Owner-reported complaints naming the brake system, filed with NHTSA
Data refreshed
Reports naming service brakes, the antilock braking system, brake hoses, master cylinders or the parking brake. Every record below is an owner-reported complaint about the 2022 Ford Maverick submitted to NHTSA — not a confirmed defect, not a recall and not a manufacturer bulletin. 13 reports on file name it.
Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.
Shown in the owner’s own words, exactly as filed
NHTSA #26V104: I purchased this vehicle to rent it out on Turo (a vehicle sharing platform). It was de-listed from Turo on March 18 due to NHTSA #26V104 recall being unresolved. I have been unable to rent my vehicle since then and Ford has not provided a remedy to this recall. I would like to log a complaint that this software fix remedy has taken too long.
The contact owns a 2022 Ford Maverick. The contact stated that while driving at an undisclosed speed, the trailer brakes became inoperable. There was no warning light illuminated. The contact was informed by another driver that the trailer brake lights were not illuminated while the vehicle was stopped. The dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 44,700. The VIN was not available.
I have a 2022 Ford Maverick XL Hybrid and the system that failed is the rear lighting system, specifically the tail lamps, brake lamps, and rear turn signals. This appears to be related to the Body Control Module (BCM) software, which was the subject of Ford Recall 24S27 affecting many 2022–2024 Ford Mavericks. The failure began on my vehicle with the left rear tail lamp assembly (running light, brake light, and turn signal), and within approximately two minutes the right rear tail lamp assembly also stopped functioning. Since that time, the entire rear lighting system has been inoperative while driving. This issue creates an extremely serious safety hazard. While driving, my vehicle has no functioning rear running lights, brake lights, or turn signals. This means other drivers cannot see when I am braking, signaling a turn, or even driving at night. This significantly increases the risk of rear-end collisions or other traffic accidents, especially in low visibility conditions. I was unaware of the issue until visually noticing it when unlocking the vehicle, and there were no dashboard alerts to warn me prior to that either. Loveland Ford in Loveland, Colorado inspected the vehicle and confirmed that the rear lighting system is not functioning. However, instead of addressing the known Recall 24S27 Body Control Module software issue, they stated that LED bulbs were installed where halogen bulbs should be and issued an $816 estimate to replace the bulbs. I have never performed any aftermarket modifications, and the vehicle has only been serviced by Ford dealerships. The vehicle has been inspected by Loveland Ford, an authorized Ford dealership. Ford customer service confirmed that Recall 24S27 exists for this exact issue in many 2022–2024 Ford Mavericks but stated there is no record of my VIN receiving the recall remedy, which could mean the recall was never accomplished. No warning lamps, dashboard messages, or other alerts appeared prior to the failure.
while i was driving the truck lost power and i could not turn on my 4 way flashers when i was on the side of the road. when i called ford and asked if i would replace the battery if i would get compensation they told me no even though there is a recall
The rear brakes and rotors have prematurely worn out at only 28k miles, while the front brakes are like new. There is no way for me or any local repair shop to put it into brake service mode. The official Ford procedure does not work. NHTSA issued SSM 51217 acknowledging the issue, but the only solution is only to take it to a Ford dealer to do a simple procedure such as changing rear brake pads. This solution is unacceptable and causes an undue burden upon the customer in time and money for a known manufacturing defect. My closest dealer is 1 hour away. It can not pass my state safety inspection without this being done. Ford should be issuing a recall to address this defect, not simply driving people to the dealer network for basic safety maintenance.
The contact owns a 2022 Ford Maverick. The contact stated while driving 35 MPH, the accelerator pedal was depressed; however, the vehicle failed to accelerate as needed. The contact stated that the message “Engine Power Reduced” was displayed. Additionally, the contact stated that the “BRAKE” warning light illuminated; however, due to the failure the computer system generated the failure code in error. The vehicle was taken to the dealer where it was diagnosed as a fractured well in the braking system. The contact was informed that the braking system needed to be replaced. The vehicle was not repaired. The contact was informed that the parts needed to be ordered to perform the repair. The manufacturer was made aware of the failure. The failure mileage was approximately 56,000. The VIN was unavailable.
Multiple instances of Auto Hold function sucking brake to floor and haulting vehicle at low speeds causing danger of a rear collision. Recommend adding a 1 second delay to current system before engaging auto hold function.
I have a 2022 Ford Maverick, 2.0 ecoboost engine, awd. I have been having brake problems since the beginning. The problem is the front brakes do not back out enough to leave a proper air gap between the brake pad and rotor when deactivating the service mode. Therefore the pads keep riding on the rotors causing glazing and grabby brakes when coming to a stop behind a vehicle. Turning off the active breaking did help with the grabby brakes when stopping behind a vehicle, but did not resolve the glazing issue. I took the truck into two dealerships and the techs. could not find a solution. the front calipers, front brake hoses and the brake master cylinder have been replaced with no success. Maybe the solution is to adjust the air gap settings somewhere in the software.
The contact owns a 2022 Ford Maverick. The contact received notification of NHTSA Campaign Number: NHTSA Campaign Number: 22V594000 (Air Bags) and 22V730000 (Exterior Lighting, Service Brakes, Hydraulic) however, the parts to do the recall repairs were not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.
(there is a brake system malfunction. When braking sometimes the brakes would skip and I could feel the brakes not grabbing the rotors the way they should. the problem has not been reproduced or confirmed by a dealer because the dealership could not figure out what was causing the problem with the brakes. the dealership inspected the brakes. there was no warning lamps or messages of the brake problem.) I first started to hear a intermittent rubbing noise when braking and driving slow a couple months after I purchased the vehicle. I took it the vehicle into the dealership and they could not figure out what was wrong. I was told perhaps i was to aggressive on the brakes. the problem continued so i went to another dealership and they looked at the brakes and could not figure out what was causing the noise. the rotors looked glossy (glazed) So I decided to replace the rotors and brakes at my cost because I was told the truck was out of warranty. one week after the repairs were made, I started to hear the rubbing noise again. I was furious! I couldnt believe this was happening on a brand new vehicle, especially on a ford. So I continued to drive until the rotors got so bad that the steering wheel was shaking when I braked.the rotors were warped. So I decided to take matters into my own hands and replace the brake pads and rotors using the ford manual for the 2022 maverick. This time I decided to only drive eco mode on the highway and normal mode in the city. I also turn off the active braking every time I got in the truck. I was also very careful not to be aggressive on the brakes and not to ride them when slowing down. I kept a close watch on the rotors. after two weeks of driving the rubbing noise started again and the rotors are glazed again. I do not know if its a mechanical issue with the brake calipers/master cylinder or a computer/software issue. I cannot afford to be replacing brakes and rotors every two weeks. I am greatly disappointed in ford motor company .
The contact owns a 2022 Ford Maverick. The contact stated that NHTSA Campaign Number: 22V193000 (Electrical System) was repaired at the dealer. The contact was stopped by the police and informed that the brake light on the trailer was illuminated. The vehicle was taken to the dealer for the Ford Tech to reprogram the brake module. The contact was informed to no use the trailer brakes. The manufacturer was contacted and referred the contact to the NHTSA Hotline for assistance. The failure mileage was 9,000.
Mavericks with Integrated Trailer Brake Controllers are not sending any voltage to the trailer brakes when the brake pedal is pressed. Customers are at risk of not having the anticipated additional braking ability of their trailers and will be putting the entire braking load on the truck alone. A Ford dealership had my vehicle for 2 weeks with no repairs done or guidance on when it would be repaired.
EL DIA 21 DE MARZO DEL 2022 LLEGANDO A MI CASA Y PARA SER BIEN ESPECIFICA FRENTE A MI CASA ME ESTABA ACOMODANDO PARA COLOCAR EN RIVERSA MI GUAGUA Y LA MISMA SE ACELERO SOLA Y LOS FRENOS NO LE FUNCIONARON, CAUSANDO QUE ME FUERA POR UN RISCO. LOS AIR BAGS NUNCA LE ABRIERON.
Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.
Categories with enough reports to have a page of their own
Data on this page last refreshed .