2023 GMC Yukon Xl Fuel system Problems

On July 14, 2026, I experienced a serious fuel system failure with my 2023 GMC Denali. That morning, I filled the vehicle with a little over 20 gallons of fuel at a gas station approximately two miles from my home. Later in the day, I made a short trip to my neighborhood swimming pool, roughly 1.5 miles round trip, with no unusual noises or warnings from the vehicle. Approximately two hours after returning home, I entered the vehicle to run an errand. When I shifted into reverse and began backing out of my carport, I immediately heard a scraping noise on the concrete. I stopped the vehicle and inspected underneath. At that point, I discovered that the entire fuel tank had fallen out of the vehicle and was resting on the ground. I contacted roadside assistance, and the vehicle was towed to the dealership. The dealership informed me that the fuel tank support straps were missing, which allowed the tank to detach and fall. I personally searched along all the routes I had driven earlier that day and did not locate any straps or debris. The tank itself showed no impact damage, suggesting it dropped cleanly rather than being torn loose by road contact. Although the vehicle is relatively new, my bumper to bumper warranty expired in September 2025, and I was charged for the repair. I have included photos taken before and during the tow, as well as the dealership’s invoice. I am extremely concerned about the safety implications of this failure. If the tank had fallen while I was driving at interstate speeds (approximately 70 mph), it could have caused a catastrophic fire hazard, loss of vehicle control, or danger to other motorists. I do not know how long the vehicle had been operating without fuel tank straps, nor why there were no warnings or indications of a structural issue. I also question why the dealership did not treat this as a manufacturing or assembly defect, given that fuel tank straps should not detach under normal use. ...RAN OUT OF CHARACTERS...

NHTSA ID

11752614

Incident

Jul 14, 2026

The car just died while going 55mph on the highway. Complete shutdown but luckily both the steering and brakes worked. After stopping it wouldn’t start again. I had my three children in the car aged [XXX], [XXX], and [XXX]. It was a horrific experience. GMC did some repairs to the engine that took over two months and then the car had a few more warnings pop up just a few weeks later. GMC now says there is a misfiring in one of the positions. I’m terrified of driving this car with my children as I don’t know when it will shut off again and how bad it will be! INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ID

11752591

Incident

Dec 12, 2025

The vehicle has the L87 GM engine. It lost complete power and the engine seized up and would not start again. Fortunately I was able to roll into a neighborhood and get off the main road with no issues. The dealer has confirmed the seized engine and a replacement engine has been ordered with no ETA. There was no prior warning of the failure, besides a shuddering, like I was running out of gas, and then a lose of complete power.

NHTSA ID

11728101

Incident

Mar 22, 2026

2023 GMC Yukon XL 6.2L V8 experienced progressive engine defects starting in first year. At 7,445 mi (Jan 2023), first dealer visit for engine issues. At 10,315 mi (Apr 2023), Cyl 2 fuel injector failed (internally open), vehicle TOWED to dealer, replaced under warranty. At 14,982 mi (Aug 2023), identical Cyl 7 injector failure (internally open), replaced under warranty. Two identical failures on different cylinders within 15,000 mi indicates systemic defect. By 30,409 mi (Aug 2024), dealer performed engine decarbonization due to carbon buildup from fuel injection issues. Dealer recommended additional decarbs at 38,077 mi and 42,577 mi. At 56,028 mi (Mar 2026), engine suffered catastrophic failure: piston ring failure causing excessive oil consumption and engine destruction, requiring full engine replacement. This matches GM's known 5.3L/6.2L V8 piston ring defect (subject of $150M class action settlement). Defective injectors caused incomplete combustion, carbon buildup on piston rings, ring tension loss, and catastrophic engine failure. Vehicle also has unfixed suspension defect (camber bolt/alignment). Vehicle visited dealer 8+ times. Engine failure poses serious safety risk from sudden power loss at highway speeds. Vehicle available for inspection.

NHTSA ID

11726556

Incident

Mar 6, 2026

High pressure fuel pump housing failed and filled the cabin with fumes. Rendered the the Yukon unsafe to drive with fuel flooding the engine compartment. Took the dealer 57 days to repair the car. No warning lights, only indication was the fumes in the cabin.

NHTSA ID

11725722

Incident

Dec 26, 2025

My vehicle was one of the vehicles that was subject to the engine failure recall by GM. I took it to the dealership for the “repair“ where I was told the oil was changed to a different weight. Last night, I was driving down the road and all of a sudden my car just stopped. It still had power, but the engine had stopped. I tried to restart was unable to.

NHTSA ID

11722641

Incident

Mar 6, 2026

Good afternoon, My 2023 GMC Yukon XL AT4 with the 6.2L L87 engine (approx. 61,000 miles) suffered a sudden and complete engine failure at highway speed while I was driving between Canton, OH, and Columbus, OH, on the expressway, returning to my home in Cincinnati. There was no warning before the engine lost all power and propulsion. I was traveling in the left lane of the interstate in moderately heavy traffic. When the engine shut down, I only had steering and braking available to me. In addition to losing all propulsion, I also lost all electronics, and there was no shoulder. The complete dashboard shut down. The only reason there was not a collision was that the traffic around me could see what was happening and slowed down themselves. I coasted on through the onramp and found a shoulder where I had three lanes of traffic on my left and two lanes on my right. Less than two months before this incident, the vehicle had been inspected and serviced by an authorized GM dealer, and no engine issues were identified. I was given no indication that the engine was at elevated risk of failure. After the breakdown, GM and the dealer determined that the failure falls under GM Safety Recall N252494002 / NHTSA Campaign 25V274000, which involves internal engine defects in the 6.2L L87 that can cause a loss of propulsion in certain GM trucks and full‑size SUVs widely used as family vehicles. GM is replacing the engine, extending the warranty, and providing a loaner, but this does not change the fact that my family was exposed to a serious safety risk, nor does it address the possibility that other owners may experience sudden loss of propulsion even after their engines “pass” dealer inspection. I am submitting this complaint so NHTSA is aware that a recalled 6.2L L87 engine, inspected shortly beforehand, still failed without warning at highway speed in a primary family‑hauler vehicle, creating a dangerous situation. Regards, [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(

NHTSA ID

11711753

Incident

Dec 6, 2025

It has been several months since recall on L87 was issued. My truck now has over 44k miles and I’ve contacted the dealer, they note there’s no fix in sight. I’ve been having some issues with engine sluggishness on acceleration at times and I’m concerned this is related to the recall. I’m now stuck with this potentially dangerous vehicle with no fix, and am concerned. I also can’t get a fiar trade in value due to open recall. Overall, I’m stuck with a defective vehicle that GM refuses to address.

NHTSA ID

11679453

Incident

Aug 1, 2025

Vehicle surged, lost all power while driving, switched to neutral and would not restart.

NHTSA ID

11666413

Incident

Jun 10, 2025

Vehicle was traveling on interstate and lost power/propulsion and automatically shifted to neutral. Grave danger for eminent death/injury as a result of possible accident.

NHTSA ID

11666176

Incident

Jun 7, 2025

I own a 2023 GMC Yukon Denali XL (VIN: [XXX] ) currently under active recall for the L87 6.2L engine. GM has no remedy available and has acknowledged a risk of complete engine failure and loss of propulsion, which could occur without warning. This is the primary vehicle I have for transporting my family of seven, including a toddler. I am significantly upside down on the loan, and the dealership cannot guarantee it is safe to drive. I am requesting that NHTSA escalate the urgency and hold the manufacturer accountable for timely resolution or replacement.” INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ID

11665392

Incident

May 29, 2025

I’ve inserted the question and their answer: What component or system failed or malfunctioned, and is it available for inspection upon request? Lifter valve number six failed causing it to shatter and send pieces of it throughout the engine along with other debris into the cylinders. How was your safety or the safety of others put at risk? Vehicle had loud engine knock, pulsation of power, had to pull off on main highways due to loss of power over 400 miles away from home. Has the problem been reproduced or confirmed by a dealer or independent service center? Yes, engine was serviced by GM dealership in Baldwinsville, NY for over $8,500. Will attach copy of bill. Now is doing same thing, again. Has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others? GM as stated above. Were there any warning lamps, messages or other symptoms of the problem prior to the failure, and when did they first appear? Check engine light flashed, traction control light came on.

NHTSA ID

11661614

Incident

Feb 5, 2025

While driving at approximately 30 mph in moderate traffic on the interstate during a return leg of a 370-mile trip, my vehicle unexpectedly shifted into neutral and became unresponsive. The dashboard displayed the warning message: "condition not correct for shift," and despite repeated attempts to restart the engine, the vehicle would not engage. Although the electrical system remained active, I had no propulsion. Critically, the vehicle became immobilized in a **very dangerous curve on the interstate**, presenting an extreme safety risk to myself and others. The car could not be manually shifted into neutral for towing, prompting Illinois Department of Transportation (IDOT) to declare the location unsafe. I was stranded there for over three hours, after dark, in a vulnerable and exposed position. During the forced tow process, two rear tires were destroyed and the two front tires sustained major damage. In the days leading up to this incident, the vehicle had also shown signs of malfunction, such as delayed acceleration from a stop and occasional lurching forward — symptoms consistent with the defect described in the recall.

NHTSA ID

11659663

Incident

May 2, 2025

I am formally requesting a complete refund for my vehicle. It has only 6,300 miles, and the remedy provided for the recall does not adequately address the issue. The recall explicitly indicates defects in the engine components (rods/cam shafts) that may lead to a loss of propulsion. Merely inspecting the vehicle and adding thicker oil does not resolve the underlying problem; it only postpones the inevitable expiration of my warranty. Currently, there are no warning lights illuminated, as the vehicle is not driven frequently. The recall raises significant concerns, and GM should be taking more substantial measures than simply applying thicker oil as a solution. This approach feels like a temporary fix rather than a genuine resolution. I have communicated with the dealership, and have been informed there is currently no solution available for this matter. They are awaiting further instructions on how to proceed. I request a more thorough investigation into this issue for an appropriate refund, and I also wish to have this matter documented for future reference.

NHTSA ID

11657745

Incident

Apr 25, 2025

I am writing to express serious safety concerns regarding our 2023 GMC Yukon XL Denali, which has been in our possession for less than two years and has only 24,000 miles. On multiple occasions, while driving at high speeds on the freeway with our four young children, the vehicle unexpectedly lost power and shifted into neutral without warning. This occurred approximately four times on March 9, 2025, when we contacted OnStar for assistance. Despite their response indicating no alerts on their end, we were advised to reach out again if the issue persisted. Unfortunately, the problem did occur again on March 16th, which prompted us to contact OnStar and have the vehicle towed to the nearest dealership for further evaluation. The service department has since informed us that the motor requires replacement. Upon conducting additional research, it seems this may be a known issue with many vehicles manufactured by GM around the same time. We are deeply concerned by this safety hazard, especially given that the malfunction could have led to a life-threatening accident. While we are grateful that we were fortunate enough to avoid any serious consequences, we believe a solution beyond standard repairs is necessary to restore our confidence in the safety of this vehicle. Our family’s well-being and trust in the reliability of our vehicle are of the utmost importance.

NHTSA ID

11649127

Incident

Mar 9, 2025

Our 2023 GMC Yukon XL Denali that has suffered multiple severe mechanical failures well beyond what is reasonable for a vehicle of this class. G At approximately 14,000 miles, the vehicle’s 6.2L engine catastrophically failed, rendering it inoperable and requiring a full engine replacement. The engine seized and failed while operating the vehicle with her 3 small children on board and nearly caused a catastrophic accident. As a result, the vehicle was out of service for eight weeks, an unreasonable disruption and an unacceptable failure for a luxury SUV of this caliber. Now, (02/11/2025) at just 20,400 miles, the vehicle’s injectors have failed, further reinforcing that this vehicle is defective, unreliable, and unfit for continued ownership. This vehicle was purchased with the expectation of owning a dependable, high-performance SUV—not one plagued with major mechanical failures at such low mileage. The repeated, severe defects have substantially impaired the vehicle’s use, value, and safety, leaving use without reliable transportation for extended periods. Given these circumstances, it is clear that this vehicle does not meet the quality and durability standards expected from General Motors’ flagship SUV lineup and present SERIOUS risks of catastrophic injuries and/or death.

NHTSA ID

11641951

Incident

Feb 11, 2025

The contact owns a 2023 GMC Yukon. The contact stated while the vehicle was parked, the vehicle shuddered. The "Service Traction Control" and the "Forward Collision System Unavailable" message was displayed on the instrument panel. The check engine warning light was illuminated. The failure occurred on several different occasions. The vehicle was taken to a dealer where it was diagnosed that the fuel injector needed to be replaced. The vehicle was repaired however, over time the failure still persisted. The vehicle was taken back to the dealer where it was diagnosed once again that the fuel injector needed to be replaced. The vehicle was repaired however, over time the failure still persisted. The vehicle was taken back to the dealer for the last time where it was diagnosed once again that the fuel injector needed to be replaced. The vehicle was repaired however, over time the failure still persisted. The manufacturer was notified of the failure. The failure mileage was unknown.

NHTSA ID

11637294

Incident

Feb 1, 2024

Driving at 70 mph, the vehicle shifted into neutral without warning. When attempting to place the vehicle back into drive, the vehicle dashboard Siad "vehicle condition not met" . I slowed the car and pulled over. It shifted into park but now will not start and will not go into neutral for towing.

NHTSA ID

11592952

Incident

Jun 6, 2024