2001 GMC Sierra 2500 Engine Problems

FUEL IS DUMPING INTO INJECTORS. 2001 GMC SIERRA 2500 DIESEL. ONLY HAS 135,000 MILES!! ENGINE BOGGS DOWN WHEN CLIMBING HILL, BRIDGE, OR TOWING.

NHTSA ID

11389800

Incident

Oct 10, 2020

Mileage

135,000 mi

TL* THE CONTACT OWNS A 2001 GMC SIERRA 2500. WHILE DRIVING VARIOUS SPEEDS, THE ENGINE SUDDENLY LOST COMPRESSION AND THE VEHICLE FAILED TO ACCELERATE PROPERLY. THE VEHICLE WAS TAKEN TO COURTESY CADILLAC (1345 EVANGELINE THRUWAY, BROUSSARD, LA) WHERE IT WAS DIAGNOSED THAT ONE OR MORE FUEL INJECTORS WERE FAULTY AND REMAINED OPEN. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED AND DID NOT ASSIST. THE CONTACT INDICATED THAT ALL EIGHT FUEL INJECTORS WERE PREVIOUSLY REPLACED APPROXIMATELY FIVE YEARS; HOWEVER, BUT THE FAILURE RECENTLY RECURRED. THE FAILURE MILEAGE WAS 200,000.

NHTSA ID

11081089

Incident

Mar 10, 2018

Mileage

200,000 mi

VEHICLE STALLS AND SHUTS OFF WHILE DRIVING AND IDLE. SOMETIMES IT STARTS BACK UP IMMEDIATELY, OTHER TIMES IT WILL JUST CRANK OVER BUT WILL NOT START. AFTER LETTING IT SIT SOMETIMES 5 TO 20 MINUTES AT A TIME IT WILL THEN START BACK UP. ALL RESEARCH AND ISSUES WITH THE VEHICLE INDICATE A MANUFACTURER RECALL OF A CRANKSHAFT POSITION SENSOR. THE VEHICLE WILL STALL OR SHUT OFF AT RANDOM WHETHER IT'S IN MOTION DOWN THE HIGHWAY IN THE MIDDLE OF A INTERSECTION OR AT A STOP SIGN . I HAVE ALMOST BEEN T-BONES DUE TO THE VEHICLE STALLING IN THE MIDDLE OF THE INTERSECTION AND I HAVE ALSO HAD TO REPLACE MY DRIVERS MIRROR DUE TO THE VEHICLE STALLING ON THE INTERSTATE AND NEARLY BEING HIT BY ANOTHER VEHICLE. *TR

NHTSA ID

10930162

Incident

Oct 5, 2016

Mileage

98,000 mi

EXHAUST MANIFOLD LEAK DUE TO BROKEN EXHAUST MANIFOLD BOLT. I AM THE ORIGINAL OWNER OF THE VEHICLE. THE VEHICLE HAS BEEN REGULARLY AND PROPERLY MAINTAINED. I UNDERSTAND THIS IS A COMMON PROBLEM FOR THIS GM VEHICLE DUE TO DEFECTIVE PARTS. I PURCHASED THIS VEHICLE NEW FROM A LOCAL GMC DEALER. *TR

NHTSA ID

10630221

Incident

Jan 1, 2014

Mileage

130,000 mi

TRUCK JUST SHUTS DOWN WHILE DRIVING, COAST TO SAFEST PULL OVER, TURN KEY OFF, SIT AND WAIT A MINUTE, SOMETIMES LONGER, TRY TO START ENGINE, USUALLY STARTS, SOMETIMES LONGER WAITS. OTHER THEN THE APPARENT SAFETY POSSIBILITIES, DIDN'T THINK MUCH ABOUT IT. WELL, THIS WOULD HAPPEN EVERY ONCE & AWHILE. FOR OVER A YEAR NOW, LAST 3 MONTHS WITH INCREASING OCCURRENCES. TRUCK OUT OF WARRANTY, SO I HAVE IT SERVICED LOCALLY, DAVE COTE AUTOMOTIVE, A GM TRAINED TECHNICIAN WITH 30 YEARS EXPERIENCE, PROBLEM DIAGNOSED, CRANKSHAFT POSITION SENSOR AT THE REAR OF THE 8.1 L ENGINE. TECHNICIAN COTE HAS EXTREMELY DIFFICULT TIME REMOVING SENSOR, AT THIS WRITING STILL NO WORD. COTE GOES ON LINE TO SEEK ONLINE HELP FROM OTHER TECH'S AND DISCOVERS A SUPPOSED RECALL FOR MY YEAR AND MODEL TRUCK, THAT I NEVER RECEIVED. I ENQUIRE AT THE LOCAL DEALER VENDEHTTI MOTORS, FRANKLIN, MA ABOUT IT AFTER SUPPLYING THE VIN NUMBER, THEY TELL ME THAT MY VIN IS NOT INCLUDED WITH THE RECALL? I SAY TO THEM THAT "HOW CAN THAT BE WHEN IT IS DOING WHAT THE RECALL WAS FOR" & THEY SAID "THE PROBLEM WAS FIXED AT THE FACTORY BEFORE MY TRUCK WAS MANUFACTURED"? SO I AM ASKING WHY I WILL HAVE TO PAY POSSIBLY THOUSANDS OF DOLLARS THAT I CAN NOT AFFORD AT PRESENT, WHEN OBVIOUSLY THE PROBLEM WAS NEVER FIXED TO BEGIN WITH. SENSOR IN BAD LOCATION. I OWN A SMALL LANDSCAPE MAINTENANCE CO. MOSTLY MOWING & SEASONAL CLEAN-UPS, I WAS EXPECTING TO USE THIS TRUCK TILL I HAD TO RETIRE. IT IS MY SOLE MEANS TO OPERATE PLOWING & LANDSCAPING BUSINESS. I CAN NOT AFFORD A NEW TRUCK. THIS TRUCK HAS LESS THEN 45,000 MILES ON IT, IT IS USED LOCALLY ONLY, LESS THEN 4,000 MI. A YEAR, I HAVE MAINTAINED IT WELL. NO MAJOR ACCIDENTS, LITTLE PLOWING DENTS. CAN SOMEBODY PLEASE HELP ME WITH THIS PROBLEM. IT SEEMS THAT GM IS NOT ONLY HAVING RECENT DIFFICULTIES WITH ITS VEHICLES BUT HAS BEEN HIDING ALLOT FROM THE PUBLIC & GOVERNMENT! *TR

NHTSA ID

10604539

Incident

Jun 1, 2013

Mileage

39,000 mi

ENGINE STALLED AFTER PULLING OUT ONTO HIGHWAY THEN RESTARTED, ENGINE STALLED AT STOP LIGHT RESTARTED 5 MINUTES LATER , ENGINE STALLED IMMEDIATELY AFTER STARTING THEN STARTED TWO MINUTES LATER. GM RECALL #06083 CRANKSHAFT POSITION SENSOR FROM DEC. 11, 2007 NEEDS TO BE EXPANDED TO INCLUDE MORE OR MAYBE ALL 2001S WITH 8.1L V8 NOT JUST THE VIN # THAT ARE LISTED. *TR

NHTSA ID

10548192

Incident

Oct 8, 2013

Mileage

70,300 mi

TL* THE CONTACT OWNS A 2001 GMC SIERRA 2500 HD. THE CONTACT STATED THAT THE CRANKSHAFT POSITION SENSOR FAILED AND WAS REPLACED. SIX YEARS LATER, THE CONTACT LOCATED A RECALL FOR THE FAILURE UNDER NHTSA CAMPAIGN ID NUMBER: 07V521000 (ENGINE AND ENGINE COOLING). THE DEALER WAS CONTACTED BUT INFORMED HIM THAT HIS VIN WAS NOT INCLUDED IN THE RECALL AND HE COULD NOT BE REIMBURSED FOR THE REPAIRS. THE CONTACT CONFIRMED THAT THE VEHICLE WAS NOT INCLUDED IN THE RECALL. THE FAILURE MILEAGE WAS 60,358 AND THE CURRENT MILEAGE WAS 82,000. UPDATED 01/30/13*LJ THE CONSUMER STATED THAT THE ENGINEWOULD TURN OFF UNEXPECTEDLY, IT WOULD RESTART AFTER A PERIOD OF TIME. IT HAS SHUT OFF AT FREEWAY SPEED, CITY TRAFFIC, AND WHILE PARKING. UPDATED 1/31/2013 *JS

NHTSA ID

10490574

Incident

Sep 7, 2006

Mileage

60,358 mi

THE ENGINE DIED ON ME IN A PARKING LOT AND WOULDN'T RESTART FOR ABOUT 15-20 MINUTES. THE SECOND INCIDENCE WAS THE SAME. THE THIRD INCIDENT, IT STOPPED ON ME AS I WAS COMING OFF AN EXIT TO GET ON THE HIGHWAY. I HAD JUST REACHED 50 MPH WHEN IT CUT OUT. IT WOULD NOT RESTART FOR 15-20 MINUTES. THE NEXT AND FINAL EVENT BEFORE REACHING A RESOLUTION TO THE PROBLEM...THE TRUCK CUT OUT AS I WAS ON AN EXTREMELY DANGEROUS AND BUSY SECTION OF HIGHWAY DOING 60 MPH. I THANK GOD IT WAS A STRAIGHT STRETCH OR SOMETHING FATAL COULD HAVE OCCURED. IN BETWEEN EACH OF THESE EVENTS, I TOOK THE TRUCK TO THE MECHANIC AND TRIED DIFFERENT OXYGEN SENSORS AND OTHER REPAIRS THAT I WAS TOLD WASN'T A PROBLEM BUT I HAD NO OTHER EXPLANATION FOR WHAT HAPPENED. THERE WERE NO CODES THROWN FOR THE MECHANIC TO GO BY. AFTER THE LAST EVENT ON THE HIGHWAY, I TOOK IT TO THE DEALER AND TOLD THEM I WOULD NOT EXCEPT THE TRUCK BACK UNTIL THEY KNEW WHAT IT WAS. AFTER MUCH ARGUING, THEY AGREED TO REPLACE THE CRANKSHAFT POSITION SENSOR UPON MY REQUEST. THEY SAID IT WAS NOT THROWING A CODE FOR THAT AND THEY COULDN'T GUARANTEE IT WOULDN'T BREAK OFF DURING REPAIR AND RESULT IN AN EVEN COSTLIER REPAIR. I DIDN'T CARE AT THAT POINT AND TOLD THEM TO DO IT. I HAD READ MANY OTHER REPORTS ON MECHANIC SITES ABOUT THIS SENSOR BEING RECALLED ON SOME BUT NOT ALL GMC 2500 HD TRUCKS SO I INSISTED THE DEALER REPLACE MINE. MINE DID NOT FALL UNDER THE RECALLED VIN# SO IT WAS OUT OF POCKET FOR ME! IT FIXED THE PROBLEM. I HAVE NOT HAD A PROBLEM SINCE AND IT'S BEEN 2 YEARS NOW. I AM STILL UPSET AT THE LACK OF AGREEMENT ABOUT EXTENDING THE RECALL ON THIS ISSUE TO OTHER VIN#'S. THIS WAS A KNOWN PROBLEM THAT COULD HAVE GOTTEN NOT ONLY ME KILLED, BUT MY 2 YOUNG SONS WHO RIDE WITH ME EVERYWHERE. I AM VERY ANGRY AT THE MAKERS! NOTHING WILL FIX THAT. EVER.

NHTSA ID

10482598

Incident

Jul 30, 2010

Mileage

48,000 mi

TL* THE CONTACT OWNS A 2001 GMC SIERRA 2500. THE CONTACT STATED WHILE DRIVING 50 MPH THE VEHICLE STALLED WITHOUT ANY WARNINGS. THE CONTACT MENTIONED THAT HE WAS ABLE TO TURN THE VEHICLE BACK ON BUT THE FAILURE PERSISTED. THE VEHICLE WAS TAKEN TO A LOCAL MECHANIC WHO DIAGNOSED THAT THE FUEL PUMP WAS DEFECTIVE AND NEEDED TO BE REPLACED. THE MECHANIC ALSO ADVISED THAT THE FUEL LINES NEEDED TO BE CLEANED. THE REMEDY FAILED TO REPAIR THE PROBLEM. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE BUT DID NOT OFFER ANY ASSISTANCE SINCE THE VEHICLE WAS NOT INCLUDED IN NHTSA RECALL CAMPAIGN ID NUMBER: 07V521000 (ENGINE AND ENGINE COOLING). THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 79,500 AND THE CURRENT MILEAGE WAS 80,000.

NHTSA ID

10427773

Incident

Jun 1, 2011

Mileage

79,500 mi

EXHAUST BOLTS BROKE OFF AND NOW GASKET HAS FAILED. *TR

NHTSA ID

10419415

Incident

Jul 27, 2011

Mileage

113,000 mi

TL* THE CONTACT OWNS A 2001 GMC SIERRA 2500 HD. WHILE DRIVING APPROXIMATELY 35 MPH, THE ENGINE STALLED WITHOUT WARNING. UPON RESTARTING, THE VEHICLE OPERATED NORMALLY AND WAS TAKEN TO AN INDEPENDENT MECHANIC FOR DIAGNOSIS. THE TECHNICIAN INFORMED THE CONTACT THAT THE CRANKSHAFT POSITION SENSOR WAS FAULTY. THE VEHICLE WAS NOT REPAIRED. THE FAILURE CONTINUED TO RECUR WHENEVER THE VEHICLE WAS IN MOTION. THE MANUFACTURER WAS NOT NOTIFIED OF THE PROBLEM. THE APPROXIMATE FAILURE MILEAGE WAS 94,000. UPDATED 09/15/11 *BF THE CONSUMER LEARNED A RECALL HAD BEEN ISSUED FOR THE CRANKSHAFT POSITION SENSOR. HOWEVER, HIS VIN WAS NOT INCLUDED. UPDATED 11/04/11

NHTSA ID

10416617

Incident

Jun 1, 2011

Mileage

94,000 mi

TL* THE CONTACT OWNS A 2001 GMC SIERRA 2500 HD. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 15 MPH THE VEHICLE SUDDENLY STALLED. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC WHERE THE CONTACT WAS INFORMED THAT THE CRANK SHAFT POSITION SENSOR NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THERE WAS A RECALL UNDER NHTSA CAMPAIGN ID NUMBER: 07V521000 (ENGINE AND ENGINE COOLING) THAT MAY BE RELATED TO THE FAILURE. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND STATED THAT THE VIN WAS NOT INCLUDED IN THE RECALL. THE APPROXIMATE FAILURE MILEAGE WAS 54,500. UPDATED 08/31/11*LJ UPDATED 09/07/11

NHTSA ID

10408785

Incident

Jun 2, 2011

Mileage

54,500 mi

TL* THE CONTACT OWNS A 2001 GMC SIERRA 2500 HD. THE CONTACT WAS DRIVING APPROXIMATELY 60 MPH WHEN THE VEHICLE STALLED WITHOUT WARNING. THE VEHICLE WAS UNABLE TO RESTART AND WAS TOWED TO THE CONTACTS HOME. THE VEHICLE WAS NOT INSPECTED OR REPAIRED. THE MANUFACTURER WAS CONTACTED AND ADVISED THE CONTACT THAT THE VEHICLE WAS NOT INCLUDED IN ANY RECALL. THE FAILURE AND CURRENT MILEAGES WERE APPROXIMATELY 101,000.

NHTSA ID

10402387

Incident

May 21, 2011

Mileage

101,000 mi

2001 GMC SIERRA - 8.1 ENGINE. ENGINE SHUTTING OFF WHILE DRIVING AND/OR FAILURE TO RESTART AFTER SHUT DOWN. THERE WAS AN NHTSA CASE FOR RECALLS, 07V521000, BUT MY VEHICLE WAS NOT PART OF THE RECALL CAMPAIGN 06083 BY GM FOR A DEFECTIVE CRANKSHAFT POSITION SENSOR. GM WOULD NOT INCLUDE MY VEHICLE IN THE RECALL IN SPITE OF IT BEING AN IDENTICAL FAILURE. I BELIEVE THERE ARE MORE VEHICLES WITH DEFECTIVE SENSORS THAT WERE NOT INCLUDED IN THE ORIGINAL RECALL. IT COST OVER $700 TO REPAIR WHAT I BELIEVE IS A BIG SAFETY PROBLEM. I WAS LUCKY TO NOT GET IN AN ACCIDENT AFTER MY ENGINE SHUT OFF WHILE DRIVING ON THE HIGHWAY. THE SHUT DOWN RESULTED IN A LOSS OF POWER STEERING AND POWER BRAKES SO IT WAS DIFFICULT TO COAST TO A SAFE LOCATION ON THE HIGHWAY. *TR

NHTSA ID

10396001

Incident

Mar 28, 2011

Mileage

60,380 mi

ENGINE DIED WHILE DRIVING ON THE FREEWAY. *TR

NHTSA ID

10383403

Incident

Feb 18, 2011

Mileage

63,471 mi

TL*THE CONTACT OWNS A 2001 GMC SIERRA 2500 HD. THE CONTACT STATED THAT FOR THE PAST YEAR THE VEHICLE HAD STALLED INTERMITTENTLY. THERE WERE NO PRIOR WARNINGS PRIOR TO THE STALLING, BUT THE MESSAGE CENTER AND BATTERY LIGHT WOULD ILLUMINATE AFTER THE FAILURE OCCURRED. THE DEALER PERFORMED A DIAGNOSTIC TEST, BUT WAS UNABLE TO DETECT ANY FAILURE CODES. THE CONTACT TRIED REPLACING THE FUEL PUMP AND RELAYS, BUT THAT DID NOT CORRECT THE FAILURE. THE CONTACT THEN BECAME AWARE OF A RECALL FOR THE CRANKSHAFT POSITION SENSOR UNDER RECALL CAMPAIGN NUMBER 07V521000, ENGINE AND ENGINE COOLING. THE MANUFACTURER CONFIRMED THAT ALTHOUGH THE VEHICLE WAS EXPERIENCING THE SAME FAILURE, IT WAS NOT INCLUDED IN THE RECALL. THE FAILURE MILEAGE WAS 52000 AND THE CURRENT MILEAGE WAS 58300. UPDATED 02/07/11 *BF UPDATED 04/20/11

NHTSA ID

10369675

Incident

Nov 17, 2009

Mileage

52,000 mi

I HAVE OWNED MY 2001 GMC SIERRA 2500HD TRUCK SINCE IT WAS NEW. THE VEHICLE CURRENTLY HAS APPROXIMATELY 92000 MILES ON IT. WITH THE BRAKE LINE PROBLEM I RECENTLY HAD I FIGURED I SHOULD REPORT THE OTHER ISSUES THAT I DON?T THINK I SHOULD BE HAVING WITH A VEHICLE THAT IS LESS THAN 10 YEARS OLD. THE OIL COOLER LINES AND THE TRANSMISSION COOLER LINES HAVE ALL RUSTED THROUGH AND HAVE HAD TO BE REPLACED. ALONG WITH THE LINES, THE CONNECTORS FOR THE LINES HAVE ALL HAD TO BE REPLACED DUE TO CATASTROPHIC FAILURE (THEY RUSTED SO BAD THAT WERE FALLING APART). IF THE VEHICLE WAS 20 YEARS OLD I MIGHT EXPECT THIS PROBLEM, BUT NOT ON ONE LESS THAN 10 YEARS OLD AND THE MILEAGE THAT IT HAS. *TR

NHTSA ID

10355178

Incident

Aug 25, 2010

Mileage

90,300 mi

I HAVE OWNED MY 2001 GMC SIERRA 2500HD TRUCK SINCE IT WAS NEW. THE VEHICLE CURRENTLY HAS APPROXIMATELY 92,000 MILES ON IT. DURING THE TIME I HAVE OWNED IT, IT HAS HAD A PROBLEM WITH THE EXHAUST MANIFOLDS COMING LOOSE, DUE TO LOOSING STUDS, BROKEN STUDS OR THE STUDS JUST FALLING OUT. THE TWO DEALERSHIPS HAVE REPAIRED THIS PROBLEM FOUR OR FIVE TIMES WHILE UNDER WARRANTY AND THE PROBLEM HAS OCCURRED AGAIN. I HAVE NEVER SEEN THIS KIND OF PROBLEM ON ANY OTHER VEHICLE THAT I HAVE OWNED AND I HAVE OWNED MANY VEHICLES. THE DANGER THAT THIS PROBLEM CREATES IS THE POSSIBILITY OF FIRE AND CARBON MONOXIDE IN THE CAB OF THE TRUCK. GM/THE DEALERSHIPS REFUSE TO ADDRESS THIS ISSUE, SO I AM FORCED TO TURN IT OVER TO YOU. *TR

NHTSA ID

10355168

Incident

Aug 1, 2008

CRANK SENSOR FAILURE, WITH VEHICLE STALLING AND NOT RE-STARTING UNTIL ENGINE COOLS DOWN. ALSO CRANK SENSOR WAS REPLACED AT APPROX. 60,000 MILES. SAME PROBLEM RE-OCCURRING WITH VEHICLE NOW AT 84,000 MILES. *TR

NHTSA ID

10250932

Incident

Dec 5, 2008

Mileage

84,000 mi

I HAVE A TRUCK THAT HAS THE SAME ISSUE AS THE RECALL IN THIS RECALL NUMBER 07V521000 YET GMC DOES NOT CLAIM IT IN THE RECALL. THE ISSUE IS THAT THE RECALL IS FOR A STALLED ENGINE THAT I HAVE EXPERIENCED MANY TIMES. WHY WOULDN'T GMC COVER ALL THE VEHICLES INVOLVED. THE ENGINE HAS STALLED A NUMBER OF TIMES AT HIGH SPEEDS. I AM ABLE TO CONTROL THE VEHICLE , BUT WHEN IT HAPPENS TO MY WIFE THE BEST SHE CAN DO IS COAST TO A STOP. THIS IS CITY DRIVING SO THE FAILURE IS AN ACCIDENT WAITING TO HAPPEN. *TR

NHTSA ID

10248549

Incident

Nov 6, 2008

Mileage

81,000 mi

I HAVE A 2001 GMC SIERRA 2500HD WITH AN 8.1 LITER V8 GASOLINE ENGINE. WHILE I WAS DOING SOME RESEARCH ON THE INTERNET TRYING TO DIAGNOSE WHAT COULD BE WRONG WITH IT, I STUMBLED ACROSS YOUR WEBSITE STATING THAT THERE HAD BEEN A RECALL ON THAT TRUCK WITH THAT ENGINE. NHTSA CAMPAIGN ID NUMBER : 07V521000. THIS RECALL INFORMATION DESCRIBES EXACTLY WHAT HAS BEEN HAPPENING WITH MY VEHICLE AND THAT PART IS ONE I WAS DOING RESEARCH ON BASED UPON A MECHANIC FRIENDS ADVICE. I WAS EXCITED TO HEAR THAT THERE WAS A RECALL AS I CANNOT AFFORD TO HAVE THE PART PUT ON PROFESSIONALLY AND AM NOT KNOWLEDGEABLE TO DO IT MYSELF. THIS DEFECT REALLY IS A SAFETY ISSUE. OVER THE PAST COUPLE OF WEEKS THE TRUCK HAS GONE DEAD AND I HAVE BEEN STUCK IN AN INTERSECTION AND ALSO HAD TO PULL OVER SEVERAL TIMES WHILE THE VEHICLE WAS NOT RUNNING AND NOT STEERING EASILY OR STOPPING EASILY. SO I CALLED A TOLL FREE NUMBER THAT I GOT FOR GMC AND THEY TELL ME THAT MY TRUCK IS NOT COVERED EVEN THOUGH IT IS CLEARLY DOING THE SAME THING THAT THE RECALL DEFINES. MY VIN# IS . I HOPE THAT THERE IS SOMETHING THAT YOUR ORGANIZATION CAN DO TO EXTEND THE RECALL TO AFFECT MY VEHICLE OR LET GMC KNOW THAT IT ALREADY DOES. THANK YOU VERY MUCH AND DO NOT HESITATE TO CALL ME IF YOU NEED ANY FURTHER INFORMATION. *TR

NHTSA ID

10240817

Incident

Jul 1, 2008

Mileage

130,000 mi

TL*THE CONTACT OWNS A 2001 GMC SIERRA 2500. WHILE DRIVING APPROXIMATELY 30 MPH, THE VEHICLE SHUT OFF ON THREE SEPARATE OCCASIONS WITHOUT WARNING AND HAD TO BE RESTARTED. THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN ID NUMBER 07V521000 (ENGINE AND ENGINE COOLING). THE CURRENT MILEAGE WAS 60,520 AND FAILURE MILEAGE WAS 60,515. UPDATED 06/09/08 *BF THE CONSUMER STATED THE PROBLEM WAS DIAGNOSED AND THE CRANKSHAFT SENSOR WAS REPLACED. UPDATED 06/09/08

NHTSA ID

10228188

Incident

May 19, 2008

Mileage

60,515 mi

WHILE REPLACING THE FUEL INJECTORS UNDER A SPECIAL INJECTOR WARRANTY, THE DEALERSHIP BROKE A GLOWPLUG OFF AND CALLED TO SAY I NEED TO REPLACE THE CYLINDER HEAD AT MY COST. CALL GMC CUSTOMER SUPPORT WHO SAY DUE TO THE AGE AND MILEAGE 2001, 124500. THAT THE CORROSION OF THE GLOWPLUG AND THE FACT IT SEIZED IN THE CYLINDER HEAD IS NOT THERE PROBLEM, EVEN THOUGH THEY ARE THE ONE WHO DESIGNED THE ENGINE. THEY SAID THAT IT'S AT MY COST FOR A NEW CYLINDER HEAD WHICH WAS QUOTED TO ME OVER THE PHONE AT A PRICE OF $1,800.00. *TR

NHTSA ID

10221961

Incident

Mar 6, 2008

Mileage

124,500 mi

TL*THE CONTACT OWNS A 2001 GMC SIERRA 2500 HD. WHILE DRIVING APPROXIMATELY 40 MPH, THE VEHICLE STALLED WITHOUT WARNING AND THEN IMMEDIATELY RESTARTED. THE CONTACT IS A PROFESSIONAL MECHANIC AND HE REPAIRED THE FUEL PUMP, FUEL FILTER, AND FUEL PRESSURE REGULATORS; HOWEVER, THE FAILURE CONTINUED. HE NOTIFIED THE DEALER AND THEY STATED THAT THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN ID NUMBER 07V521000 (ENGINE AND ENGINE COOLING), EVEN THOUGH THE FAILURE WAS IDENTICAL. HE WAS INFORMED THAT HE WOULD HAVE TO REPAIR THE VEHICLE AT HIS OWN EXPENSE. THE FAILURE MILEAGE WAS 62,000 AND CURRENT MILEAGE WAS 72,000.

NHTSA ID

10217813

Incident

Feb 12, 2006

Mileage

62,000 mi

TL*THE CONTACT OWNS A 2001 GMC SIERRA 2500. WHILE DRIVING AT ANY SPEED, THE VEHICLE SHUTS OFF AND RESTARTS AFTER A FEW MINUTES. THE DIAGNOSTIC INDICATED THAT THE CRANKSHAFT SENSOR NEEDED TO BE REPLACED. THE CURRENT MILEAGE WAS 64,200 AND FAILURE MILEAGE WAS 63,000. UPDATED 01-10-08. *KB

NHTSA ID

10212140

Incident

Nov 30, 2007

Mileage

63,000 mi