2024 Ford Maverick Hybrid Problems

Continued frozen rear view camera on dash screen despite ford recall repair (per ford campaign 24S59/24V684). Frozen rear view camera display leads to safety issue resulting in improper depiction of vehicle position.

•Incident/Repair 1 (6 Months from Delivery): At approximately six months of ownership, the vehicle suffered an internal high-voltage electrical failure. The vehicle was towed to an authorized Ford dealership, where technicians diagnosed a catastrophic failure of the High-Voltage Traction Battery system. The dealership attempted a repair by completely replacing the high-voltage hybrid battery assembly. This repair occurred well within New York State's statutory Lemon Law window of 2 years or 18,000 miles. •Incident 2 (2 Years 4 Months from Delivery / Current Status): Approximately two years 4 months from the original delivery date, the replacement high-voltage battery system suffered a secondary, catastrophic failure. While actively driving at highway speeds in live traffic, the engine completely shut off without warning. The vehicle suffered a total and sudden loss of motive power, forcing me to coast through traffic to a complete stop on the side of the road. •Automatic Shifter Hazard: Upon reaching a complete stop during this second incident, the vehicle's computer system automatically forced the electronic transmission into "Park" while still on the roadway. The vehicle's electronic center console maintained 12V power, allowing me to manually override the system into a temporary "Neutral Tow" setting so the truck could be physically pushed out of the flow of traffic to avoid a collision. The vehicle was subsequently towed back to an authorized Ford dealership, where it currently sits

•Incident/Repair 1 (6 Months from Delivery): At approximately six months of ownership, the vehicle suffered an internal high-voltage electrical failure. The vehicle was towed to an authorized Ford dealership, where technicians diagnosed a catastrophic failure of the High-Voltage Traction Battery system. The dealership attempted a repair by completely replacing the high-voltage hybrid battery assembly. This repair occurred well within New York State's statutory Lemon Law window of 2 years or 18,000 miles. •Incident 2 (2 Years 4 Months from Delivery / Current Status): Approximately two years 4 months from the original delivery date, the replacement high-voltage battery system suffered a secondary, catastrophic failure. While actively driving at highway speeds in live traffic, the engine completely shut off without warning. The vehicle suffered a total and sudden loss of motive power, forcing me to coast through traffic to a complete stop on the side of the road. •Automatic Shifter Hazard: Upon reaching a complete stop during this second incident, the vehicle's computer system automatically forced the electronic transmission into "Park" while still on the roadway. The vehicle's electronic center console maintained 12V power, allowing me to manually override the system into a temporary "Neutral Tow" setting so the truck could be physically pushed out of the flow of traffic to avoid a collision. The vehicle was subsequently towed back to an authorized Ford dealership, where it currently sits

The front 2024 Ford Maverick passenger CV axle has failed, currently leaking grease. Ford has not rolled out a recall for the 2024 Ford Maverick, unlike the prior Maverick years. The vehicle produces the same symptoms as described in the 2022 recall of Ford Mavericks with aggressive shaking from 45mph-60mph. This renders the vehicle a safety hazard as it alters the way the vehicle drives.

Nov 2nd ,2026 i was driving home in heavy stop and go traffic on the highway. Traffic stopped in front of me and as i pressed the brake it felt life the nothing. Truck hesitated and then grabbed . i was unable to stop in time and hit the car in front of me . i know i should of left mor space between the car in front . i feel like without the hesitation the accident would not of happened. this was not the first time it has done this.

in the ford maverick hybrid, ford has been aware of parasitic drain issues related to its software in the ABS braking system and it air condition system which causes degradation of the battery. there are service messages sent to ford dealerships regarding these issues (SM 55215, SSM 53801, SSM 54785). There are incidences of Ford dealerships upgrading software, upgrading batteries, and dealing with these as warranty issues. The effects cause no start situations and gear shift lockups with engine limp modes enacted. Through various Maverick owners and forums this has been seen in multiple vehicles. This can create dangerous issues if the system fails in the middle of driving on highways and stranding individuals in remote or unserviceable areas is apparent and with Ford providing service messages to dealership mechanics. It is apparent that it is something in ford's manufacturing process. The outcome to recall should not wait for a dangerous event or death to create said recall, but promote proactive response to the dangers created by faulty software that was created at Ford adn endanger the consumer purchasing their product as this not only affects them but also all others around them as we all travel the highways together.

•Incident/Repair 1 (6 Months from Delivery): At approximately six months of ownership, the vehicle suffered an internal high-voltage electrical failure. The vehicle was towed to an authorized Ford dealership, where technicians diagnosed a catastrophic failure of the High-Voltage Traction Battery system. The dealership attempted a repair by completely replacing the high-voltage hybrid battery assembly. This repair occurred well within New York State's statutory Lemon Law window of 2 years or 18,000 miles. •Incident 2 (2 Years 4 Months from Delivery / Current Status): Approximately two years 4 months from the original delivery date, the replacement high-voltage battery system suffered a secondary, catastrophic failure. While actively driving at highway speeds in live traffic, the engine completely shut off without warning. The vehicle suffered a total and sudden loss of motive power, forcing me to coast through traffic to a complete stop on the side of the road. •Automatic Shifter Hazard: Upon reaching a complete stop during this second incident, the vehicle's computer system automatically forced the electronic transmission into "Park" while still on the roadway. The vehicle's electronic center console maintained 12V power, allowing me to manually override the system into a temporary "Neutral Tow" setting so the truck could be physically pushed out of the flow of traffic to avoid a collision. The vehicle was subsequently towed back to an authorized Ford dealership, where it currently sits

I STARTED THE CAR AND MY ENGINE WONT TURN ON ONLY HYBRID SYSTEM. THE MAINTIENCE LIGHTAND ENGINE LIGHT APPEAR WITH FUEL DOOR OPEN ERROR AND TRACTION OFF AND DRIVER ASSITANCE OFF . I THEN JUMP STARTED TRUCK . TRUCK ENGINE THEN TURNED ON AND SAME ERRORS LIGHTS STILL APPEARED . BUT I WAS ABLE TO SHIFT INTO GEAR NOW WITH JUMP START . HOW EVER TRUCK WOULD NOT ACCELERATE WHEN I PUSH GAS PEDAL . BUT IF I LET GO OF THE BRAKES , THE TRUCK WILL SLOWLY ACCELERATE ON ITS ON . AND SPEED UP TO 30-40 MPH WITH OUT PRESSING THE GAS .

Under 6 MPH I feel a strong grabby breaking but my dealer couldn’t give me a solution after a inspection

Nov 2nd ,2026 i was driving home in heavy stop and go traffic on the highway. Traffic stopped in front of me and as i pressed the brake it felt life the nothing. Truck hesitated and then grabbed . i was unable to stop in time and hit the car in front of me . i know i should of left mor space between the car in front . i feel like without the hesitation the accident would not of happened. this was not the first time it has done this.

On November 9th, the vehicle became undrivable with the following alerts: "Stop safely now", "Pre-collision assist not available", "Check Brake System", "Front Camera Temporarily not available", "service vehicle soon", "service advance trac", "hill start assist not available" The accelerator was non-functional; however, when releasing the brake pedal the vehicle starts to accelerate, without pressing the accelerator. Dealer said they are unable to reproduce the event. This is the second time this has occurred with this vehicle, previously submitted complaint on this same VIN.

While driving on the freeway complete loss of power, loud sound, visible smoke. Determined by the dealer that an internal engine part failed.

The contact owns a 2024 Ford Maverick. The contact stated that while driving at undisclosed speeds and depressing the brake pedal, the vehicles driving behind contact were getting too close. Upon further investigation, the contact related the failure to NHTSA Campaign Number: 25V095000 (EXTERIOR LIGHTING, ELECTRICAL SYSTEM). No warning lights were illuminated. The vehicle was not diagnosed nor repaired. The manufacturer was contacted, and the contact was referred to the NHTSA Hotline for assistance. The failure mileage was approximately 18,000.

My battery will not hold a charge. This will not allow me to remote start or unlock doors. The interior lights don’t come on at night. It happens probably 10 times a month.

Trunk had dead battery upon startup Back in March something happened and dealer stated the truck needed a software update, which they preformed but now I have the same problem

SENCE PURCHACED the truck has a tie rod rattle, I have spoken to dealership and was informed no issue found. But as of late Vehicle wobbles very harshly when execrating or pulling away from stop signs passing another vehicle. Turns out it's a VERY common CV axle issue that the dealership doesn't have any sort of recall on. Feels very very unsafe to drive and its disappointing to see so many other drivers with the exact same issue with the tie rod ends. Now a recall on some of the mavericks suspension AKA tie rod installed wrong/ defective with a DO NOT DRIVE WARNING?

The front 2024 Ford Maverick passenger CV axle has failed, currently leaking grease. Ford has not rolled out a recall for the 2024 Ford Maverick, unlike the prior Maverick years. The vehicle produces the same symptoms as described in the 2022 recall of Ford Mavericks with aggressive shaking from 45mph-60mph. This renders the vehicle a safety hazard as it alters the way the vehicle drives.

SENCE PURCHACED the truck has a tie rod rattle, I have spoken to dealership and was informed no issue found. But as of late Vehicle wobbles very harshly when execrating or pulling away from stop signs passing another vehicle. Turns out it's a VERY common CV axle issue that the dealership doesn't have any sort of recall on. Feels very very unsafe to drive and its disappointing to see so many other drivers with the exact same issue with the tie rod ends. Now a recall on some of the mavericks suspension AKA tie rod installed wrong/ defective with a DO NOT DRIVE WARNING?

Defective spot welds of interior door hinges bind resulting in destruction of 3 remaining spot welds making door inoperable, not closing correctly, damaging other hinge and locking mechanisms. Local and corporate denied. out of warranty at 42645 miles.

The contact owns a 2024 Ford Maverick. The contact stated that while the vehicle was parked, the contact became aware that the front driver's side door middle hinge was not properly welded. The contact stated that the front driver's side door was not properly welded when the vehicle was manufactured. The contact stated that the failure caused issues while rolling down the window. The vehicle was taken to the dealer, and the failure was confirmed. The contact was informed that the driver's side front door needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure, and a case was filed. The manufacturer agreed to a 40 percent discount on the cost of the repair. The failure mileage was approximately 46,000.

The front 2024 Ford Maverick passenger CV axle has failed, currently leaking grease. Ford has not rolled out a recall for the 2024 Ford Maverick, unlike the prior Maverick years. The vehicle produces the same symptoms as described in the 2022 recall of Ford Mavericks with aggressive shaking from 45mph-60mph. This renders the vehicle a safety hazard as it alters the way the vehicle drives.

There is a constant wobble and shudder between 30-65 mph.

Rearview camera lags and occasionally freezes image during reversing. Lagging and freezing gives a false sense of vehicle position. There has been one occasion where the image froze and stayed frozen even after putting vehicle in "D" and traveling up to 30mph+. Vehicle is not part of latest recall for frozen rearview camera issue.

I purchased a 2024 Ford Maverick Lariat Hybrid truck on [XXX] and have discovered a safety issue. When I operate the windshield washer, the washer fluid tank fully drains in about ten seconds. I can visually see the fluid level fall rapidly. Washer fluid sprays at a high velocity on my windshield until the tank is empty. There is no evidence of a fluid leak. Last week, I took the truck to a local Ford dealer. They were the ones who discovered the rapidly draining tank and they escorted me from the lounge area to the shop and showed it to me. Both the service writer and three mechanics standing at my truck stated that they had never seen anything like that occur before. The service writer brought over the service manager, who took a look and suggested that perhaps there was a problem with the nozzles. He also stated that he had never seen this issue before. The dealership ordered new nozzles. I returned to the dealership this afternoon to have the replacement nozzles installed. When the function of the windshield washer was tested, the bottle again drained in about ten seconds. One of the technicians then tested a new Ford F150 that is in the shop today and it also drained rapidly. I asked that a new Maverick on the lot be tested, which the dealership immediately did, and it also drained in about ten seconds. Evidently, Ford has an issue with this function on some of their new vehicles. Windshield washing is an important safety feature and it is not functioning as it should on these three tested vehicles. This problem was observed and verified as never having been seen before by a Ford service writer, three Ford mechanics, and a Ford service manager. The selling Ford dealer is Crossroads Ford of Wake Forest, NC and the servicing dealer is Deacon Jones Ford of Goldsboro, NC. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Restraints indicator warning lamp for passenger side went off repeatedly in August (four times). Took into dealership where they replaced what they said was a faulty seatbelt tensioner. Now, the same indicator warning is going off again, two times, 9/28, 10.4. Either the part is still bad, or the sensor is defective. I suspect the latter, but it's hard to know.

The contact owns a 2024 Ford Maverick. The contact stated that while driving at approximately 45 MPH, the vehicle suddenly decelerated to 20 MPH and the check engine warning light illuminated and the vehicle failed to accelerate as needed. The contact took the vehicle to the dealer and the vehicle was diagnosed with battery failure. The battery was replaced. The contact stated shortly after the battery replacement, the failure reoccurred. The vehicle was returned to the dealer and diagnosed with PCM failure. The vehicle was not repaired. The manufacturer was made aware of the failure and referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 13,000.

Airbags did not go off in a head on collision besides the one at my feet Emergency auto braking did not brake and hindered my ability to brake