1999 Ford F-250 Transmission Problems

TL*THE CONTACT OWNS A 1999 FORD F250. WHILE DRIVING APPROXIMATELY 40 MPH, THE VEHICLE BEGAN VIBRATING. THE FAILURE WOULD OCCUR WHEN DRIVING AT SPEEDS GREATER THAN 40 MPH. THE FAILURE OCCURRED FOR APPROXIMATELY TWO YEARS. WHILE PARKED, THE CONTACT ALSO NOTICED OIL WAS LEAKING FROM THE VEHICLE. THE CONTACT INSPECTED THE VEHICLE AND NOTICED THE REAR COMB OF THE TRANSMISSION WAS BROKEN. THE VEHICLE WAS NOT TAKEN FOR REPAIRS BUT AN APPOINTMENT WAS MADE. THE APPROXIMATE FAILURE MILEAGE WAS 87,000.

NHTSA ID

10374901

Incident

Oct 1, 2008

Mileage

87,000 mi

TL*THE CONTACT OWNS A 1999 FORD F250. WHILE DRIVING 25 MPH, THE OVERDRIVE LIGHT BEGAN FLASHING. THE VEHICLE WAS TAKEN TO THE DEALER AND THEY STATED THAT THE TORQUE CONVERTER FAILED. THE VEHICLE IS CURRENTLY BEING REPAIRED. THE VIN WAS UNKNOWN. THE CURRENT MILEAGE WAS 149,000 AND FAILURE MILEAGE WAS 148,000.

NHTSA ID

10223828

Incident

Apr 4, 2008

Mileage

148,000 mi

CERTIFIED LTR. FWD TO NHTSA RE PREVIOUS LTR SUBMITTED ON 9/23/04 RE DEFECTIVE CLUTCH/TRANSMISSION FOR A 1999 FORD F250 TRUCK. THE VEHICLE WOULD LURCH FORWARD, THE CLUTCH ENGAGED TOO CLOSE TO THE FLOOR, THERE WAS DIFFICULTY WHEN GOING UPHILL, AND WHEN SHIFTING GEARS. THE CORRECTION WAS DONE INCORRECTLY PER VERDE VALLEY FORD. THE CONSUMER WAS SHOWED A BROKEN TAB THAT WAS INSTALLED INCORRECTLY. THE LINE WAS ALSO FULL OF AIR. *SC THE CONSUMER STATED THAT HE HAS TO MAKE CERTAIN THE VEHICLE DOES NOT LURCH FORWARD BECAUSE THE CLUTCH RELEASES SO CLOSE TO THE FLOOR AS TO NOT REAR END ANOTHER DRIVER. THE CLUTCH CAN NOT BE FEATHERED TO GET IT STARTED AFTER SHUTTING OFF ON AN UPHILL GRADE. THE CONSUMER STATED THAT IT IS DIFFICULT TO SHIFT GEARS CAUSING A PAUSE THAT CAN RESULT IN BEING REAR ENDED. THE CLUTCH WAS REPAIRED AT CONSUMERS EXPENSE. *TC *JB

NHTSA ID

10101331

Incident

Sep 29, 1999

THE SECOND GEAR HAS GONE OUT OF THE TRANSMISSION. THE CONSUMER TOOK THE VEHICLE TO THE DEALER. *JB *SC THE LIGHTS AT THE BOTTOM OF THE DOOR WERE INOPERATIVE. THE STEERING WHEEL WAS OUT OF ALIGNMENT.

NHTSA ID

10099104

Incident

Mar 22, 1999

Mileage

73,000 mi

FORD F 250 SAFETY ISSUE, CONSTANTLY HAVE TO MAKE CERTAIN THE TRUCK DOESN'T LURCH FORWARD ON RELEASE. *BF THE CONSUMER IS HAVING PROBLEMS WITH THE CLUTCH ON THE SIX SPEED MANUAL AND THE EMERGENCY BRAKE. THE CLUTCH RELEASES ONLY 1 TO 1 1/2 INCHES OFF THE FLOOR. THE CONSUMER WAS TOLD THAT THE ORIGINAL HAD A RUBBER HOSE PART THAT ALLOWED EXPANSION WHEN THE HYDRAULIC CLUTCH FLUID WAS COMPRESSED. THE VEHICLE WAS FOUND THAT THE PROBLEM WITH THE CLUTCH FORK WAS BENDING. THE CONSUMER STATED THAT IT IS DIFFICULT TO SHIFT GEARS CAUSING A PAUSE THAT COULD RESULT IN SOMEONE ELSE REAR ENDING HIM. THE VEHICLE EMERGENCY BRAKE WAS REPLACED DUE TO RECALL NOTICE HOWEVER THE CONSUMER STILL HAS TO LEAVE IT IN GEAR ON EVEN THESLIGHTEST GRADE BECAUSE THE EMERGENCY BRAKE DOES NOT HOLD THE TRUCK IN PLACE. FORD MOTOR COMPANY AGREED TO REPLACE THE PARKING BRAKE FRONT CABLE AND THE PEDAL CONTROL ASSEMBLY. *TC THE A/C BLEW HOT AIR. *SC

NHTSA ID

10095317

Incident

Sep 1, 2004

CONSUMER STATES THAT THE BUSHINGS IN CLUTCH KEPT BREAKING OFF. WHEN THIS HAPPENED THE CLUTCH PEDAL WENT ALL THE WAY TO THE FLOOR, AND CONSUMER COULD NOT STOP THE VEHICLE. THE PIECE THAT BROKE OFF WAS MADE OF PLASTIC, AND DID NOT DO THE JOB. THIS HAPPENED 3 TIMES. THE FIRST TIME AT 80,000 MILES. CURRENTLY, IT HAPPENED AGAIN AND THERE WAS NO RECALL ON IT. *AK

NHTSA ID

10081874

Incident

Jul 13, 2004

TRANSMISSION VIBRATES AND CUTS OUT WHEN ENGAGING SPEED , AND I HAVE NOT RECEIVED ANY RECALLS ON MY VECHIEL IT IS A 99 F250 4DR V8. SO COULD YOU PLEASE SEND ME SOMETHING TO HAVE MY VEHICLE REPAIRED AND ALSO MY AIR BAG SENSOR IS BAD , THE ENGINE LIGHT SENSOR IS ALSO ON. *AK

NHTSA ID

10062634

Incident

Jan 1, 2004

CLUTCH SLAVE CYLINDER FAILED WITHOUT WARNING. THE CLUTCH PEDAL WENT ABOUT 1/2 WAY BEFORE ENGAGING. DIFFICULT TO ENGAGE CLUTCH AND SHIFT TRANSMISSION. I WAS TOWING A TRAILER AT THE TIME OF FAILURE. WHEN I CONTACTED THE FORD DEALER TO SCHEDULE REPAIR HE SAID NOT TO DRIVE THE VEHICLE VERY FAR BECAUSE COMPLETE FAILURE WOULD PROBABLY OCCUR. I WAS ALSO TOLD THAT FORD IS VERY AWARE OF THIS DEFECT AND HAS REDESIGNED THIS PART DUE TO MANY FAILURES. EVEN THOUGH AN ACCIDENT DID NOT OCCUR, I THINK A SAFETY RECALL IS NEEDED SINCE THESE VEHICLES ARE DESIGNED TO HAUL OR CARRY HEAVY LOADS AND THIS TYPE OF FAILURE COULD MAKE IT DIFFICULT TO ENGAGE THE CLUTCH WHEN TRYING TO STOP THE VEHICLE, WHICH COULD RESULT IN A CATASTROPHIC ACCIDENT. THE COST FOR REPAIR WAS $305.26

NHTSA ID

767035

Incident

Aug 24, 2002

CONSUMER WOULD PUSH CLUTCH IN, AND THEN HE COULD NOT PUT VEHICLE IN GEAR. AFTER TAKING VEHICLE TO MECHANIC , HE FOUND OUT THAT TRANSMISSION BEARING WAS GONE/ ALL BURNED. *AK

NHTSA ID

8014552

Incident

Jun 23, 2002

WHILE AT A STOP TRANSMISSION MADE A LOUD NOISE. VEHICLE MADE IT ACROSS THE INTERSECTION, THEN ,VEHICLE WOULD NOT ACCELERATE. DEALER NOT CONTACTED YET.*AK

NHTSA ID

8012798

Incident

Jun 27, 2002

CAM POSTION SENSOR TURNED VEHICLE OFF WITHOUT PRIOR WARNING. DEALERSHIP WAS AWARE OF PROBLEM.*AK

NHTSA ID

8012504

WHILE DRIVING 10 MPH CONSUMER WAS NOT ABLE TO SHIFT GEARS. VEHICLE WAS TOWED TO DEALER. DEALER DETERMINED THAT CLUTCH FORK HAD BROKEN.*AK

NHTSA ID

8010565

Incident

May 3, 2002

CONSUMER STATES THAT HE IS HAVING TROUBLE WITH A PART THAT ATTACHES TO THE CLUTCH RELEASE PEDAL, WHEN IT COMES OFF IT IS IMPOSSIBLE TO RELEASE THE CLUTCH OR TO SHIFT GEARS, THE PART IS MADE OF A PLASTIC TYPE MATERIAL WITH TEETH TO KEEP IT IN PLACE, HOWEVER CONSUMER HAS REPLACED THIS PART SEVERAL TIMES. *SLC

NHTSA ID

565552

WHEN DRIVING AND UPON DEPRESSING BRAKE PEDAL TO MAKE A GRADUAL STOP, TRANSMISSION SUDDENLY LOCKED UP. TRANSMISSION HUNG UP IN GEAR AND FAILED TO DISENGAGE FROM ANY GEAR. CONSUMER HAD VEHICLE TOWED TO A DEALER. *AK *SLC

NHTSA ID

8004634

Incident

Feb 1, 2002

WHILE I WAS EXITING MY TRUCK, WITH MOTOR OFF AND TRANSMISSION IN PARK, THE PIN THAT HOLDS IT IN PARK FAILED AND ALLOWED THE TRUCK TO ROLL BACKWARDS. THIS SCOPED ME UP IN THE DOOR AND DRAGGED ME OVER THE HILLSIDE NEXT TO THE ROAD. I HAD TO ESCAPE FROM THE DOOR BEFORE IT RAN INTO TREES, AND IN THAT PROCESS DISLOCATED MY LEFT ELBOW AND TWO RIBS ALONG WITH NUMEROUS BRUISES. THE TRUCK IS AT A REPAIR SHOP TO REVIEW WHAT HAPPENED TO ITS PARK GEAR.*AK

NHTSA ID

757393

Incident

Jan 19, 2002

WHILE DRIVING 65 MPH TRANSFER CASE DROPPED OUT, BROKE THE CASING. DEALER REPLACED PART.*AK

NHTSA ID

899099

Incident

Sep 15, 2001

WHILE DRIVING ABOUT 20 MPH VEHICLE STALLED, THEN NOTICED A TRAIL OF TRANSMISSION FLUID BEHIND VEHICLE, ADDED TRANSMISSION FLUID TO VEHICLE, AND WAS ABLE TO DRIVE HOME. COULD NOT FIND WHERE FLUID WAS LEAKING FROM, VEHICLE AT DEALER AT THIS TIME.*AK CONSUMER STATED TRAMSMISSION HAD TO BE REBUILT, MECHANIC FOUND PIECES FLOATING INSIDE, ALSO FILTER WAS FLOTING AROUND.*SLC

NHTSA ID

897042

Incident

Sep 24, 2001

ENGINE WAS LEAKING OIL AT 8577 AND 9830 MILES ON VEHICLE. DEALERSHIP EXAMINED VEHICLE, AND DETERMINED THERE WERE TWO LEAKS. REAR MAIN SEAL AND ENGINE OIL PAN WERE LEAKING ON FIRST OCCURRENCE. DEALERSHIP PATCHED LEAK WITHOUT PULLING ENGINE. ON SECOND OCCURRENCE, DEALERSHIP HAD TO PULL ENGINE, AND FOUND THAT OIL PAN AND TRANSMISSION PAN WERE LEAKING OIL. *AK

NHTSA ID

887925

Incident

Aug 1, 1999

GEM MODULE REPLACED 6 TIMES, FIRST DAY CONSUMER TOOK DELIVERY OF VEHICLE. 4 WHEEL DRIVE FUNCTION CAME ON ON IT'S OWN, WOULD NOT DISENGAGE UNTIL VEHICLE CAME TO A COMPLETE STOP. WILL NOT COME ON WHEN CONSUMER NEEDS IT TO COME ON.*AK

NHTSA ID

887491

Incident

Aug 1, 1999

VEHICLE HAD REAR BRAKE FIRE DUE TO REAR BRAKES DRAGGING. *AK

NHTSA ID

744478

Incident

Apr 20, 2001

WHEN TRAVELING ON HIGHWAY AT NORMAL SPEED VEHICLE WILL NOT DOWN SHIFT, AND VEHICLE MAKES NOISES. DEALERSHIP IS AWARE OF PROBLEM.*AK

NHTSA ID

886394

Incident

Jan 1, 1999

SOMTIMES WHEN SHIFTING FROM TWO WHEEL DRIVE TO FOUR WHEEL DRIVE FOUR WHEEL DRIVE DOSE NOT ENGAGE. WHEN DRIVING ON WET PAVMENT IT KICKS OUT OF FOUR WHEEL DRIVE ON ITS OWN. DEALER HAS BEEN CONTACTED.*AK SOMETIMES, THE HABS DO NOT LOCK. THE O-RINGS WAS REPAIRED FOR TIMES. *YH

NHTSA ID

883913

Incident

Feb 25, 2000

TRANSMISSION SEAL FAILED, AND TRANSMISSION FLUID LEAKED OUT. PLEASE PROVIDE ANY ADDITIONAL INFORMATION.*AK

NHTSA ID

883637

Incident

Feb 2, 2001

WHEN DEPRESSING CLUTCH PEDAL TO FLOOR BOARD VEHICLE GOES INTO EXTENDED STOPING DISTANCE. TECHNICIAN STATED THAT FLYWHEEL NEEDED TO BE REPLACED. PLEASE PROVIDE FURTHER INFORMATION. *AK

NHTSA ID

883432

THE TIRES HAVE BLOWN WHILE DRIVING ON HIGHWAYS. THE CLUTCH PROBLEM IS A RECURRING ONE. 3 TO 4 TIMES A DAY THE CLUTCH PEDAL STAYS AT THE BOTTOM OF THE TRAVEL DISTANCE OR ONLY COMES HALF-WAY BACK UP. THE TRANSMISSION ALSO DOES NOT SHIFT SMOOTHLY. (TIRESIZE: LT23585R16)( DOT NUMBER: TIRE SIZE: LT23585R16 )

NHTSA ID

733408

Incident

Sep 25, 2000