2011 Ford F-350 Problems

On this day, I financed the vehicle and was promised that it was safe to be on the road. This is the second vehicle. He’s done this to me with. He gets these vehicles and just put stickers in the windows and then people break down or their lives are in jeopardy so I left there After I purchased the truck the following day I was driving and I noticed a bunch of defects which included a death wobble, front end parts being bad and engine light being on I took it to another shop and they said that it should’ve never even gotten an inspection sticker I also went on [XXX] and found out that the vehicle did not go through any emissions test and being a diesel it’s supposed to that’s why the engine lights are on on the third day of owing it. The driveshaft snapped right off this Dealership has multiple reviews and reports of being shady and just putting inspection stickers in the windows. He has somebody at another auto shop that he pays extra just to put the sticker in the window Not only is this unsafe for other people it’s not fair and it’s illegal and he does it all the time every vehicle on his lot has issues and the inspections are not done at alll so many issues half of them shouldn’t even be on the road. The dealership is. Low priced auto in Rome ny and the people Who inspect are sharkeys auto in Rome INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The contact owns a 2011 Ford F-350. The contact stated while driving 70 MPH, the vehicle experienced a Death Wobble. The contact stated that the front end of the vehicle and the steering wheel were shuddering violently from the right to the left, causing the contact to lose control of the vehicle. The contact stated that he was able to regain control of the vehicle upon decelerating to 10 MPH. The contact was able to pull to the side of the road. The vehicle was taken to Litchfield Auto Repair, where the axle track bar ball joint, the steering damper, the drag link, and the tie rod or the tie rod end were replaced. Additionally, the mechanic performed the front alignment; however, the failure recurred while driving 75 MPH and hitting a bump. The vehicle was taken to the dealer, where it was inspected, and the contact was informed that the previous repair was performed correctly. The dealer replaced the tires because the tires were worn out. The vehicle was not repaired. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 230,000.

On this day, I financed the vehicle and was promised that it was safe to be on the road. This is the second vehicle. He’s done this to me with. He gets these vehicles and just put stickers in the windows and then people break down or their lives are in jeopardy so I left there After I purchased the truck the following day I was driving and I noticed a bunch of defects which included a death wobble, front end parts being bad and engine light being on I took it to another shop and they said that it should’ve never even gotten an inspection sticker I also went on [XXX] and found out that the vehicle did not go through any emissions test and being a diesel it’s supposed to that’s why the engine lights are on on the third day of owing it. The driveshaft snapped right off this Dealership has multiple reviews and reports of being shady and just putting inspection stickers in the windows. He has somebody at another auto shop that he pays extra just to put the sticker in the window Not only is this unsafe for other people it’s not fair and it’s illegal and he does it all the time every vehicle on his lot has issues and the inspections are not done at alll so many issues half of them shouldn’t even be on the road. The dealership is. Low priced auto in Rome ny and the people Who inspect are sharkeys auto in Rome INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The contact owns a 2011 Ford F-350. The contact stated while driving 70 MPH, the vehicle experienced a Death Wobble. The contact stated that the front end of the vehicle and the steering wheel were shuddering violently from the right to the left, causing the contact to lose control of the vehicle. The contact stated that he was able to regain control of the vehicle upon decelerating to 10 MPH. The contact was able to pull to the side of the road. The vehicle was taken to Litchfield Auto Repair, where the axle track bar ball joint, the steering damper, the drag link, and the tie rod or the tie rod end were replaced. Additionally, the mechanic performed the front alignment; however, the failure recurred while driving 75 MPH and hitting a bump. The vehicle was taken to the dealer, where it was inspected, and the contact was informed that the previous repair was performed correctly. The dealer replaced the tires because the tires were worn out. The vehicle was not repaired. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 230,000.

On this day, I financed the vehicle and was promised that it was safe to be on the road. This is the second vehicle. He’s done this to me with. He gets these vehicles and just put stickers in the windows and then people break down or their lives are in jeopardy so I left there After I purchased the truck the following day I was driving and I noticed a bunch of defects which included a death wobble, front end parts being bad and engine light being on I took it to another shop and they said that it should’ve never even gotten an inspection sticker I also went on [XXX] and found out that the vehicle did not go through any emissions test and being a diesel it’s supposed to that’s why the engine lights are on on the third day of owing it. The driveshaft snapped right off this Dealership has multiple reviews and reports of being shady and just putting inspection stickers in the windows. He has somebody at another auto shop that he pays extra just to put the sticker in the window Not only is this unsafe for other people it’s not fair and it’s illegal and he does it all the time every vehicle on his lot has issues and the inspections are not done at alll so many issues half of them shouldn’t even be on the road. The dealership is. Low priced auto in Rome ny and the people Who inspect are sharkeys auto in Rome INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The contact owns a 2011 Ford F-350. The contact stated that while driving approximately 30 MPH, the vehicle lost automotive power and stalled. During the failure, diesel fuel and oil spilled from the engine. The vehicle was towed to the local mechanic who diagnosed that the strap that secured the fuel injectors had failed, causing the fuel injectors to eject from the engine. The contact was advised that the fuel injector straps, fuel injectors, and several fuel hoses needed to be replaced. The vehicle was not yet repaired. The manufacturer and local dealer were notified of the failure, but no assistance was offered. The failure mileage was 40,000.

The contact owns a 2011 Ford F-350. The contact stated while reversing, the vehicle failed to accelerate as intended while depressing the accelerator pedal. The contact stated that the vehicle stalled and failed to restart. There was no warning light illuminated. The contact stated that an independent mechanic arrived at the residence however, the vehicle failed to restart. The vehicle was towed to an independent mechanic. The contact was informed that the high-pressure fuel pump had failed, and the fuel system needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure but denied assistance in covering the cost of the repair. The failure mileage was approximately 200,000.

The contact owns a 2011 Ford F-350. The contact stated that while driving approximately 30 MPH, the vehicle lost automotive power and stalled. During the failure, diesel fuel and oil spilled from the engine. The vehicle was towed to the local mechanic who diagnosed that the strap that secured the fuel injectors had failed, causing the fuel injectors to eject from the engine. The contact was advised that the fuel injector straps, fuel injectors, and several fuel hoses needed to be replaced. The vehicle was not yet repaired. The manufacturer and local dealer were notified of the failure, but no assistance was offered. The failure mileage was 40,000.

Odometer Fraud. The contact called on behalf of his client, who purchased a 2011 Ford F-350. The contact stated that while the client was in the process of selling the vehicle to a dealer, the dealer retrieved the Carfax report and informed the client that the odometer had been rolled back and that the vehicle could not be sold. The vehicle was a private sale. At the time of the purchase, the mileage was 128,530, and a dealer later informed the client that the mileage on the Carfax report was 345,000. The current mileage displayed on the odometer was 147,000. No other agency was contacted.

THE INTERIOR WIRING HARNESS SHORTED VIA THE SEATBELT AND MELTED THE ENTIRE WIRING HARNESS. THE CAR WAS IN MOTION AND A CITY STREET AND STARTED SMOKING FROM THE DRIVER SEATBELT HOUSING. NO FUSES BLEW FROM THE SHORT WHICH CAUSED THE HARNESS TO MELT.

Annual inspection of the Progress Manufacturing Equal-I-Zer (model number 90-02-1200) steel head assembly revealed cracks in the welds holding the two steel plates that support the spring bar sockets and the welds that attach the head component (part with the hitch ball) to the U-shaped bracket that attaches/bolts the head to the shank that is inserted into the receiver. I have pictures of the cracked welds. The assembly has been sent to a certified welding/fabrication shop for repair at my expense. If the welds failed, two scenarios are very likely: 1. The spring bars will separate from the head assembly, releasing two 20+ pound steel rods in an uncontrolled and unconstrained manner onto the pavement. Of the tow vehicle, trailer, or another car are struck by one or both rods, the result could be severe damage and/or injury. 2. If the welds holding the head assembly containing the hitch ball to the U-shaped bracket that is bolted to the shank failed, the entire hitch assembly and trailer would detach from the tow vehicle; the safety chains would provide the only mechanism to keep the trailer from detaching completely from the tow vehicle. Severe damage could occur to the trailer and tow vehicle. If the safety chains fail, the trailer would careen uncontrolled into other drivers on the road. A master welder and certified weld inspector looked at the pictures of the cracked welds and stated that "Lack of weld metal fusion, likely it was there when you bought it." I posted the pictures of my cracked welds on three FaceBook groups focused on RVing with approximately 300,000 members. Several members stated they, too, found cracks in their welds. The manufacturer was sent the pictures. They refused to stand behind their product and told me to buy a replacement head for $275.00. There were no warning lamps, messages or other symptoms of the problem prior to the failure. There may be a systemic welding problem at the PM factory.

VEHICLE HIT A POTHOLE ON INTERSTATE 75 NORTH NEAR DALTON GEORGIA AT APPROXIMATELY 65 MILES PER HOUR. THE FRONT RIGHT WHEEL AND FRONT END VIOLENTLY SHOOK AND THE STEERING WHEEL SHOOK SO BAD CONTROL OF THE F350 BECAME AN ISSUE. I WAS UNABLE TO CONTROL THE VEHICLE UNTIL I SLOWED TO BELOW 20 MILES PER HOUR. THE INCIDENT PRESENTED A VERY SERIOUS SAFETY ISSUE

WHILE DRIVINGMY FORD F350 CREW CAB LONGBED DIESEL 4X4 AT 70 MPH ON INTERSTATE 10, A 4 LANE HWY IN EACH DIRECTION, THE TRUCK LOST ALL ENGINE POWER AND POWER ASSIST TO THE BRAKES AND POWER STEERING. LUCKILY THE TRAFFIC WAS LIGHT AND I WAS ABLE TO MANEUVER THE OFF THE HWY WITHOUT COMING IN CONTACT WITH ANOTHER VEHICLE. THE TRUCK WAS TOWED TO A FORD DEALERSHIP AND IT WAS DETERMINED THAT THE HIGH PRESSURE FUEL PUMP CAME APART AND PUT METAL SHAVING EVERYWHERE THROUGHOUT THE FUEL SYSTEM. FORD RECOMMENDED REPLACING ALL OF THE HIGH PRESSURE SYSTEM THIS INCLUDED ALL NEW FUEL INJECTORS. THIS REPAIR COST $9,000.. A SEARCH OF THE INTERNET REVEALED THAT THIS IS A KNOWN FAILURE. I HAD AN INDEPENDENT LAB TEST THE FUEL. THERE WERE NO CONTAMINANTS IN THE FUEL EXCEPT THE METAL SHAVING FROM THE PUMP. ( THE FORD FUEL SYSTEM RECIRCULATES THE EXCESS FUEL BACK TO THE TANK) THE TRUCK HAS 115000 MILES. I HAD THE FORD MAINTENANCE AGREEMENT WITH THE 5000 MILE SERVICES OPTION. FORD HAS PROVIDED ALL OF THE SERVICE INCLUDING THE ONES AFTER THE MAINTENANCE AGREEMENT ENDED. THIS IS A VERY EXPENSIVE REPAIR TO UNDERTAKE ON A 7 YEAR OLD VEHICLE. ENGINEERING CHANGES COULD HAVE PREVENTED THE EXTENT OF THE DAMAGE. A POST PUMP FILTER OR SCREEN WOULD HAVE PREVENTED THE REST OF THE HIGH PRESSURE SYSTEM FROM NEEDING REPLACEMENT. AN ADVISORY ABOUT THE POTENTIAL PUMP FAILURE AND REPLACING THE PUMP BEFORE FAILURE WOULD HAVE COSTED LESS THAN $2000. HAD I BEEN TOWING NEAR FULL GCWR, 21,000 LBS AND COME UP ON LOS ANGELES STOP AND GO TRAFFIC, THIS COULD HAVE BE A TERRIBLE ACCIDENT.

2011 FORD F-350. CONSUMER WRITES IN REGARDS TO DIESEL ENGINE FAILURE - SERVICE BULLETIN REFERS TO VEHICLE MISFIRE/ RUNS ROUGH DUE TO A BROKEN INJECTOR HOLD DOWN CLAMP. *SMD ..UPDATED 09/07/17*BF THE CONSUMER STATED WHILE DRIVING THE ENGINE SUDDENLY LOST POWER AND STOPPED. THE ENGINE WOULD NOT RESTART OR IDLE. THE CONSUMER ADVISES THE FAILURE SHOULD BE A RECALL.. *JS UPDATED 9/5/18*JB

I WAS DRIVING AND MY STEERING ARMS CAUGHT ON FIRE.

DRIVING ON HIGHWAY AT 70 MPH, HIT BUMP IN THE ROAD AND THE WHOLE FRONT END STARTS WOBBLING SO BAD AND HAD TO SLOW WAY DOWN TO GET IT TO STOP. WAS ALMOST REAR ENDED BY VEHICLE BEHIND ME AND CAR PULLED BESIDE ME AND WAS POINTING AT FRONT OF TRUCK, SO I THOUGHT I HAD A FLAT. PULLED OFF ROAD AND NO FLAT, SCARED ME SO WAITED A FEW MINUTES AND PROCEEDED ON. THIS HAS HAPPENED ON A COUPLE OCCASIONS, ALWAYS WHEN HIT A BY SPOT IN ROAD, ONCE GOING OVER SMOOTH RAILROAD TRACKS. ALSO WILL BE DRIVING AND FOOT ON GAS PEDAL AND ALL OF SUDDEN HAVE NO POWER. TRUCK WILL LOOSE ALL POWER OUT OF NOWHERE WHILE DRIVING AND OTHER TIMES WILL DRIVE JUST FINE. HAVE HAD TROUBLE IN THE ELECTRICAL SYSTEM WITH IT STARTING, HAVE REPLACED BATTERIES TWICE AND PERIODICALLY WILL NOT TURN OVER, IT'S LIKE THE BATTERIES ARE COMPLETELY DEAD WHEN THEY ARE NOT.

The contact owns a 2011 Ford F-350 equipped with Toyo Tires, Tire Line: Open Country AT II, Tire Size: LT295/65/R20, DOT Number: 73D9M7L2017. The contact stated while driving 55 MPH and towing a fifth-wheel trailer, he noticed the vehicle was unbalanced on the rear driver’s side. The contact stated no warning light was illuminated. The contact was able to park at a nearby parking lot and noticed a 4-inch blister on the side of the rear driver’s side tire. The contact replaced the tire with a spare tire and continued driving to his destination. The contact took the vehicle to the local dealer, where it was determined that all four tires needed to be replaced. The vehicle was not repaired. The manufacturer of the tire had been informed of the failure. The failure mileage was 91,797.

The contact owns a 2011 Ford F-350 equipped with Cooper Tires, Tire Line: Discover AT/3 XLT, DOT Number: UT15/1/ne/201915l, Tire Size: 275/70/R18. The contact stated that he was in the process of placing winter tires on the vehicle and noticed that two of the tires had formed irregular bubbles on the side of tires. The contact took the tires to a local tires shop where they stated they would replace only one of the tires under warranty coverage. The contact was concerned after finding out the tire manufacturer had recalls on similar tires that were purchased, but not the exact tires he owned. The contact was also concerned that the tires could cause an accident if a failure was experienced while driving on the tires. The tires were not replaced. The manufacturer was made aware of the failure. The failure mileage on the tires was 1,934. The vehicle failure mileage was unavailable.

This truck has never stopped well. Seems like the ABS coasts to a stop no matter how hard I stand on the brakes.

PAEKING BRAKE BACKING PLATES COMPLETELY RUSTED THROUGH WHEN REPLACONG BRAKE ROTORS. FORUMS SAY THIS IS A COMMON PROBLEM. FORD SHOULD POWDER COAT THE PARTS.IF THIS PRONE TO RUST. MAY CAUSE WHEEL.LOCK AT HIGH SPEED.

6 of the 8 polyurethane cab mounts positions 1, 2 and 4 crumbled and fell out of the truck

THE TRUCK HAS 8 CAB BODY MOUNT BUSHINGS THAT HAD DETERIORATED AWAY THAT LEFT THE CAB MOVING AND BOUNCING UP AND DOWN ON THE FRAME. THIS HAPPENED WHILE DRIVING DOWN THE ROAD WHILE IN MOTION ON THE HIGHWAY AND IN THE CITY. THE TRUCK HAS LESS THAN 80000 MILES.

POWER FOLDING SIDE REAR VIEW MIRRORS WILL NOT HOLD THEIR POSITION SETTING CAUSING LACK OF ABILITY TO MONITOR TRAFFIC ON BOTH SIDES OF THE VEHICLE WHEN VEHICLE IS IN MOTION.

MY 2011 F-350 TRUCK'S HEATING SYSTEM SUDDENLY WOULD NOT SWITCH LOCATIONS. IT WAS STUCK ON DASHBOARD HEATING, AND WOULD NOT SWITCH TO THE FLOOR OR TO THE DEFROST. THE TRUCK IS 2 YEARS OLD. AT THE BEGINNING OF WINTER, DRIVING WITHOUT DEFROST IS RATHER HAZARDOUS AS IT IS DIFFICULT TO DEFROST THE WINDSHIELD. I HAD TO PAY TO GET IT FIXED, AND IT COST ME $1862.37. I FEEL THAT ANY VEHICLE'S HEATING SYSTEM OUGHT TO OPERATE WITHOUT ISSUES FOR A DECADE OR MORE, SO IT WAS RATHER FRUSTRATING TO HEAR THAT FORD WOULD NOT COVER IT ON MY 2 YEAR OLD VEHICLE. BESIDES THE COMMON SENSE FRUSTRATION FACTOR, IT COULD BE A SAFETY CONCERN IF IT IS A COMMON OCCURRENCE IN THAT PEOPLE MAY NOT BE ABLE TO DEFROST THE WINDSHIELD, WHICH COULD RESULT IN EXCESSIVE FROST BUILDUP IN NORTHERN CLIMATES, WHICH CAN BLOCK THE DRIVER'S VISION AND RESULT IN A CRASH. *TR

TL* THE CONTACT OWNS A 2011 FORD F-350. THE CONTACT STATED THAT WHILE DRIVING AT VARIOUS SPEEDS, THE DOORS WERE SHAKING. THE DOORS SPONTANEOUSLY OPENED. THE DOOR AJAR WARNING LIGHT WAS ILLUMINATED. THE VEHICLE WAS TAKEN TO FAITH'S FORD NORTH (6896 US-5, WESTMINSTER, VT 05158 (802) 463-3300) TO BE DIAGNOSED. THE CONTACT WAS INFORMED THAT THE DOOR LATCHES NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE CONTACT STATED THE VEHICLE WAS UNSAFE TO DRIVE. THE MANUFACTURER WAS CONTACTED AND REFERRED THE CONTACT TO NHTSA. THE FAILURE MILEAGE WAS APPROXIMATELY 70,000. INVALID VIN.

TL* THE CONTACT OWNS A 2011 FORD F-350. THE CONTACT STATED THAT THE INTERIOR LIGHTING FAILED TO OPERATE WHILE HE WAS INSIDE THE VEHICLE OR WHEN THE DOORS WERE OPEN. THE VEHICLE WAS TAKEN TO TYLER FORD (2626 S SW LOOP 323, TYLER, TX 75701, (800) 788-7876) TO BE DIAGNOSED, BUT THE CAUSE OF THE FAILURE COULD NOT BE DETERMINED. THE VEHICLE WAS NOT REPAIRED AND THE FAILURE RECURRED MULTIPLE TIMES. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED, BUT THE CAUSE OF THE FAILURE COULD NOT BE DETERMINED. THE CONTACT REFERENCED NHTSA CAMPAIGN NUMBER: 11V128000 (ELECTRICAL SYSTEM). THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND INFORMED THE CONTACT THAT THE VIN WAS NOT INCLUDED IN A RECALL. THE FAILURE MILEAGE WAS APPROXIMATELY 105,000.

TL* THE CONTACT OWNS A 2011 FORD F-350. WHEN ATTEMPTING TO SHIFT BETWEEN GEARS THE VEHICLE WOULD HESITATE. THE VEHICLE WOULD ALSO DOWN SHIFT INTO NEUTRAL GEAR WHILE THE RPMS INCREASED BUT THE ACCELERATOR PEDAL DID NOT RESPOND. THE FAILURE OCCURRED INTERMITTENTLY SINCE THE VEHICLE WAS PURCHASED IN AUGUST 2010. THE DEALER MADE TWO ATTEMPTS TO DUPLICATE THE FAILURE. THE PERFORMANCE WAS MONITORED BY THE DVR SYSTEM; HOWEVER, THE SYSTEM COULD NOT DETECT ANY CODES. THE MANUFACTURER WAS AWARE OF THE FAILURE; HOWEVER, THEY DID NOT OFFER ANY ASSISTANCE. THE VEHICLE WAS NOT REPAIRED. THE CURRENT MILEAGE WAS 31,000. THE APPROXIMATE FAILURE MILEAGE WAS 1,500.

THE VEHICLE WA IN MOTION, RAN OFF THE SIDE OF THE ROAD , CLIPPED A FEW TREES, LANDED IN A POND. FORCE OF IMPACT HITTING WATER CRACKED WINDSHIELD. PASSENGER SIDE OF TRUCK WAS MAULED.TRUCK WAS TOTALED.... AIR BAGS DID NOT DEPLOY, HAD THERE BEEN A PASSENGER, IN ALL LIKELY HOOD WOULD HAVE BEEN DEAD.