2021 GMC Yukon Xl Fuel system Problems

INCIDENT 4: Fuel Injector Internal Short (Cylinder #6) Component / System Failed: Fuel Injection System / Cylinder #6 Fuel Injector & Wiring Harness Failure Description: Cylinder 6 fuel injector failed due to an internal electrical short circuit, causing immediate engine misfires and severe power reduction. Repair required replacing the Bank 2 fuel rail, four fuel injectors, and the injector wiring harness. Safety Risk: Immediate engine shuddering and abrupt drop in drive power while operating in active traffic creates a serious loss-of-acceleration hazard and heightened risk of a rear-end collision. Dealer / Repair Shop Confirmation: Official diagnosis confirmed by Service Center Technician via electronic diagnostics verifying the internal electrical short circuit. Warning Symptoms: Check Engine Light illuminated simultaneously with engine shaking and sudden power loss; no prior symptoms existed before the failure. Inspection Availability: Confirmed via technician diagnostics; Check Engine light illuminated along with four other warning lights- car had to be towed to dealership to be fixed

NHTSA ID

11775683

Incident

Oct 13, 2026

INCIDENT 3: Fuel Pump Driver Module (FPDM) Failure Component / System Failed: Fuel Pump Driver Module (FPDM - Part #13554821) / Engine Control Module (ECM) Communication Failure Description: Total loss of communication between the ECM and FPDM, causing the engine to abruptly die while idling at a traffic light. Subsequent attempt to restart using push-to-start produced a severe mechanical screeching noise. Safety Risk: Unexpected stall in active traffic left the vehicle stranded and unable to restart safely, exposing occupants to collision hazards. Dealer / Repair Shop Confirmation: Confirmed by Service Technician. Diagnostic Code P129F ("ECM lost communication with fuel pump driver module") logged; verified power and ground failures at the module. Replaced FPDM (Part #13554821). Warning Symptoms: None prior to failure. Sudden engine shutdown followed by screeching sound on attempted restart. Inspection Availability: Vehicle and replaced module are available for inspection upon request.

NHTSA ID

11775676

Incident

Mar 10, 2026

INCIDENT 2: Total Electrical / Power System Shutdown Component / System Failed: Electrical / Power Control System (Auto-Stop/Start System) Failure Description: Total loss of electrical power causing the main dashboard and display screen to go completely dark, stalling the vehicle during an autostop event at a traffic light and preventing the engine from restarting. Safety Risk: Sudden total electrical shutdown leaves the vehicle completely dead, unresponsive, and immobilized in active traffic lanes/intersections, creating a high risk of rear-end or multi-vehicle collisions. Dealer / Repair Shop Confirmation: Customer complaint and active fault codes confirmed by dealership service department following standard maintenance schedule. Warning Symptoms: Display screen went blank; failure occurred instantly during autostop/traffic light stop without prior warning. Inspection Availability: Vehicle and affected systems are available for inspection upon request. INCIDENT 3: Fuel Pump Driver Module (FPDM) Failure Component / System Failed: Fuel Pump Driver Module (FPDM - Part #13554821) / Engine Control Module (ECM) Communication Failure Description: Total loss of communication between the ECM and FPDM, causing the engine to abruptly die while idling at a traffic light. Subsequent attempt to restart using push-to-start produced a severe mechanical screeching noise. Safety Risk: Unexpected stall in active traffic leaves the vehicle stranded and unable to restart safely, exposing occupants to collision hazards. Dealer / Repair Shop Confirmation: Confirmed by Service Technician. Diagnostic Code P129F ("ECM lost communication with fuel pump driver module") logged; verified power and ground failures at the module. Replaced FPDM (Part #13554821). Warning Symptoms: None prior to failure. Sudden engine shutdown followed by screeching sound on attempted restart. Inspection Availability: Vehicle and replaced module are available for inspection upon request.

NHTSA ID

11775670

Incident

Mar 7, 2024

INCIDENT 1: Internal Engine Failure & Excessive Oil Consumption Component / System Failed: Engine Internal Components (Piston Rings, Valve Guide Seals, Spark Plugs) Failure Description: Excessive oil consumption (1.5 to 2.0 quarts burned every 2,000 miles) leading to heavy oil-fouling on spark plugs #5 and #7. Required complete cylinder head, oil pan, and piston teardown to replace all pistons, rings, connecting rod bearings, lifters, guides, valve guide seals, and spark plugs. Safety Risk: Severe internal engine oil consumption and plug fouling create an immediate risk of engine misfires, unexpected loss of power, or catastrophic engine failure while driving at highway speeds. Dealer / Repair Shop Confirmation: Confirmed by Dealership Service Department via oil consumption tests, spark plug inspection with oil dye, compression tests, cylinder leak-down tests, and physical teardown. Warning Symptoms: Low oil warning lamp illuminated; continuous need to top off oil between routine maintenance services. Inspection Availability: Vehicle and replaced components are available for inspection upon request.

NHTSA ID

11775607

Incident

Nov 14, 2020

**Mileage at repair:** 76,165 miles **Component:** Fuel Pump Power Control Module While driving my 2021 GMC Yukon XL on [XXX] on a treacherous stretch decending [XXX] the engine unexpectedly stopped running, resulting in a complete loss of propulsion. This occurred on a section of interstate where there was no safe shoulder or suitable location to pull off the roadway. The unexpected failure created an extremely dangerous situation, exposing me and other motorists to the risk of a serious collision. The vehicle was subsequently towed, diagnosed and repaired by Darrell Waltrip Buick GMC in [XXX]. The dealership documented diagnostic trouble code P129F, "Fuel Pump Driver Control Module Fuel Pump Speed Signal Incorrect." The technician verified that the control module had proper electrical power, that there was no pin damage or connector fitment issue, and that the module required replacement. The dealership's written diagnosis specifically acknowledges that a failing fuel pump driver module can cause the engine to shut down. The original factory-installed module was replaced with GM part number 13554821, and the vehicle was subsequently tested and confirmed to operate correctly. The repair was performed at no charge, and GM provided a loaner vehicle while the replacement part was unavailable. I am particularly concerned that General Motors has previously acknowledged this same type of safety hazard under NHTSA Safety Recall 21V-739 (GM N212332040), involving fuel pump power control modules on certain 2021 GM full-size SUVs. That recall identifies unexpected engine stalling and increased crash risk as consequences of module failure. My experience demonstrates the potentially catastrophic consequences of this failure in actual highway operation. I request that NHTSA investigate whether a mandatory recall and replacement of these defective components is necessary as the consequences of immediate complete unexpected loss of propulsion. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C.

NHTSA ID

11774053

Incident

Oct 17, 2026

part number 13554821 fuel pump control module has failed 2 times. April 2023 on Interstate 95 near Savannah GA in very busy traffic. Vehicle buckled and seized, just barely made it to the shoulder of the road. Same part failed again 9/18/26 while turning onto Sunrise Hwy in NY another very dangerous situation as we were stranded in the middle of a very busy intersection

NHTSA ID

11766090

Incident

Sep 18, 2026

6.2L engine has the oil change update, and engine failed recently. took vehicle for repair to Golling GMC dealer. waiting on feedback.

NHTSA ID

11765506

Incident

Sep 16, 2026

According to the GM Dealership the rod bearing failed disabling the engine. Dealer recommends replacing the entire engine. This consistent with recall N 252494000-N252494003 but my VIN is not included in the recall. Estimated repair $11,200. Our family was traveling roughly 55 mph on the interstate at the time of incident.

NHTSA ID

11764136

Incident

Sep 13, 2026

Was driving the vehicle at 70 mph on the highway without any issues for several hours and suddenly the vehicle lost power and had no propulsion. It went into neutral automatically and the engine shut off while driving. Thankfully I was on a downward slope and could steer the vehicle off the very busy highway. Once safe, I tried to restart the car but the engine would not start or turn over. Roadside assistance came to help as well as a flatbed tow truck. It was taken to a nearby GMC dealer but it remains completely dead despite the battery being fully charged and all of the electronics working. No known error codes are showing up. It’s an L87 engine and was part of the GM recall. The recall work was completed in Nov 2025.

NHTSA ID

11758876

Incident

Aug 22, 2026

I am filing a safety complaint regarding my 2021 GMC Yukon. While driving on the highway during a long-distance trip from [XXX] to [XXX], my vehicle suddenly experienced a serious loss of power, drivability issues, and loss of propulsion. The vehicle began shaking violently, slowing down unexpectedly, and struggling to maintain speed while in active highway traffic at highway speeds. At the time of the incident, the vehicle displayed a warning message indicating “Conditions Not Correct for Shift” at approximately 127,506 miles. Shortly after, the vehicle set diagnostic trouble code P0011, which relates to the engine and transmission system not performing as expected and indicates an issue with the Variable Valve Timing (VVT) system affecting engine timing and performance. The vehicle also entered a reduced performance state, and I was advised through the vehicle’s warning system to reduce speed, avoid hard acceleration, and avoid heavy load conditions. Despite following these precautions, the vehicle continued to run poorly and became increasingly unsafe to operate in highway traffic. This created a serious and potentially life-threatening situation, as I was traveling in fast-moving traffic and the vehicle lost normal propulsion and stability. I had to carefully maneuver out of active traffic lanes to avoid a potential collision. The vehicle eventually required roadside assistance/towing due to its inability to operate normally. Diagnostic trouble codes and warning messages were present at the time of failure. After the incident, I checked my VIN through the NHTSA recall system and discovered that my vehicle has three unrepaired safety recalls. Of particular concern is: NHTSA Recall Number: 25V274 GM Manufacturer Recall Number: N252494000 This recall involves certain GM vehicles equipped with the 6.2L V8 L87 engine and describes a manufacturing defect in the connecting rod and/or crankshaft components that may result in engine damag INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA),

NHTSA ID

11757435

Incident

Aug 16, 2026

My 2021 GMC Yukon XL recently suffered a failure of its fuel pump control module. This occurred at just 44,000 miles, mere weeks after my manufacturer warranty expired in June of 2026. This issue goes far beyond a financial inconvenience or a matter of consumer reimbursement; it is a severe, life-threatening safety hazard that GM has failed to permanently resolve. My Experience: Sudden Power Loss While Towing The gravity of this part failure became clear during a recent drive. I configuration-matched this vehicle—a heavy-duty Yukon XL with a 6.2L engine and a 4x4 towing package—specifically for its capacity to safely haul heavy loads. While traveling with a trailer attached, the vehicle experienced a sudden, catastrophic loss of engine power. Without warning, the engine sputtered and died. Had this occurred on a steep incline, a blind curve, or in heavy highway traffic, a catastrophic multi-vehicle collision would have been entirely unavoidable. Critical Safety Hazards and Concerns •Inability to Maintain Speed, Loss of Vital Assist Systems, & Compounded Towing Risks Systemic Failure and Inadequate Remediation What makes this situation entirely unacceptable is that this specific vehicle was already subject to previous GM safety campaigns regarding this exact component (including Safety Recall #N212332040 and subsequent Emission Recall #N252516900). GM is fully aware that their supplier produced defective modules that are prone to premature internal short-circuits. Yet, their remediation strategy has been entirely inadequate. By managing this through piecemeal, phased rollouts and limited VIN inclusion lists, they are leaving dangerous vehicles on the road until the point of failure. Drivers are effectively acting as crash test dummies, waiting for their engines to die in dangerous environments before GM acknowledges that their specific VIN was fitted with the defective supplier part.

NHTSA ID

11748033

Incident

Jun 28, 2026

The contact owns a 2021 GMC Yukon XL. The contact stated that while starting the vehicle, the engine stalled and the vehicle failed to start. The check engine warning light was illuminated. The vehicle was towed to an independent mechanic, who determined that the fuel pump power control module needed to be replaced. The vehicle was not repaired. The contact related the failure to NHTSA Campaign Number: 21V739000 (Fuel System, Gasoline); however, the VIN was not included in the recall. The manufacturer was made aware of the failure and advised the contact to file a complaint with the NHTSA Hotline. The failure mileage was approximately 59,000.

NHTSA ID

11744517

Incident

Jun 15, 2026

Mileage

59,000 mi

Check engine light comes on and an alert says "acceleration reduced" dealer says the coolant control valve is bad but the engine never overheats but the fans are running max speed 100% of the time.

NHTSA ID

11743664

Incident

Jun 11, 2026

The vehicle suddenly began vibrating noticeably when idling and at low speeds. About 30 minutes after this started happening a warning lamp lit up. We drove the vehicle about 2 miles to a local auto parts store to get an initial computer diagnosis of the issue. The test resulted in a code of "P0304" which detected a cylinder #4 misfire and recommended a fuel injector replacement. We brought the vehicle to a local mechanic to get the issue further evaluated. After this evaluation, it was determined that the cylinder #4 misfire was related to a lifter failure. The mechanic explained that this situation could possibly have caused more damage, specifically to the camshaft, but that job was bigger than he was willing to take on. He recommended we get the vehicle towed to the dealership for further evaluation. He also informed us that this situation was common with the engine in this vehicle and GMC is aware of it. He directed us to some articles online that elaborated on the potential known issues related to the automatic fuel management (AFM) system and the related engine damage. The vehicle was towed to a local GMC dealership for evaluation. They found the failed cylinder #4 with associated lifter failure and damaged camshaft. We went forward with the repair at the dealership. We asked the dealership about the known engine issues with this vehicle. They acknowledged the widespread issues but informed us that our particular VIN has not been included in any recalls or safety notifications, so we were responsible for the repairs. The vehicle spent nearly 3 weeks at the dealership. One of the parts was on backorder due to a national shortage, which delayed the repair by about one week. That seems to imply that the parts involved in this repair are in high demand, which raises the question of this being a manufacturing/parts issue that may need to be investigated further.

NHTSA ID

11739769

Incident

Apr 28, 2026

The vehicle drove normally earlier in the day with no major drivability concerns. Later, reverse gear suddenly stopped functioning and the engine would rev abnormally without the vehicle moving properly while in reverse. Shortly afterward, while driving, the vehicle displayed the warning message “Reduce Acceleration – Drive with Care” and began losing acceleration and propulsion. The vehicle would not accelerate normally and later could not exceed approximately 20-35 MPH. The condition created a significant safety concern due to sudden loss of acceleration and propulsion while operating in traffic. The engine RPM would increase abnormally while the vehicle failed to respond properly in drive and reverse. An independent mechanic inspected the transmission and found diagnostic trouble codes P0747, P0776, and P0700 related to transmission pressure control and valve body operation. Inspection also revealed significant metal contamination, sludge, and clutch material inside the transmission pan and filter. Reverse and 2nd gear were determined to be failed/burnt internally. The vehicle was later transported to an authorized GMC dealer for inspection. Dealer confirmed reverse gear would not engage even after adding transmission fluid. Vehicle is currently available for inspection.

NHTSA ID

11737062

Incident

Apr 28, 2026

*gas tank had become partially dislodged from the undercarriage. *Entire family was in vehicle at time of incident, including three small children. The safety of an entire family along with any others that may have been on the road, if the car would have combusted due to the gas tank which had just been filled to capacity. *vehicle has been at Mark Christopher GM dealership for over one month. *dealership service dept claims someone tried to steal gas tank. *Mercury insurance company claims mechanical failure. *No warning given from vehicle. We heard a dragging noise while we were driving, pulled over as soon as possible. Upon inspection, it was observed that fuel tank had begun to leak fuel from dragging on the freeway.

NHTSA ID

11736218

Incident

Apr 3, 2026

The vehicle experienced a major engine failure involving the 6.2L engine. The failure appeared sudden and premature and is not consistent with normal wear and tear for a vehicle of this type. Prior to the failure, there were intermittent performance concerns and warning indicators suggesting potential engine or drivetrain issues. The vehicle had previously undergone repair related to similar concerns, indicating a possible recurring problem. The failure created a potential safety risk due to the possibility of loss of power while driving, which could increase the risk of an accident, especially at highway speeds or in traffic. The issue has been confirmed by a service provider, and the vehicle requires significant repair. General Motors has been notified but has declined repair assistance, classifying the issue as wear and tear. While no active recall is currently associated with this specific vehicle, similar vehicles with the same engine platform have documented issues, raising concerns about reliability and safety. The failed components are available for inspection upon request.

NHTSA ID

11731580

Incident

Feb 12, 2026

March 29th 2026 my 2021 Yukon XL engine stalled while driving at 45mph (No prior warning lamps or messages, restart engine came on dash) causing me to immediately pull over and come to a stop still in traffic, it shifted my vehicle into park, I was in an in an un-safe spot and was stuck in park (conditions not correct for shift on dash) because my vehicle would not allow me to shift to neutral and push it to the side of the road, (could not jump start) Had towed to dealership and mentioned Engine Failure and Fuel pump control module Recalls but according to them it was a starter issue, I asked them to still check the fuel pump control module regardless. Picked up vehicle and a week later April 14th the exact same thing happened vehicle stalled while driving dash said Restart Engine while coasting (No prior warning lamps or messages) forcing me to pull over where it rolled to a stop and locked itself into park leaving me in unsafe conditions again. Had towed back to the same dealership and waiting to hear back from them.

NHTSA ID

11731169

Incident

Mar 29, 2026

While driving on a two lane road, my vehicle put itself into Neutral without me doing anything and the engine stopped. All things powered down. The engine stopped. not propulsion, nothing. I tried to pull over to edge of road. Car would not start - no activity. The vehicle had to be towed to the dealership. My safety was put at risk by my car simply stopping while driving down the road. The dealership has confirmed the engine needs to be replaced. There was no warning of engine problems or ANY indicators.

NHTSA ID

11707473

Incident

Dec 15, 2025

I'm vehicle has experience both active recalls for similar model year but my VIN isn't listed as been one that is covered by the call. 25V274000 and 21V739000.

NHTSA ID

11704023

Incident

Dec 7, 2025

My 2021 GMC Yukon XL Denali is part of the April 2025 recall for the 6.2L V8 engine defect. The dealership confirmed the engine must be replaced, but the part is on backorder, potentially for several months. In the meantime, GMC only authorized a GMC Acadia as a courtesy vehicle. The Acadia is not comparable to our Yukon XL. We are a family of six, and while the Acadia has a third row, there is almost no cargo space with it in use. Our Yukon XL has over three times the cargo capacity, which is necessary for safely transporting luggage and sports equipment during our frequent trips (2–3 times per month). Because of this, we have already been forced to rent a larger SUV at our own expense for a recent trip. GMC’s Courtesy Transportation Program states that owners should receive comparable transportation during recall repairs. Despite escalating through the dealership, GMC Customer Assistance, and even the regional manager, we were denied a comparable loaner or guaranteed rental coverage. This leaves our family in an unsafe and impractical situation while waiting months for the recall repair.

NHTSA ID

11684664

Incident

Jul 24, 2025

Fuel pump power control module failed while driving. This part was included in a recall in 2021 but our VIN appears to not have been impacted.

NHTSA ID

11682320

Incident

Aug 16, 2025

Vehicle stalled while driving and would not turn back on. I had to have it towed over 45 minutes.

NHTSA ID

11678442

Incident

Jun 24, 2025

The contact owns a 2021 GMC Yukon XL. The contact stated that while driving approximately 55 MPH, the vehicle decelerated and stalled. During the failure, the check engine warning light was illuminated, and the vehicle was pulled over to the shoulder of the roadway. The vehicle was towed to the local dealer, who diagnosed and determined that the fuel pump control module had failed and needed to be replaced. The vehicle was not yet repaired. The manufacturer was notified of the failure, but no assistance was offered. The contact was informed that the VIN was not included in the NHTSA Campaign Number: 21V739000 (FUEL SYSTEM, GASOLINE). The contact stated that the vehicle had experienced the failure listed in the recall. The failure mileage was 80,000.

NHTSA ID

11674970

Incident

Jul 19, 2025

Mileage

80,000 mi

I was driving home from a long trip and heard a large pop. Several warning signs and messages began popping up and the vehicle was shaking and struggling to maintain speed. I was able to get home and get my family out of the vehicle and get it to a dealer down the road. They stated the Fuel injector and harness had failed.

NHTSA ID

11669733

Incident

Feb 15, 2025