2012 Ford Focus Fuel system Problems

The contact owns a 2012 Ford Focus. The contact stated that the vehicle previously failed the vehicle state inspection due to the check engine warning light being illuminated. Additionally, the vehicle stalled intermittently while driving. The contact had to pull over, wait, and then restart the vehicle. The vehicle was taken to the dealer, who performed an unknown recall repair for the canister purge valve, but the failure persisted. The vehicle was then taken to the second dealer, Group 1 Ford of Southwest Houston (6445 Southwest Fwy, Houston, TX 77074), who performed another unknown recall repair for the canister purge valve, but the failure reoccurred. The contact later received notification of NHTSA Campaign Number: 26V369000 (Fuel System, Gasoline); however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealers were made aware of the failure but confirmed that parts were not yet available. The vehicle was not repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 130,000.

NHTSA ID

11756307

Incident

Apr 1, 2024

Mileage

130,000 mi

Days after changing the purge valve on my car, because it had failed. I was driving on the freeway confident because my screen said 15 m left before running out of gas, then the engine stalled and lose power. The lights were on but the engine stopped running while driving on the freeway. Turned out I had runned out of gas but the computer was misreading it.

NHTSA ID

11748105

Incident

May 24, 2026

For months in early 2025, I was unable to fill gas tank without gas pump stopping ( so gas dispensers work to prevent gas from leaking?) Got progressively worse so less fuel could be put in gas tank. I took car into dealership to diagnose and fixed on April 25, 2025. I was at risk because the car can’t be filled and then unable to operate. Fuel filler neck was broken. I meant to report earlier and hopefully others can avoid the fix. No recall listed.

NHTSA ID

11743754

Incident

Apr 25, 2025

I filled up my gas tank and a couple minutes later experienced shuddering while parked so I decided to turn the vehicle off and turn it back on but it struggles to turn back on. I then drove back home and as I was driving the acceleration was going up and down and then to 0. As i stopped on a red light the car completely shut down while the light then turned green and the check engine light, battery, and oil light came on. I then turned the vehicle off and in order to start it I had to step on the gas. I made it home but have not driven it since. I noticed there was a 19S22 recall but I spoke with ford and they said my vehicle didn’t get it but it is experiencing the same issues that the recall mentioned. There is a one time replacement for the CPV but it doesn’t cover half of what the 19S22 does and it seems to be the same problem.

NHTSA ID

11726335

Incident

Mar 20, 2026

After receiving program #24N07 on 12/04/2024, my 2012 ford focus was stalling out while downshifting to stops and after refueling, this happened around the 1st week of December of 2025 about a year after getting it repaired by the Ford dealership in my area. Replaced it myself this time, but sort of crazy to have to replace yet another purge valve just a year after.

NHTSA ID

11712593

Incident

Dec 1, 2025

Everytime I go to get fuel the car will not crank it makes a terrible noise then cranks but its slow. The pressure in tank causes it to stall out.

NHTSA ID

11687506

Incident

Jun 6, 2025

I was starting to pull away from a traffic light but the car would not go to second gear and was shaking violently this has happened more times then I can count and I take care of my [XXX] we travel 50 miles a day in this car on one of the most dangerous roads in the nation [XXX] ) there are places on this road with no emergency lanes in case my car stalls again or just won't go into gear and I have drivers bearing down on me at 70 miles an hour. I know for a fact these issues have come up with countless others that have bought this vehicle and I just don't understand why this isn't a big enough safety concern is it going to take the death of me and my grandson for a recall to be made on this piece of garbage ford calls a transmission? I don't have $ for another vehicle and if this one doesn't keep getting me to work I'll be out of a job and we will be homeless a friend helped me buy this car and I assumed he checked it out first and he only looked at the accident report but not the overall report on these vehicles which shouldn't even be on car lots for sale they are unsafe death traps and when people start dying in them which im sure has already happened those deaths are on ford and on this so called national highway safety because your not doing your job this recall should have happened years ago INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ID

11666933

Incident

Apr 20, 2025

The contact owns a 2012 Ford Focus. The contact stated that while attempting to refuel, the fuel nozzle continuously clicked off. Additionally, while operating the vehicle, the fuel gauge malfunctioned and displayed inaccurate fuel information. The contact stated that the fuel gauge incorrectly displayed a full fuel tank; however, the contact stated that the vehicle stalled. The tow service was called to the scene and discovered that there was no fuel in the fuel tank. The tow service added fuel and the vehicle restarted and operated normally. The vehicle was taken to the local dealer who diagnosed that the fuel tank, fuel gasket, and canister purge valve were faulty and needed to be replaced. The vehicle was not yet repaired. The manufacturer was notified of the failure, but no assistance was offered. The failure mileage was 127,255.

NHTSA ID

11662064

Incident

Apr 7, 2025

Mileage

127,255 mi

The contact owns a 2012 Ford Focus. The contact stated that while driving at an undisclosed speed, the vehicle stalled with the check engine warning light illuminated. The vehicle was towed to the dealer, where it was diagnosed that the purge valve had failed and needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure and referred the contact to the NHTSA Hotline for further assistance. The failure mileage was approximately 143,500.

NHTSA ID

11655837

Incident

Apr 21, 2025

Mileage

143,500 mi

Since I have had this vehicle, the message " steering assist fault" for my electronic steering has been popping up in the dash screen since as far back as 2016 when there were recalls on the Ford fusion. However, a simple fix would be to turn off the engine and restart the vehicle, and it was go away, only to return a few weeks, or a month later. I repeated the same steps. Now, it has gone out completely, a few months ago. Back then, they told me it would cost about $800, now they are saying $2500. It has occurred various times going back to 2016 until currently, which it is out. Keep in mind, this message has appeared since 2016 and I believe I have contacted you all, who told me that only the Ford Fusion, which has the same exact electrical steering system, went out and that the recall only covered the Ford Fusions models.

NHTSA ID

11649585

Incident

Nov 6, 2017

The contact owns a 2012 Ford Focus. The contact stated the vehicle failed to start. No warning light was illuminated. The contact called AAA, who jump-started the vehicle. The vehicle was taken to an independent mechanic who diagnosed the vehicle and determined that the purge valve had failed. The contact stated that the vehicle was repaired. The contact stated that on a separate occasion, while driving 10 MPH up a hill and attempting to accelerate, the vehicle briefly lost motive power and jerked before slamming into first gear. Several unknown warning lights were illuminated. The contact stated that the vehicle was taken to an independent mechanic who diagnosed that the transmission control module had failed. The vehicle was not repaired. The contact stated that the failure reoccurred. The contact received a postcard from the manufacturer for a manufacturer's recall for the canister purge valve (24N07). The manufacturer was not informed of the failure. The failure mileage was approximately 70,000.

NHTSA ID

11649218

Incident

Sep 19, 2024

Mileage

70,000 mi

Vehicle has difficulty starting after refuel. Vehicle stalls randomly to the point that is too much of a danger to drive. All of the symptoms correlate to recall (18S32) yet this particular vehicles vin was not listed in the list of recalled vehicles. The DTC's are as follows,P0420, P0456, P1450. Upon being serviced for the ford customer satisfaction program 24N07 it was noted by a service advisor that the replacement of a fuel tank and fuel pump was necessary which would be a reference to recall (18S32). However due to this vin not falling under recall (18S32) the service for a replacement fuel tank and fuel pump is not covered by warranty. Vehicle has erratic and innacurate fuel gauge indication. Vehicle stalled in the middle of traffic shortly after service was completed. Dealership has no clearance from Ford to address problem because 24N07 makes no mention of components that could be affected by faulty canister purge valve, unlike (18S32) and as such leaves this vehicle to be a hazard on the road.

NHTSA ID

11637488

Incident

Jan 17, 2025

The contact owns a 2012 Ford Focus. While the contact's fiancé was driving at an undisclosed speed, the vehicle sputtered. The contact's fiancé, who is an independent mechanic, diagnosed the vehicle with fuel pump failure. The contact was informed that the fuel pump needed to be replaced. The vehicle was repaired; however, the failure reoccurred. Additionally, the check engine warning light illuminated. The vehicle was taken to another independent mechanic and diagnosed with purge valve canister failure. The contact was informed that the purge valve canister needed to be replaced. The vehicle was repaired; however, the failure reoccurred. The contact stated that after the vehicle was started, the vehicle sputtered and then lost motive power. The dealer was made aware of the failure. The contact was advised to contact the manufacturer for assistance. The manufacturer was made aware of the failure but provided no assistance. The contact was informed that NHTSA Campaign Number: 18V735000 (Fuel System, Gasoline) had expired. The contact was referred to the NHTSA Hotline to report the failure. The failure mileage was approximately 147,000.

NHTSA ID

11628601

Incident

Aug 3, 2024

Mileage

147,000 mi

The contact owns a 2012 Ford Focus. The contact stated that the vehicle was difficult to start after refueling. The contact had to rev the engine to keep the vehicle running. The check engine warning light was illuminated. The contact stated that the failure was related to NHTSA Campaign Number: 19V515000 (Fuel System, Gasoline). The vehicle was taken to an independent mechanic who used a code reader and determined that the failure was due to the purge valve and charcoal canister. The contact called the local dealer, but the vehicle was not diagnosed or repaired. The manufacturer was contacted and referred the contact to the NHTSA Hotline. The failure mileage was approximately 136,000.

NHTSA ID

11618636

Incident

Sep 1, 2024

Mileage

136,000 mi

The contact owns a 2012 Ford Focus. The contact stated that after refueling the vehicle and attempting to start the vehicle, the vehicle failed to immediately start. After restarting the vehicle, the vehicle returned to normal functionality, but the failure became a regular occurrence. The check engine warning light was illuminated. The vehicle was taken to an independent mechanic, who diagnosed a failure with the canister purge valve. The vehicle was not repaired. After investigating the failure, the contact related the failure to NHTSA Campaign Number: 18V735000 (Fuel System, Gasoline). The VIN was included, but the vehicle had already been repaired. The failure mileage was 81,000.

NHTSA ID

11603838

Incident

Jul 10, 2024

Mileage

81,000 mi

1) each and every time I pop it fuel into my car, even if I'm just topping it off, when I start it it like starts to bog down like it's clogged or something, then just like that clears up. 2) while car is off, and no keys in ignition at all, my cars dashboard makes this almost clicking sound and I notice the fuel tank and gauge both shot b up to the top then drop back downs, it's strange, 3) sometimes when accelerating from hear the car almost stalks... That's v the only way I'd be by able to describe it

NHTSA ID

11599985

Incident

Jul 8, 2024

Car will stall and then completely shut down. And takes awhile to restart. This last time I was on the highway and cars were going so fast. Almost had a panic attack!!

NHTSA ID

11599857

Incident

Jul 6, 2024

For almost 5 years everytime I fill my gas tank the fumes leak from my car. About 2 days ago the tank started leaking gas from a huge crack in the tank. I told the Ford service center about this issue and they said that my individual car wasn't under the recall (for this exact issue) so they can only look at it and see what they can do. I know of a few other Focus models (a little newer than my 2012) who have also experienced this issue as well whose cars was not under the recall. Just in the 10 minute and less than 15 mile drive from my house to the service center I saw my fuel gauge go from 275 miles to 223, not to mention about 4 days ago I went to fuel up and when I got home my tank was at 330 miles and I haven't left my house since I fueled up (except going to the service center). I called the Ford Customer Center and ws told to fill out this form and to see about a recall approval for my car for this issue.

NHTSA ID

11588577

Incident

May 11, 2024

Mileage

120,044 mi

My 2012 Ford SE stalls out between First, second and third gear whenever I am accelerating to 40mph. The Transmission error continues to pop up after driving for a long period of time. Whenever driving 50 mph to 70 mph as soon as I release the gas pedal, the car goes into neutral stall out & whenever I press down on the gas pedal nothing happens and I have to pull over & Turn the car off and turn it back on to reset the transmission computer. If I don’t do that and I press the gas pedal again, the car would jerk and I have to pull over immediately and the car off. I cannot press full on the gas pedal because the car would not accelerate at full speed. Whenever I put gas in the car, it won’t start right away. It would jerk and choke just to start up. It takes me a couple attempts to start the car after putting gas in order for it to start and go. Whenever I’m finished driving and turn the car off, it makes it clicking noise in the engine area for about 2 to 5 minutes and it won’t stop and it only happens when you open the front doors or when the car is completely turned the car off. Whenever I put a full tank of gas or a half tank , the car would not dry properly install out on the highway or street I can’t drive at normal speed because I don’t know when the car is gonna stall out before it hits 1,2 or 3rd gear, which makes it very dangerous to drive on the highway.

NHTSA ID

11581162

Incident

Apr 1, 2024

The contact owns a 2012 Ford Focus. The contact stated while driving at an undisclosed speed, the vehicle stalled and ran out of fuel on several occasions. The check engine warning light was illuminated. The vehicle was taken to the local mechanic who performed a diagnostic test and informed the contact to return the vehicle to the dealer to be repaired under NHTSA Campaign Number: 18V735000 (Fuel System, Gasoline). The contact took the vehicle to the dealer and was informed that the purge valve and fuel pump needed to be replaced. The vehicle was not repaired due to the cost. The manufacturer was notified of the failure. The failure mileage was approximately 169,000.

NHTSA ID

11579503

Incident

Oct 24, 2023

Mileage

169,000 mi

Se acelera y desacelera repentinamente Quiero acelerar para llegar a la mismas velocidad del trafico y no lo hace y eso hase que ponga en peligro la vidad mia y de mi familia por que otro carro puede chocarme. Cuando sucedio eso se activo el CHECK, lo apago por completo y los parabrisas se activan repentinamente , todo esto es muy raro y no es bueno para mi

NHTSA ID

11576328

Incident

Jan 3, 2024

The transmission module, and Transmission. While on freeway with my family car shut off while driving. Yes , Yes , No there were no warning signs until after the jerking and shaking started after 39 days then the engine light came on. After that a that the sign said transmission over heating pull over and let car cool down. what was most scary is that it shut off while driving.

NHTSA ID

11567854

Incident

Jan 7, 2021

The contact owns a 2012 Ford Focus. The contact stated that once the fuel level was less than a quarter tank full, the vehicle would begin to hesitate upon the depression of the accelerator pedal. There was no warning light illuminated. Upon investigation, the contact discovered and linked the failure to NHTSA Campaign Number: 18V735000 (Fuel System, Gasoline). The dealer was notified of the failure and the contact was informed that the vehicle was not included in the recall. The manufacturer was notified of the failure. The vehicle was not repaired. The failure mileage was approximately 49,000.

NHTSA ID

11566078

Incident

Nov 1, 2023

Mileage

49,000 mi

The contact owns a 2012 Ford Focus. The contact stated that while driving at an undisclosed speed, the vehicle stalled. No warning light was illuminated. The contact pulled over to the side of the road. The contact added fuel to the vehicle and was able to restart the vehicle. The vehicle was taken to an independent mechanic, who diagnosed that the fuel tank had collapsed and needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure and informed the contact that there was no recall associated with the VIN. The contact related the failure to NHTSA Campaign Number: 18V735000 (Fuel System, Gasoline) however, the VIN was not included in the recall. The failure mileage was approximately 196,000.

NHTSA ID

11562602

Incident

Dec 1, 2023

Mileage

196,000 mi

The contact owns a 2012 Ford Focus. The contact stated while driving 45 MPH, the vehicle stalled inadvertently. The check engine warning light was illuminated. The contact veered to the side of the road, turned off, and restarted the vehicle and was able to continue driving. The contact stated that the failure reoccurred while driving. The vehicle was taken to an independent mechanic, where it was diagnosed that the emission evap canister control purge valve and fuel tank needed to be replaced. The vehicle was taken to the dealer for the recall repair. The dealer informed the contact that no repairs were needed upon inspection. The contact stated that the vehicle stalled abruptly while driving, almost causing other vehicles to crash into the vehicle. The vehicle was towed to a second independent mechanic, where it was diagnosed that the fuel tank had failed. The vehicle was towed to the dealer, who informed the contact that the failure occurred due to the lack of fuel in the fuel tank. Additionally, the contact stated that the vehicle had failed to shift into gears as intended and would shut off while driving. The contact also stated that the vehicle accelerated independently while driving, almost causing her to strike pedestrians. The vehicle was taken to the dealer, where the dealer diagnosed that the fuel tank needed to be replaced. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was unknown.

NHTSA ID

11559495

Incident

May 15, 2022