2008 Hyundai Entourage Problems

THIS THE 2RD TIME MY. REAR SLIDING DOOR FLEW OPEN WHILE ON HIGHWAY WITH MY GRANDKIDS IN THE CAR .MAJORITY OF THE TIMES THE REAR SLIDING DOORS WILL NOT OPEN THE BUTTONS DO NOT REMOTELY OPEN THE SLIDING DOORS AND THE SLIDING DOORS GET STUCK .ITS REALLY DANGEROUS BECAUSE IF MY GRANDKIDS ARE BACK THERE A DANGER BREAKS OUT THEY ARE MOST LIKELY NOT TO SURVIVE .

TL* THE CONTACT OWNS A 2008 HYUNDAI ENTOURAGE. THE CONTACT STATED THAT THE REAR SLIDING DOORS OPERATED INDEPENDENTLY. THE FAILURE OCCURRED WITHOUT WARNING. PRESTIGE AUTO MART (288 BROADWAY, TAUNTON, MA) WAS CONTACTED, BUT STATED THAT THEY DO NOT REPAIR DOORS. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 100,000. THE VIN WAS NOT PROVIDED.

TL* THE CONTACT OWNS A 2008 HYUNDAI ENTOURAGE. THE CONTACT STATED THAT THE REAR SLIDING DOORS OPERATED INDEPENDENTLY. THE FAILURE OCCURRED WITHOUT WARNING. PRESTIGE AUTO MART (288 BROADWAY, TAUNTON, MA) WAS CONTACTED, BUT STATED THAT THEY DO NOT REPAIR DOORS. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 100,000. THE VIN WAS NOT PROVIDED.

AFTER CLOSING PASSENGER SIDE SLIDER DOOR SEVERAL TIMES, IT SUDDENLY OPENED AGAIN WITHOUT PUSHING THE CEILING BUTTON ....ON ITS OWN AND I HAD TO FORCE IT SHUT PHYSICALLY. THE VEHICLE WAS IN PARK BUT ENGINE WAS IDLING

The contact's cousin owns a 2008 Hyundai Entourage. The contact stated that while driving 60-65 MPH at nighttime under snowy and icy conditions, the hood flew open and struck and shattered the windshield. The vehicle was pulled over to the side of the road, and the hood was closed but failed to latch securely. The vehicle was driven to the residence, where the contact became aware that the hood pistons were bent, and other unknown hood assembly parts were damaged. Additionally, the owner informed the contact that prior to the failure, the hood needed to be closed with excessive force to latch securely. The vehicle was taken to Safelite Auto Glass, where the windshield was replaced. The contact related the failure to NHTSA Campaign Number: 16V843000 (Latches/Locks/Linkages). The dealer and the manufacturer were not contacted. The vehicle was not diagnosed or repaired. The failure mileage was unknown.

WHEN I STEPPED ON THE GAS FROM A STOP AT A RED LIGHT THE ENGINE STARTED RACING AND THE THROTTLE STUCK.THE ENGINE WOULDN'T STOP RACING SO I HAD TO TURN THE KEY OFF TO GET IT TO STOP. PRETTY SCARY. A SECONDARY ISSUE IS THAT THE REAR PASSENGER SEAT WILL NOT FLIP UP. IT'S LOCKED IN PLACE.

While I was driving the vehicle, the front lower left/driver's side control arm broke in half and caused me to lose control of the vehicle.

The contact owns a 2008 Hyundai Entourage. The contact stated that while his daughter was driving 40 MPH, the steering wheel turned sideways as all four wheels remained straight. The ESC off warning light illuminated on the instrument panel. The contact's daughter was able to slowly drive the vehicle home despite the failure. The contact then test drove the vehicle and experienced the failure. The contact entered his driveway and noticed that the front driver’s side tire had detached from the vehicle. Upon investigation, the contact discovered NHTSA Campaign Number: 13V556000 (Suspension) which he linked to the failure. The manufacturer had been notified of the failure and the contact was provided a case number. The vehicle was not repaired. The failure mileage was approximately 135,000.

I had an appointment at the dealer for the recall only. Upon completion of scheduled appointment, I assumed the vehicle recall had been rectified. After my vehicle was at the dealership for several hours, the dealer did not complete the recall. The mechanic said the part was on backorder. They would contact me once it was in stock and available for installation. That was March 12, 2022 at Boch Hyundai in Norwood, Massachusetts. Information regarding recall is listed below: Manufacturer Recall Number 188 NHTSA Recall Number 20V061000

I WAS TAKING MY FAMILY FOR SHOPPING, AND AFTER MY KIDS (5 KIDS) WERE SEATED IN THE CAR AND MAKING SURE THE SEAT BELTS WAS WORN. I WALKED TO THE DRIVER DOOR TO START THE CAR AND DRIVE TO THE DESTINATION; A THICK WHITE SMOKE WAS COMING OUT OF UNDERNEATH THE ENGINE HOOD EVEN THOUGH THE CAR'S ENGINE WAS STILL OFF! I WAS SHOCKED AND DIDN'T KNOW WHAT TO DO FIRST! SHOULD I SAFE MY FAMILY AND HELP THE KIDS TO RUN OUT OF THE CAR OR CHECK THE CAUSE OF THE FIRE! SINCE I AM AN ELECTRICAL ENGINEERING AND HAVE EXPERIENCE WITH CARS, I KNEW THE PROBLEM WAS AN ELECTRICAL PROBLEM AND IF I UNPLUG THE BATTERY THIS SHOULD SOLVE THE PROBLEM FASTER! WITH A LOT OF SMOKE, I WAS ABLE TO UNPLUG THE CABLES OF THE BATTERY. THEN, I DID HELP MY KIDS TO GET OUT OF THE VAN' THEY WERE VERY SCARED AND DIDN'T KNOW WHAT TO DO AND HOW TO HELP! I CHECKED ON THE CAR AND I DID FIND THE SMOKE WAS LESS AND AFTER COUPLE MINUTES STOPPED COMPLETELY. SITUATION COULD BE WORSE THAN THAT, THE VAN WAS FULL OF GAS PARKED IN MIDDLE OF OTHER 4 CARS, 15 FT FROM OUR HOMES. I DID SEE THE ANTI-LOCK BRAKE (ABS) MODULE WAS BURNED-OUT! I DID ORDER A USED ABS MODULE FROM EBAY (SEE ATTACHED FILE) AND REPLACED THE OLD ONE. UNFORTUNATELY, IT DID NOT WORK! MANY LIGHTS IN THE DASHBOARD APPEARED (BREAK, ABS, ENGINE) AND LOST SOME FUNCTIONS OF THE DRIVING LIKE CRUISE AND SMOOTH ENGINE SOUND! AFTER VISITING MANY LOCAL REPAIRERS, I DID CALL THE LOCAL DEALER AND ASKED FOR NEW MODULE AND GOT QUOTE ON NEW ABS MODULE (PART ONLY COSTS ABOUT $2500). AFTER ABOUT A MONTH FROM THE ACCIDENT DAY, I RECEIVED A RECALL LETTER FROM HYUNDAI COMPANY IN USA WITH TWO RECALLS IN WHICH ONE OF THEM SAID ABS MODULE MAY SHORT CIRCUIT AN ELECTRICAL SHORT WITHIN THE ABS MODULE MAY CAUSE AN ENGINE COMPARTMENT FIRE, EVEN WHEN THE CAR IS TURNED OFF, INCREASING THE RISK OF AN INJURY. CONTACTED THE COMPANY BUT THEY DID NOT SOLVE MY PROBLEMS.

TL* THE CONTACT OWNED A 2008 HYUNDAI ENTOURAGE. THE CONTACT STATED THAT WHILE THE VEHICLE WAS PARKED IN HER DRIVEWAY, SHE WENT OUTSIDE AND NOTICED SMOKE COMING FROM THE UNDER THE HOOD. THE STATED THAT SHE AND FAMILY MEMBERS ATTEMPTED TO EXTINGUISH THE FIRE WITH HOSES AS FLAMES WERE SEEN COMING FROM UNDER THE VEHICLE. THE FIRE DEPARTMENT WAS CALLED AND EXTINGUISHED THE FIRE. A FIRE AND POLICE DEPARTMENT REPORTS WERE FILED. NO INJURIES SUSTAINED. THE VEHICLE WAS DEEMED A TOTAL LOSS BY THE FIRE DEPARTMENT. THE INSURANCE COMPANY WAS CONTACTED BUT HAS NOT SEEN THE VEHICLE AS OF YET. A LOCAL DEALER WAS NOT NOTIFIED OF THE FAILURE. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND A CASE WAS OPENED. THE CONTACT REFERRED THE FAILURE TO NHTSA CAMPAIGN NUMBER: 20V061000 (SERVICE BRAKES, HYDRAULIC). THE FAILURE MILEAGE WAS APPROXIMATELY 104,000. *LN CONSUMER STATED THERE IS A RECALL ON IT #188.*JB

VEHICLE WAS PARKED IN THE DRIVEWAY, NOT DRIVEN FOR APPROXIMATELY ONE WEEK. THE ENGINE COMPARTMENT STARTED SMOKING THEN ERUPTED IN FLAMES.

WHEN I STEPPED ON THE GAS FROM A STOP AT A RED LIGHT THE ENGINE STARTED RACING AND THE THROTTLE STUCK.THE ENGINE WOULDN'T STOP RACING SO I HAD TO TURN THE KEY OFF TO GET IT TO STOP. PRETTY SCARY. A SECONDARY ISSUE IS THAT THE REAR PASSENGER SEAT WILL NOT FLIP UP. IT'S LOCKED IN PLACE.

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

WHILE TURNING LEFT AT AN INTERSECTION, I HEARD A LOUD BANG AND LOST STEERING CONTROL. I PULLED OVER TO THE SIDE OF THE ROAD AND CALLED FOR A TOW TO MY MECHANIC. THE PASSENGER SIDE FRONT WHEEL WAS DISPLACED, THE 2 FRONT WHEELS WERE NOT PARALLEL AND THE WHEEL HAD HIT THE FRONT BUMPER COVER CAUSING IT TO COME LOOSE. THE TOW DRIVER NOTED THAT THE LOWER CONTROL ARM SNAPPED. FRONT PASSENGER WHEEL WAS HITTING THE FRONT BUMPER COVER AS IT WAS PULLED ONTO THE FLAT BED. I CALLED HYUNDAI CORP AND LOCAL DEALER ON FOLLOWING DAY (MONDAY). I TRIED TO GET DIRECTION REGARDING INSPECTION OF VEHICLE. SINCE AN ADDITIONAL TOW COULD CAUSE MORE DAMAGE; I ASKED IF HYUNDAI COULD INSPECT AT THE LOCAL SHOP. I COULD NOT GET ANY DIRECTION ON HOW TO GET THE CAR INSPECTED. ON THE 3RD CALL I WAS ADVISED THAT SAFETY RECALLS ARE ONLY COVERED FOR 1 YEAR AFTER THE RECALL SERVICE. WHEN I ASKED IF I NEEDED TO CONTACT NHTSA, JACK INDICATED THAT SINCE I MENTIONED NHTSA HE IS REQUIRED TO PASS THE CASE TO A SR HYUNDAI REPRESENTATIVE AND THAT I WOULD RECEIVE A RESPONSE VERY SOON. I HAVE NOT RECEIVED ANY RETURN CALL OR OTHER COMMUNICATION FROM ANYONE AT HYUNDAI CORP OR THE LOCAL DEALER. THE ATTACHED PICS SHOW THE FRONT PASSENGER SIDE LOWER CONTROL ARM CORROSION AND FAILURE. THE RECALL SERVICE PERFORMED IN 2014 WAS OBVIOUSLY NOT ADEQUATE. THE SUDDEN LOSS OF CONTROL WAS A HORRIFYING FEELING. I AM HOPEFUL THAT NHTSA WILL TAKE APPROPRIATE ACTION SO THAT OTHERS ARE NOT CONTINUED TO BE PUT IN PERIL. I UNDERSTAND THERE HAVE BEEN NUMEROUS OTHER OCCURRENCES OF LOWER CONTROL ARM FAILURE IN VEHICLES THAT WERE SERVICED UNDER THE RECALL. NOTE THAT MY VEHICLE WAS SERVICED FOR THE RECALL AT FREEHOLD HYUNDAI SHORTLY AFTER I RECEIVED NOTICE.

TL* THE CONTACT OWNS A 2008 HYUNDAI ENTOURAGE. THE CONTACT STATED THAT WHILE DRIVING AT 50 MPH, THE STEERING WHEEL BECAME DIFFICULT TO TURN. THE CONTACT HAD TO APPLY FORCE TO THE STEERING WHEEL IN ORDER TO TURN THE VEHICLE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC. THE TECHNICIAN DIAGNOSED THAT THE POWER STEERING PUMP NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 110,000. THE VIN WAS UNAVAILABLE.

TL* THE CONTACT OWNS A 2008 HYUNDAI ENTOURAGE. WHILE DRIVING AT VARIOUS SPEEDS, THE REAR PASSENGER SIDE DOOR INDEPENDENTLY UNLATCHED AND OPENED INDEPENDENTLY WITHOUT WARNING. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS REPAIRED; HOWEVER, THE FAILURE RECURRED WHILE LEAVING THE DEALER. THE MANUFACTURER SENT AN ENGINEER WHO DECIDED TO REPLACE THE ENTIRE DOOR. IN ADDITION, WHILE DRIVING, ALL THE INTERIOR AND EXTERIOR LIGHTING FAILED. THE VEHICLE WAS TAKEN TO THE DEALER. THE DEALER WAS UNABLE TO DETERMINE THE CAUSE OF THE FAILURES. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 6,000.

WHILE DRIVING ON INTERSTATE 40 IN MEMPHIS, TN, APPROXIMATELY 2:30 PM ON MARCH 07, 2014, THE ESC INDICATOR LIGHT BECAME ILLUMINATED ON THE DASH-BOARD. MY ATTEMPTS TO EXTINGUISH THE ILLUMINATED ESC LIGHT NUMEROUS TIMES FAILED TO RESET OR EXTINGUISHED THE ESC LIGHT. UPON ARRIVING HOME ABOUT 3:30 PM, I PARKED MY 2008 HYUNDAI ENTOURAGE, TURNED-OFF THE ENGINE AND RESTARTED THE ENGINE. THE ILLUMINATED INDICATOR ESC LIGHT DID NOT INAPPROPRIATELY ILLUMINATE. I INSPECTED THE EXTERIOR LIGHTS ONLY TO LEARN ALL OF THE REAR LIGHTS WERE STILL ILLUMINATED WITH THE ENGINE TURNED-OFF AND IN PARK. MY EFFORTS TO TURN-OFF THE REAR LIGHTS FAILED. I WAS INSTRUCTED TO DISCONNECT THE POSITIVE BATTERY TERMINAL AND BRING MY 2008 HYUNDAI ENTOURAGE IN FOR INSPECTION AND REPAIRS AT A HYUNDAI DEALERSHIP. AFTER I RECONNECTED THE BATTERY CABLE ON TUESDAY, MARCH 11, 2014, THE ESC INDICATOR LIGHT REAPPEARED (BECAME ILLUMINATED) AGAIN. AFTER ANOTHER HYUNDAI MOTOR AMERICA DEALERSHIP INSPECTED AND REPAIRED MY 2008 HYUNDAI ENTOURAGE, IT WAS LEARNED THAT THE PREVIOUS HYUNDAI DEALERSHIP PERFORMING THE "RECALL AND REPAIR" MECHANICAL WORK, "JERRY-RIGGED" (TO FIX AN OBJECT (USUALLY MECHANICAL) TO A WORKING CONDITION IN A HAPHAZARD WAY. ALSO KNOWN AS DOING A MACGYVER ON IT), OR REPAIRED MY ELECTRONIC STABILITY CONTROL (ESC) SYSTEM IN A MANNER INCONSISTENT OR CONTRARY TO HYUNDAI MOTOR AMERICA MANUFACTURER SPECIFICATIONS. THE HYUNDAI DEALERSHIP INTENTIONALLY AND PURPOSEFULLY USED PARTS THAT WOULD FAIL AND PUT MY SAFETY IN QUESTION. IN VIEW OF HOW I WAS TREATED BY PROFESSIONAL STAFF AT THAT DEALERSHIP DURING MY SEVEN (7) HOUR ORDEAL, I BELIEVE THE DEALERSHIP'S ACTION WAS AN ACT OF PURPOSEFUL SABOTAGE AND CRIMINAL NEGLIGENCE, DESIGNED TO PUT MY PERSONAL SAFETY IN QUESTION. *TR

TL* THE CONTACT OWNS A 2008 HYUNDAI ENTOURAGE EQUIPPED WITH KUMHO SOLUS KH16 TIRES, TIRE SIZE P225/70R16 (N/A). WHILE DRIVING APPROXIMATELY 65 MPH, THE VEHICLE BEGAN TO VIBRATE EXCESSIVELY. THE FAILURE WOULD RECUR WHEN DRIVING AT VARIOUS SPEEDS AND WAS MOST SEVERE WHEN DRIVING AT LOWER SPEEDS. THE CONTACT DETECTED THAT THE REAR DRIVER SIDE TIRE HAD SUBSTANTIAL TREAD SEPARATION. THE VEHICLE WAS TAKEN TO A TIRE CENTER WHERE THE TIRE WAS REPLACED. ALSO, THE REAR PASSENGER SIDE TIRE EXHIBITED THE SAME DEFECT. THE MANUFACTURER WAS NOTIFIED AND THE TIRE WAS NOT REPLACED. THE FAILURE MILEAGE WAS 19,452. UPDATED 05/24/11*LJ UPDATED 05/26/11

WHILE DRIVING UP AN INCLINE THE VEHICLE BEGAN TO MAKE A GRINDING NOISE. SHORTLY THEREAFTER THE CAR BEGAN SHAKING, WITH THE CHECK ENGINE AND ESC LIGHTS BOTH COMING ON, THEN A SUDDEN STOPPAGE OF ACCELERATION, AND THEN ENGINE SHUT DOWN WHILE THE VEHICLE WAS STILL IN MOTION. THIS CAUSED THE IMMEDIATE LOSS OF STEERING AND THE BRAKES TO GO SOFT. THE VEHICLE SAT FOR 10 MINUTES BEFORE RE-STARTING; HOWEVER, AFTER DRIVING APPROXIMATELY 100 FEET, THE CAR ONCE AGAIN MADE THE GRINDING NOISE, ENGINE AND ESC LIGHT ILLUMINATION, SHAKING, AND THEN SHUT DOWN. THIS IS THE THIRD TIME SINCE PURCHASING THIS VEHICLE IN MARCH OF 2008, THAT THE ENGINE HAS STOPPED WORKING WHILE DRIVING. THE DEALERSHIP HAS REPLACED A THROTTLE SENSOR TWICE, THE LAST TIME BEING OCTOBER 18, 2009, AND IT IS CURRENTLY IN THE SHOP AGAIN FOR THE SAME PROBLEM. THIS IS JUST ONE OF SEVERAL ONGOING PROBLEMS AND CONCERNS WITH THIS VEHICLE. MOST NOTABLY OUTSIDE OF THE SUDDEN LOSS OF POWER AND ENGINE SHUT OFF DESCRIBED, THE BRAKES HAVE BEEN CHECKED ON SEVERAL OCCASIONS FOR NOISES, VIOLENT SHAKING, AND LOSS OF FUNCTION TO WHICH THE DEALERSHIP STATES THAT THEY ARE NOT WORN OR WARPED OR THIS IS NORMAL FOR THIS VEHICLE. THE TIRES HAVE NO GRIP AND SPIN ON BOTH DRY AND WENT ROAD CONDITIONS MAKING SUDDEN ACCELERATION IMPOSSIBLE AND DANGEROUS.THE VEHICLE HAS ALSO BEEN CHECKED FOR THE LACK OF GAS MILEAGE APPROXIMATELY 13 MPG CITY AND 16 MPG HIGHWAY, WELL LESS THEN THE 19/21 ON THE STICKER. *TR

WHILE TURNING LEFT AT AN INTERSECTION, I HEARD A LOUD BANG AND LOST STEERING CONTROL. I PULLED OVER TO THE SIDE OF THE ROAD AND CALLED FOR A TOW TO MY MECHANIC. THE PASSENGER SIDE FRONT WHEEL WAS DISPLACED, THE 2 FRONT WHEELS WERE NOT PARALLEL AND THE WHEEL HAD HIT THE FRONT BUMPER COVER CAUSING IT TO COME LOOSE. THE TOW DRIVER NOTED THAT THE LOWER CONTROL ARM SNAPPED. FRONT PASSENGER WHEEL WAS HITTING THE FRONT BUMPER COVER AS IT WAS PULLED ONTO THE FLAT BED. I CALLED HYUNDAI CORP AND LOCAL DEALER ON FOLLOWING DAY (MONDAY). I TRIED TO GET DIRECTION REGARDING INSPECTION OF VEHICLE. SINCE AN ADDITIONAL TOW COULD CAUSE MORE DAMAGE; I ASKED IF HYUNDAI COULD INSPECT AT THE LOCAL SHOP. I COULD NOT GET ANY DIRECTION ON HOW TO GET THE CAR INSPECTED. ON THE 3RD CALL I WAS ADVISED THAT SAFETY RECALLS ARE ONLY COVERED FOR 1 YEAR AFTER THE RECALL SERVICE. WHEN I ASKED IF I NEEDED TO CONTACT NHTSA, JACK INDICATED THAT SINCE I MENTIONED NHTSA HE IS REQUIRED TO PASS THE CASE TO A SR HYUNDAI REPRESENTATIVE AND THAT I WOULD RECEIVE A RESPONSE VERY SOON. I HAVE NOT RECEIVED ANY RETURN CALL OR OTHER COMMUNICATION FROM ANYONE AT HYUNDAI CORP OR THE LOCAL DEALER. THE ATTACHED PICS SHOW THE FRONT PASSENGER SIDE LOWER CONTROL ARM CORROSION AND FAILURE. THE RECALL SERVICE PERFORMED IN 2014 WAS OBVIOUSLY NOT ADEQUATE. THE SUDDEN LOSS OF CONTROL WAS A HORRIFYING FEELING. I AM HOPEFUL THAT NHTSA WILL TAKE APPROPRIATE ACTION SO THAT OTHERS ARE NOT CONTINUED TO BE PUT IN PERIL. I UNDERSTAND THERE HAVE BEEN NUMEROUS OTHER OCCURRENCES OF LOWER CONTROL ARM FAILURE IN VEHICLES THAT WERE SERVICED UNDER THE RECALL. NOTE THAT MY VEHICLE WAS SERVICED FOR THE RECALL AT FREEHOLD HYUNDAI SHORTLY AFTER I RECEIVED NOTICE.

THIS IS A COMPLAINT ABOUT THE CAMBERS ON THIS VEHICLE. ON MANY OCCASIONS SINCE BUYING THIS VEHICLE I HAVE EXPERIENCED THE FOLLOWING IN LEFT HAND TURNS AT 45 - 55 MPH. WHEN TRYING TO PASS A VEHICLE, WHEN I TURNED THE STEERING WHEEL TO THE LEFT TO MOVE INTO THE LEFT PASSING LANE SOMETHING JERKED THE WHEEL FURTHER TO THE LEFT AND HAS NEARLY CAUSED ME TO RUN OFF THE ROAD ON THE OTHER SIDE. THE FIRST TIME IT HAPPENED AT ABOUT 20,000 MILES. THIS HAS ALSO HAPPENED WHEN TRAVELING DOWN THE MOUNTAINS IN WEST VIRGINIA IN SHARP LEFT HAND TURNS . MY CONCERN IS THAT THIS MAY BE CAUSED BY THE CAMBERS. EVERY TIME I TAKE MY VAN TO HAVE THE TIRES ROTATED I AM TOLD THE CAMBERS HOLD THE TIRES AT AN ANGLE AND THERE IS NOT ADJUSTMENT FOR IT. THEY ARE PERMANENTLY AT AN ANGLE AND HAVE BEEN EVER SINCE I BOUGHT THE VEHICLE. I HAVE ASKED THE DEALERSHIP ABOUT THE PROBLEM AND THE ONLY THING THEY WILL TELL ME IS THERE ARE NO AFTERMARKET PARTS TO FIX IT, AND THAT IT CANNOT BE ADJUSTED. BECAUSE THERE ARE NO ADJUSTMENT, THIS VEHICLE WEARS OUT TIRES LONG BEFORE THE TREAD LIFE IS UP. THE FIRST SET OF TIRES HAD TO BE REPLACED AT 25,000 MILES. TIRE MANUFACTURES WILL NOT GIVE CREDIT AGAINST MILEAGE BECAUSE OF THE CAMBERS. NOW DUE TO THE HEAVY CORROSION UNDERNEATH, AND NO CAMBER ADJUSTMENTS I FEEL THIS VEHICLE IS UNSAFE. *TR

DASH 'ENGINE LIGHT' ACTIVATED, CHECK BY DEALER REVEALED TRANSMISSION ISSUE. TRANY SOLENOID AND WIRE HARNESS NEED REPLACEMENT. DEALER OR HYUNDAI MOTOR WOULD NOT INCLUDE WIRE HARNESS IN WARRANTY THOUGH IT WAS STATED IT SHORTED AND CAUSED MALFUNCTION. THE COMPLETE COST OF REPAIRS SHOULD BE COVERED UNDER 10 YR / 100000 WARRANTY. NOTE: REFER NHTSA ELECTRICAL HARNESS RECALL, #06V356000. THIS COVERED 07 VEHICLES, WHICH IS WHEN MY VEHICLE WAS BUILT. NOTE: HYUNDAI MOTORS CASE # [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

WHILE DRIVING UP AN INCLINE THE VEHICLE BEGAN TO MAKE A GRINDING NOISE. SHORTLY THEREAFTER THE CAR BEGAN SHAKING, WITH THE CHECK ENGINE AND ESC LIGHTS BOTH COMING ON, THEN A SUDDEN STOPPAGE OF ACCELERATION, AND THEN ENGINE SHUT DOWN WHILE THE VEHICLE WAS STILL IN MOTION. THIS CAUSED THE IMMEDIATE LOSS OF STEERING AND THE BRAKES TO GO SOFT. THE VEHICLE SAT FOR 10 MINUTES BEFORE RE-STARTING; HOWEVER, AFTER DRIVING APPROXIMATELY 100 FEET, THE CAR ONCE AGAIN MADE THE GRINDING NOISE, ENGINE AND ESC LIGHT ILLUMINATION, SHAKING, AND THEN SHUT DOWN. THIS IS THE THIRD TIME SINCE PURCHASING THIS VEHICLE IN MARCH OF 2008, THAT THE ENGINE HAS STOPPED WORKING WHILE DRIVING. THE DEALERSHIP HAS REPLACED A THROTTLE SENSOR TWICE, THE LAST TIME BEING OCTOBER 18, 2009, AND IT IS CURRENTLY IN THE SHOP AGAIN FOR THE SAME PROBLEM. THIS IS JUST ONE OF SEVERAL ONGOING PROBLEMS AND CONCERNS WITH THIS VEHICLE. MOST NOTABLY OUTSIDE OF THE SUDDEN LOSS OF POWER AND ENGINE SHUT OFF DESCRIBED, THE BRAKES HAVE BEEN CHECKED ON SEVERAL OCCASIONS FOR NOISES, VIOLENT SHAKING, AND LOSS OF FUNCTION TO WHICH THE DEALERSHIP STATES THAT THEY ARE NOT WORN OR WARPED OR THIS IS NORMAL FOR THIS VEHICLE. THE TIRES HAVE NO GRIP AND SPIN ON BOTH DRY AND WENT ROAD CONDITIONS MAKING SUDDEN ACCELERATION IMPOSSIBLE AND DANGEROUS.THE VEHICLE HAS ALSO BEEN CHECKED FOR THE LACK OF GAS MILEAGE APPROXIMATELY 13 MPG CITY AND 16 MPG HIGHWAY, WELL LESS THEN THE 19/21 ON THE STICKER. *TR

FRONT PASSENGER SEAT WEIGHT SENSOR MALFUNCTION. THERE WAS NO INCIDENT/ACCIDENT. AIRBAG SERVICE LIGHT CAME ON, REGULAR GARAGES COULDN'T DIAGNOSE PROBLEM, ONLY A HYUNDAI DEALER CAN READ THE CODE; ONCE IT WAS DETERMINED THAT WEIGHT SENSOR WAS NOT WORKING, APPARENTLY THE ONLY SOLUTION IS TO REPLACE THE ENTIRE PASSENGER SEAT ASSEMBLY, CANNOT REPLACE JUST THE SENSOR.