Owner-reported complaints naming the fuel system system, filed with NHTSA
Data refreshed
Reports naming fuel storage or delivery — tanks, pumps, lines, injectors and fuel leaks. Every record below is an owner-reported complaint about the 2002 GMC Envoy Xl submitted to NHTSA — not a confirmed defect, not a recall and not a manufacturer bulletin. 15 reports on file name it.
Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.
Shown in the owner’s own words, exactly as filed
VEHICLE HAS A INLET FUEL LEAK, A KNOWN ISSUE ON THE GMC ENVOY XL 4X4, BUT HAS PUT A 150,000 MILE CAP ON THE RECALL WHICH I FIND NEGLIGENT AS THE ISSUE STILL EXIST REGARDLESS OF MILEAGE, JUST SEEMS LIKE A WAY TO WORM OUT OF RESPONSIBILITY.
I NOTICED A PUDDLE OF LIQUID UNDER VEHICLE . SO I CHECKED IT OUT AND FOUND TO BE GAS LOOKED UNDER VEHICLE AND SEEN THAT THE GAS TANK HAD STAINS ALL OVER IT LEADING FROM THE FILLER NECK WHERE IT ATTACHES TO THE FUEL TANK. *TR
STRONG FUEL SMELL IN MY DRIVEWAY, CAR LEAKING GAS AROUND THE TANK AREA. *TR
2002 GMC ENVOY XL HAS A PROBLEM WHEN I FILL WITH GAS IT DOES NOT SHUT OFF BUT OVERFLOWS ONTO THE PAVEMENT UNDERNEATH THE CAR. *TR
I OWN A 2003 GMC ENVOY XLT SERVICE ENGINE LIGHT IS ON RETURNED THE VEHICLE TO THE DEALER AND WAS TOLD THIS IS A CRACKED FUEL TANK. DEALER SHOWED ME WHERE THE FUEL WAS LEAKING IT WAS LEAKING ON A WELD THAT ATTACHES THE FILLER HOSE TO THE FUEL TANK. THIS CERTAINLY ISN'T A WEARABLE PART AND IT DOESN'T RECEIVE MUCH CORROSION DUE TO BEING A FLORIDA CAR. THERE ARE MANY FORUMS ON THE INTERNET AND MANY VEHICLE OWNERS THAT HAVE THE SAME PROBLEM. I WOULD THINK THAT A FUEL LEAK MAY LEAD TO EXTREMELY HAZARDOUS SITUATION FOR ALL MOTOR VEHICLE OWNERS. I UNDERSTAND AN INVESTIGATION HAS BEEN RAISED AND CLOSED. IT IS UNFAIR THAT GM MANUFACTURES A FUEL TANK THAT COULD BE A RISK TO ITS CONSUMERS. THIS CASE NEEDS TO BE REVISITED AND REOPENED. *TR
IN LATE 2007, MY WIFE BEGAN SMELLING A STRONG ODOR OF GASOLINE COMING FROM IN AND AROUND OUR 2002 GMC ENVOY XL. THE ODOR IS PRESENT WHETHER THE TANK IS FULL OR NEAR EMPTY. *TR
NOTICED THE SMELL OF GAS. TOOK TO DEALER WHERE PURCHASED. FUEL PUMP WAS FINE, BUT THE TUBE HAD CORRODED. EXTENDED WARRANTY PURCHASED WILL NOT COVER THIS BECAUSE THE PUMP DID NOT FAIL. FAILURE WAS DUE TO CORROSION. THE VEHICLE IS ONLY 5 YEARS OLD! COST ESTIMATE IS OVER $600.00 TO FIX. HAVE TO REPLACE PUMP ALSO. WHEN REPAIRED, I WILL ASK FOR THE OLD PART. THIS VEHICLE HAS BEEN IN SHOP FOR REPAIRS MORE THAN ANY ONE I HAVE EVER OWNED. (FRONT WHEEL BEARINGS WENT AT ABOUT THE SAME TIME, BUT WERE COVERED UNDER THE WARRANTY). *JB
I HAVE A 2002 GMC ENVOY THAT IS APPARENTLY EXPERIENCING A FUEL VAPOR LEAK. I TOOK IT OT THE DEALER (FRANKLIN GMC, TN) AND HE SAID IT WAS A KNOWN PROBLEM; HOWEVER, GMC HAS NOT INITIATED A RECALL PROCESS. HE TOLD ME I COULD EITHER WAIT FOR A POSSIBLE RECALL OR PAY $900 TO HAVE THE ENTIRE FUEL TANK REPLACED. I ASKED HIM IF HE FELT ANY REPSONSIBILITY FOR NOTIFYING ME OF THE KNOWN PROBLEM AND NOT REMEDYING THE SOLUTION AND HE SAID IT WOULD HAVE TO BE APPROVED BY GMC. OBVIOUSLY GMC HAS TAKEN THE POSITION THAT THEY WOULD RATHER PAY LAWSUITS INSTEAD OF CORRECTING THE PROBLEM. SAD! *TR
TL* THE CONTACT OWNS A 2002 GMC ENVOY XL. THE CHECK ENGINE INDICATOR LIGHT ILLUMINATED AND THE VEHICLE SMELLED OF GASOLINE. THE DEALER DIAGNOSED THE FAILURE AS NEEDING A NEW FUEL TANK ON THREE SEPARATE OCCASIONS. THE CONTACT HAS THE REPAIR INVOICES. THE CURRENT MILEAGE IS 150,000, AND FAILURE MILEAGE WAS 16,742.*AK
2002 GMC ENVOY HAS AN SES ILLUMINATION ACCOMPANIED BY A FUEL ODOR, AND/OR A FEW DROPS OF FUEL ON THE GROUND WHEN REFUELING THE VEHICLE. THIS IS CAUSED BY A FRACTURE OF A WELD ON THE FUEL TANK INLET CHECK VALVE (ICV). THE ICV IS LOCATED ABOVE THE FULL FUEL LEVEL. A FRACTURE IN THIS AREA MAY ALLOW FUEL VAPORS TO PASS THROUGH AND ALLOW DROPLETS OF FUEL TO ACCUMULATE ON THE SIDE OF THE FUEL TANK AS IT PASSES OVER THE FRACTURE DURING REFUELING. *JB
LEAKY GAS TANK ON 2002 GMC ENVOY XL. 48,000 MILES. FOUND BY DEALERSHIP, RECOMMENDED NEW GAS TANK FOR APPROX $500 PLUS LABOR. SERVICE BULLETIN EXISTS TO LOOK FOR CRACK IN TANK PER SERVICE DEPARTMENT. *NM
THE GMC ENVOY XLT EXPERIENCES A TOTAL LOSS OF POWER UNDER THE FOLLOWING CONDITIONS. WHEN THE FUEL TANK IS AT OR BELOW A QUARTER TANK OF GAS THE VEHICLE'S GAS PEDAL BECOMES INOPERABLE AND THE FORWARD VELOCITY IS LOST TO THE POINT THAT IF YOU ARE IN TRAFFIC THE VEHICLE WILL IMMEDIATELY BEGAN TO SLOW DOWN RESULTING IN A COMPLETELY HAZARDOUS AND UNSAFE SITUATION WHERE THE DRIVER HAS NO CHOICE BUT TO PULL OFF THE ROAD OR BE REAR ENDED. THIS HAS OCCURRED ON SEVERAL OCCASIONS ONLY UNDER THE CONDITIONS DESCRIBED ABOVE. SEVERAL GMC ENVOY XLT OWNERS HAVE EXPRESSED THE SAME SITUATION. THIS HAS BEEN REPORTED TO GMC IN 2005 BUT IT APPEARS THAT THE PROBLEM IS KNOWN BUT THEY AREN'T ACCEPTING RESPONSIBILITY AS A MANUFACTURER. POSSIBLE INDICATORS MAY BE THE FUEL PUMP ASSEMBLY, FUEL PRESSURE REGULATOR, OR SOME OTHER VITAL COMPONET IN THE FUEL SYSTEM. I AM SURE GM KNOWS. *JB
WHILE FILLING MY 2002 GMC ENVOY, I OBSERVED GAS POURING OUT OF THE TOP OF THE TANK DOWN OVER THE REAR AXLE AND NEAR THE TAILPIPE. I NOTICED THIS BECAUSE THE GAS PUMP DID NOT SHUT OFF AT THE APPROPRIATE LEVEL. I CALLED GMC AND REPORTED IT. THEY WERE AT FIRST RELUCTANT TO GIVE ME THE AGENCY I COULD REPORT THIS TOO BUT AFTER SPEAKING TO A SUPERVISOR THEY FINALLY TOLD ME I COULD REPORT THE POSSIBLE DEFECT TO THE NHTSA. *NM
CHECK ENGINE LIGHT TURNED ON. TAKEN VEHICLE TO THE DEALER AND FOUND THAT THERE WAS A LEAK AT THE FILLER PIPE AND FUEL TANK WHICH ALLOWED FUEL AND VAPORS TO ESCAPE. DEALER WILL REPAIR FOR $900.00. *AK *NM
FUEL TANK HAS LEAK AT JOINT WHERE FILLER PIPE AND TANK JOIN ALLOWING FUEL AND VAPORS TO ESCAPE. SMELLED FUEL INSIDE THE GARAGE. THE DEALER SERVICE MANAGER SAID THAT THE WELD HAD FAILED, THAT IT IS A MANUFACTURING DEFECT, AND THAT THEY HAD REPLACED THE FUEL TANK FOR 2 OTHER ENVOYS FOR THE SAME FAILURE. THERE WAS NO PRIOR REPAIR ON THE FUEL TANK OR REMOVAL OF THE FUEL TANK.
Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.
Categories with enough reports to have a page of their own
Data on this page last refreshed .