2022 Ford Maverick Problems

Due to go to dealership to inspect steering wheel

I was trying to turn and the wheel kept kicking back the other direction. About a week prior to this as I was driving down the road all of a sudden the wheel threw me across a median and into incoming traffic almost causing multiple accidents. I have a video of it but it won’t allow me to upload it. [XXX] However this link should play it. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

I had stopped at an intersection and when I applied the gas, the truck stuttered a bit before going. It ran okay for less than a mile. I stopped at the next intersection and when I applied the gas, the truck shuttered, started to go then just stopped. It stayed running but didn't want to go. I was able to get it through the intersection but that was it. The message i am getting is powertrain malfunction/reduced power. When we put our diagnosis tool on it, we get code P0757.

I am filing a formal safety defect complaint regarding a severe catastrophic transmission failure on my 2022 Ford Maverick ( 2.0L EcoBoost 8f35 8 speed transmission ) that poses an immediate safety hazard to occupants and sharing traffic. Upon inspection a heavy volume of metal shavings flakes were discovered also the code PO73D unable to engage in neutral came up. The safety risk of this specific failure is extreme because the vehicle is physically unable to respond to a neutral command the driver cannot clear or cut engine power to the drive wheels during an emergency mechanical malfunction or a potential unintended acceleration event. Furthermore because the metal debris the truck exhibits severe erratic shifting behavior and a persistent risk of sudden high speed wheel lockup drivetrain binding or stalling inactive traffic. Ford motor company is fully aware of this component failure despite my vehicle exhibiting the exact failure mode the exact code PO73D and metal debris found has refused financial responsibility I urge the NHTSA to upgrade this known issue to a mandatory safety recall

Due to go to dealership to inspect steering wheel

Clunking in the front end around 20,000 miles. Brought to multiple dealers and they all said no problem found yet clearly hear clunking both sides front going over bumps or steering back and forth quickly. Finally I just replaced them and noise gone. Second thing is headliner is completely ruined from moisture intrusion and can visibly be seen but dealer states no leaks present yet my headliner is water stained looking like those wet tiles in a school. Third is my transmission. It is very erratic when shifting and sometimes flares when downshifting. Dealers state no problems exist. Operates as designed, yet I have driven other mavericks and they do not have the same issues as myself. I have changed the fluid with genuine ford ulv transmission fluid from dealer at about 50k miles. I change my oil every 3k, changed my differentials and transfer case all with genuine fluid. I am an AAS Automotive Technology graduate and currently ASE certified and have worked in multiple dealerships replacing transmissions, engines, almost anything since I have started. I need to gather my records as I have kept receipts and records as I do all my own maintenance and repairs. I have replaced the downstream oxygen sensor twice. Yesterday morning I got a frozen throttle body and limp mode and if I did not have my scan tool I would have been stranded as it would not let me drive due to the stuck closed codes. All codes since I owned the vehicle with 3 miles on it are stored in my ford app and on my scan tool with vin. I have tried calling ford, email, different dealerships and they deny me or want me to pay out of pocket when I have warranty.

The driver's side (left front) door failed at the check-arm attachment point inside the door assembly: the spot welds securing the check-arm reinforcement bracket to the inner door structure cracked and separated. The vehicle is a commercial fleet 2022 Ford Maverick XL SuperCrew with approx. 82,000 miles. The vehicle and failed component are available for inspection upon request. First symptoms were difficulty opening and closing the door with popping/cracking noises. No warning lamps or messages occurred; the failure is concealed inside the door. This is a safety risk because the check arm attachment supports the door's structure. The same weld separation on related vehicles has been documented by NHTSA (investigation PE23-013) to cause doors that fail to latch, fail to stay closed, or open while driving, risking occupant ejection and injury. The failure was confirmed 7/17/2026 by Grapevine Collision Center (Grapevine, TX) after a Ford dealership stated there is no recall or warranty coverage for the Maverick and referred me there. The shop diagnosed broken check-arm welds and quoted $2,602.46 for a door shell replacement, noting it has seen this identical failure on Ford Escapes and Lincoln Corsairs. Not inspected by Ford, police, or insurance. This is the same failure mode NHTSA investigated on 2020-2021 Escapes (PE23-013), which Ford addressed via Customer Satisfaction Program 23B56 covering 2020-2023 Escapes. The Maverick shares the same C2 platform and door design but is excluded, leaving owners to pay out of pocket for a defect Ford repairs free on sibling vehicles.

Driver side door limiter welds broke loose. Ford said they had to replace the entire door and it was not covered by warranty. The dealer said that this happened to a bunch of Ford Escapes, but they did not have a recall for the Maverick yet.

When driving at normal speed, my truck completely shut down with no warning. The instrument panel went dark and the engine shut off. I do not believe I was able to steer, though I think the brakes allowed me to slow the vehicle to a stop. I was near an intersection, so I was lucky to not have been hit from the rear or run in to traffic in front of me. The vehicle was unresponsive and would not turn back on. I was stuck blocking 1 lane of traffic for an hour because the vehicle could not be steered or taken out of gear to push it to the side of the road. I inspected the battery connection and nothing seemed out of place or degraded while trying to get the car out of the road. Highway Patrol also looked, but only was able to offer a tow truck as a solution. My truck has been at the dealer service for almost 2 days awaiting inspection at this point so I have no additional information on what caused this dangerous situation. There had been no indication prior, the truck had started and run normally and all scheduled services had been carried out by the dealer up to this point.

My car shuts off Battery drains, burning smell Rear camera gives out Clicking noises

NHTSA #26V104: I purchased this vehicle to rent it out on Turo (a vehicle sharing platform). It was de-listed from Turo on March 18 due to NHTSA #26V104 recall being unresolved. I have been unable to rent my vehicle since then and Ford has not provided a remedy to this recall. I would like to log a complaint that this software fix remedy has taken too long.

The contact owns a 2022 Ford Maverick. The contact stated that while driving at an undisclosed speed, the trailer brakes became inoperable. There was no warning light illuminated. The contact was informed by another driver that the trailer brake lights were not illuminated while the vehicle was stopped. The dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 44,700. The VIN was not available.

while i was driving the truck lost power and i could not turn on my 4 way flashers when i was on the side of the road. when i called ford and asked if i would replace the battery if i would get compensation they told me no even though there is a recall

The component that failed on this vehicle was the restraint control module (RCM). It was replaced by the dealer and is not available for inspection. The safety of the driver I believe was at risk due to the vehicle occupant sensor not showing an occupant and only showing a question mark on the dash display. This was also causing an airbag and seat belt indicator light. The problem has been reproduced by a dealer. The problem first showed a rear seat occupant issue and then started showing for the left front seat. Showing an air bag and seat belt indicator.

I have a 2022 Ford Maverick XL Hybrid and the system that failed is the rear lighting system, specifically the tail lamps, brake lamps, and rear turn signals. This appears to be related to the Body Control Module (BCM) software, which was the subject of Ford Recall 24S27 affecting many 2022–2024 Ford Mavericks. The failure began on my vehicle with the left rear tail lamp assembly (running light, brake light, and turn signal), and within approximately two minutes the right rear tail lamp assembly also stopped functioning. Since that time, the entire rear lighting system has been inoperative while driving. This issue creates an extremely serious safety hazard. While driving, my vehicle has no functioning rear running lights, brake lights, or turn signals. This means other drivers cannot see when I am braking, signaling a turn, or even driving at night. This significantly increases the risk of rear-end collisions or other traffic accidents, especially in low visibility conditions. I was unaware of the issue until visually noticing it when unlocking the vehicle, and there were no dashboard alerts to warn me prior to that either. Loveland Ford in Loveland, Colorado inspected the vehicle and confirmed that the rear lighting system is not functioning. However, instead of addressing the known Recall 24S27 Body Control Module software issue, they stated that LED bulbs were installed where halogen bulbs should be and issued an $816 estimate to replace the bulbs. I have never performed any aftermarket modifications, and the vehicle has only been serviced by Ford dealerships. The vehicle has been inspected by Loveland Ford, an authorized Ford dealership. Ford customer service confirmed that Recall 24S27 exists for this exact issue in many 2022–2024 Ford Mavericks but stated there is no record of my VIN receiving the recall remedy, which could mean the recall was never accomplished. No warning lamps, dashboard messages, or other alerts appeared prior to the failure.

The rear brake lights intermittently do not work, but at the same time the middle third light brake light works fine. also the turn signals work fine. People will rear end me if they don’t see my brake lights. I am a retired, master mechanic, and my son is also a mechanic. We have both looked into this problem and it possibly could be either a module or the turn signal switch. I had no warning of this problem coming on other than someone telling me my rear brake lights stopped working when they were following me. This is a very dangerous situation.

Due to go to dealership to inspect steering wheel

I was trying to turn and the wheel kept kicking back the other direction. About a week prior to this as I was driving down the road all of a sudden the wheel threw me across a median and into incoming traffic almost causing multiple accidents. I have a video of it but it won’t allow me to upload it. [XXX] However this link should play it. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

When we brought it in for first oil change at the dealership ; when we got it back it had a broken axle which they tried to say we just needed new tires , after contacting service manager and he and I go for a ride in it they kept it for several weeks and put over 300 miles on it and got ford engineering involved to determine the cause was broken axle. It has been replaced again since then supposedly by a recall but it feels like it is broken again ! Ford took some shortcuts and used inferior parts, infrastructure etc , we had tremendous problems with the battery to which they said their shouldn’t be any reason for this be happening loss of power loss of electrical display and distribution finally I just had to replace the battery on my own because they refused to accept responsibility 4-6 months later a recall for the batteries was issued. The axles on the truck are not sufficient and they are not taking care of it properly! I would also like to report that they cut so many corners on the Maverick that the tailgate just drops no shock absorber nothing just slams on the bumper very dangerous! & They also chose to leave many open” holes” where mud rocks , leaves etc get into the front quarter panels from the hood area at the corner of windshield . So this wet material gets trapped in there n I’m sure will eventually affect the structural integrity of the panel - maybe rust through! Same thing happens with the tailgate fills with debris from bed , rear wheel wells also have a whole. I just wish ford would go back to how Henry Ford ran the company ! Help NHTSA

Clunking in the front end around 20,000 miles. Brought to multiple dealers and they all said no problem found yet clearly hear clunking both sides front going over bumps or steering back and forth quickly. Finally I just replaced them and noise gone. Second thing is headliner is completely ruined from moisture intrusion and can visibly be seen but dealer states no leaks present yet my headliner is water stained looking like those wet tiles in a school. Third is my transmission. It is very erratic when shifting and sometimes flares when downshifting. Dealers state no problems exist. Operates as designed, yet I have driven other mavericks and they do not have the same issues as myself. I have changed the fluid with genuine ford ulv transmission fluid from dealer at about 50k miles. I change my oil every 3k, changed my differentials and transfer case all with genuine fluid. I am an AAS Automotive Technology graduate and currently ASE certified and have worked in multiple dealerships replacing transmissions, engines, almost anything since I have started. I need to gather my records as I have kept receipts and records as I do all my own maintenance and repairs. I have replaced the downstream oxygen sensor twice. Yesterday morning I got a frozen throttle body and limp mode and if I did not have my scan tool I would have been stranded as it would not let me drive due to the stuck closed codes. All codes since I owned the vehicle with 3 miles on it are stored in my ford app and on my scan tool with vin. I have tried calling ford, email, different dealerships and they deny me or want me to pay out of pocket when I have warranty.

I am getting a “rear seat belt monitor fault” warning on my dash accompanied by an air bag warning light. It is also not allowing the auto start stop function to work as the vehicle states it cannot verify the driver seat belt is fastened. I have read in online forums that this is not an isolated issue.

The component that failed on this vehicle was the restraint control module (RCM). It was replaced by the dealer and is not available for inspection. The safety of the driver I believe was at risk due to the vehicle occupant sensor not showing an occupant and only showing a question mark on the dash display. This was also causing an airbag and seat belt indicator light. The problem has been reproduced by a dealer. The problem first showed a rear seat occupant issue and then started showing for the left front seat. Showing an air bag and seat belt indicator.

The contact owns a 2022 Ford Maverick. The contact stated that the vehicle would not properly accelerate from a stationary position and the check engine warning light remained illuminated. The vehicle was taken to the local dealer who diagnosed that the EVP Emissions Control System and the purge valve were faulty and needed to be replaced. The vehicle was not yet repaired. The manufacturer was notified of the failure. The failure mileage was 43,000.

I bought a 2022 Maverick on 12 JAN 2022. The car broke down on the highway six months after (23 JUL 2022). Ford service department claimed it was a fuel injector issue and by replacing the part, the truck should be as good as new. Fast forward to Sat 30 DEC 2023 and the truck breaks down on the highway again with the engine light flashing. Ford service department informed me that the engine has to be replaced because several parts are broken/shattered and they do not know how. I am inclined to believe that the issue was never fixed to begin with and Ford put my safety and the lives of the people I care about at risk. I was sold a lemon with major engine issues and I am terrified of driving the truck again. All the service reports are currently at the dealership; I can acquire copies when needed.

Never in all my years of driving have I or anyone i know experienced a vehicle with such a sensitive windshield that cracks with even minimal impact. I've owned this Ford maverick for under 3 years with 3 chip repairs and 2 replacements. This is unfair to consumers as often we are not aware of this issue until it is too late to change undo the purchases on these vehicles and have to drive faulty vehicles. It's surprising that there's no recall already assessed for something that causes customers to have higher insurance premiums, constant damage that affects visibility and causes some to drive with these defects to avoid extra costs and wasted money. I am hopeful you can assist us consumers in having Ford rectifying these issues at no cost to us as their choice to use defective windshield glass has cost all of us. This issue is widely known by owners and discussed on social media forums in abundance. Dealers are aware of this issue and offer nothing but an attempt to purchase other vehicles. Minimal research on the internet provides an abundance of evidence. I thank you for your time and assistance in advance for this issue.

My license plate light has stopped working. It was replaced and still isn’t working. This reduces visibility and increases risk of a crash. This is in addition to the legal requirement to have an operating license plate light.

The contact owns a 2022 Ford Maverick. The contact stated that while her son was driving approximately 60-65 MPH on the Interstate, the passenger’s side front wheel detached. There were no warning lights illuminated. The local dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 40,000.

See attached document for complaint

What component or system failed or malfunctioned? It’s not exactly failed or malfunctioned as much as it is just a flawed design. However, the problem is that the drivers seatbelt keeps getting wrapped up in the lever to recline the seat. This results in the handle getting pulled off of the seat constantly, the seat unexpectedly reclining when the driver pulls on the seatbelt too hard, or the seatbelt simply getting bunched up in the handle causing it to just become stuck and non functional. Is it available for inspection upon request? It is available for inspection anytime. How was your safety or the safety of others put at risk? When the drivers seat suddenly reclines or the seatbelt fails to engage due to being caught up in another component of the vehicle that’s a problem. Has the problem been reproduced or confirmed by a dealer or independent service center? No although I can duplicate that issue. Has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others? No Were there any warning lamps, messages or other symptoms of the problem prior to the failure, and when did they first appear? No.

I was working on my vehicle, when I close the hood. Upon closing, I heard something, I go to open, and the hood latch is stuck closed, not sure if that's a safety concern, but it was for me, as I could not access any important components of my vehicle, took it to the dealer, but still something of concern on a new vehicle.

I ordered my truck with all terain tires, they installed Falken wildpeak A/T AT3W 235 65R 17 tires.When me vehicle sits for a while (especially when its cold out) .I get a vibration for the first few miles down the road then it goes away. I have taken it to the dealer they are blameing the issue on the Falken tires,they said these tires develop a flat spot after sitting for a while. So they didnt think it was going to hurt my vehicle so they where not going to replace them.Seeing how I paid extra for all terrain tires and they installed these tires I don't think that was the correct action on there part.