2021 Ford Mustang Mach E Owner Complaints

The panoramic roof glass panel is not properly bonded/sealed to the vehicle body structure, allowing water to leak into the cabin on the driver’s side. The vehicle and the failed component (roof glass/moulding) remain available for inspection upon request. This creates a safety risk consistent with the one described in NHTSA Campaign 21V712000 / Ford Safety Recall 21S42, which covers 2021 Mustang Mach-E vehicles with inadequate panoramic roof glass panel adhesion to the vehicle body structure — a defect that, per Ford’s own recall filing, creates risk of the roof panel separating from the vehicle while driving, increasing the risk of a road hazard, injury, or crash. My vehicle exhibits the water leak symptom associated with this defect, but my VIN was not included in the recall population. The first visible symptom — staining on the driver’s side rear headliner — was documented in a photograph dated XXX, with continued staining documented in a follow-up photograph dated XXX. The vehicle was presented to an authorized Ford dealer (All American Ford of [XXX]) for inspection on XXX. The dealer confirmed the water leak and documented the driver-side top moulding as faulty, with the roof panel requiring replacement. The vehicle was also examined through a BBB AUTO LINE arbitration proceeding (Case #XXX), which acknowledged the existence of Safety Recall 21V712 in connection with this vehicle’s file. There were no warning lamps or dashboard messages associated with this failure; the only symptom has been visible water intrusion and headliner staining. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ID

11755711

Incident

Apr 21, 2026

While merging onto the freeway and accelerating, the center touchscreen detached from its mount. The screen has two components: a rear housing fixed to the dash and a glass front panel that sits on top of it — the glass panel came loose on its own; I have never attempted to remove or pry it. The panel remained connected only by internal wiring and hung loose from the dash while the vehicle was in motion. This created three distinct safety hazards: (1) the screen was dangling and at risk of fully detaching, (2) the failure occurred during a high-attention driving maneuver (accelerating while merging), and (3) I was forced to catch the glass panel with one hand to prevent it from falling or shattering, then reattach it while still navigating traffic — as the sole occupant of the vehicle. Heavier-than-usual traffic that day gave me a lower-speed window to manage this; at highway speed under normal conditions, this could have been considerably more dangerous. No warning lights or dashboard messages preceded the failure — this is a hardware/mechanical defect, likely related to the internal mounting clips. Since the initial failure, the screen has detached repeatedly during acceleration, occurring frequently over the following days. In subsequent incidents, my boyfriend was a passenger and able to assist in stabilizing the screen. The screen has since stopped functioning entirely, which independently constitutes a safety issue, as it disables the backup camera display and other driver-assist systems that rely on it. The dealer has not yet been able to reproduce the issue. A service appointment has been scheduled and is pending.

NHTSA ID

11755696

Incident

Aug 5, 2026

The HVBJB ($3500 + Tax) went on my car. It is out of battery system warranty by 25,000 miles (ended at 100,000 miles, I have 125,000 miles). I called Ford Corporate and they said they "have no current programs" to give me any good will discount on the repair. This is a big, known issue with Mustang Mach-e's There was a recall for this HVBJB part / system on many of the 2021 models, but somehow mine wasn't included in the recall. I cannot afford this repair, and I was hoping the NHTSA can get involved to get me some financial relief from Ford. There was also a safety issue as this morning when this all happened, the car forced me to stop at an intersection and would not move or restart. The police had to push me through the intersection. It's currently at Chapman Ford in Egg Harbour Townshop, NJ.

NHTSA ID

11755300

Incident

Aug 6, 2026

The contact owns a 2021 Ford Mustang Mach-E. While the contact's daughter was driving at an undisclosed speed, the vehicle independently accelerated. The brake pedal was depressed; however, the vehicle failed to stop as intended. No warning lights were illuminated. The contact stated that the failure occurred while the vehicle was being parked in the residence driveway. The vehicle crashed into the right side of the residence before coming to a stop. The air bags did not deploy. The contact stated that the right side of the garage was damaged. No injuries were sustained. The contact stated that the failure was a known failure with the vehicle. The contact stated that an unknown recall with a similar failure was completed in 2022. The vehicle was towed to a local tow yard. The vehicle was deemed a total loss by the insurance company. The manufacturer was not made aware of the failure. The failure mileage was approximately 65,000.

NHTSA ID

11754043

Incident

Jul 22, 2026

Mileage

65,000 mi

While driving my 2021 Ford Mustang Mach-E, the front electric drive unit failed suddenly with no warning signs, warning lights, unusual noises, or any prior indication of a problem. During the failure, multiple fault messages appeared on the instrument cluster, including warnings that disabled adaptive cruise control and indicated the all-wheel-drive system was no longer functioning. The vehicle began to vibrate severely, feeling as though it was driving over rumble strips. As I slowed down, the front of the vehicle became extremely clunky and exhibited abnormal drivetrain behavior. Shortly afterward, the vehicle became undrivable and could no longer be operated under its own power. It had to be towed to a Ford dealership, where I was informed that the front electric drive assembly had failed and required replacement. This is the second time this exact component has failed on the same vehicle. The first front electric drive assembly failed at approximately 33,000 miles and was replaced under warranty. The second failure occurred at approximately 102,000 miles with no warning. I believe this repeated and sudden failure of a critical drivetrain component presents a significant safety concern because it can leave drivers stranded without warning and results in an unexpected loss of propulsion while operating the vehicle in traffic.

NHTSA ID

11751215

Incident

Jul 3, 2026

While driving my 2021 Ford Mustang Mach-E, the front electric drive unit failed suddenly with no warning signs, warning lights, unusual noises, or any prior indication of a problem. During the failure, multiple fault messages appeared on the instrument cluster, including warnings that disabled adaptive cruise control and indicated the all-wheel-drive system was no longer functioning. The vehicle began to vibrate severely, feeling as though it was driving over rumble strips. As I slowed down, the front of the vehicle became extremely clunky and exhibited abnormal drivetrain behavior. Shortly afterward, the vehicle became undrivable and could no longer be operated under its own power. It had to be towed to a Ford dealership, where I was informed that the front electric drive assembly had failed and required replacement. This is the second time this exact component has failed on the same vehicle. The first front electric drive assembly failed at approximately 33,000 miles and was replaced under warranty. The second failure occurred at approximately 102,000 miles with no warning. I believe this repeated and sudden failure of a critical drivetrain component presents a significant safety concern because it can leave drivers stranded without warning and results in an unexpected loss of propulsion while operating the vehicle in traffic.

NHTSA ID

11751214

Incident

Jul 3, 2026

Vehicle: 2021 Ford Mustang Mach-E VIN: [XXX] Mileage: 56,005 I am filing this complaint to bring to NHTSA's attention a safety concern regarding Ford Motor Company's decision to make the Blue Cruise driver-assistance system available only via a paid subscription beginning January 2027, at a cost of $49.99 per month. Blue Cruise is a hands-free highway driving assistance system — a Level 2 driver-assistance safety technology. The hardware enabling this system was installed in my vehicle at the time of purchase and was represented as a feature of the vehicle. Ford is now moving to disable this safety feature on existing, in-service vehicles unless owners pay an ongoing subscription fee. I respectfully request that NHTSA examine whether a manufacturer's ability to remotely disable or withhold active safety technology on vehicles already in service — technology that was sold as part of the vehicle — raises concerns under federal motor vehicle safety standards. Specifically: 1. Consumers purchased these vehicles with the reasonable expectation that installed safety hardware would remain functional. 2. Ford's decision to monetize this feature post-sale, on vehicles already in service, effectively degrades the safety capability of those vehicles for owners who cannot or will not pay. 3. The precedent this sets — manufacturers using over-the-air software controls to disable safety features for revenue — warrants regulatory attention. I am not alone in this concern. There are thousands of Blue Cruise-equipped Mustang Mach-E, F-150, and Expedition owners facing this same situation. I respectfully ask NHTSA to investigate whether Ford's subscription model for Blue Cruise is consistent with federal vehicle safety obligations, and whether any regulatory guidance is warranted to protect consumers from the post-sale removal of safety technology. [XXX] [XXX] [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ID

11745591

Incident

Jun 22, 2026

The front camera system does not function which causes all forward collision safety features to become unavailable, as well as any cruise control or automatic high beam lights. Seems to be a common issues and is related to faulty fiber optic cables.

NHTSA ID

11744862

Incident

Jun 12, 2024

This is a safety issue. The front collision assist is not working. I have returned the car to the Ford Dealer (Biener Ford) several times but the dangerous issue persists. I'm not the only one. There are many complaints listed on the web and the Ford Mach E forum. Ford needs to recall their EV Ford Mach-E vehicles and fix this dangerous safety issue once and for all.

NHTSA ID

11740320

Incident

Sep 5, 2023

The car gives two messages, "Front Camera Fault Service Required" and "Pre-Collision assist not available." The cruise control does not work, however, the front camera does work. I had the vehicle scan done at the Ford dealer and was told it needs a 7 hour software update, after which it may need cables replaced. I do not understand how software goes bad. I do understand something may have happened to cables but that would not be checked until they had charged me $ 1,400 for a software update. This is a safety issue and, from what I read on the Mach E forum, is not where near unique to my vehicle.

NHTSA ID

11736423

Incident

Apr 20, 2026

There’s a known recall. “2021 Mach-E models produced between Feb 24, 2020, and July 18, 2021, are at risk of the glass panels detaching or leaking.” But my car, a 2021 model, isn’t on the list. I just discovered that my headliner is stained and there’s a leak.

NHTSA ID

11734875

Incident

Apr 21, 2026

Vehicle: 2021 Ford Mustang Mach-E Component: Image Processing Module A (IPMA) / Front Camera / Forward Collision Avoidance System The IPMA and front camera system have failed, disabling Pre-Collision Assist, AEB, forward collision warning, and adaptive cruise control while driving. The vehicle is available for inspection upon request. Warning messages "Front Camera Fault Service Required" and "Pre-Collision Assist Not Available" first appeared August 24, 2022 and have recurred consistently over nearly four years. No accident, physical damage, or obstruction was present at any occurrence. This failure puts safety at risk by silently disabling AEB and forward collision warning during normal driving — systems a driver may depend on in an emergency braking situation with no advance notice they are unavailable. The problem was confirmed by a Ford dealership in February 2026. Their repair order documents: "RAN IPMA SELF TEST AND FOUND DTC SET U3000-49... HARDWARE TEST FAILED... FOUND TSB RELATED REC REPLACE MODULE." The dealer contacted Ford, who authorized 50% off the module replacement only, characterizing it as a "loyal customer discount" rather than a warranty or goodwill repair. I declined to pay for the fix. NHTSA Campaign 11028164 (superseding TSB 25-2156) covers this exact failure. Ford's own TSB acknowledges the defect and the dealer confirmed it applies to my vehicle, yet owners are being quoted up to $8,000 for a known safety system failure. I'm requesting NHTSA investigate whether this warrants a recall. First occurrence: August 24, 2022 (mileage not recorded) Service visit: February 17-18, 2026 at 80,029 miles Current mileage: 83,988 Attachments: photos of both fault messages, dealer invoice

NHTSA ID

11734458

Incident

Aug 24, 2022

The front camera has failed and it is available for inspection upon request. The safety of myself and everyone in my car is at risk when the pre-collision assist is not available due to this components failure. Yes, it is a daily occurrence and the camera never stays on for long. A fix was attempted once by a dealer. The component has not been inspected by either of those parties. Only the dealer whom the car was purchased from. Yes, warning messages pop up every time in the car and in the phone app about the issue. They first appeared before car purchase when the dealer fixed it in early February. Then it resumed again in late February/March.

NHTSA ID

11728154

Incident

Feb 26, 2026

An error message intermittently pops up on my vehicle that says, "Front Camera Fault", causing collision assistance and adaptive cruise control to suddenly stop working. This is a major safety issue, as a failure of adaptive cruise control while under operation may lead to a risk of an accident. Ford is aware of this issue and has issued TSB 23-2155, but they are treating it like a standard repair and not covering vehicles out of warranty. This should be a safety recall. See here for many others with the same issue: [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ID

11726068

Incident

Mar 21, 2026

Vehicle experienced immediate loss of motive power while in motion at 45 mph after "Stop Safely Now" alert. This is a repeat power failure. The vehicle was in service for 75+ days (Dec-Feb) for this exact defect. The Ford service center said they replaced the “battery controller” yet the issue recurred. The car previously flagged this alert while in motion 2 times prior (one on the highway going ~65mph and on another major street going roughly ~45 mph). As a Ford Reacquired Vehicle (Buyback), the failure to resolve this catastrophic electrical fault creates an extreme risk of crash and entrapment in traffic, putting myself, my family and the drivers in vicinity at significant safety risk. The car is currently at a different Ford Service Center. They have been able to reproduce the issue and are currently running diagnostics to identify a resolution.

NHTSA ID

11719257

Incident

Feb 19, 2026

After recall-related software updates were performed on my 2021 Ford Mustang Mach-E, the vehicle began experiencing repeated electrical and climate control failures. The heating and defrost system stopped working, leaving the vehicle without heat and causing the windows to fog, which reduces visibility in cold weather and creates unsafe driving conditions. The vehicle has been taken to multiple authorized Ford dealerships for inspection and repair; however, the problem returned immediately after the repair. The issue was reproduced and confirmed by a second dealer. A required part is currently on back order until the end of Feburary, leaving the vehicle unrepaired for an extended period. In addition, the vehicle experienced 12-volt battery failure and slow charging after the last recall update. These issues were not present prior to the recall. There were no warning lights before the failures occurred. During severe winter weather conditions in Pennsylvania, the lack of heat and defrost made it extremely difficult and unsafe to operate the vehicle. Because of reduced visibility and freezing interior temperatures, the vehicle could not be safely driven and, due to frigid temperatures, has remained parked. I am still making monthly payments on a vehicle that cannot be reliably or safely used.

NHTSA ID

11716499

Incident

Dec 3, 2025

On Saturday, [XXX], while driving under normal conditions, the vehicle experienced a sudden and complete loss of propulsion without warning. There was no reduced-power mode, no dashboard alert, and no mobile app notification prior to shutdown. The vehicle was subsequently inspected by a Ford dealership. The technician identified an intermittent software-related condition consistent with Ford TSB 26-2005, which documents a fault capable of draining the 12-volt electrical system during vehicle operation. The technician stated the 12-volt battery is not believed to be the root cause. The loss of propulsion occurred while the vehicle was in motion and resulted in a full shutdown. The condition was not preceded by any driver warning or controlled degradation. No driver warning was received after shutdown. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ID

11715476

Incident

Jan 24, 2026

I am requesting immediate escalation regarding my 2021 Ford Mustang Mach-E (VIN: [XXX] ), which is currently undrivable due to being stuck in “Power Accessory Active” mode. The vehicle will not enter Drive. The dealer has diagnosed DCEM / high-voltage system-related faults and stated that recall repairs cannot be completed unless I first pay approximately $3,000 to repair the “main battery.” My concern is that the symptoms and failure mode exactly match the known High-Voltage Battery Junction Box / DCEM defect described in Ford Safety Recall 23S56, including: •Vehicle unable to drive •High-voltage system refusing to close contactors •Vehicle remaining in accessory power mode •Safety-related loss of motive power While my VIN may not be currently listed as eligible for these recalls, my vehicle is exhibiting identical symptoms and failure modes associated with the following Ford safety recalls: •HV Battery Junction Box / DCEM defect (Recall 23S56) •Powertrain / Software Update (Recall 22S29) •12-Volt Battery / Door Latch Entrapment Risk (Recall 25S65) It is important to note that other Mustang Mach-E owners have reported the same recall-related failures even when their VINs were not listed for these recalls. These failures involve contactor issues, loss of motive power, and vehicles being stuck in accessory mode — identical to the symptoms my vehicle is experiencing. Given that my vehicle is experiencing a safety-related loss of motive power, Given the safety implications and known defect history, I request that this matter be reviewed. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ID

11712665

Incident

Dec 17, 2025

The spot welds connecting the door at the hinges have failed. The metal is shearing, over 10mm, at multiple of the world locations.

NHTSA ID

11710605

Incident

Sep 12, 2025

The backup camera and 360 view stopped working, and the reverse break assist is not available when placing the vehicle in reverse. [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ID

11706917

Incident

Nov 1, 2025

Ford is unable to perform two safety recalls. The first is over the windshield which can lead to its failure while driving. The second is for the glass roof which can cause a failure while driving. The local dealer in Springfield Illinois says they can not do the work and can not identify anyone locally who will do the work. The dealership with the Ford autobody repair shop in the next town over in taylorville Illinois says they can not do the work. I called Ford customer service and they just sent me to the taylorville shop that said they can't do the work. The windshield or roof can come off and no one will do the repair including Fords own autobody shop. Help.

NHTSA ID

11706695

Incident

Dec 18, 2025

While charging my electric vehicle with this Enel X JuiceBox 40 charger, a burning plastic smell was noted. Upon examining the Enel X charger plug that was attached to my home's NEMA 14-50, it appeared partially melted and very to touch. Using a towel, the plug was removed and a small fire and sparks flew out of the NEMA outlet. The right half of the outlet's plastic shell was melted and the inner metal was charred. Same charring and melting was noted on the corresponding side of the Enel X plug. I turned the circuit breaker off and the sparks and fire subsided. Model of JuiceBox: 2JBO401RNA-PJWX-300

NHTSA ID

11705449

Incident

Dec 16, 2025

I bought this car in August of 2024. It started having issues with the door lock in September and in December I decided to sell it back to the dealer but was in a car accident on the way to the dealership. Unfortunately the door jamming issue caused repair problems and the auto repair shop could not fix the door issues. I lost the car to the repair shop in a lien sale due to the cost of repair which was over $20,000. In August of 2025 Ford issued a recall which allowed the auto repair shop was able to fix the car and sell it to a dealership. I have contacted Ford several times in relation to the issues with the car and how they caused me to loose the car, but they have not responded despite the promise to do so in 7-15 business days. Loosing this car has caused deep stresses in my life. I have lost several business clients because I'm no longer able to get around. I have had my life impacted to the point of having to relocate. I bought the car outright paying $45,000. Ford has refused to do anything to compensate for my loss.

NHTSA ID

11701857

Incident

Dec 15, 2024

The car would intermittently give an error saying pre-collision assist not available and now this error is permanent. There is a technical service bulletin for it 23-2155 Lots of people have been complaining about this in the mach e forum https://www.macheforum.com/site/threads/front-camera-fault-pre-collision-assist-not-available-errors.18710/page-69#post-1026803 This causes people to drop out from the automatic driving bluecruise without notice and adaptive cruise control becomes unusable.

NHTSA ID

11695140

Incident

Oct 21, 2025

The contact owns a 2021 Ford Mustang Mach-E. The contact stated that while driving approximately 20 - 25 MPH in the rain at night, the brake pedal was bouncing up and down. The contact stated that the doors locked and failed to open. Additionally, the vehicle stalled. The contact stated that the hazard lights were inoperable. They stated that one of the passenger’s side tire warning lights was illuminated. The contact stated that the battery was at 98 percent and that several unknown warning lights were illuminated. The vehicle was taken to the local dealer to be repaired under NHTSA Campaign Number: 22V333000 (Vehicle Speed Control, Power Train) prior to the failure. The contact called Roadside Assistance, but Roadside Assistance was unable to assist. The contact stated that a Police Officer arrived on the scene to assist. The vehicle was towed to the local dealer after several hours. The vehicle was not diagnosed or repaired. The manufacturer was contacted but no assistance was provided. The failure mileage was approximately 40,400.

NHTSA ID

11694472

Incident

Oct 17, 2025

Mileage

40,400 mi