stated that the check engine light illuminated for approximately 30 seconds. The contact would turn off and restart the vehicle and the vehicle would return to normal operation. The contact stated he took his vehicle to several independent mechanics and was informed that the camshaft sensor was faulty and needed to be replaced. The vehicle was not repaired. The contact stated that similar vehicles were included in NHTSA Campaign number 07V553000 (Engine and Engine Cooling) however, the VIN was not included in the recall. The manufacturer was notified of the failure. The failure mileage was 300,000.

TL* THE CONTACT OWNS A 1999 FORD F-250. WHILE DRIVING 55 MPH, THE FUEL TANK DROPPED OUT OF PLACE WITHOUT WARNING. THE CONTACT HEARD A DRAGGING, SCRAPING SOUND UNDERNEATH THE VEHICLE. THE CONTACT PULLED OVER INTO A PARKING LOT AND DISCOVERED THE FAILURE. BRAD HOWELL FORD (2170 E BLVD ST, KOKOMO, IN 46902) AND THE MANUFACTURER WERE CONTACTED AND STATED THAT THE CONTACT WOULD BE RESPONSIBLE FOR THE REPAIRS SINCE THERE WERE NO RECALLS. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE FAILURE MILEAGE WAS UNKNOWN.

My fiancé & I were driving down a 35mph road & I told her my steering wheel was a little crooked & I don't remember hitting anything to knock out of alignment. We got to my friends house to move a car trailer for him up his steep driveway. I hooked up to the trailer pulled it out, moved it around to line up to back up driveway & making the last adjustment all of a sudden I was turning my steering wheel but the tires were not turning, jumped out to find the output shaft of the steering box was cracked in half diagonally & the steering arm was laying on the street. When I got under the truck & looked at the part that broke you could see it was fractured for a long time. There was only about an 1/8" on one side that was raw metal from just finally breaking. Thank God we are alive if it would have happened going fast probably would have killed someone.

I WAS GOING DOWN THE FREEWAY @ 65MPH AND I NOTICED MY STEERING WAS NOT RESPONDING IN THE NORMAL WAY. I HAD MADE IT TO A EXIT AND STOPPED AT LIGHT TRIED TO MAKE RIGHT TURN TRUCK CONTINUED STRAIGHT, AND I WAS STOPPED IN RUSH HOUR TRAFFIC IN CA. GOT OUT AND SAW MY SECTOR SHAFT HAD BROKEN OFF MY STEERING GEAR BOX.

TL*THE CONTACT OWNS A 1999 FORD F250. WHILE DRIVING APPROXIMATELY 40 MPH, THE VEHICLE BEGAN VIBRATING. THE FAILURE WOULD OCCUR WHEN DRIVING AT SPEEDS GREATER THAN 40 MPH. THE FAILURE OCCURRED FOR APPROXIMATELY TWO YEARS. WHILE PARKED, THE CONTACT ALSO NOTICED OIL WAS LEAKING FROM THE VEHICLE. THE CONTACT INSPECTED THE VEHICLE AND NOTICED THE REAR COMB OF THE TRANSMISSION WAS BROKEN. THE VEHICLE WAS NOT TAKEN FOR REPAIRS BUT AN APPOINTMENT WAS MADE. THE APPROXIMATE FAILURE MILEAGE WAS 87,000.

TL*THE CONTACT OWNS A 1999 FORD F250. WHILE DRIVING 25 MPH, THE OVERDRIVE LIGHT BEGAN FLASHING. THE VEHICLE WAS TAKEN TO THE DEALER AND THEY STATED THAT THE TORQUE CONVERTER FAILED. THE VEHICLE IS CURRENTLY BEING REPAIRED. THE VIN WAS UNKNOWN. THE CURRENT MILEAGE WAS 149,000 AND FAILURE MILEAGE WAS 148,000.

I was driving on the interstate going highway speed of 65 mph and the accelerator was stuck open and I could not slow down. The engine stayed at a high rpm. I had to press with a lot of force to slow down and come to a stop with the engine still at high rpm and had trouble stopping. Luckily, where I live there's not much traffic, and I made it to a shop with this issue. Upon investigating, the accelerator cable became frayed where it enters the sheath and gets stuck there. The Ford dealer didn't have a replacement in stock or any nationwide. So I went to a junk yard to find one and found the same vehicle that had the same frayed accelerator cable. I located a newer, second vehicle with less mileage with same cable that matched without any fraying. In the meantime, I ordered a new accelerator cable through Ford, but it was backordered several months and tied up in shipping. With this happening on these two same vehicles, I thought I should report it. Thank you.

TL* THE CONTACT OWNS A 1999 FORD F-250. WHILE DRIVING 5 MPH, THE CONTACT HEARD SOMETHING SNAP ON HIS VEHICLE. THE CONTACT PULLED THE VEHICLE OVER AND DISCOVERED THAT THE REAR STRAP CONNECTED TO THE FUEL TANK DETACHED FROM THE VEHICLE. THE CONTACT WIRED THE TANK BACK INTO PLACE AND DROVE HOME. THE CONTACT ASSOCIATED THE FAILURE WITH NHTSA CAMPAIGN NUMBER: 11V385000 (FUEL SYSTEM, GASOLINE). THE CONTACT INFORMED THE MANUFACTURER OF THE FAILURE AND WAS INFORMED THAT THE VEHICLE WAS NOT INCLUDED IN THE RECALL; THEREFORE, HE WOULD BE RESPONSIBLE FOR THE REPAIRS. A DEALER WAS NOT NOTIFIED OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS UNKNOWN.

i was involved in a collision on US30 3 miles west of Rainer Oregon. where I struck another Ford truck while cruising at 55 mph. The vehicle I struck pulled in front of me, my vehicle was severely damaged in the front end and the steering wheel and lower dash panel injured me.,

CLOCK SPRING FAILED . AS A RESULT, HORN AND CRUISE CONTROL BECOME INOPERABLE. *AK

RUSTED THREW FUEL TANK STRAPS NO CRUISE CONTROL NO AIR CONDITIONING

TL* THE CONTACT OWNS A 1999 FORD F-250. THE CONTACT STATED THAT WHILE ATTEMPTING TO MERGE INTO TRAFFIC WITH THE BRAKES ENGAGED, THE VEHICLE SUDDENLY ACCELERATED. THE VEHICLE WAS NOT TAKEN TO THE DEALER. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 135,000. *TR...UPDATED 05/22/13 *BF THE CONSUMER STATED THE BATTERY CABLE WAS REMOVED AND REINSTALLED IN ORDER TO RESET THE COMPUTER. THE FAILURE HAS YET TO RECUR. UPDATED 06/10/2013 *JS

TL*THE CONTACT OWNS A 1999 FORD F250. WHILE DRIVING ABOVE 30 MPH, THE VEHICLE PULLED TO THE LEFT AND RIGHT. THE WHEEL BEARINGS WORE THROUGH THE DRIVER SIDE 4 WHEEL AXLE. THE 4 WHEEL AXLE NEEDS TO BE REPLACED. THE WHEEL BEARING HUBS WERE REPLACED FOUR TIMES. THE FAILURE MILEAGE WAS 189,000 AND CURRENT MILEAGE WAS 196,000.

1999 FORD F-250 WITH TRANSMISSION PROBLEMS. CONSUMER HAD THIS PROBLEM REPAIRED. SHE WAS THEN INFORMED THAT THERE WAS A TSB THAT SHE NEVER KNEW ABOUT. FORD IS REFUSING TO REIMBURSE HER FOR THE REPAIRS. *KB THE CONSUMER STATED THE MANUFACTURER WAS FULLY AWARE OF THE TRANSMISSION PROBLEM, BUT FAILED TO NOTIFY THEIR CUSTOMERS. THE PROBLEM WAS THE FLUID WOULD OVERHEAT DURING SEVERE DUTY AND WEAR OUT THE TORQUE CONVERTER, WHICH RESULTED IN THE RADIATOR, COOLER LINES AND HOSES FOR THE TRANSMISSION TO BE REPLACED. THE STABILIZER BAR LINK AND BATTERY WERE REPLACED. *JB

TL* THE CONTACT OWNS A 1999 FORD F-250. WHEN THE CONTACT EXITED AND RETURNED TO THE VEHICLE, IT MADE AN ABNORMAL SOUND WHEN IT WAS RESTARTED. SUDDENLY, A FIRE ERUPTED UNDER THE HOOD, WHICH SPREAD TO THE CABIN OF THE VEHICLE. THE DRIVER FELL AND HURT HER KNEE WHILE ATTEMPTING TO EXIT THE VEHICLE QUICKLY. MEDICAL TREATMENT WAS REQUIRED. THE FIRE WAS EXTINGUISHED BY THE FIRE DEPARTMENT. THERE WAS EXTENSIVE DAMAGE TO THE FRONT END OF THE VEHICLE. THE INSURANCE COMPANY WAS MADE AWARE OF THE FAILURE. THE MANUFACTURER WAS NOTIFIED. THE DEALER WAS NOT CONTACTED. THE CAUSE OF THE FAILURE WAS NOT DETERMINED. THE VIN WAS NOT AVAILABLE. THE APPROXIMATE FAILURE MILEAGE WAS 300,000.

TL*THE CONTACT OWNS A 1999 FORD F250. WHILE DRIVING 70 MPH, THE LIGHTS BLINKED ON AND OFF ON THE INSTRUMENT PANEL. THE CONTACT ASSUMED THAT THE FAILURE WAS DUE TO BARE WIRES UNDER THE STEERING COLUMN. WHEN THE VEHICLE WAS RUNNING, THE LIGHTS FLICKERED ON AND OFF HABITUALLY WHEN THE STEERING WAS IN USE. THE DEALER STATED THAT THE FAILURE WAS NOT A SAFETY ISSUE. THE PURCHASE DATE WAS UNKNOWN. THE CURRENT MILEAGE WAS 124,000 AND FAILURE MILEAGE WAS 97,000.

THE FRONT WINDSHIELD LEAKED WHICH ALLOWED WATER TO ENTER THE VEHICLE. THE WATER LEAKED ONTO THE FUSE BOX WHICH CAUSED AN ELECTRICAL MALFUNCTION. AS A RESULT THE VEHICLE CAUGHT ON FIRE. DEALER WAS NOTIFIED. *AK THE VEHICLE WAS ON INA FLEET OF VEHICLES. *NM

WIPERS COME ON BY THEMSELVES FROM TIME TO TIME. 8JB

TL* THE CONTACT OWNS A 1999 FORD F-250. AFTER THE VEHICLE WAS PLACED INTO THE PARK POSITION, IT INDEPENDENTLY ROLLED BACKWARDS WITHOUT WARNING. THE PASSENGER WAS ABLE TO STOP THE VEHICLE. THE CONTACT DISCOVERED THAT THE VEHICLE INADVERTENTLY SWITCHED INTO THE REVERSE POSITION. AS A RESULT, THE CONTACT WAS KNOCKED DOWN AND SUSTAINED INJURIES THAT REQUIRED MEDICAL ATTENTION. A POLICE REPORT WAS FILED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 245,000. ....UPDATED 07/05/16 *BF THE CONSUMER STATED HE EXITED THE VEHICLE AND WALKED TO THE REAR OF THE VEHICLE. THE VEHICLE SOMEHOW WENT INTO REVERSE, WHILE THE DOOR WAS STILL OPEN. UPDATED 07/21/16.*JB

1999 FORD F-250 WITH TRANSMISSION PROBLEMS. CONSUMER HAD THIS PROBLEM REPAIRED. SHE WAS THEN INFORMED THAT THERE WAS A TSB THAT SHE NEVER KNEW ABOUT. FORD IS REFUSING TO REIMBURSE HER FOR THE REPAIRS. *KB THE CONSUMER STATED THE MANUFACTURER WAS FULLY AWARE OF THE TRANSMISSION PROBLEM, BUT FAILED TO NOTIFY THEIR CUSTOMERS. THE PROBLEM WAS THE FLUID WOULD OVERHEAT DURING SEVERE DUTY AND WEAR OUT THE TORQUE CONVERTER, WHICH RESULTED IN THE RADIATOR, COOLER LINES AND HOSES FOR THE TRANSMISSION TO BE REPLACED. THE STABILIZER BAR LINK AND BATTERY WERE REPLACED. *JB

THE SECOND GEAR HAS GONE OUT OF THE TRANSMISSION. THE CONSUMER TOOK THE VEHICLE TO THE DEALER. *JB *SC THE LIGHTS AT THE BOTTOM OF THE DOOR WERE INOPERATIVE. THE STEERING WHEEL WAS OUT OF ALIGNMENT.

THE VEHICLE PULLED TO THE LEFT AND THE RIGHT, THE TIRE WERE CUPPING ON THE EDGES, THE CLOTH SEAT WERE WEARING, THE RADIUS ARMS WERE LOOSE, THE LIGHTS WERE INOERATIVE, THERE WAS A SQUEAK IN THE COWEL, THE ENGINE EXPERIENCED GASKET AND SEAL PROBLEMS, HOWEVER ONCE THE ENGINE WAS REPLACED, IT BURNED OIL FAST.*SCC *JB

TL* THE CONTACT OWNS A 1999 FORD F-250. WHILE DRIVING APPROXIMATELY 55 MPH, THE SPARE TIRE DETACHED AND WENT UNDER THE TRAILER THAT WAS BEING HAULED. THE CONTACT LOST CONTROL OF THE VEHICLE AND CRASHED INTO THE MEDIAN. A POLICE REPORT WAS NOT FILED. THE CONTACT WENT TO THE HOSPITAL, BUT THERE WERE NO INJURIES. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE VEHICLE WAS BEING REPAIRED. THE VIN WAS UNKNOWN. THE APPROXIMATE FAILURE MILEAGE WAS 165,000.

TL* THE CONTACT OWNS A 1999 FORD F-250. THE CONTACT STATED WHILE PARKED THE REAR DRIVER AND PASSENGER SIDE DOORS WOULD NOT OPEN WHEN THE LATCH WAS PULLED FROM THE INTERIOR OR EXTERIOR OF THE VEHICLE. AN INDEPENDENT MECHANIC PERFORMED A DIAGNOSTIC TEST AND STATED THE LOCK AND CABLE ASSEMBLY HAD TO BE REPLACED ON BOTH DOORS. THE VEHICLE WAS REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 200,000.

TRUCK BEGAN MAKING TICKING SOUNDS FOR ABOUT 3 DAYS. WHEN STARTED A SPARK PLUG WAS BLOWN OUT OF ITS MOUNTING HOLE. THREADS IN HEAD ARE NOT DEEP ENOUGH.

WHILE DRIVING THE VEHICLE'S LEFT REAR TIRE SHEARED OFF FROM THE HUB. THE TIRE WENT THROUGH THE MEDIAN AND STRUCK ANOTHER VEHICLE. *MR *NM

CONSUMER HAD LOST CONTROL OF VEHICLE AND RAN OFF ROAD, HTTING TWO TREES HEAD-ON. UPON IMPACT, DUAL AIRBAGS DID NOT DEPLOY, AND SEATBELT CAME LOOSE, CAUSING INJURIES, AND $11,000 WORTH OF DAMAGE. BODY SHOP THAT REPAIRED VEHICLE COULD NOT FIND AIRBAG SENSORS, AND FELT THAT THEY WERE MISSING, THAT THEY WERE NEVER INSTALLED AT FACTORY. *AK

DURING INCLEMENT WEATHER BRAKE FAILED WHEN APPLIED. CONSUMEER TRIED TO AVOID HITTING VEHICLE IN FRONT AND HIT A POLE. THERE WAS NO DEPLOYMENT OF DRIVER AND PASSENGER SIDE AIRBAGES AND THE SEAT BELT DID NOT RESTRAIN DRIVER AND KILL SWITH FAILED. YH

CONSUMER WAS DRIVING AT APPROXIMATELY 50 MPH WHEN HIGH BEAMS FAILED, THERE WAS NO LIGHT AT ALL. CONSUMER WAS TOLD THAT HE MUST HIT SWITCH ON DASH, AND SWITCH IT TO LOW BEAMS. *AK CONSUMER BELEAVE THAT THIS TO BE A DESIGN PROBLEM. *YH

TAIL LIGHTS KEEP BLOWING OUT EVERY THREE MONTHS DUE TO OVERHEATING OF THE SOCKETS, CAUSING THE BULBS TO FALL OUT OF THE SOCKET. DEALER NOTIFIED, AND INFORMED CONSUMER THAT NOTHING ELSE COULD BE DONE EXCEPT KEEP ON REPLACING THE SOCKETS. *AK *ML

FORD F 250 SAFETY ISSUE, CONSTANTLY HAVE TO MAKE CERTAIN THE TRUCK DOESN'T LURCH FORWARD ON RELEASE. *BF THE CONSUMER IS HAVING PROBLEMS WITH THE CLUTCH ON THE SIX SPEED MANUAL AND THE EMERGENCY BRAKE. THE CLUTCH RELEASES ONLY 1 TO 1 1/2 INCHES OFF THE FLOOR. THE CONSUMER WAS TOLD THAT THE ORIGINAL HAD A RUBBER HOSE PART THAT ALLOWED EXPANSION WHEN THE HYDRAULIC CLUTCH FLUID WAS COMPRESSED. THE VEHICLE WAS FOUND THAT THE PROBLEM WITH THE CLUTCH FORK WAS BENDING. THE CONSUMER STATED THAT IT IS DIFFICULT TO SHIFT GEARS CAUSING A PAUSE THAT COULD RESULT IN SOMEONE ELSE REAR ENDING HIM. THE VEHICLE EMERGENCY BRAKE WAS REPLACED DUE TO RECALL NOTICE HOWEVER THE CONSUMER STILL HAS TO LEAVE IT IN GEAR ON EVEN THESLIGHTEST GRADE BECAUSE THE EMERGENCY BRAKE DOES NOT HOLD THE TRUCK IN PLACE. FORD MOTOR COMPANY AGREED TO REPLACE THE PARKING BRAKE FRONT CABLE AND THE PEDAL CONTROL ASSEMBLY. *TC THE A/C BLEW HOT AIR. *SC

AT 20,000 MILES ONGOING PROBLEM WITH LOSS OF POWER AFTER 1/2 HOURS OF RUNNING AND STALLING OUT WHEN APPLYING ACCELERATOR PEDAL FROM A STOP POSITION. VEHICLE BEEN IN DEALER SHOP ON FIVE OCCASIONS, AND PROBELEM STILL REOCCURRING. *AK DEALER HAS REPLACED THE FUEL PUMP, AIR FLOW SENSOR, MASS AIR FLOW SENSOR, AND THE O2 SENSORS, SOME OF THESE HAVE BEEN REPLACED MORE THAN ONCE AND VEHICLE CONTINUES TO LOSE POWER AND STALL. DOOR AJAR LIGHT ILLUMINATED, DEALER ORDERED LEFT DOOR JAM SWITCH. FUEL GAUGE READS FULL WHEN IT IS NOT, DEALER REPLACED FUEL SENDER. CONSUMER STATES PASSENGER FRONT RIM IS WARPED. SHIFTER HANDLE BEZEL KEEPS POPPING OFF, TRANSMISSION WOULD NOT GO INTO ALL GEARS, WHEN BACKING IN REVERSE, THER IS A SQUEALING NOISE. LEFT DOOR CYLINDER REPLACED. ABS LIGHT ILLUMINATED WHEN GOING IN REVERSE. AIR CONDITIONER DOES NOT GET COLD. *SLC