Owner-reported complaints naming the fuel system system, filed with NHTSA
Data refreshed
Reports naming fuel storage or delivery — tanks, pumps, lines, injectors and fuel leaks. Every record below is an owner-reported complaint about the 2022 Ford F-350 Sd submitted to NHTSA — not a confirmed defect, not a recall and not a manufacturer bulletin. 18 reports on file name it.
Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.
Shown in the owner’s own words, exactly as filed
I have been waiting over a year for this low pressure fuel pump recall and it has stopped me from driving long distance to visit my daughter where part of the trip is hoursbthrew the Nevada high desert with extreme heat and NO CELL SERVICE. I AM FED UP AND NEED YHISNISDUE REDOVLED NOW OR A NEW DARN TRUCK. PLEASE ADVISE
The contact owns a 2022 Ford F-350 SD. The contact stated that while attempting to accelerate from a complete stop, the vehicle lost power. There was no warning light illuminated. The vehicle was able to restart. The contact received notification of NHTSA Campaign Numbers: 25V455000 (Fuel System, Gasoline), 25V686000 (Back Over Prevention), 26V104000 (Electrical System, Exterior Lighting), and 26V204000 (Visibility); however, the parts to do the recall repairs were not yet available. The vehicle was taken to the dealer but was not diagnosed or repaired. The dealer stated that parts were not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the failure. The failure mileage was approximately 30,000.
The contact owns a 2022 Ford F-350 SD. The contact received the recall notice for NHTSA Campaign Numbers: 25V455000 (Fuel System, Gasoline) and 25V686000 (Back Over Prevention). The contact expressed safety concerns about driving the recalled vehicle. The local dealer was contacted and confirmed that the parts to do the recall repairs were not available. The manufacturer was contacted by mail regarding vehicle rental and buyback assistance, which was denied. The contact had not experienced a failure.
The contact owns a 2022 Ford F-350 SD. The contact received notification of NHTSA Campaign Number: 25V455000(Fuel System, Gasoline). The contact was concerned about driving the vehicle. The local dealer was contacted and informed the contact that there was no related recall information from the manufacturer. The vehicle was not diagnosed or repaired. The manufacturer was not contacted. The contact had not experienced a failure.
The contact owns a 2022 Ford F-350 SD. The contact received notifications of NHTSA Campaign Numbers: 25V455000 (Fuel System, Gasoline) and 25V686000 (Back Over Prevention); however, the parts to do the recall repairs were unavailable. The contact stated that the manufacturer exceeded a reasonable amount of time for the recall repairs. The contact stated that while attempting to accelerate from a stop, the vehicle hesitated before accelerating. There were no warning lights illuminated. The dealer was contacted, and it was confirmed that parts were not yet available. The manufacturer was made aware of the issue. The failure mileage was unknown.
The contact owns a 2022 Ford F-350 SD. The contact received notifications of NHTSA Campaign Numbers: 22V250000 (VISIBILITY), 24V957000 (FUEL SYSTEM, DIESEL), and 25V686000 (Back Over Prevention). However, the parts to do two of the recall repairs were not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure.
The contact owns a 2022 Ford F-350. The contact stated that while stopped at a traffic signal with his foot on the brake pedal, the vehicle suddenly accelerated as if he had applied the accelerator. The contact stated that his vehicle front end crashed into the rear end of the vehicle. The contact stated that he turned the vehicle off to stop it from continuing to gain forward momentum. The contact stated that he was able to restart the vehicle and pulled over. The contact stated that his lower front bumper was dented and had scratches. The contact stated that the vehicle he had crashed into had damage to the tail gate and rear bumper. The contact stated that no one was injured and both vehicles were able to drive away. The police were not called. The contact stated that prior to the crash the vehicle was having multiple electrical failures and numerous warning lights had illuminated. The contact had taken the vehicle to a local dealer, where it was diagnosed and determined that the transmission needed to be rebuilt. The vehicle repaired, however the contact stated that he was still having warning lights and that the vehicle was shifting roughly from park (P) to drive (D) or from park (P) to reverse (R). Additionally, the contact stated that the accelerator pedal was failing to respond when he applied the pedal. The contact had taken the vehicle back to the same dealer who replaced the battery junction box. The contact stated that the dealer had replaced the battery junction box according to a manufacturer technical service bulletin number 23-2133 (Electrical System). The contact stated that prior to the crash, again the accelerator pedal failed to respond when he applied the pedal. The contact stated that he had used a hand held scanner and was getting codes for electrical system failures, ignition cylinder codes, ABS faults, Body Control Module throttle control codes. The vehicle was taken back to the same dealer and was not repaired. The manufacturer was informed of the failure and advised the dealer not conti
NHTSA Complaint Draft Vehicle Information: Year/Make/Model: 2022 Ford F-350 VIN: [XXX] Recall Campaign: 25S75 / 25V455 Mileage: 38606 Problem Description: My 2022 Ford F-350 is subject to recall 25S75/25V455 (low-pressure fuel pump failure). Ford notified me on July 8, 2025, that no remedy is currently available. The recall states the fuel pump can fail, resulting in a loss of fuel pressure and engine stall while driving. This creates a serious safety risk of crash or injury. Despite acknowledging the defect, Ford has not provided a remedy, a timeline for repair, or safe alternative transportation. I feel unsafe driving this vehicle, and I am still financially responsible for it. Safety Concern: The risk of the engine stalling while driving, especially at highway speeds, creates an immediate danger to myself, passengers, and other motorists. Resolution Sought: Require Ford to provide a safe loaner or rental vehicle until a remedy is available, OR Require Ford to buy back or pay off the balance of this unsafe vehicle until the defect is resolved. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
The contact owns a 2022 Ford F-350SD. The contact stated while driving at 5 MPH, the vehicle shut off with the check engine warning light illuminated. The contact used a diagnostic machine and diagnosed the vehicle and determined that the high-pressure fuel rail and high-pressure fuel rail sensor were defective. The contact replaced the high-pressure rail fuel sensor; however, the error code remained. The contact stated that while driving at an undisclosed speed, there was an abnormal popping sound coming from the vehicle, with the check engine warning light illuminated. The contact self-diagnosed the vehicle and retrieved a code that the low-pressure fuel rail was defective. The contact also discovered oil leaking out of the O-rings where the fuel injectors were located. The dealer was contacted, and the vehicle towed to the dealer. The dealer diagnosed the vehicle with a defective low-pressure fuel pump. Upon investigation, the contact linked the failure to NHTSA Campaign Number: 25V455000 (Fuel System, Gasoline); however, the VIN was not included in the recall. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline to report the failure. The vehicle was not repaired and remained with the dealer. The failure mileage was approximately 61,000.
Sudden loss of acceleration at highway speed. Engine sputtered and died as I coasted to a stop on a two lane bridge. Very dangerous location. Was able to restart engine. Ford dealer at next exit. Checked out and no codes thrown. Advised to keep driving until recurrence. Took to hometown Ford dealership and after three days reported no codes, no recurrence, and no problems detected. Advised to keep driving until recurrence.
The contact's husband owns a 2022 Ford F-350 SD. The contact stated that while depressing the accelerator pedal, the vehicle lost motive power with the check engine warning light displayed on the instrument panel. The vehicle was taken to the dealer where a diagnostic test was performed, and the contact was informed that the high-pressure fuel pump (HPFP) needed to be replaced. The contact initially assumed that the vehicle would be covered under warranty; however, the warranty did not cover the repair. The contact was then referred to the manufacturer for assistance. The manufacturer referred the contact to the NHTSA Hotline to report the failure. The vehicle was repaired out of pocket. The failure mileage was approximately 140,000.
1 month ago my vehicle intermittently would not shut off. You could hit the Start/Stop button and from all dash board appearances the truck was off, but the truck was still running. I resorted to pulling a circuit breaker to get the truck off. I found NHTSA 10226938 and replaced the Battery Junction Box as prescribed. This fixed the vehicle for a few weeks, but now the issue is back. There is no water intrusion in the BSB junction box.
The contact owns a 2022 Ford F-350 SD. The contact stated while driving 15 MPH, the vehicle lost motive power and vehicle stalled. The contact stated there was an abnormal sound coming from the engine. An unknown message was displayed on the instrument panel. The vehicle failed to restart and was pulled into a gas station by another driver. The vehicle was then towed to the residence. A mobile mechanic diagnosed that the CP4 pump had failed. The contact was informed that the CP4 pump needed to be replaced. The vehicle had not been repaired. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 90,000.
The contact owns a 2022 Ford F-350 SD. The contact received notification of NHTSA Campaign Number: 24V957000 (Fuel System, Diesel); however, the part to do the recall repair was not yet available. The dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.
After the truck had been sitting in the driveway for a couple days I noticed a wet spot underneath the truck, I looked under the truck and noticed there was diesel on the fuel line and the top of the fuel tank was wet with diesel fuel.
The contact owns a 2022 Ford F-350 SD. The contact stated while starting the vehicle with the brake pedal depressed, the RPM rose to the RED line. The contact turned off the vehicle and then restarted the vehicle made sure that the accelerator pedal was not depressed. After restarting the vehicle with the brake pedal depressed, the RPMs increased immediately, and the vehicle lunged forward. The contact placed the vehicle into drive which had caused the RPMs to immediately decrease. The vehicle was taken to the dealer however, the mechanic was unable to determine the cause of the failure due to not being able to duplicate the failure. The dealer did not have the diesel mechanic-certified staff needed to repair the vehicle. The vehicle had not been repaired. The vehicle was towed to another dealer who had the diesel mechanic-certified staff needed for the repair. The second dealer was unable to determine the cause of the failure. The vehicle had not been repaired due to an aftermarket air intake. The manufacturer had not been made aware of the failure. The failure mileage was 7,420.
The fuel lines are made of a plastic that attracts rodents. At 3000 miles on the odometer mine were chewed thru, I remote started it and saw the fuel dumping and spraying on the ground. Had I not seen or smelt the gas and got into the vehicle before starting it. It would have caught fire and burnt to the ground. Ford would not take ownership of this design flaw, rodent damage is not under their warranty, so I had to pay for the repair which included a 34 gallon fuel cell replacement. I would imagine many other vehicles including the recent SUV fires might have a similar issue. Once the fire starts, there's no way to establish root cause for the failure because all evidence would be destroyed.
The contact owns a 2022 Ford F-350 SD. The contact became aware that there was fuel leaking from the vehicle. The vehicle was taken to the dealer where it was diagnosed that the fuel lines were chewed on by rodents causing the fuel leak. The vehicle was not repaired. The manufacturer was notified of the failure. The approximate failure mileage was 3,167. Update: The contact owns a 2022 Ford F-350 SD. The contact became aware that there was fuel leaking from the vehicle upon remote startup. Gasoline was spraying from the vehicle and was noticed by sight and smell when approaching the vehicle. The vehicle was flatbed towed to the dealer, after being cleared from being a fire hazard by the Lake County Fire Dept claim [XXX]. The dealer diagnosed that the tank vent and nearby fuel lines were chewed on by rodents causing the fuel leak. The vehicle was not repaired under warranty. Plant-based plastic mono-wall fuel lines and tank were replaced at the owners expense. Nothing has been changed to prevent the failure from reoccurring. Old parts were retained by the owner. The manufacturer was notified of the failure and offered no assistance. The exact failure mileage was 3,167. INFORMATION Redacted PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).”
Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.
Categories with enough reports to have a page of their own
Data on this page last refreshed .