2000 Ford F-250 Problems

Left front tire blew without warning, lost control of truck and trailer and crossed the median into oncoming interstate traffic. Stearing link on truck broke, not sure when. Truck and trailer were totaled. LEFT REAR TIRE BLEW WHILE PARKED A COUPLE OF MONTHS LATER. No visible defects. I have attached two pictures of the left front tire taken at the scene of the accident and three pictures of the left rear tire taken as it failed in two stages, first a bulge in the tread, followed a few weeks later by a zipper-like sidewall separation. Tires were less than 10 years old when they failed. I still have the tires as well as the other two matching tires from the set. The accident occurred in Bath NY. Michelin LT235/85R16

TL* THE CONTACT OWNS A 2000 FORD F-250 EQUIPPED WITH CONTINENTAL GENERAL (NA) TIRES, SIZE: 265/75/R16 (NA). WHILE DRIVING 60 MPH, THE TREAD SEPARATED FROM THE REAR TIRE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO CONFIRMED THAT THE TREAD SEPARATED FROM THE PASSENGER SIDE FRONT AND REAR TIRE. THE TIRES WERE REPLACED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE FAILURE MILEAGE, TIRE FAILURE MILEAGE, AND VIN WERE UNAVAILABLE.

WHEN DRIVING AND HITTING A BUMP ESPECIALLY IN A TURN, THE FRONT WHEELS SHUTTER VIOLENTLY.

WE HAD JUST HAD NEW FIRESTONE TRANSFORCE HT TIRES PUT ON OUR TRUCK. APPROXIMATELY FOUR MONTHS LATER, AS WE ARE TRAVELING DOWN THE HIGHWAY AT 65 MPH, WE FELT A SERIOUS VIBRATION IN THE LEFT REAR TIRE. WE SLOWED DOWN TO 60 MPH & THAT'S WHEN THE TIRE BLEW OUT. WE PULLED TO THE SHOULDER OF THE HIGHWAY TO INSPECT & THE TIRE BLEW OUT THE SIDEWALL. WE DID NOT HIT ANYTHING & NO ROAD HAZARD CAUSED THIS DAMAGE. WE SIMPLY FELT AS A SERIOUS VIBRATION & WITHIN A HALF A MILE OR MILE IT BLEW OUT. THE SHOP WHERE WE PURCHASED THE TIRES CHARGED US FOR ANOTHER TIRE. THIS SHOULD HAVE BEEN COVERED BY WARRANTY BUT WE WENT AHEAD AND PAID FOR IT BECAUSE WE NEEDED THE VEHICLE FOR WORK. IT CONTINUED TO HAVE SEVERE VIBRATIONS WHICH CAUSE DIFFICULTY STEERING THE VEHICLE IN ACCELERATION & IN BRAKING. SO WE HAD EVERYTHING REPLACED ON THE FRONT END. AFTER THIS, THE TRUCK STILL FELT UNSTABLE...THE VIBRATION WAS STILL THERE AND IT WAS STILL DIFFICULT TO STEER.. IT ALSO HAD A TENDENCY TO PULL FROM ONE SIDE TO THE OTHER & AT ALL TIMES & MY AIR PRESSURE WAS AT SPEC. THEN JUST RECENTLY, WE NOTICE THAT ALL THE TIRES, INCLUDING THE ONE THAT WE HAD REPLACED FROM THE BLOWOUT, WERE COMING APART ON THE SIDE WALLS. THERE WERE CRACKS ALL AROUND THE SIDEWALL OF EVERY SINGLE TIRE. THIS CAUSED QUITE AN ALARM TO US AS WE HAD BEEN DRIVING THIS TRUCK & COULD HAVE BEEN SERIOUSLY INJURED OR KILLED HAD WE NOT NOTICE THIS FLAW! THERE'S A PROBLEM WITH THESE TIRES AND IT IS SERIOUS! THERE'S ALSO ALSO A PROBLEM WITH SOME OF YOUR DEALERS AS WELL, BECAUSE THEY ALSO REFUSED TO REPLACE THESE FOUR TIRES UNDER WARRANTY JUST AS THEY DID FOR THE BLOWOUT. THEY PRORATED MY TIRE USAGE WITH NO KNOWN MILEAGE OF WHEN THE TIRES WERE ORIGINALLY PURCHASED BECAUSE THEY DIDN'T DOCUMENT IT. ALL FIVE OF THESE TIRES SHOULD HAVE BEEN REPLACED UNDER FACTORY WARRANTY WITH NO CHARGE! THEY NEED TO BE RECALLED IMMEDIATELY BEFORE SOMEONE GETS KILLED!

WENT TO START ENGINE IN THE TRUCK AFTER SETTING OVER NIGHT UNDER MY CARPORT AND SPARK PLUG BLEW OUT OF THE HEAD . THIS TRUCK HAS A 5.4 LITER V8

I HAVE HAD THREE DIFFERENT OCCASIONS WHERE THE SPARK PLUG HAS BLOWN OUT WHILE I WAS DRIVING TO AND FROM WORK AND TWO OF THE THREE TIMES I ALMOST HIT ANOTHER VEHICLE.WE FIXED THEM WITH NEW PARTS FROM AUTO STORE BUT WAS REMINDED THAT THE REPAIR IS ONLY TEMPORARY.TWO OR THE THREE TIMES I WAS ON A HIGHWAY IN BUSY TRAFFIC AND THE OTHER TIME I WAS ON A RURAL ROAD.

The contact owns a 2000 Ford F-250. The contact stated that while standing next to the vehicle a burning odor was present coming from under the hood. Upon inspection of the vehicle, it was discovered that several wiring harnesses were saturated with leaking brake fluid. The contact was concerned that the saturated wiring harnessed had caused electrical failures within the vehicle. The cause of the failure was not yet determined. The local dealer was notified of the failure. The manufacturer was not yet contacted. The failure mileage was 240,000.

WHILE I WAS ON A HIGHWAY DRIVING AT 65 MPH MY STEERING AND BRAKES WENT OUT AT THE SAME TIME. I HAPPENED TO BE 200 YARDS BEHIND THE TRAFFIC IN FRONT OF ME AND I WAS ABLE TO STOP THE VEHICLE BEFORE IMPACT. A HYDRAULIC HOSE FAILED AND RENDERED THE STEERING AND BRAKES ALMOST COMPLETELY USELESS. THE STEERING WAS EXTREMELY DIFFICULT TO CONTROL BUT I MANAGED. THE BRAKES WERE ALMOST COMPLETELY GONE BUT I MANAGED TO SLOW THE TRUCK DOWN TO A SAFE STOP OFF THE HIGHWAY. WHEN I HAD THE TRUCK TOWED TO MY DIESEL MECHANIC I WAS TOLD BY THE OWNER THAT FORD ENGINEERED THE HYDRAULIC SYSTEM TO CONTROL THE STEERING AND BRAKES. I WILL NEVER BUY ANOTHER FORD WITH THAT KIND OF RIDICULOUS ENGINEERING. I HAD THREE HOSES REPLACED AT A TOTAL COST OF $451.54. ONE FACTORY HOSE WAS $172.53, ANOTHER $100.68 AND THE THIRD WAS $24.04. THE SAFETY ISSUE HERE IS UNREAL. HOW COULD FORD ENGINEERING HAVE DONE SUCH A STUPID THING.

Odometer Fraud. The contact purchased a 1999 N/A Ford F-250. The contact discovered a mileage discrepancy after the purchase. The vehicle was a private sale. At the time of purchase, the vehicle mileage was 176,369. The contact stated that the odometer was inoperable. The contact stated that the odometer only operated while the 4WD feature was activated. Upon further investigation, the contact became aware that when the previous owner purchased the vehicle in 2023, the mileage was 167,697. The correct odometer reading was unknown.

The contact owns a 2000 Ford F-250. The contact stated that while standing next to the vehicle a burning odor was present coming from under the hood. Upon inspection of the vehicle, it was discovered that several wiring harnesses were saturated with leaking brake fluid. The contact was concerned that the saturated wiring harnessed had caused electrical failures within the vehicle. The cause of the failure was not yet determined. The local dealer was notified of the failure. The manufacturer was not yet contacted. The failure mileage was 240,000.

WHEN DRIVING AND HITTING A BUMP ESPECIALLY IN A TURN, THE FRONT WHEELS SHUTTER VIOLENTLY.

WHILE DRIVING AT ANY SPEED, THE CONSUMER NOTICE AFTER BRAKING, THE VEHICLE PULLED TO THE LEFT. PLEASE PROVIDE FURTHER INFORMATION. *JB

2000 FORD F250. CONSUMER WRITES IN REGARDS TO DEFECTIVE CLUTCH PEDAL. *LD THE CONSUMER STATED THE CONNECTION BETWEEN THE CLUTCH PEDAL AND THE LINKAGE FAILED AT LEAST 4 TIMES *JS

DT: LIVE ON LAKE, DRIVEWAY HAS A SLOPE AND PUT THE VEHICLE IN PARK AND THE CUT SWITCH OFF GET OUT OF THE TRUCK AND THE VEHICLE STARTED ROLLING. HAD TO JUMP BACK IN AND MESS WITH THE GEARS IN ORDER TO GET THE VEHICLE TO STOP.*AK

CONSUMER WAS HAVING A PROBLEM WITH THE AIR BAG LIGHT. THE LIGHT ON THE DASHBOARD KEPT COMING ON, INDICATING THAT THERE WAS AN AIR BAG PROBLEM. *AK *CB

CONSUMERS VEHICLE WAS INVOLVED IN A HEAD ON COLLISION AT 55 MPH, HOWEVER THE AIR BAG DID NOT DEPLOY, AS A RESULT THE CONSUMER SUSTAINED A BROKEN NECK AND CLOSED HEAD INJURIES. NLM

RECALL CAMPAIGN 01V258000 CONCERNING WINDSHIELD WIPERS. WHEN THE CONSUMER CONTACTED THE MANUFACTURER, HE WAS TOLD THAT THIS VEHICLE DID NOT FALL INTO THIS RECALL ALTHOUGH THE CONSUMER WAS EXPERIENCING THE SAME PROBLEM. *AK THE WIPERS WERE INTERMITTENT AFTER ABOUT TEN MILES OF OPERATION, THEN WOULD NOT SHUT OFF. A LOCAL FORD DEALER REPLACED THE WIPER MOTOR ASSEMBLY. *SC *JB

WHILE DRIVING APPROXIMATELY 30 MPH IN HEAVY RAIN WINDSHIELD WIPERS STOPPED WORKING. CONSUMER SMELLED BURNING PLASTIC, AND VEHICLE CAUGHT ON FIRE. CONSUMER WAS ABLE TO MAINTAIN CONTROL OF THE VEHICLE AND PULLED OVER. THE RAIN PUT OUT THE FIRE. *AK

The contact owns a 2000 Ford F-250. The contact stated that the passenger’s side and driver’s side rear door locking mechanism was faulty and the doors could no longer be opened. The cause of the failure was not determined. The local dealer and manufacturer were not notified of the failure. The VIN was not available. The failure mileage was unknown.

BACK DOORS OF MY F250 EXTENDED CAB PICKUP WILL UNLATCH TO THE SAFETY LATCH WHILE DRIVING DOWN A ROAD - FORD WILL NOT REPLACE THE TRUCK OR EVEN REPLACE THE LATCHES - THEY SAID THEY CANNOT DUPLICATE THE PROBLEM - WHAT IF A DOOR OPENS WHEN I HAVE SOMEONE RIDING IN THE BACK SEAT AREA - KIDS OR GRANDKIDS? *TR

The contact owns a 1993 N/A Ford F-250. The contact received notification of NHTSA Campaign Number: 00V424000 (FUEL SYSTEM, GASOLINE). The contact stated that fuel spewed out of the rear tank filler neck. The vehicle was taken to the dealer; however, the dealer refused to perform the recall repair. The contact was informed that the recall repair pertained only to the chassis and not light-duty trucks. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 155,000.

THE STRAPS ON THE FUEL TANK BROKE WHILE I WAS DRIVING. I DID NOT DISCOVER UNTIL I ARRIVED HOME AND SMELLED A STRONG ODOR OF GAS. I LOOKED UNDER THE TRUCK AND THE GAS TANK WAS DRAGGING ON THE GROUND. LUCKILY IT WAS SNOWING OR A FIRE WOULD HAVE OCCURRED. *TR

The contact owns a 1994 Ford F-250. The contact stated that while renewing the registration, the contact was informed of an open, unrepaired recall associated with the VIN. The unrepaired open recall was NHTSA Campaign Number: 09V399000 (Vehicle Speed Control). The vehicle was taken to the dealer; however, the dealer declined to perform the recall repair because the VIN was not in the Manufacturer’s Database. The manufacturer was made aware of the failure but provided no assistance. The manufacturer located the VIN information in the database and the contact was referred to the dealer for assistance. The contact had not experienced a failure.

MY CRUISE CONTROL WENT OUT, I WAS RESEARCHING ONLINE WHAT PARTS MAY HAVE GONE OUT WHEN I SEEN A RECALL DONE FOR CRUISE CONTROLS COVERING FORD VEHICLES INCLUDING THE DIESEL OF MY TRUCK AND YEAR. WHEN I CALL TODAY I WAS TOLD MY VEHICLE WAS NOT COVERED I DO NOT SEE HOW ALL THESE OTHER VEHICLES ARE COVERED DID INCLUDE AT THE DIESEL AND THE YEAR OF MY TRUCK AND NOW THEY SAY IT'S NOT COVERED. THE CRUISE CONTROL STOPPED WORKING ON MY WAY TO WORK OCTOBER 7TH.

TL* THE CONTACT OWNS A 2000 FORD F-250. THE CONTACT STATED THAT WHILE ATTEMPTING TO ENTER HIS VEHICLE, THE GEAR SHIFTER INADVERTENTLY SHIFTED INTO REVERSE CAUSING THE DOOR TO KNOCK THE CONTACT DOWN TO THE GROUND WHERE THE CONTACT WAS RAN OVER BY THE VEHICLE. THE CONTACT SUFFERED BROKEN RIBS, TWO FRACTURED VERTEBRAE IN THE NECK, A PARTIALLY SEVERED RIGHT EAR, AND AN UNSTATED INJURY TO HIS LEGS. THE VEHICLE THEN PROCEEDED TO ROLL DOWN A SLIGHT HILL AND CAME TO A STOP AFTER CRASHING INTO A PARKED VEHICLE. MEDICAL ASSISTANCE ARRIVED TO THE SCENE AND THE AMBULANCE TOOK THE CONTACT TO THE HOSPITAL FOR MEDICAL TREATMENT TO HIS INJURIES. THE CONTACT WANTED TO STAY THAT HE WAS ON LIFE SUPPORT FOR TWO WEEKS AND ON A FEEDING TUBE FOR A FEW WEEKS. THERE WAS NO ONE ELSE INJURED. A POLICE REPORT WAS FILED. THE VEHICLE WAS TOWED TO AN IMPOUND LOT AND LATER SENT TO AN INDEPENDENT MECHANIC. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 295,000.

THE TRUCK HAS AN INTERMITTENT HIGH IDLE PROBLEM. WHEN SLOWING DOWN, (EITHER BY DOWNSHIFTING THE MANUAL TRANSMISSION OR COASTING TO A STOP), THE ENGINE WILL SOMETIMES IDLE AT 1500 RPM RATHER THAN THE NOMINAL 700-800 RPM. IF I DON'T COME TO A COMPLETE STOP (LIKE WHEN TURNING ONTO MY STREET), THE IDLE WILL REMAIN HIGH TRYING TO MAKE THE TRUCK GO FASTER. IF I DO COME TO A COMPLETE STOP (LIKE AT A STOP SIGN), THE ENGINE WILL IDLE DOWN THE SECOND I COME TO A COMPLETE STOP. I AM CONCERNED ABOUT NOT ONLY MY BUT OTHERS SAFETY AS THE TRUCK TRIES DRIVING FASTER THAN I WANT WHEN THE IDLE IS HIGH. I HAVE TAKEN THE TRUCK TO SEVERAL DEALERS WHO HAVE PERFORMED MANY SERVICES TO THE TRUCK IN AN ATTEMPT TO DIAGNOSE AND SOLVE THE PROBLEM BUT TO NO AVAIL. I HAVE REPLACED NUMEROUS SENSORS ON THE TRUCK WITH ORIGINAL FORD EQUIPMENT BUT AGAIN NO IMPROVEMENT. I HAVE CONTACTED FORD DIRECTLY BUT ALL THEY TELL ME IS TO TAKE THE TRUCK TO MY FORD DEALER. I AM OUT OF OPTIONS AS THE FORD DEALER CANNOT SEEM TO DIAGNOSE THIS PROBLEM AND ALONG WITH IT MY CONCERN FOR SAFETY. *TR

WE JUST BOUGHT THIS TRUCK AND THE OLD MAN THAT OWNED IT HAS USED A BUNGEE CORD TO KEEP IT SHUT BUT WE PREFER NOT TO DO THAT SO I'M LETTING THE PROPER AUTHORITIES BE AWARE THAT THE DRIVER'S DOOR LATCH WON'T STAY SHUT, SOMETHING WRONG WITH THE LATCH, THE DOOR OPENS WHEN DRIVING.

TRUCK HAD BEEN PARKED ALL AFTERNOON AT WORK. UPON LEAVING WORK THERE WAS A SUDDEN LOUD NOISE THAT WENT ON FOR A FEW SECONDS AND THEN STOPPED. IMMEDIATELY I THOUGHT I HAD HIT SOMETHING BUT ONCE THE VEHICAL WAS STOPPED I SAW THAT THE UNIROYAL LIBERATOR A/T TIRE HAD BEEN THE ISSUE. IT HAD TREAD SEPERATION AND HAD DESTROYED THE BED OF MY TRUCK WHEN IT CAME APART.

TL* THE CONTACT OWNS A 2000 FORD F-250. THE CONTACT STATED THAT THE FRONT DRIVER'S SEAT BELT WOULD EXPERIENCE DIFFICULTY LATCHING INTO THE BUCKLE. THE FAILURE PROGRESSED UNTIL THE SEAT BELT COULD NO LONGER BE REMOVED FROM THE BUCKLE. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER AND THE CONTACT WAS INFORMED THAT THE SEAT BELT BUCKLE WOULD NEED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND OFFERED NO ASSISTANCE. THE FAILURE MILEAGE WAS 120,000.

THE SEAT BELT WOULD NOT RETRACT PROPERLY. *NLM

WHEN DRIVING AND HITTING A BUMP ESPECIALLY IN A TURN, THE FRONT WHEELS SHUTTER VIOLENTLY.

WHILE DRIVING, THE CABLE THAT HOLDS SPARE TIRE BROKE AND TIRE FELL OFF, CONSUMER CONTACTED DEALER, AND THEY TOLD CONSUMER TO CONTACT MANUFACTURER. *AK *SLC

TRUCK HAD BEEN PARKED ALL AFTERNOON AT WORK. UPON LEAVING WORK THERE WAS A SUDDEN LOUD NOISE THAT WENT ON FOR A FEW SECONDS AND THEN STOPPED. IMMEDIATELY I THOUGHT I HAD HIT SOMETHING BUT ONCE THE VEHICAL WAS STOPPED I SAW THAT THE UNIROYAL LIBERATOR A/T TIRE HAD BEEN THE ISSUE. IT HAD TREAD SEPERATION AND HAD DESTROYED THE BED OF MY TRUCK WHEN IT CAME APART.

SINCE 2006 AND BEFORE, I HAVE HAD UNEXPLAINED INCIDENCES OF BATTERY FAILURES AND DASHBOARD WARNINGS. THE WINDSHIELD WAS REPLACED IN 2006 AT MY REQUEST. MY BATTERY WAS REPLACED IN 2006. I ALSO HAD A TEMPORARY ENGINE SHUTDOWN ABOUT THIS TIME. I HAD BATTERY REPLACEMENT IN 2009 AND 2012. ON 11/02/2012 I ATTEMPTED TO START MY F250 ONLY TO DISCOVER ABOUT A PINT OF WATER IN THE FLOOR TRAY. I JUMP STARTED, CONTINUED THE TRIP ONLY TO DISCOVER THE HEATER FAN STILL OPERATING! AFTER FURTHER CHECKS, MY FORD DEALER PROVIDED A TSB 04-23-9 WHICH HAD NO WARNING OF THE POTENTIAL ELECTRONIC MALFUNCTIONS OR DAMAGES AND NOT MAILED TO ME. I HAD THE DEFECT CORRECTED BY A LOCAL SHOP AND FORD WAS MAILED MY COMPLAINT ON 11/28/2012 AND HAVE RECEIVED NO ANSWER. I HAVE HAD MORE THAN ENOUGH MAILING FOR SERVICE AND FORD SHOULD HAVE BEEN REQUIRED TO INFORM ME.