2005 Ford Five Hundred Brakes Problems

I DONT FEEL SAFE DRIVING MY CAR I PUT 2000 DOLLARS OF WORK AND STILL DO NOT FEEL SAVE.

NHTSA ID

10865576

Incident

May 5, 2016

Mileage

110,000 mi

TRIED TO PULL OUT ON TO HWY. THE FAIL SAFE LIGHT CAME ON AND SHUT DOWN ENGINE. COULD NOT STEER OR CONTROL CAR AT ALL, WAS VERY CLOSE TO HAVING A BAD ACCIDENT. *TR

NHTSA ID

10622073

Incident

Aug 8, 2014

Mileage

74,000 mi

WHILE STUCK IN RUSH HOUR TRAFFIC, CAR WAS AT A COMPLETE STOP AT A RED LIGHT. WHEN TRYING TO LET OFF THE GAS, THE CAR LURCHED FORWARD ALMOST PLOWING INTO THE CAR IN FRONT OF ME. THIS OCCURRED ON 06/20/2012. DURING SUMMER 2011, THIS SAME TYPE OF BEHAVIOR OCCURRED 4 DIFFERENT TIMES. THE ENTIRE PROCESS BEGINS WITH THE CAR BEING AT A COMPLETE STOP, THEN WHEN LETTING OFF THE GAS, THE CAR'S ENGINE REV'S AND THE CAR LURCHES FORWARD REQUIRING THE DRIVER TO SLAM ON THE BREAKS FROM HITTING OTHER DRIVERS/PEDESTRIANS. WHEN THE VEHICLE DOES THIS LURCHING FORWARD MOTION, SEVERAL RED LIGHTS COME ON THE INSTRUMENT PANEL AND ALSO THE COMPUTER READS AN ERROR OF "FAILSAFE ENGINE MODE". POWER STEERING, POWER BRAKES HAVE BEEN LOST WHILE THIS EVENT OCCURS AS WELL. SEEMS AS IF IT COULD BE AFFECTED BY WARMER WEATHER BECAUSE I HAVE OWNED THE VEHICLE TWO YEARS AND HAVE ONLY HAD THIS HAPPEN DURING WARMER (90 DEGREE OR MORE) WEATHER. DURING SUMMER 2011, TWO OCCURRENCES HAPPENED THAT ALSO ALMOST CAUSED COLLISIONS. THE FIRST TIME WAS ON A SUMMER NIGHT IN A PARKING GARAGE. AS I WAS COMING INTO A STOP IN A PARKING SPACE, THE ENGINE LURCHED FORWARD AND CAME APPROXIMATELY 4-5 INCHES FROM HITTING A CONCRETE WALL. DURING THE OTHER OCCURRENCE, I WAS STOPPING AT A RED LIGHT AND CAME CLOSE TO RUNNING OVER A PEDESTRIAN DUE TO LURCHING FROM CAR. WHEN CAR ENTERS "FAILSAFE ENGINE MODE' AND LURCHES FORWARD, CAR MUST BE PARKED AND RESTARTED FOR THE VEHICLE TO RUN NORMALLY AGAIN. ALSO, IT ONLY HAPPENS AT LOW SPEEDS (I.E. WHEN SLOWING THE CAR BELOW 5 MPH OR FIRST BEGINNING TO ACCELERATE THE CAR WHILE STILL BELOW 5 MPH). OTHER OWNERS THAT HAVE EXPERIENCED THIS SAME ISSUE CAN BE FOUND HERE: HTTP://WWW.FORDTAURUS.NET/FORUMS/VIEWTOPIC.PHP?F=5&T=9366 AND ALSO: HTTP://WWW.ABOUTAUTOMOBILE.COM/COMPLAINT/2007/FORD/FIVE+HUNDRED/10439966 *TT

NHTSA ID

10462801

Incident

Jun 1, 2011

Mileage

95,000 mi

WE BOUGHT MY CAR IN JULY 2011, ITS WAS GARAGED BY THE 1ST OWNER SO IT WAS LIKE BRAND NEW!! LOW MILES JUST 12,850 , START WHAT NOW SEEMS TO BE THE ENDLESS DRIVES IN A RENTAL CAR AND WITH EMPTY WALLETS TOTALING NOW APPROX; CLOSE TO AN ADDITIONAL $3,500 NOW IN REPAIRS FROM THE BATTERY IN AUG 2011 TO NOW TO HAVING THE THROTTLE BEING REPLACE ALONG WITH A SET IF TIRES AND THE 2ND SET OF BOTH REAR AND FRONT BRAKES IN LESS THEN A YEAR , ALL DUE TO THE CONSENT STOPPING AND GOING OF THE CAR BY HITTING THE BRAKES TOO MUCH AND HAVING TO ACCELERATE, BECAUSE THE CAR WOULD WHILE TEMPTING TO PULL OUT OF MY GARAGE AT WHAT SHOULD OF BEEN A MERE 3MILES PER HOUR; RESULTED IN FLYING BACKWARDS SUDDENLY WHILE FOOT WAS APPLYING PRESSURE ON THE BRAKES TO KEEP FROM MOWING DOWN MY TEENAGE SON AT 15 MILES A HOUR ON ITS OWN WITH THE MP RISING RAPIDLY , WAS THE SCARE OF MY LIFE!!!! PLEASE SOMEONE RECALL THIS CAR , BEFORE SOMEONE REALLY DOES GET KILLED OR HURT!!! AS OF TODAY THE TOTAL THIS TIME TO REPAIR MY CAR IS AT A TOTAL IF$ 1,585.00; TO REPLACE THE THROTTLE AND TIRES & BRAKES AGAIN, AND FORD WOULDN'T EVEN COMP, US A RENTAL CAR THIS TIME ON OUR 5 TRIP DOWN TO THE SERVICE DEPT OF FORD!!!! *TR

NHTSA ID

10446102

Incident

Aug 15, 2011

Mileage

12,500 mi

I OWN A 2005 FORD 500. I HAVE HAD TO HAVE THE RIGHT PASSENGER FRONT BALL JOINT TIGHTENED SEVERAL TIMES. THE LOCAL FORD DEALER DOES NOT WHAT IS CAUSING THIS ISSUE. THE BALL JOINT BECOMES LOOSE CAUSE THE FRONT END TO COME OUT OF ALIGNMENT AND WILL JERK THE CAR ACROSS THE HIGHWAY. *TR

NHTSA ID

10392980

Incident

Mar 2, 2011

Mileage

47,000 mi

TL*THE CONTACT OWNS A 2005 FORD FIVE HUNDRED. THE CONTACT WAS DRIVING APPROXIMATELY 2 MPH IN THE DRIVEWAY. WHEN PRESSURE WAS APPLIED TO THE BRAKE PEDAL, A LOUD GRINDING NOISE SOUNDED. THE VEHICLE WAS TAKEN TO THE DEALER FOR DIAGNOSIS; AND THE BRAKE LINING KIT WAS REPLACED UNDER A VOLUNTARY RECALL ISSUED BY THE MANUFACTURER. THE IDENTICAL FAILURE OCCURRED THREE YEARS LATER. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THE ROTORS AND BRAKE LINING KIT WERE REPLACED. THE FAILURE MILEAGE WAS 76,400. UPDATED 02/17/11*LJ UPDATED 05/02/11

NHTSA ID

10360363

Incident

Sep 3, 2007

Mileage

76,400 mi

TL*THE CONTACT OWNS A 2005 FORD FIVE HUNDRED. WHILE DRIVING APPROXIMATELY 5 MPH PRESSURE WAS APPLIED TO THE BRAKE PEDAL AND SHE COULD HEAR A SQUEAKING NOISE IN THE BRAKES. THE FAILURE BEGAN TO OCCUR MORE FREQUENTLY WHEN PRESSURE WAS APPLIED TO THE BRAKE PEDAL. SHE WAS NOTIFIED BY THE MANUFACTURER OF AN UNKNOWN BRAKE RECALL SO THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER WHERE IT WAS REPAIRED. THE FAILURE CONTINUED TO OCCUR. WHILE THE VEHICLE WAS PARKED SHE OPENED THE FRONT PASSENGER SIDE DOOR AND NOTICED WATER LEAKING FROM THE BOTTOM OF THE DOOR PANEL. THE VEHICLE WAS NOT EXAMINED FOR THE CAUSE OF FAILURE BUT SHE INSTALLED WINDOW RAIN GUARDS ON ALL FOUR WINDOWS. THE FAILURE CONTINUED TO OCCUR. WHILE DRIVING APPROXIMATELY 35 MPH SHE COULD FEEL THE VEHICLE SHAKING IN THE STEERING WHEEL. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE THE OEM MOTOR MOUNT AND BRACKET WERE REPLACED. THE FAILURE HAD NOT RECURRED. SHE ALSO STATED THAT WHILE THE VEHICLE WAS PARKED SHE TURNED ON THE AIR CONDITIONER BUT THERE WAS ONLY MINOR AIR FLOW COMING THROUGH THE VENTS. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE A NEW COMPRESSOR AND EXPANSION VALVE WERE INSTALLED. THE FAILURE MILEAGE WAS UNKNOWN AND THE CURRENT MILEAGE WAS 80,000. UPDATED 12/23/10*LJ THE BLEND DOOR MOTOR WAS REPLACED. UPDATED 04/06/11 UPDATED 05/26/11 *BF UPDATED 05/31/11

NHTSA ID

10353757

Incident

Sep 3, 2007

HI, I HAVE A 2005 FORD FIVE HUNDRED WHILE DRIVING ONE DAY ABOUT A MONTH AGO I HEARD THIS NOISE WHEN I PRESS THE BRAKE PEDAL,I DIDN'T THINK IT TO BE NOTHING, BUT IT FELT LIKE A STUGGLE TO STOP AND THE NOISE GET WORST IT FEELS LIKE THE CABLES OF THE BRAKE LINE ARE TO TIGHT AND EVERTIME I STEP ON THE BRAKES IT MAKES A CREEKING SOUND, A FEW DAY AGO I TOOK THE CAR IN TO HAVE THE NOISE CHECK I FOUND OUT THAT IT WAS THE BRAKE BOOSTER AND MASTER CYLINDER AND WAS TOLD IT WAS NO NEED TO HAVE IT FIX BECAUSE THE NOISE WOULD ONLY COME BACK AND THAT THE ESTIMATED COST TO REPAIR WAS AROUND $1345.99. I CONTACT THE FORD CORP., BY E-MAIL AND RECIEVED A REPONSE AND WAS TOLD THAT THERE WAS NO RECALL OR WARRANT ON THIS PART IN OTHER WORDS THEY COULD NOT HELP. I HOPE THAT YOU CAN HELP BECAUSE I'M AFRAID OF THE SAFETY FOR OTHERS AND MY FAMILY. THANK YOU *TR

NHTSA ID

10345797

Incident

Jun 1, 2010

TL*THE CONTACT OWNS A 2005 FORD FIVE HUNDRED. WHILE WASHING THE VEHICLE THE CONTACT NOTICED THAT THE REAR BRAKES WERE HOTTER THAN THE FRONT BRAKES AND THEY BEGAN MAKING A SQUEAKY NOISE WHEN APPLIED AT ANY SPEED. THE FAILURE MILEAGE WAS 14000 AND THE CURRENT MILEAGE WAS 86000.

NHTSA ID

10342059

Incident

Sep 13, 2006

Mileage

86,000 mi

I RECENTLY TOOK MY CAR IN FOR AN OIL CHANGE AND TIRE ROTATION ONLY TO BE ADVISED THAT I NEEDED REAR BRAKE ROTORS, REAR BRAKE PADS AND BRAKE FLUID FLUSH. THIS IS THE THIRD TIME I'VE REPLACED THE BRAKES ON THIS VEHICLE. THE VEHICLE HAS APPROX. 83,000 MILES ON IT AND I LIVE IN THE SUBURBS. I ARGUE WITH THE SERVICE TECH'S EVERY TIME THEY INSIST THAT THE BRAKES NEED TO BE REPLACED. I CAN'T BELIEVE THAT A CAR CAN GO THROUGH SO MANY BRAKES IN SUCH A SHORT PERIOD OF TIME. *TR

NHTSA ID

10260221

Incident

Feb 23, 2009

Mileage

83,235 mi

2005 FORD 500 REAR BRAKE PROBLEM. AT 42,469 MILES A GRINDING NOISE CAME FROM THE REAR OF THE CAR. BOTH REAR ROTORS AND PADS WERE DAMAGED AND NEEDED TO BE REPLACED. THE FRONT BRAKES WERE NOT WORN. FORD DOES NOT PAY TO CORRECT THIS WHICH IS EVIDENTLY A DESIGN PROBLEM. *TR

NHTSA ID

10247973

Incident

Sep 29, 2008

Mileage

42,469 mi

REAR BRAKES EXCESSIVE WEAR. *TR

NHTSA ID

10226002

Incident

Apr 27, 2008

Mileage

38,800 mi

PURCHASED MY 500 9/05 IT ONLY HAD 5 MILES ON IT. 6 MONTHS LATER LOUD EXPLOSION IN ENGINE WHICH BEGAN TO LEAK SOME SORT OF FLUID GOT THE CAR TOWED TO DEALER PURCHASED WAS TOLD A/C LEAKING OIL AND THEY HAD TO REPLACE THE MANIFOLD I WASN'T EVEN USING THE A/C WAS MARCH!!! MY DASH CONSOLE HAD TO BE REPLACED SINCE IT WAS DEFECTIVE AND THE COMPUTER ALSO HAD TO BE REPROGRAMMED SINCE THE CAR WOULDN'T START IN 30 DEGREE WEATHER THIS HAPPENED IN JAN06......MY FUEL STRAPS WERE REPLACED DUE TO RECALL AND MY DOOR LOCKS WERE REPLACED DUE TO RECALL AND I HAD 22K MILES WHEN THE BACK BRAKES BEGAN MAKING A TERRIBLE GRINDING NOISE WHEN BACKING UP TOOK TO DEALER SAID THAT ALTHOUGH CAR IS UNDER WARRANTY BRAKES ARE UNDER WEAR AND TEAR AND WOULD NOT BE COVERED NOW WHICH DIDN'T MAKE ANY SENSE SINCE THE FRONT BRAKES WERE GOOD HOW COULD BACK BRAKES GO BAD BEFORE FRONT BRAKES UNLESS YOU ONLY DRIVE YOUR CAR IN REVERSE????? I PAID THE $400 TO FIX SINCE WAS INFORMED 500 ROTORS CANT BE TURNED EVER WILL ALWAYS HAVE TO PURCHASE NEW ONES......THEN 6 MONTHS LATER BRAKES WERE RECALLED AND I DID REQUEST REFUND WHICH I DID RECEIVE. HOWEVER I NOW HAVE 44K NO LONGER HAVE WARRANTY SINCE EXPIRED AND I DIDN'T BUY EXTENDED WARRANTY BROUGHT CAR IN TO FORD SINCE TRANSMISSION LIGHT WAS TURNING ON AND OFF ALONG WITH THE TRACTION CONTROL LIGHT THEN HAD TRANS CENSOR REPLACED WAS TOLD THAT WAS PROBLEM THEN 2 DAYS LATER LIGHT STILL TURNING ON AND CAR WILL NOT REVERSE TOOK INTO DEALER AGAIN WAS TOLD TRANS AXLE BROKE IN HALF AND NEED NEW TRANS WHICH COSTS $5300 CAR IS ONLY WORK 9K!!!! FORD COMPANY SAID THEY WILL OFFER ASSISTANCE ONLY OF 3K SINCE OUT OF WARRANTY THEY ALSO INFORMED ME THAT HAD I PURCHASED THE EXTENDED WARRANTY I WOULD ONLY BE PAYING $100 NOTHING LIKE THROWING THAT IN YOUR FACE. I HAVE NO CHOICE BUT TO PAY IT NEED A CAR AND AM A SINGLE PARENT OF 2. ALSO BACK DOORS TRIM IS COMING APART PASSENGER SINCE IS COMPLETELY ROTTED OUT. *TR

NHTSA ID

10217296

Incident

Jan 29, 2008

Mileage

44,444 mi

2005 FORD FIVE HUNDRED REAR BRAKES WORN AT 14,000 MILES. SCRAPPING SOUNDS WERE COMING FROM THE REAR OF VEHICLE, TAKEN TO DEALER, TOLD 15 DAYS TO GET PARTS. 1 MONTH LATER WENT TO DEALER, TOLD PARTS AVAILABLE FEB 2008, TOLD TO REPAIR VEHICLE ON MY OWN AND WOULD BE REIMBURSED. CALLED FORD, TOLD TO GO AHEAD. FOUND PARTS AND HAD VEHICLE REPAIRED (NEW PADS AND ROTORS - $192.00), LATER IN THE AFTERNOON DEALER CALLS, PARTS HAVE MAGICALLY APPEARED, DEALER TOLD CAR IS REPAIRED. BOTH FORD AND DEALER REFUSE TO REIMBURSE. THIS SEEMS TO BE A PROBLEM WITH THE VEHICLE AND FORD WILL NOT OWN UP TO IT. THE REAR WHEELS UP TO THE TIME OF SCRAPPING SOUNDS SHOWED EXCESSIVE BRAKE DUST VS THE FRONT WHICH SHOWED ALMOST NO DUST. BOTH FORD AND THE DEALERSHIP DISMISSED THE REIMBURSEMENT SAYING REPAIR WAS OFFERED, WHERE WERE THE PARTS THAT JUST APPEARED OUT OF THIN AIR WHEN THE WERE SUPPOSED TO BE RECEIVED IN FEB 2008? THIS IS A SAFETY ISSUE THAT FORD IS IGNORING. GUESS I WILL NEVER BUY A FORD AGAIN IF THIS IS THE WAY THEY TREAT A CUSTOMER. *TR

NHTSA ID

10212955

Incident

Oct 27, 2007

I OWN A 2005 FORD FIVE HUNDRED. WHEN I TOOK THE CAR FOR OIL CHANGE MAINTENANCE ON 11/25 AND TO HAVE THE TIRES ROTATED AND ALIGNED, THE MECHANIC SAID THE REAR BRAKES ON THE VEHICLE WERE 95% WORN, AND SHOULD BE REPLACED IN SHORT ORDER. THIS IS UNUSUAL SINCE THE VEHICLE IS FRONT WHEEL DRIVE AND ONLY HAD 21,300 MILES. THE MECHANIC AT THE DEALER STATED THAT THEY WERE RECEIVING SEVERAL COMPLAINTS REGARDING THE BRAKES FOR THAT MAKE OF VEHICLE. *TR

NHTSA ID

10211313

Incident

Nov 25, 2007

MY WIFE RECEIVED A NOTICE FROM FORD ABOUT A POSSIBLE SAFETY PROBLEM WITH THE REAR BRAKES. THE NOTICE WAS RECEIVED AFTER THE REPAIRS WERE MADE AND WE PAID FOR THEM. *JB

NHTSA ID

10198221

Incident

May 1, 2007

TL*THE CONTACT OWNS A 2005 FORD FIVE HUNDRED. THE CONTACT HAD TO REPLACE THE REAR BRAKES ON HIS VEHICLE. HE FOUND IT TO BE UNUSUAL SINCE THE VEHICLE IS FRONT WHEEL DRIVE AND ONLY HAD 19,500 MILES. THE MECHANIC AT THE DEALER STATED THAT THEY WERE RECEIVING SEVERAL COMPLAINTS REGARDING THE BRAKES FOR THAT MAKE OF VEHICLE. THE CURRENT MILEAGE IS 20,500 AND FAILURE MILEAGE WAS 19,500.

NHTSA ID

10194258

Incident

Mar 1, 2007

Mileage

19,500 mi

TL*THE CONTACT OWNS A 2005 FORD FIVE HUNDRED. THE CONTACT STATED THAT THE VEHICLE'S TWO REAR ROTORS HAVE FAILED. SHE HAD BOTH OF THEM REPLACED ALONG WITH THE BRAKE PADS. THE DEALER STATED THAT THERE WAS A GROOVE IN THE REAR ROTORS DUE TO A DESIGN FLAW THAT FORD HAS JUST RECENTLY NOTICED IN THE FORD FIVE HUNDREDS AND FREESTYLES. THE CONTACT HEARD A LOUD GRINDING NOISE WHEN DRIVING IN REVERSE. FORD STATED THAT THE VENDOR OF THE PARTS IS FOR THE FAILURE. THE CONTACT ALSO NOTIFIED THE BETTER BUSINESS BUREAU. THE ENGINE SIZE WAS UNKNOWN. THE CURRENT MILEAGE IS 40,400 AND FAILURE MILEAGE WAS 39,000.

NHTSA ID

10190915

Incident

Apr 1, 2007

Mileage

39,000 mi

TL*THE CONTACT OWNS A 2005 FORD FIVE HUNDRED. ON MARCH 26, 2007, THE CONTACT HAD THE REAR BRAKES ON HIS VEHICLE CHECKED AND WAS TOLD BY THE MECHANIC THAT THE BRAKES WERE IN GOOD CONDITION. ON MAY 10, 2007, THE BRAKES BEGAN TO FAIL. WHILE DRIVING 35 MPH UNDER NORMAL CONDITIONS, THE CONTACT HEARD THE REAR BRAKES GRINDING METAL TO METAL. THE CONTACT TOOK THE VEHICLE TO THE DEALER WHO REPLACED THE REAR ROTORS AND BRAKE PADS. THE CONTACT HAS THE REAR ROTORS TO SHOW THE UNUSUAL WEAR. THE CONTACT ALSO HAS THE REPAIR ORDERS FROM BOTH REPAIRS. THE ENGINE SIZE WAS UNKNOWN. THE CURRENT AND FAILURE MILEAGES WERE 38,585. THE DEALER STATED THAT THE RECALL FOR THIS CAR WAS PERFORMED ON THE LATCH OF THE DOOR FOR THIS VEHICLE. UPDATED 06/06/07 *TR

NHTSA ID

10190662

Incident

May 10, 2007

Mileage

38,585 mi

TL*THE CONTACT OWNS A 2005 FORD FIVE HUNDRED. WHILE DRIVING 55 MPH, THE CONTACT HEARD A NOISE AND PULLED INTO A PARKING LOT. SHE ATTEMPTED TO DRIVE BUT WAS UNABLE TO BECAUSE THE REAR BRAKES LOCKED AND RUINED THE ROTORS. THE VEHICLE WAS TOWED TO THE DEALER AND WAS REPAIRED. THE CURRENT MILEAGE IS 19,000 AND FAILURE MILEAGE WAS 17,736. THE CONSUMER HAS PROVIDED A COPY OF THE INVOICE. UPDATED 05/21/07 *TR

NHTSA ID

10189997

Incident

Feb 12, 2007

Mileage

17,736 mi

I PURCHASED A 2005 FORD 500 NEW IN SEPTEMBER 2005. ON APRIL 17, 2007, 20 MONTHS I TOOK IT TO THE FORD DEALER FOR A ROUTINE OIL CHANGE AND THE 16,000 MILE CHECK UP AND I WAS TOLD IT NEEDED NEW REAR BRAKES. THERE WAS ABSOLUTELY NO REASON WHY REAR BRAKES SHOULD BE REQUIRED SINCE I DRIVE VERY LITTLE, AND I TOOK EXTREMELY GOOD CAR OF THE VEHICLES. I OWN TWO OTHER CARS. THIS APPEARED TO BE A MANUFACTURING OR AN ENGINEERING FLAW. I WAS SURPRISED ON HOW QUICKLY THE FORD DEALER KNEW TO LOOK AT THE BRAKES FOR PROBLEMS. THEY MUST BE DOING THIS ON A REGULAR BASIS. I CALLED FORD, AND THEY SAID THAT THE WARRANTY ON THE BRAKES WAS ONLY FOR 12 MONTHS, VERY CONVENIENT. NHTSA SHOULD START AN INVESTIGATION GIVING THE NUMBER OF COMPLAINTS ON THIS PROBLEM.AK

NHTSA ID

10188120

Incident

Apr 17, 2007

THE FORD FIVE HUNDRED HAD REAR BRAKE PAD AND ROTOR FAILURES AFTER ONLY 22,137 MILES. THIS REQUIRED REPLACING THE PADS AND ROTORS AT MY EXPENSE. MY LAST CAR REQUIRED NEW BRAKES AT 53,000 MILES. IN ADDITION ONLY THE REAR BRAKES WERE WARN OUT. THE FRONT PADS WERE STILL OKAY. IN MY OPINION THIS WAS CLEARLY EITHER A DESIGN FAILURE OR A MATERIALS FAILURE. I CONTACTED FORD, AND WAS TOLD THAT BRAKES WERE A WEAR ITEM, AND THEY WILL DO NOTHING. FROM THE NUMBER OF CASES OF THIS TYPE FAILURE ON THE FORD FIVE HUNDRED AND THE MERCURY MONTEGO, ON THIS WEB SITE I WOULD THINK AN INVESTIGATION WOULD BE STARTED. *AK

NHTSA ID

10187802

Incident

Apr 10, 2007

Mileage

22,137 mi

TL* - THE CONTACT OWNS A 2005 FORD FIVE HUNDRED WITH A CURRENT MILEAGE OF 29,345 MILES. AFTER DRIVING THE VEHICLE FOR 191 MILES THE CONTACT HEARD A THUMPING NOISE COMING FROM THE REAR BRAKES. SHE TOOK THE VEHICLE TO THE DEALER, AND WAS TOLD THAT THERE WAS CORROSION BETWEEN THE BRAKE PADS AND ROTORS. BOTH REAR BRAKES WERE REPLACED. THE CONTACT DROVE THE VEHICLE FOR ANOTHER 9,319 MILES. WHEN THE CONTACT TOOK THE VEHICLE TO THE DEALER FOR ROUTINE MAINTENANCE SHE WAS TOLD THAT THE REAR BRAKES WERE 90% CORRODED. THE CONTACT REPLACED THE BRAKES. THE CONTACT CALLED FORD, AND WAS TOLD NOT TO USE THE BRAKES AS FREQUENTLY. *AK THE CONSUMER STATES DOOR LATCH FREEZES AT TIMES, DEALER PERFORMED RECALL ON VEHICLE. UPDATE 05/04/07*TR

NHTSA ID

10187664

Incident

Apr 10, 2007

Mileage

20,024 mi

TL*THE CONTACT OWNS A 2005 FORD FIVE HUNDRED. THE VEHICLE WAS TAKEN TO DEALER FOR ROUTINE MAINTENANCE ON MARCH 26, 2007. THE CONTACT BELIEVES THERE WAS A DEFECT WITH THE BRAKE ROTORS AND REAR BRAKES. THE CURRENT AND FAILURE MILEAGE WERE 19600.*AK THE CONSUMER TOOK THE VEHICLE TO DEALER AND THE DEALER FIXED THE REAR BRAKES AND ROTORS. CONSUMER IS CONCERNED THAT THERE WAS NO INDICATION THAT THE REAR BRAKES AND ROTORS WERE WORN AND STATES THAT POSES A SAFETY ISSUE. *4/17TR

NHTSA ID

10186217

Incident

Mar 26, 2007

Mileage

19,619 mi

2005 FORD FIVE HUNDRED CUSTOMER STATES THAT THE VEHICLE IS A LEMON AND THAT THE BRAKES NEEDS TO BE RECALLED**NAR**CC THE REAR ROTORS WERE MACHINED. *JB

NHTSA ID

10186854

Incident

Mar 1, 2007