2024 Hyundai Elantra Hybrid

We have had the car for 2 months and when I went out to start it the other day I noticed a large crack in the lower 1/3 of the windshield, starting at the edge/gasket of the passengers side and spreading horizontally all the way to the drivers side. There is no impact mark anywhere on the windshield leading us to believe it is a defect in the glass itself or it was not bonded properly when installed. The crack is directly in the line of sight of the driver and presents a safety hazard while driving. There were no warnings or rock chips prior to the crack showing up one morning. I have reached out to the dealer but have not received a response.

NHTSA ID

11753044

Incident

Jul 22, 2026

The vehicle experienced a catastrophic engine compartment fire while safely parked inside an employment parking garage in [XXX] on XXX, at approximately 3:04 PM. I was physically sitting inside the vehicle cabin when heavy smoke suddenly began pouring out from the engine bay. I immediately evacuated the vehicle for my safety. Within moments, the smoke escalated into an active, un-contained fire that completely consumed the vehicle. The local fire department responded to the scene to extinguish the blaze. The vehicle is a total loss. This safety incident occurred exactly one week after I received the official manufacturer safety recall notice by mail for Hyundai Recall 301 (NHTSA Campaign Number: 26V308000), which outlines an overheating transistor defect within the Hybrid Power Control Unit (HPCU) capable of causing a vehicle fire. The vehicle caught fire due to this exact un-remedied defect before I could realistically bring it to a dealership for the required safety software update. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ID

11750544

Incident

Jul 14, 2026

We lease 5 Hyundai 2024 Elantra Blue hybrids that were bought new a few months back. We have experienced the same issues with 3 of the 5 so far. Cars will STALL at low speeds and sometimes ENGINE LIGHT goes on. Cars will suddenly not accelerate after stopping at a stop sign. Extreme danger for our drivers who are transporting developmentally disabled clients to outings and shopping, etc. Hyundai REPLACED throttle body replacement but same issues reappeared 2 days after getting car back. Now, Hyundai is claiming the GPS units plugged in may be causing this, but other 2 are not experiencing this issue (2 of 5). They refuse to work on further unless GPS units are out, but customer needs GPS units per insurance. So we need help from Hyundai in dealing with the dealer Zimbrick East of Madison, WI. We need the vehicles, but don't want our employees at risk.

NHTSA ID

11627453

Incident

Nov 14, 2024

The car has an annoying picture of a coffee cup and tells me to consider taking a break followed by annoying beeps. This announcement happens every 5-10 minutes on the expressway regardless of who drives the car and if they are staying in the lanes. Hyundai took the way to disable this out of the menu this year and all the people in the car hear is annoying and distracting beeps on trips on the expressway

NHTSA ID

11608704

Incident

Aug 15, 2024

I received two emails from Hyundai Bluelink that "Vehicle battery level is below normal" late night 16 March 2024 shortly before midnight and several hours after I had parked my vehicle for the night. The car is less than two weeks old with less than 300 miles. After each email notice I checked my car and could not see any device or process which was drawing electrical power. By 10 am the next morning all electrical power to the car was gone and I needed a towing service to jump start my car. It appears the car battery spontaneously drained all its power through the night.

NHTSA ID

11577911

Incident

Mar 16, 2024

This bulletin provides information related to the navigation and head unit software changes introduced in the 2026 1st Navigation Map and Software Update. The changes may vary depending on vehicle type, model, and navigation system. Refer to the 2026 1st Navigation Map and Software Update Key Improvements and Additional Improvements tables in this TSB for a list of specific changes. The software can be downloaded via Navigation Updater (NAU) and updated by USB.

The National Highway Traffic Safety Administration (NHTSA) has issued an urgent safety advisory regarding dangerous, counterfeit driver‑side airbag inflators manufactured by Jilin Province Detiannuo Automobile Safety System Co., Ltd. (DTN), that have been identified in U.S. vehicles following prior crashes, theft, or non‑certified airbag replacements. These inflators are not approved for use, may rupture during deployment, and have caused serious injuries and fatalities. Please see attached announcement, provided by NHTSA, for more details.

The National Highway Traffic Safety Administration (NHTSA) has identified the presence of substandard and dangerous driver’s-side airbag inflators manufactured by Jilin Province Detiannuo Automobile Safety System Co., Ltd. (DTN). These inflators were not supplied, approved, or authorized by the vehicle manufacturers and have primarily been found in vehicles that previously experienced a crash and underwent airbag replacement using non-genuine parts. These dangerous inflators have ruptured during deployment, posing a serious risk of injury or death due to metal fragments entering the vehicle cabin. To date, Hyundai is aware of three people who have died while driving a Hyundai vehicle with one of these substandard replacement airbag inflators that deployed in what likely would have been a survivable crash. NHTSA has issued a public advisory urging vehicle owners and service professionals to have vehicles inspected if there is reason to believe that a non-genuine replacement airbag may have been installed. Vehicles with salvage or rebuilt titles, prior airbag deployments, or unknown repair histories may present a higher risk. NHTSA strongly cautions against self-inspection by vehicle owners and recommends inspection by trained technicians.

Some 2019MY and newer vehicles equipped with a front view camera may illuminate certain warning lights and trigger DTC C272246 fault code for the front camera. In the following cases, the front camera auto-calibration range may be exceeded while driving: • If the front camera is not properly installed and is completely or partially detached. • In case of excessive changes affecting the vehicle's balance (e.g., loading excessively heavy cargo in a specific location of the vehicle, or significant under-inflation of the tires). • Specific road conditions affecting the vehicle's balance (e.g., excessive road crown) This TSB provides instructions on how to service the vehicle when the front camera related warning light(s) are triggered due to system out of calibration (DTC_C272246).

Some Elantra (CN7/CN7A), Elantra N (CN7 N) and Elantra Hybrid (CN7 HEV) vehicles may experience the following conditions: • Lack of airflow coming from the forward-facing center vents • Mode actuator not changing airflow direction after various inputs • Popping/snap noise when switching between different modes If any of the conditions above exist, follow the repair procedure in this bulletin to replace the ventilator lever and cam mode guide.

This bulletin provides information regarding condensation related to the accumulated moisture in the headlamp, rear combination lamp, daytime running lamp (DRL), or fog lamp. This TSB illustrates the various causes of condensation inside the lamp assembly. Lamp assembly replacement is NOT necessary in most cases. This condition can be eliminated by turning on the lamps with the engine running for several minutes or during normal driving operation.