2021 GMC Sierra 1500 Steering Problems

Vehicle: 2021 GMC Sierra SLT | VIN: [XXX] Dealership: Carl Black GMC Roswell, GA (11225 Alpharetta Hwy, 30076) | Invoice #[XXX] | Service Date: [XXX] Paragraph 1 – Suspension Hazard: Dealership diagnosed a worn left upper ball joint (popping sound on left turns) and installed Rough Country aftermarket upper control arms on my stock-height Sierra SLT. These arms are designed for lifted suspension and alter factory caster/camber geometry, placing extreme stress on ball joints. This can cause sudden ball joint separation, wheel collapse, and total loss of steering control at speed. The dealership admitted on the invoice they "could not find branding" on original parts and chose non-OEM lift components without my consent or any safety disclosure. Paragraph 2 – Brake Failure & No Safety Warning: The same service included a full front/rear brake job (pads + resurfaced rotors) using their certified technicians and parts. After pickup, the brakes failed to operate properly. When I returned, the service manager refused to correct their own workmanship and instead quoted $1,900 to repair the very brakes they just serviced. Most critically, at vehicle pickup they issued no written or verbal safety warning—no "do not drive" instruction—despite the brakes being knowingly compromised, endangering me and the public. Paragraph 3 – Requested Action: The service manager was unprofessional, condescending, and refused accountability. I request an immediate NHTSA investigation into Carl Black GMC's unauthorized use of lift-kit suspension parts on stock vehicles, failure to warranty their own brake service, and reckless omission of safety warnings at delivery. This dealership pattern poses an imminent public risk. Please escalate. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ID

11752674

Incident

Jul 16, 2026

power steering locked up while driving. has been inspected and repaired by manufacturer. recall.

NHTSA ID

11741190

Incident

Mar 29, 2026

power steering locked up while driving. multiple dash lights turned on, on its own after the issue, 4wd, emergency brake, abs, and other ones im not sure what they are. took it to the dealership for a recall and told them the issue that happened.

NHTSA ID

11741189

Incident

Mar 29, 2026

My truck will not start when I press the push-button ignition. After waiting a few seconds and trying multiple times, it typically starts on the third attempt. Additionally, it will not restart after the auto stop feature activates at stop signs or traffic lights. This is very concerning, especially when pulling into oncoming traffic, as I’m worried the truck could shut off while I’m crossing. I have already had the battery, starter, and alternator checked, and all components tested fine. However, the issue is still occurring. There are also no warning lights or messages displayed on the dashboard.

NHTSA ID

11739883

Incident

May 24, 2026

Shift to park dings continuously and vehicle won’t turn off draining battery leaving doors unlocked. Don’t want to force into park and break anything more.

NHTSA ID

11739515

Incident

Dec 31, 1969

Driving down road and had total loss of power steering and yes it is available for inspection. Almost drove it off the road due to loss of steering Yes, it happened to be a failed main grounding strap that created the issue. The dealership made the repair. No, it was inspected and repaired by the dealership Yes, started with loss of power steering, then truck died and these codes popped up: Low fuel code, but tank was full; trailer brake system code; side detection code and esc traction control code.

NHTSA ID

11733610

Incident

Apr 19, 2026

Loss of steering, erratic steering control. Steering locks up

NHTSA ID

11727719

Incident

Mar 20, 2026

The contact owns a 2021 GMC Sierra 1500. The contact stated that while driving 5 MPH, the vehicle lost proper steering ability, and the steering wheel became loose and spun around in a circle. The air bag message was later displayed on the instrument panel. Upon inspecting the vehicle, the contact discovered that the bolt connecting the steering shaft was missing. Due to the failure, the vehicle was towed to a dealer, where the cause of the failure was confirmed. The contact was then informed that there were no recalls or warranties on the vehicle. The manufacturer was notified several times about the failure and agreed that the part should never fail. However, the manufacturer then stated that the owner of the vehicle was responsible for the repair. The vehicle remained with the dealer unrepaired. The failure mileage was approximately 80,000.

NHTSA ID

11710896

Incident

Jan 2, 2026

Mileage

80,000 mi

The power steering on the truck would quit working at times. I made an appointment with a local dealership to have it checked out. I was told the steering rack was binding and would need to be replaced. I was also told there was a two to four week backorder on the parts. As I am trying to back out of my garage to take it to the dealer the steering totally locked up. I called a wrecker to take the truck to the dealer the next day. When the wrecker operator started to load the truck, at first the steering wheel wouldn't turn . Then it broke lose and worked fine. Imagine if I were driving when this on again off again power steering would quit working!! I should also say this truck only has fifty-seven thousand miles on it. Since there is a backorder on these parts it tells me that I'm not the only one that is having this problem. In my opinion this is a very dangerous safety problem and should be a national recall. Thank you

NHTSA ID

11706098

Incident

Dec 15, 2025

My power steering completely failed. This is a safety issue and could have caused bodily harm. I have looked on line and I am not the only one with this issue, and as I investigated it shows that this issue was recall situation on earlier models. My truck is currently in the shop and looks like it will cost $5,000 to do the full repair.

NHTSA ID

11686554

Incident

Sep 4, 2025

While traveling on the interstate the vehicle lost all propulsion and started to rapidly decelerate. Shortly after propulsion was lost the engine turned off completely affecting the steering and braking of the vehicle. The vehicle was towed to the GMC dealership that we purchased it from. repairs have not begun so I assume it would be available for inspection. We were traveling on a three lane interstate up a grade at 80 MPH. Had I not been able to safely get the vehicle stopped and out of traffic or had we lost control going down a grade we would not have been able to stop the vehicle and there would've potentially been a catastrophic accident most likely resulting in injury or death. No the dealership has not diagnosed the failure physically. The service writer did suggest that it sounds like the failure reported from the recall not being addressed. I did contact the dealer about the recall on Saturday May6th. At which time I was informed there was not a solution for the vehicle for my vehicle at that time. There were no warning prior to the incident. After the engine stopped operating there was a warning produced on the instrument panel that read "Engine Oil Hot" and the instrument panel no longer registered any oil pressure.

NHTSA ID

11664233

Incident

May 31, 2025

I was driving approximately 25-30 mph coming over an overpass moving into the right hand lane when my truck right front end failed. The steering and brakes locked up for approximately 50’ until I hit the curb for the sidewalk and stopped. I safely exited the vehicle checked the left side of my truck for damage and didn’t find anything. I walked around the back of my truck and came to the passenger side where I found my right front wheel and tire completely broken away from both upper and lower control arms, the ball joint broke and failed as well as the brake line. If I was driving on the highway at 65-75 this catastrophic failure could have resulted in a fatal collision. The night before my [XXX] daughter and I returned from her outdoor Ed trip in Sausalito and we drove an hour home to Napa on [XXX] and [XXX] . I thank god this didn’t happen with her in the car on the highway. I had my truck towed to Jimmy Vasser Chevy in Napa so I can see if the extended warranty will cover the repairs since it was an obvious catastrophic failure of the whole right front end. It’s still sitting there. The extended warranty inspector came Friday to take pictures of the damage INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ID

11658813

Incident

Apr 26, 2025

The contact owns a 2021 GMC Sierra 1500. The contact stated while driving at slow speeds and accelerating out of the neighborhood, the vehicle experienced a loss of automotive power, with the check engine and EPS warning lights illuminated. The contact was able to drive the vehicle back to the residence. The vehicle was then towed to a local dealer where the vehicle was diagnosed, and the contact was informed that the engine had failed and needed to be replaced. The vehicle was repaired. The manufacturer was notified of the failure. The approximate failure mileage was 103,000.

NHTSA ID

11658150

Incident

Apr 16, 2025

Mileage

103,000 mi

Front upper control arm ball joint separated from socket.

NHTSA ID

11628321

Incident

Nov 13, 2024

Getting shift to park safety warning, car is in park, and cannot move at all, Cannot start because vehicle does not believe it is in park. Have been stranded multiple times on this error.

NHTSA ID

11618222

Incident

Sep 27, 2024

I just purchased a used 2021 GMC Sierra after having for a month the SERVICE POWER STEERING came on, I took it in for service and was told the part is on back order. Not to worried if the dealership and GM sold it to me that way. I am going to drive it and hope and pray that nothing bad happens. And if it does i will be getting a Lawyer.

NHTSA ID

11591379

Incident

May 1, 2024

Alignment Cam Guide Pins sheared off while driving on highway. Alignment went all over the place and car was drifting side to side. Also, steering wheel spun a quarter turn while car was not turning but still driving on highway. Almost caused me to crash. GMC does not want to acknowledge the issue or allow me to file a warranty claim. Car could not be driven to GM dealership safely and had to be repaired at closest shop

NHTSA ID

11576218

Incident

Mar 7, 2024

"Service parking brake" "steering assist is reduced drive with care" comments showed up on screen…check engine light on, truck shaking/ vibrating completely as if wanting to turn off this all happened while driving on the road and randomly happened…please help..very Concerned

NHTSA ID

11552483

Incident

Oct 29, 2023

Steering wheel stopped working

NHTSA ID

11521259

Incident

May 9, 2023

My 2021 gmc Sierra displays (service power steering with care) the truck only has 13184 miles and barely moves.

NHTSA ID

11518476

Incident

Apr 22, 2023

While driving home from work around 6 am, my car had multiple warning lights and warning messages come up all of a sudden. Immediately after that I lost my power brakes and steering and was not able to control my car at 40 mph. I was lucky the light I passed was green and there was no other traffic. I was able to bring my truck to a stop after more than a quarter mile by putting all my weight on the brake pedal. The truck was towed to the dealer and has been there ever since.

NHTSA ID

11517110

Incident

Mar 31, 2023

I parked my car for about an hour after driving for months with absolutely no issues or warnings. When I started my car and went to pull off the steering wheel locked up and I couldn’t turn it. A message appeared on the screen saying: Service power steering drive with care, and an esc message. A light also appeared. I turned the car off and let it sit for an hour. When I started it again everything worked fine. My dealership won't do anything because the warning codes went away, and the vehicle is not included in any current recalls. When looking up this problem it appears there are multiple recalls for the exact same issue on other 2021 Yukon and Tahoe models but not the Sierra. Though I see many forums and threads complaining about the same problem on the Sierra's. Since it is the same vehicle and systems as the Yukon, shouldn't the same recall apply?

NHTSA ID

11516713

Incident

Apr 12, 2023

I start my car and I went to pull off and the steering wheel locked up and I couldn’t turn it and it was just stuck going to sit power steering EC something. And then came home parked the car few days later try driving it and then the ABS brake light came on warning me not to go over 65 mph and my brakes pad feel really loose now.

NHTSA ID

11485362

Incident

Sep 19, 2022

I took my truck to the dealership because of my issues and they said they had many trucks going in with the same issue but there was no fix to it. The issues Popping Noise Heard On Hard Turns and/or Going Over Speed Bumps, Creaking Noise While Turning Wheel Left and/or Right, Clicking Noise Heard On Slow Sharp Turns.Also when you go over a bump the truck makes a spring loud noise to the point that the whole truck bounces. shifter is also very hard when you try to change gears.

NHTSA ID

11479962

Incident

Jun 1, 2022

As I was driving out of the parking lot my power steering suddenly was lost. A message appeared on the screen saying: Service Power Steering Drive with care and an esc message. A light also appeared. I was not able to steer at all and had to turn the truck off. I tried multiple times. After 5 minutes the message cleared as did the light. A day later (today- 4/19)the same thing happened in the parking lot. THIS IS VERY DANGEROUS. I have an appointment with the dealer. When looking up this problem it appears there are multiple recalls on other 2021 models but not the Sierra though I see many complaints about the same problem on the Sierra's. This is not safe and needs to be looked into further.

NHTSA ID

11461412

Incident

Apr 19, 2022