2002 Honda CR-V Fuel system Problems

NO AIR BAG

NHTSA ID

11176061

Incident

Feb 6, 2019

THE COATED FUEL LINE UP NEAR THE FUEL TANK RUSTED FROM INSIDE OUT YET THE REST OF THE FUEL LINE ESPECIALLY THE PART EXPOSED TO THE ROAD DEBRIS AND SALT WAS PRISTINE CONDITION. THE FUEL BEGAN SPILLING WHILE DRIVING AND WE NOTICED IT WHEN WE WENT TO PARK THE CAR IN THE DRIVEWAY - LOSING ~ 1 L/MIN..

NHTSA ID

10956181

Incident

Jan 29, 2017

Mileage

132,973 mi

WHEN I TURNED IGNITION TO START ENGINE, THE CAR SUDDENLY STARTED TO REV ERRATICALLY WITH RPM RANGING UP TO 5K+. MY FOOT WAS ON THE FLOOR NOT ON BRAKE OR GAS PEDAL. CRUISE CONTROL WAS OFF. FLOOR MAT WAS FAR FROM GAS PEDALL. THE CAR WAS ON PARK PLUS HAND BRAKE WAS ON. MY WIFE AND I BOTH WERE DUMBFOUNDED FOR COUPLE OF SECS THEN I FINALLY TURNED OFF THE IGNITION. WAITED A COUPLE OF SECONDS AND CAR RESTARTED FINE. INCIDENT DID NOT RECUR. CAR WAS IN GARAGE.

NHTSA ID

10785817

Incident

Oct 24, 2015

Mileage

98,000 mi

TL* THE CONTACT OWNS A 2002 HONDA CR-V. THE CONTACT WAS DRIVING APPROXIMATELY 55 MPH WITH THE AIR CONDITIONER ACTIVATED WHEN SUDDENLY, WARM AIR BEGAN TO CIRCULATE THROUGHOUT THE VENTS. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER WHO STATED THE AIR CONDITIONER COMPRESSOR WOULD NEED TO BE REPLACED. THE VEHICLE HAD NOT BEEN REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE PROBLEM. THE APPROXIMATE FAILURE MILEAGE WAS 75,000. ALSO, THE CHECK ENGINE LIGHT HAS BEEN COMING ON AND GOING OFF, SINCE THE VEHICLE WAS PURCHASED IN 2002. THE DEALER INFORMED THE CONSUMER THERE WAS A CRACK AT THE TOP OF THE FUEL TANK. UPDATED 07/17/14 UPDATED 03/10/16.*JB

NHTSA ID

10471148

Incident

Jul 16, 2011

Mileage

75,000 mi

SINCE I BOUGHT CRV (USED), IN SEPTEMBER 2011, MY GAS GAUGE HAS BEEN INACCURATE. *TR

NHTSA ID

10467729

Incident

Oct 19, 2011

MY FUEL GAUGE IS NOT ACCURATE: IF THE TANK DROPS TO HALF FULL, THE GAUGE IS UNRELIABLE AND OFTEN REGISTERS MORE OR LESS GAS THAN THERE IS. USUALLY THERE IS LESS GAS THAN THE GAUGE REGISTERS, BUT I'VE FILLED UP THE TANK UNTIL THE TANK CLICKED, AND THE GAUGE STILL READ 3/4 FULL. I'VE BEEN BROWSING ON SOME ONLINE FORUMS, AND THIS SEEMS TO BE A COMMON PROBLEM WITH THE 2002 CRV. ON THIS SITE, IT LOOKS LIKE 8 DIFFERENT PEOPLE WITH 2002 HONDA CRVS HAVE POSTED THE SAME COMPLAINT: HTTP://WWW.TOPIX.COM/FORUM/AUTOS/HONDA-CR-V/TPHIOAURAC0I3T5O3 THIS IS A SAFETY HAZARD FOR ME BECAUSE I LIVE IN WI, WHERE TEMPERATURES COMMONLY REACH BELOW ZERO IN THE WINTER! I COMMUTE 50 MINUTES USING A COUNTRY ROAD, AND I COULD LITERALLY FREEZE IF MY GAS GAUGE IS UNRELIABLE, AND I THINK THAT I HAVE MORE GAS THAN I HAVE. (THERE ARE NO PUBLIC PAY PHONES ON MY ROUTE, AND THERE AREN'T ALWAYS HOUSES WITHIN WALKING DISTANCE.) THIS COULD, OF COURSE, ALSO BE A PROBLEM FOR ANYONE DRIVING ON THE FREEWAY WHO RUNS OUT OF FUEL DUE TO A FAULT GAUGE/SENDING UNIT. I TOOK IT TO A DEALER IN MADISON, WI, AND THE DEALER SAID THAT THE ESTIMATED COST WAS $450+ FOR PARTS AND LABOR. HELP! DO THE RIGHT THING, HONDA, AND ISSUE A RECALL IF THIS IS A KNOWN PROBLEM. IT DOES SEEM TO BE A FLAW IN THE MASS-PRODUCED COMPONENT, NOT JUST INDIVIDUAL QUIRK OF ONE CAR/DRIVER. *TR

NHTSA ID

10457730

Incident

Jul 1, 2011

Mileage

110,000 mi

I OWN A 2002 HONDA CR-V. THE GAS TANK CAP HAS CAUSED MY CHECK ENGINE LIGHT TO COME ON SEVERAL TIMES IN THE PAST. EACH TIME, I BUY A NEW GAS CAP AND THE ERROR GOES AWAY. I AM ON MY 3RD GAS CAP AND I'M GETTING A CHECK ENGINE LIGHT AGAIN. I WILL CALL HONDA TO REPORT THIS ISSUE AND TO REQUEST A REAL "FIX" TO THE PROBLEM. AS STATED BY OTHERS, THE CHECK ENGINE LIGHT IS A WARNING TO DRIVERS. IT'S IMPORTANCE IS WATERED DOWN BY SPURIOUS ERRORS LIKE THIS. HONDA NEEDS TO ADDRESS THIS. *TR

NHTSA ID

10329905

Incident

May 10, 2010

Mileage

154,000 mi

MY FILLER CAP ALSO LOOSENS BY ITSELF AND CAUSES THE CHECK ENGINE LIGHT TO GO ON. I AM ON MY 3RD CAP AND CONTINUE TO HAVE SPORADIC PROBLEMS WITH IT LOOSENING ON ITS OWN. WHEN THE CHECK ENGINE LIGHT GOES ON, I GET OUT OF THE CAR AND SURE ENOUGH THE CAP IS LOOSE. IT TAKES A COUPLE OF DAYS FOR THE COMPUTER TO RESET ITSELF AND THE ENGINE LIGHT TO GO OFF. VERY ANNOYING. *TR

NHTSA ID

10325155

Incident

Apr 12, 2010

MY 2002 HONDA CR-V HAS A FUEL FILLER DEFECT WHICH CAUSES THE "CHECK ENGINE" LIGHT TO COME ON. CHANGES IN TEMPERATURE OR OTHER WEATHER RELATED FACTORS CAUSE THE FILLER CAP TO LOOSEN AND THE LIGHT COMES ON. HONDA RECOMMENDS MANUALLY TIGHTENING THE CAP PAST "SEVERAL CLICKS" TO ENSURE A TIGHT SEAL AFTER FUELING. THE CAP LOOSENS ANYWAY ACCOMPANIED BY STRONG GASOLINE FUMES FROM THE LOOSENED CAP. HONDA KNOWS OF THE PROBLEM. THEY REPLACED THE FUEL CAP TWICE AND ONCE GAVE ME A $ 300 ESTIMATE TO REPLACE THE PLASTIC GAS TANK FILLER PIPE WHICH IS APPARENTLY THE ROOT CAUSE OF THE PROBLEM. TODAY WAS A WARM DAY AND THE LIGHT WAS ON ALL DAY AS I DROVE. THE ISSUE IS THIS: IF THE CHECK ENGINE LIGHT OFTEN COMES ON SPURIOUSLY, A DRIVER DOESN'T PAY ATTENTION TO WHAT MAY BE A LEGITIMATE WARNING FOR A SERIOUS ENGINE PROBLEM THAT COULD HAVE SAFETY IMPLICATIONS. IN ADDITION, THE LOOSE CAP CAUSES GASOLINE FUMES TO ENTER THE PASSENGER COMPARTMENT. HAVE THERE BEEN OTHER COMPLAINTS ABOUT THE FILLER CAP ISSUE? *TR

NHTSA ID

10324906

Incident

Apr 10, 2010

Mileage

120,000 mi

REPEATED MECHANICAL FAILURES OF THE 2002 HONDA CRV THAT I BOUGHT BRAND NEW HAVE BEEN OCCURRING SINCE AUGUST OF 2002. THE CAR WAS BOUGHT IN JULY OF 2002. THE ODOR FROM THE INSIDE CABIN FILTER FIRST OCCURRED IN AUGUST. THE FUSE TO THE WARNING DEVISE THAT WOULD ALERT THE DRIVER TO LIGHTS BEING LEFT ON, ETC. WENT OUT WITHIN 3-4 MONTHS. THEN MAJOR ITEMS WHICH HAD TO BE REPLACED: DIFFERENTIAL, 2004(THOUGH STILL UNDER WARRANTY, HONDA REFUSED TO REPLACE IT FOR 2 YEARS), NECK OF FUEL TANK BROKE, 2006, AIR CONDITIONING SYSTEM, 2007, DRIVER-SIDE WINDOW FELL OFF TRACK BECAUSE THE PLASTIC CLAMP CRACKED, 2008, CATALYTIC CONVERTER, 2009, O2 SENSOR, 2009, DRIVER'S SEAT UNSTABLE SINCE 2003, SRS SLOWLY WENT OUT BEGINNING WITH INTERMITTENT WARNINGS ABOUT SIDE DOOR AIR BAG BEING TURNED OFF BEGINNING IN 2003 WHICH DEALERSHIPS IGNORED AS JUST AN OCCURENCE FROM SOMETHING OR SOMEONE BUMPING AGAINST THE CLOSED DOOR FROM THE INSIDE. FINALLY IN 2008, WHEN THE LIGHT CAME ON TO STAY, I WAS TOLD THAT IT WAS A FAILURE OF THE SENSOR MOTOR__NOW MY PROBLEM TO AGAIN PAY FOR A MAJOR REPAIR. *TR

NHTSA ID

10278555

Incident

Dec 4, 2008

Mileage

300 mi

IN JANUARY OF 2005 I ECNOUNTERED THAT MY GAS GAUGE INTERMITTENTLY DOES NOT GO TO FULL WHEN I FILL UP THE TANK IF THE GAS TANK WAS 1/4 FULL OR LESS. I BROUGHT THE CAR INTO THE HONDA DEALERSHIP THE FIRST TIME AND THEY COULD NOT FIND ANYTHING. I JUST GOT THE CAR BACK YESTERDAY, 3/23/2005, FOR THE SAME PROBLEM AND AGAIN NOTHING WAS DONE TO FIX THE PROBLEM. MY BIGGEST CONCERN IS THAT THE GAUGE WILL FAIL IN THE FUTURE WITH MY DAUGHTER USING THIS VEHICLE FOR COLLEGE. I DO NOT WANT HER TO RUN OUT OF GAS OR HAVE AN ACCIDENT ON THE HIGHWAY IF SHE RUNS OUT OF GAS DUE TO A DEFECTIVE GAS GAUGE READING PROBLEM.*AK

NHTSA ID

10114532

Incident

Jan 23, 2005

Mileage

32,500 mi

WHILE DRIVING AWAY FROM A RIVERSIDE CAMPSITE, TRIED TO STRADDLE SOME RUTS ON THE ACCESS ROAD. VEHICLE SLIPPED INTO THE RUTS AND BOTTOMED OUT SLIGHTLY, BUT I WAS STILL ABLE TO DRIVE OUT AND DID NOT GET STUCK. THE BRACKET DIRECTLY BEHIND THE GAS TANK ON THE UNDERCARRIAGE, WHICH HOLDS FUEL SYSTEM RELATED COMPONENTS, WAS ALMOST RIPPED OFF BY THIS MINOR CONTACT. IT IS THE LOWEST PART OF THE UNDERCARRIAGE AND VERY VULNERABLE TO DAMAGE WITHOUT ANY SORT OF PROTECTION. 2 OF 3 MOUNTS WERE RIPPED LOOSE, AND THE ASSEMBLY WAS BENT BACK TO RUB ON THE REAR AXLE AND HANG DOWN EVEN LOWER. THIS PROBLEM WAS REPORTED BY OTHER VR-V DRIVERS WHO HAD TO NAVIGATE DEEP SNOW AND SAND. SENSITIVE FUEL SYSTEM PARTS SHOULD NOT BE VULNERABLE TO DAMAGE IN THIS WAY! VEHICLE IS OUT OF WARRANTY. I WILL HAVE A CUSTOM MADE SKID PLATE AND MOUNTING BRACKET INSTALLED IF HONDA DOESN'T OFFER TO FIX FOR FREE WITH A NEW, SAFER DESIGN. *JB

NHTSA ID

10100365

Incident

Nov 8, 2004

Mileage

46,250 mi

ENGINE LIGHT KEEPS COMING ON & THEN CAR WILL DRIVE ROUGH. I HAVE TAKEN IT IN 3 TIMES ALREADY FOR SAME PROBLEM, THEY TOLD ME TO MAKE SURE GAS CAP IS ON TIGHT AND NOT TO OVER/UNDER FILL WITH GAS I HAVE BEEN DOING AS TOLD AND THE PROBLEM IS STILL PRESENT FOR THE 4TH TIME. CAR WAS PURCHASED ON AUGUST 2002.

NHTSA ID

10068973

Incident

Jun 15, 2003

Mileage

11,661 mi

WHILE DRIVING, FUEL PUMP WAS DISLODGED AND CAME IN CONTACT WITH TURNING AXLE. COULD HAVE RESULTED IN A FUEL LEAK AND VEHICLE FIRE. CONTACTED DEALERSHIP.*AKTHE BRACKET NEARLY CUT THROUGH THE PLASTIC FUEL CANISTER. LIGHT CONTACT WITH SAND WHILE DRIVING VEHICLE ON THE BEACH DISPLACED THE FUEL PUMP ASSEMBLY REAR WARD INTO THE REAR AXLE. *JG

NHTSA ID

8017167

Incident

Aug 25, 2002