2005 Ford Five Hundred Interior & seats Problems

TL* THE CONTACT OWNS A 2005 FORD FIVE HUNDRED. DURING INCLEMENT COLD WEATHER CONDITIONS, THE FRONT DRIVER AND PASSENGER DOORS FAILED TO LATCH SECURELY. THE VEHICLE WAS REPAIRED PER NHTSA CAMPAIGN NUMBER: 06V383000 (LATCHES/LOCKS/LINKAGES), BUT THE FAILURE RECURRED. BOYD COUNTY FORD (LOCATED AT 2119 GREENUP AVENUE, ASHLAND, KY 41101) PERFORMED THE RECALL REPAIR. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 235,000.

NHTSA ID

11171807

Incident

Jan 24, 2019

Mileage

235,000 mi

GEARING INTO REVERSE IS HEAVY SHIFTING TRANSMISSION O2 SENSOR BANK 1 NEED REPLACING

NHTSA ID

11030447

Incident

Sep 4, 2017

Mileage

264,000 mi

TL* THE CONTACT OWNS A 2005 FORD FIVE HUNDRED. THE CONTACT STATED THAT THE DRIVER'S DOOR WAS NOT ABLE TO SHUT COMPLETELY. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 06V383000 (LATCHES/LOCKS/LINKAGES). THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 100,000.

NHTSA ID

10936755

Incident

Dec 30, 2011

Mileage

100,000 mi

IN EXTREMELY COLD TEMPERATURES, THE DOOR WILL NOT LATCH OR WILL POP OPEN WHILE DRIVING. IT HAS HAPPENED MULTIPLE TIMES, BUT ONLY IN BELOW FREEZING TEMPERATURES. FORD RECALL NOTICE 06S45 DESCRIBES IT PERFECTLY, BUT SOMEHOW MY FORD FIVE HUNDRED IS NOT INCLUDED IN THE RECALL. *TR

NHTSA ID

10936443

Incident

Dec 14, 2016

Mileage

125,000 mi

2005 FORD FIVE HUNDRED. CONSUMER WRITES IN REGARDS TO DOOR LATCH MAY NOT OPERATE PROPERLY IN AN WET ENVIRONMENT RECALL NOTICE. CONSUMER STATES VEHICLE DOOR LATCHES COLLECTS WATER IN LOCKING MECHANISM/DOOR FRAME DUE TO MANUFACTURED DESIGN ISSUES. *SMD THE CONSUMER STATED THE DRIVER SIDE DOOR/LATCH WOULD NOT LOCK. THE CONSUMER STATED HE WAS ABLE TO DRAIN 8-10 OUNCES OF WATER OUT OF THE DOOR CAVITIES, BY LIFTING THE RUBBER GASKET ON THE DOOR FRAME AT THE BOTTOM. *JB

NHTSA ID

10875107

Incident

Jun 1, 2016

TL* THE CONTACT OWNS A 2005 FORD FIVE HUNDRED. THE CONTACT STATED THAT THE DOOR LATCH FAILED TO CLOSE. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE DOOR LATCH NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 145,618.

NHTSA ID

10811435

Incident

Oct 15, 2015

Mileage

145,618 mi

TL* THE CONTACT OWNS A 2005 FORD FIVE HUNDRED. THE CONTACT STATED THAT DURING COLD WEATHER, THE FRONT DRIVER AND PASSENGER SIDE DOORS WERE ALMOST IMPOSSIBLE TO OPEN DUE THE LATCHES BECOMING FROZEN. THE CONTACT MENTIONED THAT THERE WERE TIMES WHEN THE LATCHES WOULD FREEZE IN AN OPEN POSITION. ALSO, THE CONTACT STATED THAT THE DOORS WOULD OPEN INDEPENDENTLY WHILE THE VEHICLE WAS IN MOTION. THE DEALER WAS CONTACTED AND THEY INFORMED THE CONTACT THAT THE VIN WAS NOT INCLUDED IN RECALL NHTSA CAMPAIGN: 06V383000 (LATCHES/LOCKS/LINKAGES). THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 147,000. PAM

NHTSA ID

10643082

Incident

Dec 2, 2013

Mileage

147,000 mi

TL* THE CONTACT OWNS A 2005 FORD FIVE HUNDRED. THE CONTACT STATED THAT BOTH THE FRONT DRIVER AND PASSENGER'S SIDE DOORS FAILED TO LATCH DURING EXTREMELY COLD WEATHER. THE CONTACT REFERENCED NHTSA CAMPAIGN ID NUMBER 06V383000 (LATCHES/LOCKS/LINKAGES) BUT WAS ADVISED BY THE DEALER THAT THE VEHICLE WAS PREVIOUSLY REPAIRED UNDER THE RECALL. THE CONTACT STATED THAT THE REMEDY REPAIR HAD NEVER BEEN PERFORMED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE PROBLEM. THE FAILURE MILEAGE WAS UNAVAILABLE. UPDATED 02/24/14*LJ THE DEALER REPLACED THE LATCHES, AT NO CHARGE. UPDATED 02/25/14

NHTSA ID

10561255

Incident

Jan 23, 2014

TL* THE CONTACT OWNS A 2005 FORD FIVE HUNDRED. THE CONTACT STATED THAT THE FRONT PASSENGER SIDE PAWL LATCH WOULD NOT RETURN TO THE LATCH POSITION WHEN CLOSED. THE CONTACT ALSO MENTIONED THAT ON SEVERAL OCCASIONS THE DOOR WOULD OPEN INDEPENDENTLY WHILE THE VEHICLE WAS IN MOTION. THE VEHICLE WAS TAKEN TO A DEALER WHERE THE TECHNICIAN STATED THAT THE DOOR LATCH MECHANISM NEEDED TO BE REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND STATED THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 06V383000 (LATCHES/LOCKS/LINKAGES). THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 151,000 AND THE CURRENT MILEAGE WAS 153,000. *TR UPDATED 06/18/13*LJ UPDATED 06/21/2013 *JS

NHTSA ID

10504930

Incident

Feb 1, 2013

Mileage

151,000 mi

TL* THE CONTACT OWNS A 2005 FORD FIVE HUNDRED. THE CONTACT STATED THAT THE FRONT DRIVER SIDE DOOR WOULD NOT LATCH PROPERLY AFTER INCLEMENT WEATHER SUCH AS ICE, SNOW OR RAIN. THE CONTACT WOULD HOLD OPEN THE DOOR HANDLE AND SHOVE IT A FEW TIMES IN ORDER TO ENTER ON THE PASSENGER SIDE TO ENSURE THAT THE DOOR WOULD REMAIN SHUT WHILE OPERATING THE VEHICLE. THE DEALER ADVISED THE CONTACT THAT HER VIN WAS NOT INCLUDED IN THE RECALL ASSOCIATED WITH NHTSA CAMPAIGN ID NUMBER: 06V383000 (LATCHES/LOCKS/LINKAGES:DOORS:LATCH) AND OFFERED NO FURTHER ASSISTANCE. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. NO REPAIRS WERE PERFORMED. THE CURRENT MILEAGE WAS 74,000 AND THE FAILURE MILEAGE WAS 71,000.

NHTSA ID

10446381

Incident

Dec 24, 2011

Mileage

71,000 mi

TL* THE CONTACT OWNS A 2005 FORD FIVE HUNDRED. THE CONTACT STATED THAT THE VEHICLE WAS REPAIRED UNDER NHTSA CAMPAIGN ID NUMBER: 06V383000 (LATCHES/LOCKS/LINKAGES:DOORS:LATCH). HE THEN NOTICED THAT DURING BELOW FREEZING TEMPERATURES, THE DRIVER AND FRONT PASSENGER DOORS WOULD BECOME UNLATCHED INDEPENDENTLY OR WOULD NOT LATCH AT ALL. THE VEHICLE WAS TAKEN BACK TO THE DEALER AND THEY ADVISED HIM THAT THEY WERE UNABLE TO DUPLICATE THE FAILURE AND THAT HE WOULD POTENTIALLY NEED TO REPLACE THE LATCHES BUT THE REPAIRS WOULD NOT BE COVERED UNDER THE PREVIOUS RECALL. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS CONTACTED AND THEY OFFERED NO ASSISTANCE. THE FAILURE MILEAGE WAS APPROXIMATELY 138,000.

NHTSA ID

10390411

Incident

Mar 9, 2011

Mileage

138,000 mi

THIS IS THE PROBLEM THAT I AM HAVING #06V383000 WITH MY 2005 FORD FIVE HUNDRED I TOOK IT TO A DEALER AND WAS TOLD THAT SINCE IT WAS NOT A FORD RECALL THAT THEY COULD NOT FIX THE PROBLEM. IT SEEMS TO HAPPEN WHEN IT GET EXTREMELY COLD OUT. SOME TIMES I HAVE TO DRIVE TO WORK HOLDING THE DOOR UNTIL THE LATCH CATCHES. ANY AND ALL HELP WILL BE GREATLY APPRECIATED. THANK YOU *TR

NHTSA ID

10384595

Incident

Dec 28, 2007

I HAVE A 2005 FORD FIVE HUNDRED AND THE DOORS WILL NOT LATCH IN COLD WEATHER AND OPEN WHILE VEHICLE IS MOVING; WE CONTACTED FORD AND THEY SAID THEY HAD THAT RECALL BUT NOT IN MY STATE, SAID IT WASN'T COLD ENOUGH IN OUR AREA; WELL , IT IS AND IT HAPPENS EVERY WINTER WITH THIS CAR. FORD SHOULD FIX THIS AS IT IS A MAJOR SAFETY CONCERN FOR MY FAMILY. *TR

NHTSA ID

10383160

Incident

Jan 3, 2011

I PURCHASED A 2005 FORD 500 4-DOOR SEDAN 2-1/2 YEARS AGO FROM A FORD DEALERSHIP. IT WAS DESCRIBED AS A "PROGRAM" CAR. I SOON NOTICED THAT THE DASHBOARD DISPLAY LIGHTS WOULD NOT LIGHT UP DURING DAYLIGHT HOURS, EVEN THOUGH THE RHEOSTAT WAS SET ON MAXIMUM BRILLIANCE. I PROVED THIS BY DRIVING INTO A DARK PARKING GARAGE AND SAW THAT THE SAID LIGHTS TURNED ON AT MAXIMUM. I ASKED THE SERVICE MANAGER ABOUT THIS AND HE SAID FORD HAD WIRED THE LIGHTS THROUGH THE SOLAR SWITCH VIA THE ELECTRONIC CONTROL UNIT AND COULD NOT BE CHANGED. THIS IS A DANGEROUS DISTRACTION WHEN DRIVING IN DAYLIGHT HOURS AND TO SEE THE INFORMATION O THE DASHBOARD THE RUNNING LIGHTS MUST BE TURNED OFF. IN MY OPINION THIS DEFECT NEEDS TO BE REMEDIED WITH A RECALL. THANK YOU. *TR

NHTSA ID

10361868

Incident

Jun 1, 2010

Mileage

19,000 mi

I PURCHASED A 2005 FORD 500 LTD. THE FIRST INCIDENT OCCURRED WHILE DRIVING HOME FROM ATLANTIC CITY. THE DASHBOARD LIT UP LIKE I WAS STARTING THE CAR AND WENT INTO FAILSAFE ENGINE MODE. AFTER PULLING OVER, THE CAR RAN NORMAL. THE NEXT OCCURRENCE WAS WHEN THE CAR STARTED SHUTTING OFF WHILE DRIVING. IT HAS DONE THIS ON NUMEROUS OCCASTIONS. THEN THE DASHBOARD LIT UP AGAIN AND THE REVERSE LIGHTS STAYED ON. THIS WINTER SEASON THE DOOR LATCHES WOULD NOT CATCH TO KEEP THE DOORS SHUT. AFTER IT RAINS THE REAR DOORS HAVE WATER SITTING INSIDE OF THEM. UPON DOING SOME RESEARCH, I FOUND THAT THESE PROBLEMS WERE ON FORD'S TECHNICAL SERVICE BULLITEN (TSB). I CALLED FORD AND THEY SAID THERE WERE NO RECALLS ACCORDING TO THE VEHICLE IDENTIFICATION NUMBER. THEY ALSO STATED THAT THERE WAS WORK DONE PRIOR TO ME PURCHASING THE VEHICLE. I ALSO HAD THE CAR WORKED ON FOR THE ELECTRICAL PROBLEM AND WAS TOLD THE CAR WAS FIXED. THE CAR IS STILL EXPERIENCING THESE PROBLEMS. I DON'T HAVE THE FINANCES TO CONTINUE TO HAVE WORK DONE AND THE PROBLEMS NOT BE FIXED. *TR

NHTSA ID

10318440

Incident

Jun 16, 2007

Mileage

84,000 mi

JUST PURCHASED A 2005 FIVE HUNDRED WITH 32000 MILES AND HAD TO BRING BACK TO DEALER FOR TRANSMISSION UP-DOWN HARD SHIFTING. THEY SAID THEY HAD TO FLASH W/NEW SOFTWARE. PICKED UP AND DID NOT NOTICE ANY DIFFERENCE, STILL HARD SHIFTING. HAVE 10 DAYS LEFT ON MY 60 DAY WARRANTY. WILL BRING BACK TO DEALER FOR DIAGNOSTICS. SOUNDS TO ME THAT A HUGE AMOUNT OF LOYAL FORD CUSTOMERS ARE HAVING A HUGE PROBLEM WITH THE THIS TRANSMISSION. I SUPPOSE I WILL HAVE AN TRANSMISSION FAILURE SOON TO COME. WHY IN GODS NAME IS NOBODY DOING SOMETHING ABOUT THIS PROBLEM. I ALSO HAD TO HAVE MY DRIVER HEATED SEAT PADS REPLACED BECAUSE OF FAILURE. *TR

NHTSA ID

10314842

Incident

Feb 1, 2010

Mileage

31,589 mi

TL*THE CONTACT OWNS A 2005 FORD FIVE HUNDRED. THE CONTACT STATED THAT THE DRIVER'S SIDE DOOR FAILED TO CLOSE SECURELY. THERE WAS A MALFUNCTION WITH THE LATCH SYSTEM. THE INTERIOR DOOR HANDLE HAD TO BE HELD IN ORDER TO SECURE THE DOOR WHILE THE VEHICLE WAS IN MOTION. THE FAILURE OCCURRED WITHOUT WARNING. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER, BUT THEY COULD NOT DETERMINE THE CAUSE OF THE FAILURE. THE VEHICLE WAS TAKEN TO THE DEALER FOUR ADDITIONAL TIMES. THE CONTACT STATED THAT THE VEHICLE WAS PREVIOUSLY REPAIRED UNDER A RECALL; HOWEVER, THE NHTSA CAMPAIGN ID NUMBER WAS UNABLE TO BE FOUND. THE RECALL REMEDY HAS NOT CORRECTED THE FAILURE. THE VIN WAS UNKNOWN. THE FAILURE MILEAGE WAS 3,000 AND CURRENT MILEAGE WAS 3,753.

NHTSA ID

10250752

Incident

Nov 22, 2005

Mileage

3,000 mi

STARTED DRIVING MY 2005 FORD FIVE HUNDRED SEL FRONT WHEEL DRIVE AS I NORMALLY DO, EXCEPT THE INSTRUMENT CLUSTER AND LIGHTS STARTED FLICKERING, MY A/C TURNED OFF AND CHECK ENGINE LIGHT CAME ON. AFTER STOPPING ON THE SIDE OF THE ROAD EVERYTHING RETURNED TO NORMAL. ABOUT 40 MINUTES LATER A SIMILAR SITUATION OCCURRED, ONLY THIS TIME JUST THE INSTRUMENT PANEL FAILED. MY CRUISE CONTROL STILL WORKED BUT MY TACH, SPEED, BATTERY AND POWER GAUGE ALL DROPPED TO ZERO, HOWEVER THE LIGHTS REMAINED ON. I AM WRITING TODAY BECAUSE I SAW ONLINE THAT OTHER OWNERS OF THE SAME MAKE AND MODEL ARE HAVING IDENTICAL PROBLEMS. THIS IS A MAJOR SAFETY ISSUE AND COULD CAUSE AN ACCIDENT, ESPECIALLY IF THE LIGHTS CUT OFF AT RANDOM. I'M SURPRISED THERE HASN'T BEEN A RECALL ISSUED OR AN ACCIDENT YET AS A RESULT OF THIS. *TR

NHTSA ID

10242029

Incident

Sep 12, 2008

Mileage

74,500 mi

I PURCHASED MY FIRST FORD PRODUCT IN THE SPRING OF 2007. IN DECEMBER THE DRIVER SIDE DOOR WOULD NOT CLOSE. THERE WAS A TSB DATED 06-25-04 FOR WHICH SERVICE WAS CLAIMED TO HAVE BEEN PERFORMED. ON FEBRUARY 11, 2008 AGAIN THE DRIVER DOOR WOULD NOT LATCH. I HAD TO DRIVE IT UP TO FAMILY FORD IN WATERBURY, HOLDING THE DOOR CLOSED. ALL THEY DID ON THAT DAY WAS SPRAY SOME SORT OF LUBRICANT IN THE DOOR LATCH. TODAY, FEBRUARY 28TH AT 5:30 AM WHILE TAKING A RIGHT TURN ON MY WAY INTO WORK, THE DOOR FLEW OPEN. IT HAD NOT LATCHED. I HAD TO SLAM THE DOOR FIVE TIMES TO GET IT TO LATCH CLOSED. THIS IS NOW THE THIRD INCIDENT WITH THIS DOOR. I FEEL THIS NOW FALLS INTO THE LEMON LAW CATEGORY. FAMILY FORD JUST WANTS TO SPRAY LUBRICANT AND TRY TO BLAME DAMP WEATHER. I HAVE ALWAYS OWNED GM VEHICLES AND NEVER HAVE I HAD THIS TYPE OF PROBLEM. THIS IS A SAFETY ISSUE. *TR

NHTSA ID

10219359

Incident

Feb 28, 2008

PURCHASED MY 500 9/05 IT ONLY HAD 5 MILES ON IT. 6 MONTHS LATER LOUD EXPLOSION IN ENGINE WHICH BEGAN TO LEAK SOME SORT OF FLUID GOT THE CAR TOWED TO DEALER PURCHASED WAS TOLD A/C LEAKING OIL AND THEY HAD TO REPLACE THE MANIFOLD I WASN'T EVEN USING THE A/C WAS MARCH!!! MY DASH CONSOLE HAD TO BE REPLACED SINCE IT WAS DEFECTIVE AND THE COMPUTER ALSO HAD TO BE REPROGRAMMED SINCE THE CAR WOULDN'T START IN 30 DEGREE WEATHER THIS HAPPENED IN JAN06......MY FUEL STRAPS WERE REPLACED DUE TO RECALL AND MY DOOR LOCKS WERE REPLACED DUE TO RECALL AND I HAD 22K MILES WHEN THE BACK BRAKES BEGAN MAKING A TERRIBLE GRINDING NOISE WHEN BACKING UP TOOK TO DEALER SAID THAT ALTHOUGH CAR IS UNDER WARRANTY BRAKES ARE UNDER WEAR AND TEAR AND WOULD NOT BE COVERED NOW WHICH DIDN'T MAKE ANY SENSE SINCE THE FRONT BRAKES WERE GOOD HOW COULD BACK BRAKES GO BAD BEFORE FRONT BRAKES UNLESS YOU ONLY DRIVE YOUR CAR IN REVERSE????? I PAID THE $400 TO FIX SINCE WAS INFORMED 500 ROTORS CANT BE TURNED EVER WILL ALWAYS HAVE TO PURCHASE NEW ONES......THEN 6 MONTHS LATER BRAKES WERE RECALLED AND I DID REQUEST REFUND WHICH I DID RECEIVE. HOWEVER I NOW HAVE 44K NO LONGER HAVE WARRANTY SINCE EXPIRED AND I DIDN'T BUY EXTENDED WARRANTY BROUGHT CAR IN TO FORD SINCE TRANSMISSION LIGHT WAS TURNING ON AND OFF ALONG WITH THE TRACTION CONTROL LIGHT THEN HAD TRANS CENSOR REPLACED WAS TOLD THAT WAS PROBLEM THEN 2 DAYS LATER LIGHT STILL TURNING ON AND CAR WILL NOT REVERSE TOOK INTO DEALER AGAIN WAS TOLD TRANS AXLE BROKE IN HALF AND NEED NEW TRANS WHICH COSTS $5300 CAR IS ONLY WORK 9K!!!! FORD COMPANY SAID THEY WILL OFFER ASSISTANCE ONLY OF 3K SINCE OUT OF WARRANTY THEY ALSO INFORMED ME THAT HAD I PURCHASED THE EXTENDED WARRANTY I WOULD ONLY BE PAYING $100 NOTHING LIKE THROWING THAT IN YOUR FACE. I HAVE NO CHOICE BUT TO PAY IT NEED A CAR AND AM A SINGLE PARENT OF 2. ALSO BACK DOORS TRIM IS COMING APART PASSENGER SINCE IS COMPLETELY ROTTED OUT. *TR

NHTSA ID

10217296

Incident

Jan 29, 2008

Mileage

44,444 mi

TL*THE CONTACT OWNS A 2005 FORD FIVE HUNDRED. ON MARCH 26, 2007, THE CONTACT HAD THE REAR BRAKES ON HIS VEHICLE CHECKED AND WAS TOLD BY THE MECHANIC THAT THE BRAKES WERE IN GOOD CONDITION. ON MAY 10, 2007, THE BRAKES BEGAN TO FAIL. WHILE DRIVING 35 MPH UNDER NORMAL CONDITIONS, THE CONTACT HEARD THE REAR BRAKES GRINDING METAL TO METAL. THE CONTACT TOOK THE VEHICLE TO THE DEALER WHO REPLACED THE REAR ROTORS AND BRAKE PADS. THE CONTACT HAS THE REAR ROTORS TO SHOW THE UNUSUAL WEAR. THE CONTACT ALSO HAS THE REPAIR ORDERS FROM BOTH REPAIRS. THE ENGINE SIZE WAS UNKNOWN. THE CURRENT AND FAILURE MILEAGES WERE 38,585. THE DEALER STATED THAT THE RECALL FOR THIS CAR WAS PERFORMED ON THE LATCH OF THE DOOR FOR THIS VEHICLE. UPDATED 06/06/07 *TR

NHTSA ID

10190662

Incident

May 10, 2007

Mileage

38,585 mi

TL* - THE CONTACT OWNS A 2005 FORD FIVE HUNDRED WITH A CURRENT MILEAGE OF 29,345 MILES. AFTER DRIVING THE VEHICLE FOR 191 MILES THE CONTACT HEARD A THUMPING NOISE COMING FROM THE REAR BRAKES. SHE TOOK THE VEHICLE TO THE DEALER, AND WAS TOLD THAT THERE WAS CORROSION BETWEEN THE BRAKE PADS AND ROTORS. BOTH REAR BRAKES WERE REPLACED. THE CONTACT DROVE THE VEHICLE FOR ANOTHER 9,319 MILES. WHEN THE CONTACT TOOK THE VEHICLE TO THE DEALER FOR ROUTINE MAINTENANCE SHE WAS TOLD THAT THE REAR BRAKES WERE 90% CORRODED. THE CONTACT REPLACED THE BRAKES. THE CONTACT CALLED FORD, AND WAS TOLD NOT TO USE THE BRAKES AS FREQUENTLY. *AK THE CONSUMER STATES DOOR LATCH FREEZES AT TIMES, DEALER PERFORMED RECALL ON VEHICLE. UPDATE 05/04/07*TR

NHTSA ID

10187664

Incident

Apr 10, 2007

Mileage

20,024 mi

FORD RECALL NO. 06S45 DID NOT FIX THE PROBLEM. OUR FORD FIVE HUNDRED DRIVERS DOOR FAILED TO LATCH THE DAY AFTER A TRIP THROUGH THE CAR WASH IN BELOW FREEZING WEATHER. MY WIFE TRIED TO LATCH THE DOOR MANY TIMES AND LOCKED AND UNLOCKED IT SEVERAL TIMES. IT FINALLY LATCHED. THE LOCAL DEALER LOOKED AT IT AND LUBED IT (AGAIN). THE TECHNICIAN STATED THAT THIS WAS NOT THE FIRST ONE HE HAD SEEN. *JB

NHTSA ID

10184617

Incident

Feb 27, 2007

Mileage

32,000 mi

RECEIVED A RECALL NOTICE FROM FORD MOCO. TOOK THE WIFES VEHICLE INTO THE DEALERSHIP FOR REPAIRS, THE TECHNICIAN CALLED AND SAID THE CAR WAS REPAIRED AND WE TOOK THE VEHICLE HOME. I TOOK THE VEHICLE TO WORK THAT EVENING AND WHEN I GOT OFF WORK MY FREIND AND I THAT RIDES TO WORK WITH ME NOTICED THAST THE DOOR STILL WASN'T SHUTTING PROPERLY. I SLAMMED THE DOOR 3 OR4 TIMES AND THOUGHT IT HAD LATCHED AS THE DOME LIGHT WENT OUT. I DROPPED MY FREIND OFF AT HIS HOME AND WAS HEADING TO A NEARBY CONVENIENCE STORE WHEN THE DOOR POPPED OPEN. I WAS STARTLED AND WAS TRYING TO CLOSE THE DOOR, WHILE I WAS DISTRACTED WITH THE DOOR I WENT OFF THE ROAD AND STRUCK A POWER POLE AND CHAIN LINK FENCE. I REFUSED AN AMBULANCE RIDE TO THE HOSPITAL BUT HAD TO GO LATER WITH NECH PAIN.

NHTSA ID

10178157

Incident

Jan 2, 2007

Mileage

18,600 mi

I HAVE A RECALL OF NOV 2006 ON MY 2005 FORD 500 FOR THE DOORS FLYING OPEN AFTER FREEZING VIN [XXX] AND ROBIN OF FORD CORPORATE HEADQUARTERS STATES FORD WILL NOT PICK THIS CAR UP (AS IT HAS DEFECTIVE BRAKES AS PREVIOUSLY NOTED TO YOU AND HAS AN AFFIDAVIT OF NON USE FILED). FORD IS REFUSING TO PERFORM WORK ON THE RECALL. *JB UPDATED 07/11/2012 *JS INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ID

10177463

Incident

Dec 1, 2006

Mileage

720 mi