2012 Ford Focus Problems

Beginning in approximately May 2025, the vehicle began displaying diagnostic trouble codes identified by independent auto parts retailers and service providers. These codes indicated potential issues within the engine, electrical, and powertrain systems. The vehicle was subsequently brought to a dealership for diagnostic evaluation and remained there from approximately May 15 through May 19, 2025. During this time, the dealership reported that no diagnostic codes were present and did not resolve the reported issue. However, the vehicle had recently exhibited repeatable symptoms, including entering “limp mode” and triggering diagnostic trouble codes, prior to being delivered to the dealership. Similar codes and issues were again identified after the dealership visit. The vehicle has experienced multiple incidents of entering “limp mode,” resulting in sudden loss of power and reduced drivability while in operation. This condition occurred without reliable warning and created unsafe driving situations, including the inability to maintain normal traffic flow. Due to safety concerns, the vehicle has not been driven under normal conditions since approximately May 2025 and has been limited to short, local movements only. The issue poses a safety risk to the driver, passengers, and surrounding traffic due to unexpected loss of power and inconsistent system diagnostics. The problem appears to be ongoing and unresolved. Independent diagnostic records and service visit documentation are available upon request.

I filled up my gas tank and a couple minutes later experienced shuddering while parked so I decided to turn the vehicle off and turn it back on but it struggles to turn back on. I then drove back home and as I was driving the acceleration was going up and down and then to 0. As i stopped on a red light the car completely shut down while the light then turned green and the check engine light, battery, and oil light came on. I then turned the vehicle off and in order to start it I had to step on the gas. I made it home but have not driven it since. I noticed there was a 19S22 recall but I spoke with ford and they said my vehicle didn’t get it but it is experiencing the same issues that the recall mentioned. There is a one time replacement for the CPV but it doesn’t cover half of what the 19S22 does and it seems to be the same problem.

The TCU/TCM has been going in and out of control. Sometimes it will work then others it will shut off. Speedometer won’t work, power steering won’t work, cruise control won’t work, etc. and when you do the transmission reset for it, it won’t work at all.

Electric power steering failed at 65,000 miles. No power assist in the steering. Trying to steer the car with no power assist is very difficult and not safe.

The contact owns a 2012 Ford Focus. The contact stated that the vehicle previously failed the vehicle state inspection due to the check engine warning light being illuminated. Additionally, the vehicle stalled intermittently while driving. The contact had to pull over, wait, and then restart the vehicle. The vehicle was taken to the dealer, who performed an unknown recall repair for the canister purge valve, but the failure persisted. The vehicle was then taken to the second dealer, Group 1 Ford of Southwest Houston (6445 Southwest Fwy, Houston, TX 77074), who performed another unknown recall repair for the canister purge valve, but the failure reoccurred. The contact later received notification of NHTSA Campaign Number: 26V369000 (Fuel System, Gasoline); however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealers were made aware of the failure but confirmed that parts were not yet available. The vehicle was not repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 130,000.

On XXX I received email from CARFAX regarding my vehicle recall "26S40 PCM REPROGRAMMING FOR FUEL TANK DEFORMATION”. I contacted Ford Cutter Hawaii answering spoke with [XXX] over the phone regarding the recall, she asked me to forward the email then she after she read the email she dismissed the information as not reliable as it came from Carfax. She will only follow up if I got recall notice in the mail. XXX my car stalled in the middle of freeway and got towed. At the time the reading of fuel is low but not empty. The car started and only run for 1-2 seconds before it died again. That is very similar symptoms described in the recall information: "Safety Risk THIS MAY RESULT IN AN ENGINE STALL WHILE DRIVING WITHOUT WARNING OR WITHOUT THE ABILITY TO RESTART AND CAN INCREASE THE RISK OF A CRASH.” End of complain. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Beginning in approximately May 2025, the vehicle began displaying diagnostic trouble codes identified by independent auto parts retailers and service providers. These codes indicated potential issues within the engine, electrical, and powertrain systems. The vehicle was subsequently brought to a dealership for diagnostic evaluation and remained there from approximately May 15 through May 19, 2025. During this time, the dealership reported that no diagnostic codes were present and did not resolve the reported issue. However, the vehicle had recently exhibited repeatable symptoms, including entering “limp mode” and triggering diagnostic trouble codes, prior to being delivered to the dealership. Similar codes and issues were again identified after the dealership visit. The vehicle has experienced multiple incidents of entering “limp mode,” resulting in sudden loss of power and reduced drivability while in operation. This condition occurred without reliable warning and created unsafe driving situations, including the inability to maintain normal traffic flow. Due to safety concerns, the vehicle has not been driven under normal conditions since approximately May 2025 and has been limited to short, local movements only. The issue poses a safety risk to the driver, passengers, and surrounding traffic due to unexpected loss of power and inconsistent system diagnostics. The problem appears to be ongoing and unresolved. Independent diagnostic records and service visit documentation are available upon request.

The car started shutting down while I am driving and also hard to start after

The contact owns a 2012 Ford Focus. The contact stated that the vehicle previously failed the vehicle state inspection due to the check engine warning light being illuminated. Additionally, the vehicle stalled intermittently while driving. The contact had to pull over, wait, and then restart the vehicle. The vehicle was taken to the dealer, who performed an unknown recall repair for the canister purge valve, but the failure persisted. The vehicle was then taken to the second dealer, Group 1 Ford of Southwest Houston (6445 Southwest Fwy, Houston, TX 77074), who performed another unknown recall repair for the canister purge valve, but the failure reoccurred. The contact later received notification of NHTSA Campaign Number: 26V369000 (Fuel System, Gasoline); however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealers were made aware of the failure but confirmed that parts were not yet available. The vehicle was not repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 130,000.

Days after changing the purge valve on my car, because it had failed. I was driving on the freeway confident because my screen said 15 m left before running out of gas, then the engine stalled and lose power. The lights were on but the engine stopped running while driving on the freeway. Turned out I had runned out of gas but the computer was misreading it.

Started July 2026, my drivers side door handle keeps getting stuck open

My driver side door was working perfect until one day i went into my car and tryed closing my door but it wont close so i had to go to work while holding the door so it dosent open i favent talked to ford itself bucause om scared they will charge me a lot

The TCU/TCM has been going in and out of control. Sometimes it will work then others it will shut off. Speedometer won’t work, power steering won’t work, cruise control won’t work, etc. and when you do the transmission reset for it, it won’t work at all.

the car runs without power when shifted to drive gear. It is sluggish trying to speed up. Took to Ford Dealers on a recall with that is suppose to take care of it..nothing seems to have changed. I am not sure anything was done. trans makes a rough sound starting..

The contact owns a 2012 Ford Focus. The contact stated that the rear driver’s side door failed to open as intended. The contact used force to attempt to open the door and failed. No warning lights were illuminated. The contact stated that when the vehicle was purchased, she was informed that the vehicle had an open recall related to NHTSA Campaign Number: 20V331000 (LATCHES/LOCKS/LINKAGES). When the contact retrieved the vehicle, the contact was informed that the recall had been repaired; however, there was no proof that the vehicle was under recall or that the recall repair was performed. The contact stated that several weeks later, mold was found in the driver’s seat and on the driver’s side seat belt. The contact stated that after a snowstorm, the moonroof was misty, and there was a water ring found above the interior roof. The vehicle was not taken to the dealer or an independent mechanic. The vehicle was not repaired. The contact stated that on a separate occasion, after starting the vehicle, there was an abnormal hissing sound coming from the vehicle underneath the driver’s side of the vehicle. No warning lights were illuminated. The contact was able to drive to the post office. After returning to the vehicle and starting the vehicle, the abnormal hissing sound persisted. The vehicle was not taken to the dealer or an independent mechanic. Upon further investigation, the contact related the failure to Manufacturer Recall Number: 18S32. The manufacturer was notified of the failures and would not confirm if the VIN was or was not under recall. The failure mileage was 129,354.

The contact owns a 2012 Ford Focus. The contact stated that the front driver's side door failed to latch securely while closed. The contact stated that the door occasionally unintendedly opened while driving. The contact stated that the failure required him to drive with an arm out the window holding the door closed. The vehicle was taken to the dealer to be repaired under NHTSA Campaign Number: 16V643000 (Latches/Locks/Linkages); however, the part to do the recall repair was not yet available. The dealer diagnosed the vehicle and informed the contact that the part to repair the vehicle was on backorder. The vehicle was not repaired. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the failure and referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 178,000. Parts distribution disconnect.

While driving back window spontaneously imploded

The contact owns a 2012 Ford Focus. The contact stated that the window motor in the passenger’s side window was no longer functioning while attempting to roll down the window. There was no warning light illuminated. The local dealer was contacted; however, the vehicle was not diagnosed. The contact was informed that the VIN was not under recall. The vehicle was not repaired. The manufacturer was notified of the failure. The approximate failure mileage was 99,085.

The contact owns a 2012 Ford Focus. The contact stated that upon starting the vehicle, the engine started to shake violently; occasionally, causing the vehicle to shut off unexpectedly. The contact was able to restart the vehicle. There was no warning light illuminated. The vehicle was taken to an independent mechanic, where it was diagnosed, and the contact was informed that the torque converter was faulty and needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure. The approximate failure mileage was 81,000.

The contact owns a 2012 Ford Focus. The contact stated while the vehicle was parked and attempting to start the vehicle, the vehicle failed to respond. The vehicle was under warranty and was taken to the dealer. The vehicle was diagnosed with clutch failure. The vehicle was repaired, and the clutch was replaced. On another occasion, the vehicle started to lose motive power and failed to reverse. The check engine warning light was illuminated. The vehicle was towed to an independent mechanic where it was diagnosed that the clutch had left residue, which caused the transmission to fail. The vehicle was then taken to a dealer where it was diagnosed with clutch failure; however, the contact was informed that the clutch was not under warranty. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 93,000.

I was starting to pull away from a traffic light but the car would not go to second gear and was shaking violently this has happened more times then I can count and I take care of my [XXX] we travel 50 miles a day in this car on one of the most dangerous roads in the nation [XXX] ) there are places on this road with no emergency lanes in case my car stalls again or just won't go into gear and I have drivers bearing down on me at 70 miles an hour. I know for a fact these issues have come up with countless others that have bought this vehicle and I just don't understand why this isn't a big enough safety concern is it going to take the death of me and my grandson for a recall to be made on this piece of garbage ford calls a transmission? I don't have $ for another vehicle and if this one doesn't keep getting me to work I'll be out of a job and we will be homeless a friend helped me buy this car and I assumed he checked it out first and he only looked at the accident report but not the overall report on these vehicles which shouldn't even be on car lots for sale they are unsafe death traps and when people start dying in them which im sure has already happened those deaths are on ford and on this so called national highway safety because your not doing your job this recall should have happened years ago INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Intermittent loss of brake pressure. ABS would activate and leave the brake pedal feeling soft and having low brake pressure. This problem would randomly fix itself and then randomly happen again while braking normally or after the ABS would engage. Sometime the problem would last for weeks until suddenly the brake pedal would be firm and have strong brake pressure.

My car was sitting ,in the driveway of my,home it was t-boned after which it spun around 90 degrees,it was damaged severely.The air bags did not deploy,I think they should've deployed. The car went to the shop and it has not been properly repaired,the body is structurally distorted ,and some of the mechanisms related to suspension and the trailing axle aren't properly installed or repaired.

Was in frontal/near frontal collision at 20-25mph. No airbags deployed.

14-Dec-2023, Brought my car into the tire repair store to have flat fixed. Was told the 5 lug nuts would have to be replaced because the original ones were corroded due to their design. This cost me $51.00 on this trip. 20-Aug-2020, Brought my car into the Ford dealership to have tires rotated. Was tolld 12 lug nuts would have be replace becaue the original ones were corroded due to their design. It cost me $82.08 on that trip. These lug nuts can break because of corrision, causing a serious accident.

Was told my lug nuts are swollen and need to be replaced.

Driver seatbelt is stuck and doesn't budge. I think I saw an old recall regarding this possibly... Since I've owned the car it hasn't came u jammed not at all a single time.not even moved an inch. I sprayed WD-40 down to it and nothing...

the buckle for the front passenger and back driver do not work properly. The buckles will not latch. It has not been confirm by a dealer because when i called to ask about repairing it and cost for parts I was told the part is discontinued and there is not another option for a replacement. 2 of the 5 have stopped working in the last 3 months. It puts my life and other passengers life's in danger every time it is driven due to not being able to put on a seatbelt. There was no warning just one day they would not buckle, we have tried different remedies and suggestions to fix the issue but nothing works and they need replaced.

Since I have had this vehicle, the message " steering assist fault" for my electronic steering has been popping up in the dash screen since as far back as 2016 when there were recalls on the Ford fusion. However, a simple fix would be to turn off the engine and restart the vehicle, and it was go away, only to return a few weeks, or a month later. I repeated the same steps. Now, it has gone out completely, a few months ago. Back then, they told me it would cost about $800, now they are saying $2500. It has occurred various times going back to 2016 until currently, which it is out. Keep in mind, this message has appeared since 2016 and I believe I have contacted you all, who told me that only the Ford Fusion, which has the same exact electrical steering system, went out and that the recall only covered the Ford Fusions models.

I bought the car in 2012. It has not run properly since that year. We took it in for computer flashes and the recalls each time they asked and several times more because the lurching, shuddering, and delayed acceleration would always come back. I had to readjust how I drove the Ford Focus compared to any other car knowing that it sometimes stuck or delayed in acceleration. It also would sometimes jolt forward. It rolls back once at a stop sometimes while the car is running. I would have to adjust how far ahead I pulled from people in lines to make sure they had enough space between parking or in line so I didn't roll back and hit them. My car died in the middle of the road on way to get gas back in 2017. We took it in to get looked at and cost hundreds of dollars to fix a fuel tank that suctioned in on itself. We found out a year later there was a recall for that same issue. It was supposed to fix the fuel gauge reading issues too but even after being "fixed" it still never read right. I could never tell what the actual contents of my fuel levels were which is dangerous especially on long road trips. The struts started to leak and go bad well before they should have. This car is totally unsafe between the constant transmission/computer issues, the fuel tank system, door latch recalls (2 of them). We had to have the radiator replaced because one of the Ford Service Centers screwed something up when they did the clutch recall. It broke down while driving the day after the clutch replacement and was overheating. They admitted their fault and replaced it for free thankfully but why did they have to be in there in the first place? Ford needs to finally recall all of these vehicles and make it right. My family has been lifelong Ford vehicle owners and I'm about at the end of my rope with this car.

Se acelera y desacelera repentinamente Quiero acelerar para llegar a la mismas velocidad del trafico y no lo hace y eso hase que ponga en peligro la vidad mia y de mi familia por que otro carro puede chocarme. Cuando sucedio eso se activo el CHECK, lo apago por completo y los parabrisas se activan repentinamente , todo esto es muy raro y no es bueno para mi

I have reported before my vehicle is and has been cyber attacked. This time around my horn has been disable. They turn on the radio, they turn on the light lights of the vehicle, they turn on the radio, they turn on the ac/heat control. If I take it in again, they are going to tell me nothing is wrong. This is very dangerous for me as a driver. I cannot drive a vehicle without a horn. I NEVER heard from you guys on the last report I made. Not sure how this one is going to help. This Ford vehicle is dangerous! If you can please assist, I would appreciate it. Thank you!

The contact owns a 2012 Ford Focus. The contact stated that while driving at an undisclosed speed, the brake pedal was depressed but the brakes failed to stop the vehicle. The failure caused the vehicle to rear-end another vehicle. The contact sustained back injuries and scratches from the seat belt; however, medical attention was not yet received. A police report was filed. The contact then parked the vehicle in a parking lot, where it remained. The vehicle was not deemed totaled by the insurance company due to a lapse in insurance coverage. The manufacturer was made aware of the failure. The contact stated that prior to the failure, the vehicle lost motive power with the ABS, TPMS, and brake warning lights illuminated. The vehicle was taken to the dealer, where it was diagnosed with transmission failure, and the ABS, TPMS, and brake sensors were faulty, causing the battery to drain rapidly. The dealer replaced the transmission and the sensors for the ABS, TPMS, and brakes; however, the failure recurred. The failure mileage was approximately 101,000.

Tread wore away

TL* THE CONTACT OWNS A 2012 FORD FOCUS. WHILE ATTEMPTING TO START THE VEHICLE, THERE WAS AN ABNORMAL SOUND FROM THE FRONT OF THE VEHICLE. THE VEHICLE WAS TAKEN TO A DEALER FOR DIAGNOSTIC TESTING. THE MECHANIC STATED THAT IT COULD BE THE AIR CONDITIONER COMPRESSOR AND STATED THAT THE VEHICLE WAS SAFE TO DRIVE. THE VEHICLE WAS NOT REPAIRED. WHILE DRIVING APPROXIMATELY 30 MPH, THERE WAS A SMELL OF SMOKE INSIDE THE VEHICLE AND NOTICED THAT THE REAR OF THE VEHICLE WAS SMOKING. THE VEHICLE WAS TOWED TO A DEALER WHERE IT WAS CONFIRMED THAT THE AIR CONDITIONER COMPRESSOR AND THE BELT NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 51,000.

TL* THE CONTACT OWNS A 2012 FORD FOCUS. IMMEDIATELY AFTER TURNING ON THE VEHICLE, THE WINDSHIELD WIPERS ACTIVATED INDEPENDENTLY. ALSO, WHEN THE AIR CONDITIONER WAS ACTIVATED, AN UNUSUAL YELLOW SUBSTANCE CAME OUT OF THE VENT. THE DEALER WAS UNABLE TO DIAGNOSE THE FAILURE. THE CONTACT REPLACED THE PASSENGER SIDE WINDSHIELD WIPER. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE VEHICLE WAS REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 26,000.