2015 Ford Focus Electrical Problems

I made an initial post on 06/18/2026 so please reference that as well as this. I have not been able to drive the car since it died on me on the 18th of June. The car has been looked at a few times (actually stalling a third time while idling but was able to turn back on.) It has also displayed symptoms associated with the Ford Recall #26S40 / NHTSA recall #26V369 but it is listed at NOT included in the recall as of 07/06/2026. MIL is pulling Code P0420 (catalytic system efficiency below threshold) while only having 40k miles. It is also putting out an inaccurate fuel level for miles driven. The fuel tank itself is misshapen (concave bottom of the fuel tank). Again, reiterating here that it stopped twice while driving within 2 days on major PA highways/interstates and stalled for a third time while in idle mode as described earlier in this post. This has all happened within 28 miles of the TCM being replaced.

NHTSA ID

11748702

Incident

Jun 27, 2026

own a 2015 Ford Focus that has experienced repeated transmission-related problems over several years. The symptoms have included harsh shifting, hesitation, failure to shift properly, and at one point the vehicle would not shift into reverse. These transmission issues have caused ongoing concerns about the vehicle's safety and reliability. I have brought the vehicle to Ford dealerships on multiple occasions seeking diagnosis and repair. Ford replaced the Transmission Control Module (TCM) on November 16, 2024 under Ford Field Service Action 14M02 after diagnosing transmission-related problems, including Diagnostic Trouble Code P087A. Despite that repair, the vehicle continued to experience transmission-related concerns. Approximately one year later, another Ford repair order documented multiple TCM-related diagnostic codes and directed that the vehicle be returned to a Ford dealership for further evaluation. The transmission concerns persisted even after the previous TCM replacement. Most recently, I again presented the vehicle to a Ford dealership because of continuing transmission issues. I was provided an estimate of approximately $2,000 for additional transmission repairs. At the time of the estimate, I was not provided the complete diagnostic trouble codes or technician findings explaining why another major transmission repair was necessary. Over the course of ownership, I have made multiple appointments, diagnostic visits, and repair visits related to the transmission and have incurred significant out-of-pocket expenses, including diagnostic charges, towing costs, and repairs. The repeated failures and recurring transmission concerns have required multiple visits to Ford dealerships and have not resulted in a lasting repair. My concern is not only the financial cost but also the safety of operating this vehicle. Unexpected transmission malfunction can affect acceleration, shifting, and the vehicle's ability to move normally in traffic, creating a potential safe

NHTSA ID

11747178

Incident

Jun 29, 2026

There were two times within a week where the car stopped in the middle of traffic. One was on Route 100 in a merge lane and the other was on the offramp of route 30 to 100 Exton. This happened in the middle left turn lane with traffic behind me causing me to need immediate police assistance to ensure my safety. The Check Engine light was popping from the TCM indicator which I was told I could still drive on without repairing it immediately. This came directly from Fred Beans Ford of West Chester PA. My car has been in the shop multiple times since December 2025 beginning with the original CPV recall and things got worse from there. It's caused lots of anxiety and ptsd while driving to the point I want to sell the car after it is repaired because I just don't feel safe anymore in it.

NHTSA ID

11745120

Incident

Jun 11, 2026

I was getting ready to leave the grocery store and I crank up my car and I had a light come on stating that my car was overheating transmission turn off the car and as I tried to pull out of the parking lot, the car would barely accelerate it would barely go to mountain and it was stuttering up the heels I had to turn off the vehicle. Let it sit for five minutes to let it cool off and then I had to crank the car back up and then it started to drive again, but I did get a indication on my front dash stating that it was transmission

NHTSA ID

11704157

Incident

Dec 10, 2025

Transmission overheating and internal wear (metal particles in fluid) following electrical/TCM malfunction in Ford Focus DPS6. Transmission failure recurred after earlier repair under 14M02. Current failure includes overheating messages, shudder, and loss of safe drivability. Ford acknowledges issue relates to known PowerShift defect but refuses coverage. Vehicle unsafe.

NHTSA ID

11701399

Incident

Nov 7, 2025

While driving my car on July 25, it started jerking then it stopped reversing. My LCD dashboard stopped displaying several years ago. This affects my ability to see warning lights and my mileage.

NHTSA ID

11677241

Incident

Jul 25, 2025

A major electrical issue has occurred in this car since June 1, 2025. The Traction Control System dashboard indicator (the skidding car) comes on even though I am not using the TCS. When this happens, I get a message saying "Hill start assist not available," and am unable to manipulate my headlights, use turn signals, or lock/unlock my doors (I need to use the physical key to lock/unlock the driver's side door). If this "Hill start assist" issue occurs and I turn off my car (or if it occurs when the car is off), then I am unable to start my car. I get a new message saying "No Key Detected," and the ignition does nothing. I have a physical key, and not a fob. If the TCS light goes away, then I am able to start up my car. However, this is unpredictable; there appears to be no way to force the TCS light to disappear, and sometimes it will stay on for over an hour with my key in the "on" position. As of late, it hasn't gone away at all, making the car unusable. This causes obvious safety issues when on the road, as I cannot use turn signals or change my lights as it gets darker or it begins to rain/snow. When not on the road, I cannot use my car at all. A dealer recently confirmed the problem with the Body Control Module, but was unable to fix it. They managed to turn the car on, but the problems returned after 24 hours. As I was driving home on July 18, 2025, the TCS light came on and suddenly I could not use turn signals or change my lights. I still had over an hour to drive home. I did arrive home safely, but have not been able to use my car since.

NHTSA ID

11675262

Incident

Jun 1, 2025

My transmission is always having problems with it. My check engine light will not turn after put over $5,000 into it.

NHTSA ID

11655138

Incident

Jan 7, 2025

While driving vehicle on highway the Ford Focus started down shifting while accelerating. This caused the car to not be able to reach sufficient speeds on the road and could have caused an accident. With my family in the car I exited the highway and drove the vehicle home, with the car continuously down shifting and not being able to accelerate as designed. The transmission has known problems and model recalls. I brought it to the dealer for repair but the dealer would not honor the recall. I also called Ford customer care and they were of no help in covering this known issue.

NHTSA ID

11627432

Incident

Nov 21, 2024

Mileage

105,221 mi

UNKNOWN. Power steering assist fault message appeared. After driving the car on the road and stopping to fuel up and turning off the car the error message appeared. The power steering was not working making the steering wheel hard to turn. No warnings or errors prior and as well no error codes found via OBD reader. Safety was put at risk as I was not able to turn the wheel when trying to take off after stopping. Several people have complained online already about this same issue.

NHTSA ID

11606309

Incident

Jul 25, 2024

Unknown, vehicle slips out of gear leaving you stranded in the middle of the street

NHTSA ID

11574584

Incident

Feb 28, 2024

1. MY car shuts off while driving and I don't understand why because my battery is new and all other components don't seem to be the issue i.e.: battery, starter, alternator. 2. My safety and the safety of my passengers were at risk because the car shuts off with no warning while driving. 3 I currently have the vehicle being inspected by my local Ford dealership but the problem has happened several times before taking the car to the dealership. 4. The problem is currently being inspected by the Ford dealership. 5. There were no warning's before the car shut off.

NHTSA ID

11558280

Incident

Nov 29, 2023

In August 2023 Focus would not accelerate smoothly while in traffic. Check engine light turned on. Vehicle would not go into reverse. Diagnostic scan negative with personal scanner. Took to transmission shop. Actuators replaced per diagnostic check $880. TCM ok. Slipping on acceleration continued with RPM to between 5-6 on acceleration. Took vehicle back to shop and actuators resynched with TCM. I received Ford Recall for defective TCM module dated September 2023. Ford evaluated by local Ford repair shop. Diagnostics performed. Recommendation was to replace clutch assembly $4100. Was charged $200 for diagnostics. Ford diagnostic report states: Description-U0073 Control module communication bus A off Failure type-88 Bus off Status-28 (Not current DTC) *Fault previously detected, not currently present* My concern with this info is if the fault was detected there is still fault! Am concerned that the faulty TCM and actuators caused issues with the clutch assembly and do not feel safe operating my 8 year old Ford due to skipping while accelerating in traffic. Vehicle one owner with 70,000 miles. No accidents and am young senior driver-age [XXX] . I can forward repair shop documentation. Thank you for your review and look forward to your recommendation. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ID

11549596

Incident

Aug 19, 2023

Spark Plugs/Ignition Coils. Car was not shifting into gear while driving, jerking. Revs up in between 5-7 Rpms. Car has stalled while driving. Car got spark plugs and ignition coils changed and problem got worse. No. Engine light was on for codes that read spark plug and ignition coil. Fixed problem. Engine light still on problem worse and still the same. Reading same codes.

NHTSA ID

11545551

Incident

Sep 1, 2023

My car stopped working on the freeway due to a recall. Multiple Ford dealerships have refused to fix it.

NHTSA ID

11532143

Incident

Jul 1, 2023

Radio and speakers have not worked for over a year- making loud popping and screeching sounds. Automotive center #1 stated it was a computer system fail and they could not fix it because they did not have the proper software. Then I went to get a new fuse for the cigarette lighter and was told something is leaking. Took it to Firestone automotive center to be told nothing is leaking and I should go to Ford because it is most likely a sensor issue. Car says it is overheating when it is in idle. And no one I go to seems to care to help me get things fix. Ford can't help for 2 weeks due to availability. This has been the worst experience with a car I have encountered with trying to figure out the problem.

NHTSA ID

11528399

Incident

Jun 22, 2023

I am having issues with the company Ford in regards to my vehicle. It has been at Dowling Ford, in Cheshire, Connecticut for 5 weeks. I believe I am one of the unlucky 2015 Ford Focus owners who was sold a one of the cars that has a faulty transmission. After doing some research, I discovered that Ford has a lawsuit against them for unloading Ford Focus' with faulty transmissions. I will attach the link to the article stating this information. Ford is trying to charge me $5900.00 to fix the car that wasn't even brought in for the reasons that they are trying to charge me with. I bought the car for just under 7,000. It is only a 2015 and has 106,000 miles on it and should not be running into these problems. I have contacted the corporate office of Ford multiple times and they refuse to offer any help what so ever. I have only had the car for two years. My car was only brought in because the wipers weren't working properly and it was overheating while only in idle. It was diagnosed that the transmission module needed to be replaced which was covered under the warranty. Well, the bad news began there when I had to wait 2 weeks for that part to come in because it was "back ordered". Once that was replaced, they tried to tell me now that something else needs to be replaced which was the clutches on the transmission and it would cost $3200. Then once they fixed that which took 4 more days, they now are saying something else is wrong which is the transmission case and would be an additional $2700. My car was not brought in for any of these issues and now all of a sudden, my car needs them all replaced. Ford, hasn't even offered me a loaner during the last 5 weeks. I don't feel safe in this vehicle, and I know that I am driving an unsafe vehicle that shouldn't have even been sold to anyone.

NHTSA ID

11526280

Incident

May 5, 2023

Ford Focus 2015 w Select Shift. The warranty is in effect for 10 yr 100,000 drivetrain. TCM - AE8Z7Z369F The car began sputtering in the middle of August when pressing on the gas. The car would jump when hitting about 12-15 mph and again at 28-35 mph. At this point the engine light was on I took the car to a local certified auto shop where it was diagnosed that the TCM module was having problems and I would need to take it to a dealership. Late august I took it to the Beacon Healey Ford Dealership to get it fixed and they confirmed it was the TCM and that it could be a few weeks because the part was on backorder. I called every few weeks and it has been the same status since then. Luckily this part and the labor will be covered under warranty but this has left me in a very difficult situation that the dealership or ford are not doing much to help with. I was not offered a loaner/rental car and have been using a relative's car which they will be needing back soon. It has been 3 months and they still do not have a loaner for me or any updates at all on an estimated time for resolution or when the part will at least become available.

NHTSA ID

11493351

Incident

Aug 18, 2022

Radio is making a loud popping noise at random times. It’s easily distracting and could very possibly cause an accident due to the random loudness of the popping.

NHTSA ID

11467530

Incident

May 24, 2022

Vehicle stalls & shuts off during use with zero warning, both while in park and while car is running and stopped with foot on brake at a stoplight, and also seems sluggish and straining during active driving as if it wants to stall and shut down. When car stalls, a warning displays (System Start Fault) when attempt is made to restart vehicle and the vehicle WILL NOT restart for anywhere between 45 minutes to 4 hours (so far). The vehicle will then go through varied reactions to attempts to restart when ignition key is turned ... ranging from the dashboard warning of System Start Fault with no success at restart to absolutely NO response of dashboard or other lights/warnings/electrical (completely dead). When this stall/complete shut down occurs, it also becomes locked in whatever gear it was in (Park or Drive) when the stall & immediate shutdown occurs and the gearshift locks in place and you're unable to shift into park or neutral as needed for tow or to move the vehicle off the roadway without the tow driver or other person dismantling the area covering the gearshift to access the hidden pin to shift into neutral to move the vehicle from the roadway. After the first complete shutdown during use occurred, it was taken to a local Ford dealership who was "unable to find the cause" at that time. Since that time, this complete shutdown while in use has occurred another four times within the 3 months following, resulting in either towing the vehicle or waiting 1-4 hours where the vehicle stalls/dies (parking lot, stoplight, etc) until the vehicle decides to restart. I have become terrified of driving this only means of transportation as I don't know when or where this vehicle is going to shut down without warning and fear I will be struck and killed by another vehicle or someone else killed when it shuts down again on the active roadway.

NHTSA ID

11466180

Incident

Mar 3, 2022

I had a ford certified tech work on my Ford Focus and after my recalls were supposedly repaired my car is doing worse than ever, if I stop on a hill I will sometimes roll backwards due to apparent engagement issue, and after a new tcm to fix that my car now displays “transmission overheating stop safely” after a few miles on the highway. it shifts really rough and I haven’t ran the risk of stopping on a hill. Not what I would expect coming from a family who has over 100 years put into working at ford motor company.

NHTSA ID

11464896

Incident

Mar 16, 2022

I was driving down the highway and my door locking latch and cable failed. The door came open going 75 MPH.The defective dealership part I found out is the subject of recalls on other Ford Focus year models but my model was left off the recall. This is a huge safety concern as my door is unable to lock at all times including highway driving.

NHTSA ID

11457382

Incident

Feb 9, 2022

1. Fluctuating fuel gage. 2. Car stopped while driving on highway multiple times. 3. Rough Idle and hard to start. DTC code P1450 is displayed. I went to the Ford dealership for 18S32 Recall and I was charged over $ 400 for recall to be performed. I did show them the Safety Recall Notice-18S32. There was not a crash but I went from Middle lane on GSP to right most lane and a nice lady slowed down to let me pull over to the shoulder. This could have been an accident. How can Ford dealership refuse to perform this recall and charge customers over $ 400? I will have to scan and upload the bill tomorrow.

NHTSA ID

11457160

Incident

Mar 6, 2022

My car shut off randomly in the middle of lane and on the highway too. My car show "system fault". Didn't start until I put a new battery. The next day it happened again it show again "system fault". So I change a wire sensor that connects to the battery. It work then while you are driving it stop or when you are parked too. I really don't want to drive I'm afraid I get into a accident while on the road.

NHTSA ID

11432383

Incident

Aug 9, 2021

WHILE DRIVING MY CAR THE CENTER DISPLAY WHICH HAS MY ODOMETER AND DIGITAL SPEED AS WELL AS ANY WARNINGS FOR MY CAR SHOWED LINES ACROSS IT AND IT IS DIFFICULT TO READ. IN RESEARCHING IT I FOUND THIS IS A COMMON OCCURRENCE WITH THESE CARS AND IT WILL EVENTUALLY GO COMPLETELY BLACK AND NOT WORK AT ALL.

NHTSA ID

11382896

Incident

Dec 1, 2020

Mileage

60,000 mi