2005 Ford Five Hundred Powertrain (other) Problems

The contact owns a 2005 Ford Five Hundred. The contact stated that while driving at various speeds, the vehicle made an abnormal knocking sound. The vehicle was taken to two independent mechanics, where the flywheel was replaced twice with used parts because the part had been discontinued. The contact stated that while her son was driving approximately 20 MPH, the vehicle stalled. The check transmission warning light, the check engine warning light, and other unknown warning lights were illuminated. The driver was able to pull over to the side of the road. The vehicle was able to restart but was undrivable. The vehicle was towed to the residence. The vehicle was not diagnosed or repaired. The manufacturer was notified of the failure. The failure mileage was 80,000.

NHTSA ID

11681667

Incident

Feb 19, 2025

Mileage

80,000 mi

While waiting at the light in traffic, my car all of a sudden Accelerated, and decelerates, I have to push hard on the breaks in order for it to not slam into the cars infront of me.. this is really dangerous, from what I have been reading this is a wide spread issue that ford has ignored for years..

NHTSA ID

11473538

Incident

Jul 12, 2022

I PURCHASED THE CAR USED WITH THE UNDERSTANDING THAT IT HAD SOME ISSUES WITH A MISFIRE. UPON INITIAL INSPECTION I FOUNT THE CAR WAS THROWING THE CODE P0351 I CLEARED ALL FAULTS AND PROBLEM WENT AWAY WEKS WENT BY AND PROBLEM STARTED AGAIN BUT MORE SEVER DURING NORMAL OPERATION THE CAR STARTED SHAKING AND SHIFTING ERRATIC I THEN CAME UPON SOME K FORMATION AS TO A RECALL FORD PUT IN PLACE STATING IMPROPER CALIBRATION OF PCM AND TCM CAUSE UNNECESSARY INTERACTION I THE ELECTRICAL SYSTEM AND MALFUNCTION OF THE VEHICLE

NHTSA ID

11366459

Incident

Aug 26, 2020

Mileage

237,232 mi

TRANSMISSION HAS VERY HARD AND DELAYED UPSHIFT AND DOWNSHIFT MAKING IT DIFFICULT TO CONTROL SPEED WHEN ACCELERATING AND DECELERATING. RPM GETS STUCK AROUND 3000 AT LOWER SPEEDS AND UPON ENGAGING INTO GEAR HAS MADE MY TIRES SQUAWK WITH A SUDDEN LUNGE IN SPEED AND SAME PROBLEM WHEN TRYING TO STOP, THE CAR LUNGES FORWARD. IT ACTS AS THOUGH IT IS IN NEUTRAL BUT THEN WHEN IT ENGAGES INTO GEAR SUDDEN CHANGES IN SPEED OCCUR CAUSING RAPID ACCELERATION OR DECELERATION. THE PROBLEM GETS WORSE AFTER THE CAR IS UP TO NORMAL OPERATING TEMPERATURE. IT DOESN'T OCCUR AS OFTEN AT COLDER OPERATING TEMPERATURE. THIS PROBLEM MAKES IT DIFFICULT TO GET BACK UP TO SAFE HIGHWAY SPEEDS AFTER HAVING TO STOP FOR TRAFFIC OR RED LIGHTS AS WELL AS HARD TO GET UP TO SPEED TO SAFELY MERGE INTO TRAFFIC FROM AN ON RAMP. AS FAR AS "WHEN" THIS HAPPENED IT IS EVERY DAY AS I DRIVE DAILY.

NHTSA ID

11365936

Incident

Oct 22, 2020

Mileage

226,768 mi

RECEIVED A CODE STATING THAT I HAVE A FAULTY PCM. WHEN I DRIVE ALL THE LIGHTS COME ON AND THE SPEED GAUGE SHUTS DOWN.

NHTSA ID

11348696

Incident

Aug 11, 2020

Mileage

266,000 mi

(ETB) ELECTRONIC THROTTLE BODY ON MY CAR CAUSES AN ACCELERATION THAT MAKES THE CAR JERK FORWARD. I'VE ALMOST HIT A WALL, AND GOD FORBID THIS HAPPENS ON THE HIGHWAY I COULD CAUSE AN ACCIDENT. ITS UNSAFE AND SHOULD BE RECALLED. POOR DESIGN I GUESS BUT IT'S NOT WORTH MY LIFE. THIS HAPPENED WHILE IDLING IN DRIVE THRU WHEN I TRIED TO GO FORWARD IT IDLED REALLY HIGH THEN DROPPED DOWN. WOULD BOT ACCELERATE AFTERWARDS.

NHTSA ID

11244759

Incident

Aug 18, 2019

Mileage

270,453 mi

I STOPPED ON A CITY STREET AT STOP SIGN. AS I TRIED TO ACCELERATE, BUT THE CAR WOULD BARELY MOVE. THE THROTTLE CONTROL/TRANSMISSION WARNING LIGHT ILLUMINATED ON THE INSTRUMENT PANEL. I TURNED THE CAR OFF AND LET IT SIT FOR ABOUT 2 TO 3 MINUTES. I STARTED THE CAR UP AND WAS ABLE TO MAKE IT HOME. I AM THANKFUL THAT THIS HAPPEN ON CITY STREET AND NOT ON THE HIGHWAY. I PLAN ON CONTACTING MY FORD DEALER TOMORROW.

NHTSA ID

11185706

Incident

Mar 10, 2019

Mileage

86,921 mi

BOUGHT THE VEHICLE USED IN MAY 2010. REALIZED EARLY-ON THAT THE TRANSMISSION WAS NOT SMOOTH, BUT WILLING TO SETTLE FOR LESS THAN PERFECTION SINCE IT WAS A 2005 VEHICLE. IN LATE 2012 OR EARLY 2013, I RECEIVED 'RECALL' NOTICE THAT PCM (I.E. - POWERTRAIN CONTROL MODULE) COULD NEED TO BE REPROGRAMMED DUE TO STALLING, HERKY-JERKY TRANSMISSION, ETC. TOOK CAR TO DEALERSHIP, THEY RAN DIAGNOSTICS, CHARGED ME $100, AND TOLD ME THAT MY CAR WASN'T EFFECTED BECAUSE NO ERROR CODES WERE NOTED AND CHECK ENGINE LIGHT WASN'T ON. I WAS NOT HAPPY, AND REFUSED TO TAKE MY CAR TO THE DEALERSHIP FOR REPAIR. PROBLEM PERSISTED, UNTIL CHECK ENGINE LIGHT CAME ON IN OCTOBER 2017 AT ROUGHLY 125,000 MILES. TOOK TO LOCAL MECHANIC, WAS CHARGED $150 FOR SENSOR REPLACEMENT. LIGHT CAME BACK ON A DAY LATER. TOOK BACK, REPLACED SENSOR FOR FREE (NICE!), BUT LIGHT BACK ON A DAY LATER. TOOK TO A DIFFERENT MECHANIC, WAS CHARGED $250, REPLACED MULTIPLE SENSORS, LIGHT BACK ON THE NEXT DAY. TOOK BACK TO 2ND MECHANIC, WHEN THEY SHARED WITH ME THAT IT WAS LIKELY THE PCM AND THE DEALERSHIP WOULD NEED TO FIX. CALLED DEALERSHIP 3 DAYS IN A ROW, ON HOLD FOR NEARLY AN HOUR THE 3RD TIME, WAS NEVER CONNECTED TO A SERVICE WRITER OR TECH, LEFT 3 VOICE MAILS FOR SERVICE MANAGER AND WAS NEVER CALLED BACK. RESEARCHED ISSUE AND FOUND NHTSA ACTION NUMBER PE11018, WHERE FORD INITIATED A CUSTOMER SATISFACTION PROGRAM 12N03 TO EXTEND COVERAGE TERMS OF REPAIR OF ENGINE IDLE RPM SURGE CAUSED BY PCM NEEDING REPROGRAMMING WITH SOFTWARE CONTAINING UPDATED IDLE SPEED CONTROL. PER NHTSA, SYMPTOMS ASSOCIATED WITH THE CONDITION MAY INCLUDE CHECK ENGINE LIGHT, DIAGNOSTIC CODES (DTCS) P0505, P0506, OR P061B. FORD ISSUED BULLETIN TSB 11-10-21 THAT INCLUDED UPDATED POWERTRAIN CONTROL CALIBRATION.

NHTSA ID

11052150

Incident

Oct 15, 2017

Mileage

100,000 mi

HARSH AND DELAYED SHIFTING. LUNGES FORWARD WHEN IN DRIVE AT STOP EVEN WITH FOOT ON BRAKE, SAME IN REVERSE. CAR SHIFTS FINE FOR FIRST 20-30 MINUTES THEN STARTS TO SHIFT HARD UP AND DOWN... SEEMS TO GET WORSE AS CAR GETS WARMER

NHTSA ID

10995044

Incident

Jun 13, 2006

Mileage

80,000 mi

AT LOW SPEEDS, WHEN TURNING AND WHEN ACCELERATING FROM A STOP, THE CAR WILL SHAKE, LUNGE AND THEN SHUT OFF. SOMETIMES IT JUST SHAKES AND HESITATES AND THEN KEEPS GOING. SOMETIMES IT TAKES A WHILE TO GET IT RUNNING AGAIN. IT ALWAYS HAPPENS WHEN THE CAR IS IN MOTION. A COUPLE OF TIMES THIS HAPPENED, THE TRANSMISSION ERROR CODES WERE DISPLAYED. I HAVE HAD THE TRANSMISSION CHECKED OUT AND IT WAS FINE.

NHTSA ID

10992138

Incident

May 29, 2017

Mileage

130,000 mi

FRONT DRIVER SIDE LOWER CONTROL ARM BALL JOINT SHEARED OFF AT 25 MPH WHILE MAKING A LEFT HAND TURN AND THEN SNAPPED THE CV JOINT AXLE SHAFT CAUSING THE DRIVER SIDE WHEEL TO JAM INSIDE THE WHEEL WELL AND DAMAGE LOWER PART OF BODY AND FENDER. THE VEHICL WAS TOTALLY DISABLE AT THIS POINT SITTING IN THE MIDDLE OF AN INTERSECTION. SIMILAR INCIDENT HAPPENED TWO YEARS AGO WITH THE PASSENGER SIDE FRONT WHEEL AND THE LOWER CONTROL ARM BALL JOINT SHEARED AND SNAPPED THE CV JOINT AXLE SHAFT AT 45 MPH AND CAUSED VEHICLE TO TURN 180 DEGREES BLOCKING TWO LANES OF HWY. THAT TIME FRONT WHEEL DAMAGED WHEEL WELL AND SENSOR WIRES ON THAT SIDE FO THE ENGINE BAY

NHTSA ID

10956245

Incident

Feb 21, 2017

Mileage

295,000 mi

TL* THE CONTACT OWNS A 2005 FORD FIVE HUNDRED. WHILE DRIVING VARIOUS SPEEDS, IT WAS DIFFICULT TO SHIFT GEARS. THE CONTACT DID NOT NOTICE IF ANY WARNING INDICATORS WERE ILLUMINATED. A MECHANIC DETERMINED THAT THE TRANSMISSION FAILED. THE VEHICLE WAS NOT REPAIRED. THE VIN WAS UNKNOWN. THE FAILURE MILEAGE WAS 145,753.

NHTSA ID

10914258

Incident

Oct 4, 2016

Mileage

145,753 mi

THE TRANSMISSION DISENGAGES AT VARIOUS SPEEDS EVEN ON THE INTERSTATE AT 55+ MPH CAUSING IT TO LOSE POWER. YOU MUST BE ABLE TO GET IT STOPPED ON THE SIDE OF THE ROAD AND SHUT THE CAR OFF AND THEN RESTART IT TO CORRECT THE PROBLEM FOR A SHORT PERIOD OF TIME.

NHTSA ID

10855177

Incident

Apr 12, 2016

Mileage

188,000 mi

I OWN A 2005 FORD FIVE HUNDRED CVT. 2 MONTHS AGO THE TRANSMISSION BEGAN ACTING UP. DRIVING ALONG AND THE "WRENCH" LITE COMES ON THEN THE "SKID" LITE COMES ON. THE CAR GOES INTO A LOSS OF POWER, LIKE LOW GEAR. IT MOVED BUT REVS UP AND WON'T SHIFTS UP. I KNOW ITS A CONSTANT VELOCITY TRANS SO IT IS AT IT'S LOWER RATIO. AFTER HOURS OF DIAGNOSTIC IT COMES DOWN TO THE TRANS CONTROL MODULE, AND STILL NOT SURE. THE OBD CODES SAY LOSS OF COMMUNICATION, A U CODE. EVERY INCH OF HARNESS HAS BEEN CHECKED THE WHOLE INTERIOR HAS BEEN REMOVED, DASH DISASSEMBLED. I'M INTO IT OVER $2,000. I LOVE THE CAR, IT RIDES GREAT. ITS HAS BEEN WELL MAINTAINED. FORD I NEED HELP. NEED TO RECALL THIS ISSUE OR HOW ABOUT A P01 OR Z01 POLICY ADJUSTMENT.

NHTSA ID

10845951

Incident

Feb 2, 2016

Mileage

141,000 mi

LEAVING A GROCER AT 13:15 ON 9/7/2015 STARTED TO BACK OUT OF PARKING SPOT WHEN AUTO SUDDENLY ACCELERATED BACKWARD, ACROSS THE AISLE AND SLAMMED INTO PARKED VEHICLE WITH IMPACT SENDING THAT AUTO INTO A 3RD. DAMAGES TO BOTH VEHICLES. WHEN I WENT TO PULL INTO MY ORIGINAL SLOT TO DEAL WITH SITUATION, AS SOON AS I REMOVED FOOT FROM BRAKE, AUTO LUNGED FORWARD AT HIGH RATE OF SPEED, JUMPED A 6" LANDSCAPE CURB AND PLOWED INTO THE FRONT END OF A CADILLAC SRX CAUSING MAJOR DAMAGE TO THAT VEHICLE, STILL UNK TOTAL DAMAGE TO MINE. IT WAS A VERY HOT DAY AND THE AC WAS RUNNING. NO OTHER VEHICLES WERE OCCUPIED OTHER THAN MINE, AND I WAS SOLE OCCUPANT. MY AIRBAG DID NOT DEPLOY AND PASSENGER'S WAS NOT TURNED ON. I DID RECEIVE A SIGNIFICANT BRUISE ON MY STERNUM FROM THE SHOULDER COMPONENT OF MY SEAT BELT. MY FOOT WAS NOT ON THE ACCELERATOR FOR EITHER "LUNGE". CRASHES WERE WITNESSED AND PEORIA AZ POLICE DID RESPOND WITH 2 UNITS. OFFICERS DID TAKE INFORMATION, BUT WHEN I INQUIRED ABOUT INCIDENT # FOR MY RECORDS OFFICER RESPONDED THAT THERE WOULD BE NO REPORT AND NO CITATIONS AS IT OCCURRED ON PRIVATE PROPERTY. MY INSURANCE CARRIER WAS CONTACTED FROM SITE, BUT BEING A HOLIDAY, I WAS NOT ABLE TO SPEAK WITH ADJUSTER AT THAT TIME. KNOWING THAT IT WAS NOT MY ACTIONS THAT CAUSED THIS INCIDENT, I CHECKED THE NEXT DAY AND DISCOVERED THAT THIS IDENTICAL SITUATION HAD BEEN UNDER INVESTIGATION WITH NHTSA AT THE TIME I PURCHASED THE CAR ON OR ABOUT 11/16/12 AT WHICH A SERVICE PROGRAM TO RETIFY WAS IN EFFECT. WITH MY INCIDENT THOUGH, MAJOR DAMAGE OCCURRED. NEITHER AT THE TIME OF PURCHASE, NOR THROUGHOUT THE INVESTIGATION & TENURE OF MY OWNERSHIP (CURRENT) WAS I NOTIFIED OF THE KNOWN SAFETY PROBLEM NOR IT'S PROGRAM TO MITIGATE. ATTACHED AERIAL PHOTO SHOWS BACK TO BACK DIMENSION TO FIRST IMPACT AND BACK TO FRONT DIMENSION OF 2ND. I WAS PARKED IN POSITION OF WHITE VEHICLE.

NHTSA ID

10778833

Incident

Sep 7, 2015

Mileage

82,700 mi

THIS PROBLEM IS GOING FOR A WHILE, EVEN IN A STOP LIGHT, FOOT ON BRAKE PEDAL THE ENGINE ACCELERATE HIMSELF AND WHILE SHIFTING FROM PARK TO REVERSE OR DRIVE THE SOUND ON THE TRANSMISSION IS HARD. IT GO FROM 700 RPMS TO 1300 RPMS ON SECONDS, AND NOW IS WORSE. TOOK THE VEHICLE TO TWO FORD REPAIR DEALERS, AFTER PUTTING ON THE COMPUTER,BOTH WANTED TO CHARGE ME $6,000.00 ON A TRANSMISSION, EVEN KNOWING THE RECALLS ON THIS UNITS.THIS CAR LOOKS LIKE NEW I CAN SEND YOU PHOTOS, AND I LOVE MY CAR.

NHTSA ID

10716614

Incident

Aug 1, 2014

Mileage

94,000 mi

I WAS DRIVING DOWN THE ROAD 35MPH AT THE TIME AND ALL OF A SUDDEN MY CAR STOPS IN THE MIDDLE OF THE ROAD AND THE WRENCH LIGHT CAME ON. I HAD TO CUT THE CAR OFF THEN SIT FOR A FEW MINUTES THEN CRANK BACK UP. THE NEXT TIME I DROVE IT I WAS DRIVING 55 MPH AND THEN ALL OF A SUDDEN IT STOPPED WHILE I WAS DRIVING THE WRENCH LIGHT CAME ON AGAIN I WAS STUCK IN THE ROAD THEN AFTER A FEW MINUTES I WAS ABLE TO CRANK BACK UP. I DROVE THE CAR FOR A FEW WEEKS SO I DECIDED TO DRIVE HOME ONE DAY ON I-95 AS I WAS DRIVING IT STOPPED AGAIN WITH CRAZY TRAFFIC. AFTER THIS EPISODE WHEN I FINALLY MADE IT HOME I DECIDED TO PARK MY CAR FOR SEVERAL WEEKS UNTIL I CALLED FORD TO SEE IF THERE WAS A WARRANTY AND THEY TOLD ME TO BRING MY CAR TO BE REPAIRED ONLY TO BE TOLD IT WAS NOT UNDER WARRANTY AND IT WOULD COST ME $2000 TO GET MY CAR REPAIRED BECAUSE THERE WAS A ALSO A LEAK WHICH IS SUPPOSED TO BE UNDER RECALL. I'VE READ A LOT OF THINGS GOING ON WITH THIS CAR IN PARTICULAR THE 2005 FORD FIVE HUNDRED. I CALLED THE FORD 800 NUMBER THAT THE MECHANIC GAVE ME TO SEE IF THEY WOULD REPAIR THE THROTTLE FOR MY CAR THEY TOLD ME THAT ITS OVER THE MILEAGE WARRANTY AND THERE IS NOTHING THEY CAN DO AND THEY DIDN'T EVEN APOLOGIZE FOR MY INCONVENIENCES WHEN I WAS STOPPED ON THE ROAD, I AM CURRENTLY USING A BORROWED CAR BECAUSE I DON'T WANT TO PUT MY LIFE IN JEOPARDY DRIVING THIS CAR UNTIL I AM ABLE TO GET IT REPAIRED. *TR

NHTSA ID

10650542

Incident

Jul 12, 2014

Mileage

156,000 mi

TL* THE CONTACT OWNS A 2005 FORD FIVE HUNDRED. WHILE DRIVING APPROXIMATELY 30 MPH, THE VEHICLE FAILED TO SHIFT INTO GEAR AND BECAME INOPERABLE. THE FAILURE OCCURRED FIVE TIMES. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC FOR DIAGNOSTIC TESTING. THE TECHNICIAN STATED THAT THE TRANSMISSION NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 139,000.

NHTSA ID

10637220

Incident

Aug 28, 2013

Mileage

139,000 mi

TRAVELING DOWN THE INTERSTATE AT 75 MPH WE RECEIVED A MESSAGE ON THE MESSAGE CENTER ABOUT A FAILURE OF SOME SORT (I DON'T REMEMBER WHAT IT SAID EXACTLY NOW). WE LOST ALL ACCELERATION OF THE CAR. WE PULLED OVER AND LET IT SIT WHILE I LOOKED UP THE ERROR ON MY PHONE. I TRIED THE CAR A BIT LATER AND IT WAS FINE. THEN WE KEPT GETTING THE ERROR. I TOOK IT TO OUR FORD DEALER AND HE CLEANED THE THROTTLE BODY...THEN REPLACE IT A WEEK LATER WHEN THAT DIDN'T FIX IT. A ABOUT 2 WEEKS LATER WE WERE GETTING ANOTHER ERROR ABOUT THE TRANSMISSION FAILING. IT STARTED MAKING A TERRIBLE NOISE. I STILL OWE 3200 ON THIS CAR,,.AND A NEW TRANSMISSION IS OVER 7K. SERIOUSLY?? I HAVE READ SO MANY POSTS ABOUT THE CVT TRANSMISSION ON THE FIVE HUNDRED AND OTHER CARS FAILING. FORD SHOULD BE ASHAMED OF THEMSELVES FOR PASSING OFF SOMETHING LIKE THIS. NOW I HAVE A 3200.00 PAPER WEIGHT IN MY DRIVEWAY....AND I CANNOT AFFORD TO BUY ANOTHER CAR. THANKS FORD!! *TR

NHTSA ID

10626874

Incident

Apr 8, 2014

Mileage

150,000 mi

THROTTLE ASSEMBLY PROBLEM. VERY SIMILAR CONCERNS AS EARLIER RECALL WHICH SUPPOSEDLY APPLIED FIX TO THE CAR A COUPLE YEARS AGO. EXCEPT .ALONG WITH UNEXPECTED ACCELERATION WHILE STOPPED A NEW PROBLEM ARISES. MOTOR ACTS AS IF IT IS NOT GETTING FUEL AND SLOWS TO A CRAWL SPUTTERING TO A STOP.. WRENCH MALFUNCTION LIGHT COMES ON. AFTER CARS SITS FOR A PERIOD OF TIME WRENCH DISPLAY GOES OFF AND CAR OPERATES NORMALLY. OWNERS MANUAL INDICATES THAT THIS MAY BE A THROTTLE ASSEMBLY PROBLEM. PRIOR RECALL NOTICE THAT HAS EXPIRED. ON MULTIPLE WEB BOARDS PROBLEM IS MENTION WITH GREAT FREQUENCY FOR THE FORD 500. THIS HAPPENED TO MY WIFE ON A SIDE STREET AT 15-20 MPH. IF IT OCCURRED ON NEXT BUST STREET IT COULD HAVE PRESENTED A DANGEROUS SCENARIO. FORD DEALER ACKNOWLEDGED THIS AS A KNOWN PROBLEM, BUT FORD MFG ONLY PROVIDED 1 TIME FIX IN RECALL & SINCE THE THROTTLE CLEANING FIXED THE PROBLEM AT THE TIME OF RECALL NO FURTHER ATTENTION WAS NEEDED. I MENTIONED THEY DID EXTEND FOR RECURRING PROBLEM BUT THAT EXTENSION 2013. I DON'T FEEL A MFG SHOULD BE ABLE TO TIME LIMIT A PROBLEM RESOLUTION THAT THEY NEVER PERMANENTLY FIX. BY WHAT I READ ON THE WEB THIS IS AN ISSUE THAT NEEDS AREAL RESOLUTION.....COST ME 900+ DOLLARS TO FIX AND FORD NOTHING! *TR

NHTSA ID

10618003

Incident

Jul 31, 2014

Mileage

163,000 mi

2005 FORD FIVE HUNDRED THIS PRODUCT WITH A CVT TRANSMISSION SHOULD BE INVESTIGATED AND RECALLED IMMEDIATELY. THERE ARE THOUSANDS FAILING AND IT IS VERY DANGEROUS! THE TRANSMISSION DISENGAGES CAUSING THE AUTOMOBILE TO LOSE POWER WITHOUT WARNING. I'VE SEEN POSTS OF THOUSANDS OF THIS SAME FAILURE BEGINNING AT 3500 MILES! I CONTACTED FORD BECAUSE MINE IS DOING THIS AND THEY BASICALLY SENT A FORM LETTER SAYING OH WELL, SORRY ABOUT YOUR LUCK. MANY OF FORD'S PRODUCTS HAVE THIS SAME ISSUE WITH THE CVT TRANSMISSION INCLUDING THE FORD FLEX WHICH IS INVOLVED IN A CLASS ACTION LAWSUIT. THE FIVE HUNDRED SHOULD BE INVOLVED IN THIS LAWSUIT AS WELL. *JS

NHTSA ID

10617188

Incident

May 8, 2014

Mileage

120,500 mi

PART OF AN ONGOING SERIES OF ISSUES WITH THIS VEHICLE (SEE EARLIER REPORTS), INITIAL SYMPTOM WAS THE DASH LIGHTS & NEEDLES SHUTTING OFF INTERMITTENTLY (BUT NOW FOR EXTENDED PERIODS). VEHICLE THEN BEGAN SHOWING RANDOM WARNING LIGHTS INCLUDING "CHECK ENGINE", WHICH WAS DIAGNOSED FIRST TIME AS LOW FUEL LEVEL SENSORS A & B. SINCE THAT TIME I'D DISCONNECTED THE BATTERY ON A SUGGESTION OF A MECHANIC FRIEND AND ALL THE ISSUES DISAPPEARED FOR A FEW WEEKS. YESTERDAY THE CHECK ENGINE LIGHT CAME BACK, AND THE CAR WAS RUNNING POORLY (CREEPING WHEN FIRST OFF BRAKES, NOT UP SHIFTING), WHEN THE DASH WAS OPERABLE IT SHOWED ALTERNATING CHECK ENGINE/CHECK TRANSMISSION WARNINGS, AND VEHICLE WAS SURGING/LAGGING NOTICEABLY AT HIGHWAY SPEEDS. I AGAIN DID THE BATTERY DISCONNECT LAST NIGHT, AND THE CAR IS OPERATING NORMAL TODAY, BUT I'M SURE IT WILL RECUR SHORTLY. I AM HESITANT TO TAKE IT TO A DEALER AS THIS SOUNDS LIKE A SIGNIFICANT ELECTRONICS ISSUE, AND I HAVE ALREADY READ UP ON THE FORD TSB 06-17-9 THAT IS DOCUMENTED ONLINE, NOT ALL OF WHICH ALIGNS WITH MY ISSUES. HAD THE BATTERY RESET HAD NO IMPACT ON THE PROBLEMS I WOULD SAY IT'S A MECHANICAL MATTER, BUT IT SEEMS CLEAR ITS A COMPUTER OR ELECTRICAL ISSUE. *TR

NHTSA ID

10593629

Incident

May 22, 2014

Mileage

36,000 mi

ON THE INTERSTATE HEADED TOWARDS DENVER, AFTER ABOUT AN HOUR, WHEN TO ACCELERATE FROM ABOUT 70MPH TO ASCEND UP THE HILLS, THE ENGINE RPMS ACCELERATE, HOWEVER, IT FEELS THAT THE TRANSMISSION IS DISENGAGED (SLIPPING) WITH NO POWER TO THE DRIVETRAIN RESULTING IN A DRASTIC LOSS OF SPEED. THIS HAPPENED NUMEROUS TIMES IN EFFORTS TO REGAIN CONTROL AND MAINTAIN SPEED. THIS WAS EXTREMELY HAZARDOUS AS TRAFFIC WAS SOMEWHAT CONGESTED, AND OTHER DRIVERS ARE EXPECTING ME TO ACCELERATE, HOWEVER, VEHICLE WAS IN A DECELERATING MODE. THIS WAS ONLY WITH LIGHT PRESSURE TO THE ACCELERATOR. IT SOUNDED AS IF THE GEARS HAD STRIPPED IN THE TRANSMISSION. WE TURNED AROUND AND HEADED HOME, AUTO WOULD NOT ALLOW SPEEDS OVER 60MPH. LATER THE SAME HAPPENED AT SPEEDS OF 35-40 ON LOCAL ROADS. THESE TRANSMISSIONS ARE EXTREMELY DANGEROUS. FORD KNOWS OF THIS PROBLEM AND REFUSES TO DO ANYTHING ABOUT THEM. *JS

NHTSA ID

10592189

Incident

May 17, 2014

Mileage

89,600 mi

WHEN STOPPED AT RED LIGHT, CAR SHOOK A COUPLE TIMES THEN CHECK ENGINE LIGHT IMMEDIATELY CAME ON. WHEN RED LIGHT TURNED GREEN, TOOK FOOT OFF OF BRAKE AND PRESSED GAS PEDAL AND WAS UNABLE TO DRIVE, BUT CAR WAS STILL ON. THROTTLE BODY CONTROL SYSTEM FAILED AND NEEDS REPLACEMENT. *TR

NHTSA ID

10577790

Incident

Apr 5, 2014

Mileage

96,651 mi

APPROXIMATELY TWO MONTHS AFTER SERVICE PERFORMED UNDER NHTSA CAMPAIGN PE11018 THE VEHICLE BEGAN TO ACCELERATE IRREGULARLY AND THEN IT PLACED ITSELF INTO "FAIL SAFE" MODE AND ILLUMINATED THE CHECK ENGINE LIGHT. VEHICLE WAS RETURNED TO THE FORD DEALER THAT PERFORMED THE SERVICE AND THEY DETERMINED THAT THE ELECTRIC THROTTLE CONTROL WAS AT FAULT BUT WAS NOT ASSOCIATED WITH THE SERVICE THEY PERFORMED ON THE SAME COMPONENT JUST WEEKS EARLIER. DEALER CONTACTED FORD MOTOR CO AND THEY ALSO CLAIMED THE TWO WERE NOT RELATED REGARDLESS OF THE SIMILAR CLAIMS FOUND ONLINE. *TR

NHTSA ID

10566671

Incident

May 5, 2013

Mileage

129,928 mi