2002 GMC Yukon Xl Owner Complaints

The contact owns a 2002 GMC Yukon XL. The contact stated while driving approximately 70 MPH, the contact started to slow for traffic and depressed the brake, and felt no braking. The contact had to depress the brake pedal to the floorboard. The contact stated that the brake warning light was illuminated. The contact was able to safely stop and drove the vehicle to his residence. The contact had taken the vehicle to a local dealer who diagnosed that there was a fractured parking brake spring. The vehicle was not repaired. The manufacturer had not been informed of the failure. The failure mileage was approximately 189,000.

NHTSA ID

11470657

Incident

Jun 22, 2022

Mileage

189,000 mi

AS VEHICLE COMES TO A SLOW STOP THE BRAKES FEEL AS IF THE RELEASE AND STILL ROLL ALSO WHEN PULLING INTO A DRIVEWAY OR PARKING SPOT THIS HAS HAPPED OFTEN.

NHTSA ID

11319808

Incident

Mar 31, 2020

Mileage

201,000 mi

I SWERVED TO MISS A DEER AND I HIT A TREE RUNNING 47 MPH AND MY AIR BAGS DIDN'T DEPLOY AND NO ONE CAN TELL ME WHY. MY HUSBAND AND I WERE VERY LUCKY BUT WHY DIDN'T THE AIR BAGS DEPLOY? MY HUSBAND WAS OUT OF WORK FOR 5 MONTHS DUE TO TORN LIGAMENTS IN HIS SHOULDERS AND STILL HAS TO HAVE SURGERY.

NHTSA ID

11298082

Incident

Feb 5, 2019

Mileage

195,000 mi

TL* THE CONTACT OWNS A 2002 GMC YUKON XL. THE CONTACT STATED THAT WHILE THE BRAKE PEDAL WAS DEPRESSED, THE VEHICLE JUMPED AND HESITATED WITHOUT WARNING. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE WHEEL SPEED SENSOR WAS CORRODED AND NEEDED TO BE REPLACED. THE DEALER WAS NOT CONTACTED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND THE CONTACT WAS PROVIDED CASE NUMBER 8-3140697651. THE APPROXIMATE FAILURE MILEAGE WAS 145,000.

NHTSA ID

11013947

Incident

Jun 9, 2017

Mileage

145,000 mi

TWO YEARS AGO I HAD A SEVER ACCIDENT THAT CAUSE ME TO HIT ANOTHER CAR AND SPIN AROUND. THE GMC DEALER SAID THE CAUSE WAS RUSTED OUT BRAKE LINES. TODAY IT HAPPENED, BUT I WAS LUCK ENOUGH TO BE JUST PULLING INTO MY PARKING SPOT WHEN IT HAPPENED. THE BRAKE LINE MUST HAVE RUSTED OUT AGAIN BECAUSE I PUMPED THE BRAKE AND NOTICED IT COMING OUT OF THE LEFT REAR LINE. THIS IS VERY DANGEROUS BECAUSE IT WILL LIKELY ONLY HAPPEN WHEN YOU ARE IN AN EMERGENCY SITUATION. THERE IS NO PRE WARNING. IT WILL JUST HAPPEN. PERHAPS THEY ARE MAKING THE BRAKE LINES OUT OF THINNER MATERIAL BECAUSE WE HAVE MANY VEHICLES MUCH OLDER, AND NEVER HAD THIS PROBLEM.

NHTSA ID

10849598

Incident

Mar 14, 2016

Mileage

192,219 mi

I DROVE APPROX. 30 MILES TO MY DESTINATION WITHOUT ANY TROUBLE. I SPENT ABOUT 2 HOURS THERE THEN STARTED MY 2002 YUKON XL TO HEAD BACK HOME. UPON MOVING THE VEHICLE I REALIZED I HAD VERY LIMITED BREAKING POWER. THE BRAKE PEDAL WENT RIGHT TO THE FLOOR. I DREAD THINKING ABOUT WHAT COULD HAVE HAPPENED IF I WAS ON THE INTERSTATE HEADING HOME. MY MECHANIC SAID THE BRAKE LINE FAILED CAUSING THE REAR BRAKES TO LOSE ALL STOPPING POWER. HE SAID HE HAS SEEN SEVERAL CASES OF THIS SAME PROBLEM ON EARLY 2000'S GMC TRUCKS AND SUV'S. I RESEARCHED THIS ISSUE AND FOUND MANY OF THE SAME COMPLAINTS ONLINE. GMC SHOULD STAND BEHIND THIS AND PAY TO REPAIR THIS OBVIOUSLY DEFECTIVE PART REPLACEMENT. THIS WILL BE AN $800 REPAIR FOR ME AND A BIG DISAPPOINTMENT IN GMC IF THEY DON'T STAND BEHIND THEIR VEHICLES.

NHTSA ID

10836552

Incident

Feb 15, 2016

Mileage

88,000 mi

DURING LOW SPEED THE ABS KICKS IN ON NO SLIP CONDITIONS CAUSING IT TO TAKE LONGER TO STOP THE VEHICLE. THIS STARTED OCCURRING IN JUNE 2014. I SEE A RECALL ON 2002 YUKON XL VEHICLES FOR THIS PROBLEM BUT IT DOES NOT SHOW UP ON THE VIN REPORT. *TR

NHTSA ID

10671122

Incident

Jun 2, 2014

Mileage

211,055 mi

WHILE TURNING INTO A MALL PARKING LOT FROM A MAIN STREET, APPLIED BRAKES TO SLOW DOWN INTO THE PARKING LOT FOR A VEHICLE TO PASS IN FRONT OF ME. WITHOUT ANY PRIOR WARNING THE BREAK PEDDLE WENT TO THE FLOOR AND I WAS UNABLE TO STOP EVEN FROM A SLOW SPEED. LUCKLY I WAS ABLE TO DRIVE AROUND THE VEHICLE IN FRONT OF ME BECAUSE THE BREAKS SEEMED TO FAIL ABOUT 95%. I PUMPED THE BREAKS A FEW TIME AND GOT INTO THE CLOSEST PARKING SPACE. THE VEHICLE WAS NOT SAFE TO DRIVE DO TO SUDDEN BREAK FAILURE. THE REPAIR GARAGE CERTIFIED MECHANIC SAID THE BREAK LINE HAD RUSTED THRU AND THE BREAK FLUID WAS RAPIDLY LEAKING. I HAD THE GARAGE REPLACE ALL THE ENTIRE RUSTED BREAK LINES ($646.00) TO BE ABLE TO DRIVE SAFELY AND AVOID ANOTHER SUDDEN BREAK FAILURE DUE TO RUSTED BREAK LINES. OTHERWISE THE CAR HAS BEEN WELL TAKEN CARE FOR AND IN EXCELLENT RUNNING CONDITION. MY MECHANIC SAID THEY HAD REPAIRED SEVERAL GMC VEHICLES WITH THIS IDENTICAL PROBLEM. I BELIEVE GMC HAS SOLD A CAR WITH DEFECTIVE SAFETY PARTS WHICH HAVE WORN PREMATURELY. *TR

NHTSA ID

10651966

Incident

Oct 31, 2014

Mileage

120,000 mi

TL* THE CONTACT OWNS A 2002 GMC YUKON XL. THE CONTACT STATED WHILE DRIVING APPROXIMATELY 30 MPH, THE ENGINE STALLED WITHOUT WARNING. THE VEHICLE RESTARTED AFTER EIGHT ATTEMPTS. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER WHO STATED THAT THE CRANKSHAFT POSITION SENSOR WAS FAULTY. THERE WAS A RECALL ISSUED FOR THE 2001 GMC YUKON MODEL UNDER NHTSA CAMPAIGN ID NUMBER 07V521000 (ENGINE AND ENGINE COOLING). THE VEHICLE WAS CURRENTLY BEING REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE DEFECT. THE APPROXIMATE FAILURE MILEAGE WAS 62,700.

NHTSA ID

10575129

Incident

Mar 10, 2014

Mileage

62,700 mi

WE PURCHASED THE 2002 YUKON FROM MCGUIRE DEALERSHIP IN NJ ITS BEEN CARED FOR TAKEN TO THE DEALERSHIP FAITHFULLY DRIVEN BY MY 50 YEAR OLD FATHER, WHEN FIRST DRIVING HE NOTICED THE PEDAL VIBRATING RAPIDLY DURING NORMAL BRAKE APPLICATIONS. THE ABS CONTROL VALVE WAS THE CULPRIT ALONG WITH A RUSTY WHEEL SENSOR. IT WAS REPLACED AT THE DEALER AND AFTER 5 YEARS THE FRAME OF THE TRUCK IS RUSTING AND ROTTING ALONG WITH SUSPENSION PARTS AND MOST OF ALL THE BRAKES. WE CAME CLOSE TO CRASHING ONE DAY WHEN THE PEDAL WENT STRAIGHT TO THE FLOOR, WE TAKE IT TO THE LOCAL FIRESTONE AND THEY TELL US ALL THE BRAKE LINES ARE RUSTED OUT ALONG WITH THE MASTER CYLINDER. WE REPLACED THE LINES AND MASTER CYLINDER WITH A HEFTY PRICE TAG. WE GET THE CAR BACK 3 DAYS LATER PEDAL GOES TO THE FLOOR AGAIN, BACK AT THE MECHANIC BOTH REAR CALIPERS ARE RUSTED AND LEAKING. WE REPLACED ALL 4 CALIPERS AND THE PROBLEM STOPPED BUT NOW THE FRAME IS RUSTING AND THE ABS IS STILL VIBRATING BADLY. LONG STORY SHORT GM NEEDS TO BE HELD ACCOUNTABLE FOR SELLING SUCH CHEAP CRAPPY TRUCKS, WE CAME CLOSE A FEW TIMES TO CRASHING, AND I FEEL SORRY FOR THE PEOPLE THAT HAVE LOST THEIR LIVES DUE TO THE NEGLIGENCE OF THE EMPLOYEES OF GM. *TR

NHTSA ID

10568634

Incident

Mar 5, 2010

Mileage

50,000 mi

PURCHASED A NEW 2002 GMC YUKON XL, AT ABOUT 6800 MILES THE STEERING DEVELOPED A RATTLE, DEALER UNDER WARRANTY REGREASED THE STEERING SHAFT, THIS HELPED FOR A ABOUT A YEAR AND IT STARTED AGAIN. DEALER RE-GREASED WITH WHAT THEY SAID WAS A NEW GREASE THAT SHOULD SOLVE THE RATTLE PROBLEM. IT HAS STARTED THE RATTLE AGAIN AND ONLY HAS 38000 MILES. I UNDERSTAND THERE IS A REDESIGNED STEERING SHAFT THAT SOLVES THIS RATTLE PROBLEM. HERE IS THE BULLETIN TO SOLVE THE POOR SHAFT DESIGN, SHOULD BE A RECALL BUT LOOKS LIKE GM IS ONLY REPLACING ON A CASE BY CASE ISSUE WAITING FOR YOUR WARRANTY TO BE OUT, AT WHICH TIME THEY CHARGE YOU FOR THE POOR DESIGN STEERING SHAFT. GMC TECH BULLETIN 00-02-35-003M (LATEST REVISION) SUBJECT: CLUNKING NOISE UNDER HOOD AND CAN BE FELT IN STEERING WHEEL AND/OR STEERING COLUMN (REPLACE UPPER INTERMEDIATE STEERING SHAFT (I-SHAFT) ASSEMBLY) #00-02-35-003M - (01/31/2007) MODELS: 2002-2006 CADILLAC ESCALADE MODELS 1999-2007 CHEVROLET SILVERADO MODELS (CLASSIC) 2000-2006 CHEVROLET SUBURBAN, TAHOE MODELS 2002-2006 CHEVROLET AVALANCHE 1999-2007 GMC SIERRA MODELS (CLASSIC) 2000-2006 GMC YUKON, YUKON XL MODELS 2003-2006 HUMMER H2 . *TR

NHTSA ID

10537115

Incident

Aug 12, 2003

Mileage

6,800 mi

STEPPED ON BRAKE PEDAL AND BRAKES FAILED TO STOP VEHICLE. INSPECTED VEHICLE AND NOTICED RUSTED BRAKE LINES FAILED.I AM THE ORIGINAL OWNER OF THIS VEHICLE. *TR

NHTSA ID

10532852

Incident

Jul 30, 2013

Mileage

215,000 mi

THE ANTILOCK BRAKE SENSORS ARE MALFUNCTIONING AND CAUSING EXTENDED STOPPING DISTANCES THAT COULD LEAD TO AN ACCIDENT. THE ORIGINAL RECALL WAS COMPLETED IN 2006, ACCORDING TO GMC THEY ONLY CLEANED THE PARTS AND DID NOT REPLACE THEM. AS A RESULT THERE IS SEVERE CORROSION ON THE ANTILOCK BRAKE SENSOR CAUSING INCREASED STOPPING DISTANCES THAT COULD CAUSE AN ACCIDENT. *TR

NHTSA ID

10480664

Incident

Oct 16, 2012

Mileage

192,000 mi

BROKEN EXHAUST MANIFOLD STUDS ARE CAUSING ENVIRONMENTAL HAZARD AND MAY LEAD TO FAILED CATALYTIC CONVERTER AND OTHER ENGINE PROBLEMS. THIS IS A MANUFACTURING DEFECT THAT SHOULD BE RECALLED, AS IT RENDERS THE VEHICLE EITHER UNUSABLE OR UNABLE TO PASS ENVIRONMENTAL TESTING. *TR

NHTSA ID

10423891

Incident

Aug 1, 2011

Mileage

145,000 mi

VEHICLE RAN OUT OF GAS, FUEL GAUGE READ 1/4 TANK

NHTSA ID

10400170

Incident

Apr 11, 2011

Mileage

103,029 mi

TL* THE CONTACT OWNS A 2002 GMC YUKON XL. THE CONTACT STATED THAT WHILE APPROACHING AN INTERSECTION, THE ABS WARNING LIGHT ILLUMINATED AND THE VEHICLE VIBRATED AS THE BRAKE PEDAL WAS DEPRESSED. THE VEHICLE DID NOT STOP WHEN THE BRAKES WERE APPLIED AND WAS IN THE INTERSECTION BEFORE IT FINALLY STOPPED. THE BRAKING ISSUES PERSISTED AS THE VEHICLE WAS CONTINUOUSLY DRIVEN. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER WHO STATED THAT THE ELECTRONIC BRAKE CONTROL MODULE HAD FAILED AND WOULD NEED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE CONTACT CALLED THE MANUFACTURER WHO OFFERED NO ASSISTANCE. THE CURRENT AND FAILURE MILEAGE WAS 156,000.

NHTSA ID

10397339

Incident

Apr 15, 2011

Mileage

156,000 mi

TL*THE CONTACT OWNS A 2002 GMC YUKON XL. WHILE DRIVING APPROXIMATELY 30 MPH, THE VEHICLE STOPPED ACCELERATING AND A BATTERY INDICATION LIGHT ILLUMINATED ON THE INSTRUMENT PANEL. THE VEHICLE STALLED AND WHEN IT WAS RESTARTED, THE FAILURE OCCURRED AGAIN. THE VEHICLE WAS TAKEN TO A LOCAL REPAIR SHOP WHERE THE CONTACT WAS INFORMED THAT THE CRANKSHAFT POSITION SENSOR NEEDED TO BE REPLACED. THE VEHICLE WAS BEING REPAIRED. THE CURRENT AND FAILURE MILEAGES WERE APPROXIMATELY 116,000.

NHTSA ID

10367093

Incident

Nov 19, 2010

Mileage

116,000 mi

2002 GMC YUKON XL REAR TAILGATE GLASS FAILED/BROKEN HINGE DUE TO POOR DESIGN. THIS RESULTS IN THE REAR GLASS HELD ON BY ONE HINGE INSTEAD OF TWO. REAR GLASS DOES NOT CLOSE PROPERLY AND IS AT RISK TO DETACH FROM VEHICLE. MANY OWNERS OF THIS VEHICLE (AND SISTER VEHICLES TAHOE AND SUBURBAN) HAVE EXPERIENCED THIS DEFECT. GM FAILS TO ACKNOWLEDGE OR ASSUME RESPONSIBILITY. *TR

NHTSA ID

10356376

Incident

Jun 15, 2010

Mileage

103,000 mi

ENGINE SHUTS DOWN WHILE DRIVING: I HAVE A YUKON XL 2002. OVER THE PAST 6 MONTHS THE ENGINE WOULD SUDDENLY SHUT DOWN WHILE THE CAR IS BEING DRIVEN. IT HAS OCCURRED AT HIGH SPEED AND AT LOW SPEED. I HAVE TAKEN IT BACK TO THE DEALER NO LESS THAN 5 TIMES AND THE PROBLEM PERSISTS. THIS REPRESENTS A MAJOR DANGER AS WHILE ON THE HIGHWAY, WHEN THE ENGINE SHUTS DOWN THE CAR BECOMES DIFFICULT TO MANEUVER AND MOVING OUT OF THE HIGHWAY TRAFFIC HAS BEEN EACH TIME EXTREMELY DANGEROUS TO ME AND TO OTHER DRIVERS. *TR

NHTSA ID

10327021

Incident

Oct 1, 2009

Mileage

89,000 mi

I HAVE A 2002 GMC YUKON XL AND IT DOES NOT HAVE THE LATCH SYSTEM. I LEARNED FROM THE LOCAL SHERIFF'S OFFICE THAT ALL VEHICLES MANUFACTURED IN THE YEAR 2002 AND AFTER SHOULD HAVE THE LATCH SYSTEM. *TR

NHTSA ID

10325587

Incident

Apr 13, 2010

Mileage

158,000 mi

KNOCKING NOISE IS HEARD COMING FROM THE FRONT OF THE VEHICLE AND IS FELT AS A "CLUNK" THROUGH THE STEERING WHEEL. HAPPENS WHEN PARALLEL PARKING....TIGHT, SLOW TURNS IN REVERSE. FEELS LIKE GEARS IN THE DIFFERENTIAL ARE STICKING AND LURCHING. IT HAS BEEN HAPPENING ON AND OFF FOR A LONG TIME. *TR

NHTSA ID

10298664

Incident

Jan 5, 2010

Mileage

45,000 mi

WAS DRIVING APPROX 60MPH ON NEWLY PAVED 4 LANE HIGHWAY (US 31). VEHICLE BEGAN TO MAKE A NOISE AND THEN SHAKE. FRONT DRIVER'S SIDE TIRE WAS COMPLETELY DESTROYED WITH APPROX 80% OF THE TREAD AND BELT SEPARATED FROM THE TIRE AND NUMEROUS HOLES IN THE TIRE. MANY SHARP STEEL PRONG ENDS WERE STICKING OUT OF THE TIRE AND THE SEPARATED TREAD/BELT. DESTROYED THE WHEEL WELL COVERING. 2002 YUKON XL. TIRES HAD BEEN INSTALLED IN MARCH 2008. WHEN LOOKING AT THE FRONT PASSENGER SIDE TIRE, IT HAD NUMEROUS LARGE CRACKS FROM THE TREAD EXTENDING INTO THE SIDEWALL. TO AVOID HAVING ANOTHER BLOWOUT/SEPARATION, QUICKLY REPLACED THAT TIRE AND RETURNED BOTH TO THE DEALER WHERE PURCHASED. HAVING THE DEALER CONTACT COOPER AND INSPECT THE REAR 2 TIRES AS WELL (VISUAL INSPECTION DID NOT SHOW THE TREAD/SIDEWALL CRACKS). *TR

NHTSA ID

10277517

Incident

Jul 18, 2009

Mileage

125,000 mi

TL*THE CONTACT OWNS A 2002 GMC YUKON XL. THE CONTACT REFERENCED NHTSA CAMPAIGN ID NUMBER 05V379000 (SERVICE BRAKES, HYDRAULIC:ANTILOCK) BECAUSE HER VEHICLE IS EXPERIENCING THE SAME ISSUES. THE ABS INDICATOR ILLUMINATES AND MAKES A LOUD NOISE WHEN DRIVING AND WHEN THE VEHICLE IS STOPPED. THE ABS ACTIVATION ALSO MAKES STOPPING THE VEHICLE VERY DIFFICULT. THE DEALER ADVISED THE CONTACT TO DEFUSE THE FUSE WHERE THE ABS INDICATOR IS LOCATED IN ORDER TO STOP THE NOISE WHILE THE ENGINE IS RUNNING. THE VEHICLE WAS TAKEN TO THE DEALER AND THEY STATED THAT THE REPAIR WOULD COST $1,100. THE CONTACT CALLED THE MANUFACTURER AND THEY INSTRUCTED THE DEALER TO REPAIR THE VEHICLE AT 50% OF THE COST; HOWEVER, THE DEALER REFUSED. THE FAILURE MILEAGE WAS 80,000.

NHTSA ID

10256505

Incident

Jan 26, 2009

Mileage

80,000 mi

TL*THE CONTACT OWNS A 2002 GMC YUKON XL. ON SIX SEPARATE OCCASIONS, WHILE DRIVING AT ANY SPEED, THE VEHICLE COMPLETELY SHUT OFF AND WOULD NOT RESTART IMMEDIATELY. THE VEHICLE WOULD SHUT OFF WHILE ACCELERATING FROM A TRAFFIC LIGHT OR STOP SIGN, AND WOULD NOT RESTART IMMEDIATELY. THE VEHICLE FAILED TO START ON A FEW OCCASIONS WHILE IN PARK. NHTSA CAMPAIGN ID NUMBER 07V521000 (ENGINE AND ENGINE COOLING) IS IDENTICAL TO THE FAILURE THE CONTACT IS EXPERIENCING. THE CURRENT MILEAGE WAS 76,000 AND FAILURE MILEAGE WAS 70,000. UPDATED 11/12/08. *LJ UPDATED 11/14/08. *JB

NHTSA ID

10245579

Incident

Dec 16, 2007

Mileage

70,000 mi

TL*THE CONTACT OWNS A 2002 GMC YUKON XL. WHEN THE BRAKE PEDAL WAS DEPRESSED, THE CONTACT EXPERIENCED UNWANTED ANTILOCK BRAKE ACTIVATION. AS A RESULT, THE VEHICLE LUNGES FORWARD BEFORE COMING TO A COMPLETE STOP. THE DEALER REPLACED THE ANTILOCK SPEED SENSOR AND THE FRONT HUB ASSEMBLY AT THE COST OF $600. THE FAILURE MILEAGE WAS 62,500 AND CURRENT MILEAGE WAS 63,630. UPDATED 11/14/08. *LJ UPDATED 11/18/08. *JB

NHTSA ID

10245578

Incident

Aug 15, 2008

Mileage

62,500 mi