Owner-reported complaints naming the fuel system system, filed with NHTSA
Data refreshed
Reports naming fuel storage or delivery — tanks, pumps, lines, injectors and fuel leaks. Every record below is an owner-reported complaint about the 2018 Honda Pilot submitted to NHTSA — not a confirmed defect, not a recall and not a manufacturer bulletin. 124 reports on file name it.
Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.
The 25 most recent of 124, in the owner's own words
Honda pilot would not restart after auto ideal engine stop. This issue caused all the warnings lights to come on with blinking engine light! Honda dealer was not able to resolve the issue and ended up paying $1500 even though it was a part of their service bulletin 23-009.
While driving down a freeway, my car shuddered and my engine suddenly lost power and was put into limp mode. Mechanic determined it was the high pressure fuel pump that failed. This vehicle was part of the recall for the low pressure fuel pump that was completed. It also had to have fuel injectors replaced under Honda’s extended warranty over faulty injectors.
Safety recall on 2018 Honda pilot fuel pump Honda dealership refuse to repair unless other repairs where done due to engine light on . I ask advisor who was helping me [XXX] to give me clarification on the reason his respond was i am just doing my job no other dealer will be able to help you Technician doesn’t want to proceed with repair due to engine light on , unless you do other repairs rough estimate amount $1851.64 I politely denied those services walk out contact another Honda dealer on May 28 2026 , I spoke to advisor Jennifer Cruz explain the situation set up an appointment for safety recall on fuel pump @ location 9055 Washington blvd , Culver City , Ca 90232 [XXX] Repairs will be done by 3pm on May 29 2026 , Jennifer Cruz was really helpful and apologized for my bad experience with previous Honda dealership INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
The contact owns a 2018 Honda Pilot. The contact stated that while driving 80 MPH, the vehicle decelerated and stalled while depressing the accelerator pedal. Several unknown warning lights were illuminated. Neither an independent mechanic nor a dealer was contacted. The contact was able to pull over to the right side of the road, depressed the brake pedal, and turned off and restarted the vehicle after several seconds, and the vehicle operated as intended. A dealer was contacted. The vehicle was not taken to a dealer or an independent mechanic. The vehicle was not repaired. The contact associated the failure with NHTSA Campaign Number: 23V858000 (FUEL SYSTEM, GASOLINE); however, the VIN was not included in the recall. The manufacturer was not notified of the failure. The failure mileage was 82,000.
What component or system failed or malfunctioned, and is it available for inspection upon request? The vehicle’s high-pressure fuel pump failed approximately one year after the low-pressure fuel pump was replaced under a manufacturer recall. The low-pressure pump had been identified as defective and replaced accordingly. Because the low-pressure pump is responsible for supplying fuel to the high-pressure pump, it is reasonable to believe the defective component may have placed abnormal stress on the high-pressure fuel pump prior to its replacement, potentially leading to premature failure. The failed high-pressure fuel pump is still in the vehicle. How was your safety or the safety of others put at risk? Failure of the high-pressure fuel pump can result in a sudden loss of fuel pressure to the engine, causing hesitation, loss of power, or engine stalling while the vehicle is in operation. This created a significant safety hazard, particularly as it occurred during highway driving, where sudden loss of propulsion occurred. Has the problem been reproduced or confirmed by a dealer or independent service center? The issue was diagnosed and confirmed by a service center as a failed high-pressure fuel pump. Has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others? The vehicle was inspected by my personal mechanic who indicated fuel pump issues and noted recall then a Honda dealer during diagnosis but recall was for previously replaced low pressure pump and not the High pressure pump the issue has yet to be repaired. Were there any warning lamps, messages or other symptoms of the problem prior to the failure, and when did they first appear? Prior to the failure, the vehicle began experiencing noticeable fuel system performance issues, including reduced engine performance loss of MPG and drivability concerns. No lamps
Driving to work on the freeway, all of a sudden acceleration stopped. Pulled over as warning lights came on due to transmission. Additionally, the check engine light appears randomly due to emission and also the “AWD” light comes on. Within a few days or even weeks it turns off. This has been on and off since we purchased the vehicle from CarMax.
[XXX] an Error Code "Emissions System Problem" came up. We brought to personal mechanic error code P0430 came up when they attached the code reader to the underside of the dashboard. Our mechanic told us we had to bring to Honda. Brought to Millenium Honda in NY, no code was in "system", they told us about recalls and fixed the recalls. We took the car on vacation and the light came on again while driving from NY to SC. Brought to Honda dealership to have looked at, code was off. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
My Honda Pilot 2018 is a modified vehicle with wheelchair ramp. It is in the recall list for Honda. Recall: swelling of fuel pump motor impeller, fuel pump may seize/stop working. Defective impeller may cause fuel pump inoperative, which could prevent engine from functioning. May cause a loss of motive power/stall while driving, increasing risk of crash or injury creating a safety hazard. -Replace the fuel pump motor. I contact the Honda dealer in San Jose, CA, but they were unable to perform Fuel Pump replacement due vehicle being modified. Tell me to find a dealer that specialize in accessible vehicle to removed cover on floor to access fuel pump then bring fuel pump to Honda for them to replace. DMV requires to perform recall to renew vehicle registration. I do not know which dealer I need to perform this recall.
The car is Less than 80,000 miles and all 6 fuel injectors are faulty and need replacing. As well as the fuel pump. Other Hondas have been recalled for the same issue but this make and model has not.
when honda service perfomed the recall repair on 12/12/2024. We notice that there is something wrong with the vehicle and we immediately report to Honda service and return the vehicle the following day for further diagnosis but the Honda service failed to resolved the issue until now. We spend out of pocket payment for their recommended repair @ parts replacement . With hopefull promises to resolved the issue but this resulted to more repairs and no guarantee in resolving the issue. And this delay of resolving the issue causing much more concern on our safety onto what will happened as this issue was not resolved
I did mentioned this recall when I got my car I am having issues with acceleration, fuel pump . Car takes a bit long to take offline
The contact owns a 2018 Honda Pilot. The contact received notification of NHTSA Campaign Number: 23V858000 (Fuel System, Gasoline); however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact stated that the issue had prevented her from renewing the vehicle registration in the State of California. The manufacturer was not made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.
The car unexpectedly sent out emissions failure systems warning Effecting the ability to accelerate without a pause in a forward movement. I had my mechanic diagnose the warning lights which indicate a connector rod issue. This diagnosis aligns with all of the symptoms. My mechanic warned me the engine could stop at any time. We will have the repair done this month. Honda put out a recall and stop production for this issue in March of 2024 but my car does not show up in the recall when I inquired to Honda about the issues I was experiencing. They basically said there is nothing for me to do.
The contact owns a 2018 Honda Pilot. The contact received notifications of NHTSA Campaign Numbers: 23V858000 (FUEL SYSTEM, GASOLINE) and 21V932000 (STRUCTURE, LATCHES/LOCKS/LINKAGES). The contact stated that the vehicle was at the dealer, pending the repairs. The dealer informed the contact that all 6 fuel injectors had failed and needed to be replaced. However, while diagnosing the vehicle, the diagnostic tool failed to retrieve any fault codes. The dealer refused to replace the fuel injectors. The manufacturer was not made aware of the issue. The failure mileage was approximately 72,100. Parts distribution disconnect.
Unfortunately, due to the extended delay in this repair, my vehicle has experienced significant mechanical problems, which I believe are directly related to the faulty fuel pump.Fuel Injector Contamination, Catalytic Converter Stress, Transmission Performance Issues
The "start/stop" function has always been an issue and also the response to acceleration. Luckily the start/stop failed at the mailbox in front of our home. The car shut off just like at a light but instead of picking back up upon acceleration, it completely died. We have had it shutter and slowly pick up in an intersection before but we have learned to really over exert the acceleration to complensate. We have had the fuel pump recalled but i dont think it fixed our problem. Luckily nobody has been hurt yet, but this is my wife and eight year old daugthers car. We have had multiple warning lamps "fixed" in the past, but there are currently no indicators on the dash.
Auto restart failed. Vehicle failed to move forward at a red light. Dash instructed to place vehicle on park then press the engine start-stop button hence restarting in the middle of the road presenting a safety hazard, cars behind me almost tail ending mine. People were honking and I couldn’t move fast enough. Why is the Honda dealer saying they will charge $222 to inspect to see if it’s a starter issue? Just fix the problem. I already had the system reset due to recall. This is a prevalent problem, shouldn’t it be inclusive to a recall. Also putting the customers at risk knowing its an issue is a huge problem. Please advise and help resolve this safety issue.
See attached document for complaint.
EVAP Error Code for the capless gas cap error. you have to super careful when filling your car up with gas. Honda needs to fix this defective capless gas tank system. It is too fragile and requires an immense amount of work to repair for a regular old Joe.
The contact owns a 2018 Honda Pilot. The contact received notification of NHTSA Campaign Number: 23V858000 (FUEL SYSTEM, GASOLINE); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.
I have had a recall that the dealer has renegged on helping me with. About a couple of years ago we scheduled appointments, we missed work, showed up at the appointments for our two cars, only to be told that the parts are on back order. We keep getting the same response over and over. The last time I called a couple of weeks ago, the service department hung up on me. I called back and asked to have the Service Manager call me. He did not return my call. I have left message for the general manager, and he has NOT returned my calls. I need my recall remedied. My vehicle sometimes hesitates to start and has acceleration issues.
The contact owns a 2018 Honda Pilot. The contact received notification of NHTSA Campaign Number: 23V858000 (Fuel System, Gasoline); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact stated that several attempts were needed to start the vehicle daily and that there was a loss of miles per gallon of fuel. The vehicle was not taken to a local dealer or independent mechanic. The vehicle was not diagnosed or repaired. The contact related the failure to NHTSA Campaign Number: 23V858000 (Fuel System, Gasoline). The failure mileage was approximately 69,000. Parts distribution disconnect.
The contact owns a 2018 Honda Pilot. The contact received notification of NHTSA Campaign Number: 23V858000 (Fuel System, Gasoline); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.
The contact owns a 2018 Honda Pilot. The contact received notification of NHTSA Campaign Number: 23V858000 (Fuel System, Gasoline) however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.
The contact owns a 2018 Honda Pilot. The contact received notification of NHTSA Campaign Number: 23V858000 (Fuel System, Gasoline) however, the part to do the repair was unavailable. The contact stated that the manufacturer exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.
Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.
Categories with enough reports to have a page of their own
Data on this page last refreshed .