2020 Hyundai Palisade Visibility Problems

The contact owns a 2020 Hyundai Palisade. The contact stated that the front camera was reportedly installed incorrectly, causing the automatic emergency braking system to engage unexpectedly, almost causing several crashes. Additionally, the windshield wiper motor became inoperable, and there was a fluid leak coming from the wiper system that migrated into the transmission, causing a mechanical failure with the gearbox. The rear seat belts also failed to buckle securely and were frequently unlatched while children were inside the vehicle. The contact referenced NHTSA Campaign Numbers: 26V034000 (Air Bags), 25V607000 (Seat Belts), and 22V627000 (Visibility); however, the VIN was not included in NHTSA Campaign Number: 22V627000 (Visibility). The dealer was notified of the failure. The vehicle was not repaired. The manufacturer was notified of the failures. The failure mileage was 90,000.

NHTSA ID

11730949

Incident

Apr 13, 2026

Mileage

90,000 mi

The contact owns a 2020 Hyundai Palisade. The contact received notifications of NHTSA Campaign Numbers: 25V607000 (Seat Belts) and 26V034000 (Air Bags); however, the parts to do the recall repairs were unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repairs. The contact stated that while attempting to clean the windshield, the windshield washer fluid system failed to spray as intended to clean the windshield. The dealer was contacted, and it was confirmed that parts were not yet available for the recall repairs. The manufacturer was not made aware of the issue. The failure mileage was approximately 37,000.

NHTSA ID

11727897

Incident

Mar 23, 2026

Mileage

37,000 mi

AC FAILIRE IM SUMMER, just outside warranty but tsb issued. Holler Hyundai Service wants to charge me $350 diagnostic fee to take a look and diagnose. Extreme heat while having to use vehicle to go to work, run errands and transport children. No alternate vehicle is available and dealership is unreasonable to work with. Due to high humidity in Florida windows fog and hard to defog, visibility is impaired suddenly while driving

NHTSA ID

11667684

Incident

Mar 27, 2025

The driver side wiper stopped functioning during a rain storm. Fortunately, I was not on a major road and was able to navigate. If I had been on the highway, I would have been blinded and potentially in a major accident if not able to pull over expeditiously. This malfunction occurred approximately one year earlier and was corrected by the dealer at that time. I believe some Hyundai Palisades have had a recall for this issue in the past. I am concerned that this has recurred and not been fixed definitively. This issue has potential fatal consequences. I am taking the vehicle to the dealer tomorrow to address the issue. I cannot take it today as it is still raining and I would be placing myself and others at risk.

NHTSA ID

11646441

Incident

Mar 5, 2025

Driver side windshield wiper has stopped working after encountering snow. The issue was initially intermittent, but now the wiper on the driver's side has stopped working completely. In searching, this is a known issue with other Palisades.

NHTSA ID

11635584

Incident

Jan 10, 2025

The contact owns a 2020 Hyundai Palisade. The contact stated that while driving at an undisclosed speed, the sunroof glass fell off the track. The message that the sunroof was open was displayed. The local dealer was contacted, but the vehicle had not been diagnosed or repaired. The manufacturer was not contacted. The failure mileage was approximately 95,390.

NHTSA ID

11610400

Incident

Aug 19, 2024

Mileage

95,390 mi

1) Back end of the vehicle sways, bounces at any speed when going over slightest bump. Driving with failing shocks or struts has a direct impact on your ability to control vehicle. Research indicates KNOWN ISSUE with 2020-2021 Hyundai Palisades - TSB22-SS-001H issued for PART of the problem but no recall. Hyundai clearly knows about it but not issuing needed recall because it is a warranty item, hoping customers don't realize it until out of warranty. Mine still in warranty, 48K miles. Rear- self leveling shocks appear to be the issue along with upper insulator piece. See Forum: [XXX] ) Another KNOWN ISSUE with cracking windshields same model. Mine cracked [XXX] while parked under cover - no apparent cause, Hyundai wanted over 1K to replace - had to use insurance to replace it. [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ID

11584605

Incident

Jun 1, 2023

The car started very slightly making a clunking noise and it progressively got worse. We've taken it for every scheduled maintenance and didn't know anything was wrong. We asked for it to be specifically checked at our recent oil change and were told it is a unfortunate COMMON issue that HYUNDAI IS AWARE of BUT the warranty ended on that about 6 months ago - something that should've been addressed and resolved, they waited until out of warranty and didn't do anything and now the fix is $1700 (rear struts need to be replaced) car jumps and it will get even worse. Also the wipers turn on when there is no rain but don't turn on when it rains the sensors are messed up

NHTSA ID

11554592

Incident

May 1, 2023

The contact owns a 2020 Hyundai Palisade. The contact stated while driving approximately 75 MPH, the contact heard an explosion above her head. The contact stated no warning light was illuminated. The contact pulled over and looked for a tire blowout or damage from road debris. The contact stated that she looked at the sunroof and noticed a hole the size of a basketball in the center of the sunroof. The contact stated that the sunroof was almost completely shattered. The contact had taken the vehicle to a local dealer, where it was diagnosed and determined that the sunroof was shattered by road debris and needed to be replaced. The vehicle had not been repaired. The manufacturer had been informed of the failure. The failure mileage was 43,731.

NHTSA ID

11548207

Incident

Oct 2, 2023

Mileage

43,731 mi

The contact owns a 2020 Hyundai Palisade. The contact stated while driving 30-35 MPH in a snowstorm, with his son in the front passenger's seat, another vehicle drove by the driver's side of the vehicle and sprayed a significant amount of snow on the vehicle, and the windshield wipers seized. The contact then lost visibility of the roadway and slowed down. The vehicle was rear-ended by another vehicle. Both the contact and his son sustained back injuries but did not received medical assistance. The contact was unsure whether the other driver had sustained an injury. A police report was filed. The contact was able to drive the vehicle to the residence. The vehicle was taken to an auto body repair shop, where it was repaired. Additionally, the contact stated that the windshield wipers seized on a second occasion, due to the presence of snow at the base of the windshield. The contact became aware of that the VIN was included in NHTSA Campaign Number: 22V627000 (Visibility), and the vehicle was taken to the dealer, where the windshield wiper arm was replaced under the recall; however, the failure persisted. The contact stated that the recall remedy did not fix the safety issue. The manufacturer was notified of the failure and a case was opened; however, the case was later closed. The vehicle was not repaired. The failure mileage was approximately 61,450. The VIN was unavailable.

NHTSA ID

11545494

Incident

Sep 19, 2023

Mileage

61,450 mi

Windshield developed a 30 in crack without hitting anything on the road. Other owners report a similar problem on a Facebook group.

NHTSA ID

11544995

Incident

Sep 15, 2023

The contact owns a 2020 Hyundai Palisade. The contact received notification of NHTSA Campaign Numbers: 22V627000 (Visibility) and 22V633000 (Trailer Hitches) however, the parts to do the recall repairs were unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repairs. The manufacturer was made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.

NHTSA ID

11524913

Incident

Nov 15, 2022

I was driving in a downpour today at approximately 11:30 am at 40mph when the driver side wiper stopped working. This is a verified recall issue which WAS REPAIRED on February 28, 2023. I was able to pull over safely into a parking lot until the weather calmed and then was able to very carefully drive home on side roads.

NHTSA ID

11521310

Incident

May 9, 2023

The contact owns a 2020 Hyundai Palisade. The contact received notification of NHTSA Campaign Number: 22V627000 (Visibility) however, the part to do the recall repair was not available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer has been notified of the issue. The contact had not experienced a failure. Parts distribution disconnect.

NHTSA ID

11519788

Incident

Apr 15, 2023

Two cracks to windshield that started spontaneously from the upper and lower edges of windshield when vehicle was only a few months old. Both cracks immediately lengthened 2.5 to 3 feet within 15 minutes of crack starting. Multiple small chips over past 2 years that have not occurred in our other vehicles that are driven similar routes and distances. It is evident that there is a problem as so many other owners have complained of the same issue . With the ease in which these windshields chip and crack , it is very concerning for safety in that it would likely provide little protection in a crash and it likely does not meet safety standards. Based on the major cracks starting spontaneously on the edges, it could be a problem with the frame/structure as well as lack of strength in the glass. Steps should be taken to correct this issue before serious injuries or fatalities occur.

NHTSA ID

11511329

Incident

Aug 1, 2020

The windshield on the Hyundai Palisade presents a safety hazard. The windshield cracks at low impact of a micro-pebble. The windshield could potentially cause a fatality if the car is involved in an accident. The problem has been confirmed by Hyundai but the company is only recalling the Kia Telluride for a defective windshield. The chip in the windshield immediately expands a crack across the driver's view which causes a visibility issue. The cracks cause a blinding reflection from the crack which makes the vehicle inoperable due to the driver's inability to see clearly due to the crack in eyeview.

NHTSA ID

11504813

Incident

Sep 28, 2022

The contact owns a 2020 Hyundai Palisade. The contact stated that while driving at various speeds, the windshield wipers were engaged and wiped across the windshield once and then stopped working. There were no warning lights illuminated. The contact received notification of NHTSA Campaign Number: 22V627000 (Visibility) and 22V633000 (Trailer Hitches) however, the parts to do the recall repairs were not yet available. The local dealer was contacted. The contact stated that the tow hitch fuse was removed. The dealer was unable to duplicate the failure with the windshield wipers. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repairs. The manufacturer was not made aware of the issue. The approximate failure mileage was 100. Parts distribution disconnect. The contact stated that the trailer hitch issue was resolved. The wiper failure occurs regularly and even during clear, sunny weather conditions. Hyundai states that the wipers are operating at "normal function".

NHTSA ID

11498584

Incident

Aug 1, 2020

Mileage

100 mi

The contact owns a 2020 Hyundai Palisade. The contact received notification of NHTSA Campaign Number: 22V627000 (Visibility) however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.

NHTSA ID

11497638

Incident

Dec 15, 2022

Four windshields in 2 years. Very small rocks cause major cracks. $6000 on windshields.

NHTSA ID

11492829

Incident

Nov 8, 2022

The contact owns a 2020 Hyundai Palisade. The contact stated while driving in the snow, the windshield wipers became inoperable. The contact stated no warning light was illuminated. The contact stated the failure only occurred in cold weather. The contact took the vehicle to the local dealer, where it was diagnosed with needing the windshield wiper motors to be replaced. The vehicle was not repaired. The contact received notification of NHTSA Campaign Number: 22V627000 (Visibility) however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. VIN tool confirms parts not available. The failure mileage was approximately 40,000.

NHTSA ID

11490266

Incident

Feb 1, 2021

Mileage

40,000 mi

TINY PEBBLE HIT MY WINDSCEEN WHILE I WAS DRIVING AND IMMEDIATELY A LARGE CRACK SPREAD ALL OVER THE WINDCSREEN

NHTSA ID

11488934

Incident

Oct 11, 2022

Windshield is fragile and breaks easily. Windshield will break from low impact debris. Crack impairs drivers vision due to extensive quick spread across windshield.. Car is inoperable due to light refraction on crack.

NHTSA ID

11488627

Incident

Sep 16, 2022

The contact owns a 2020 Hyundai Palisade. The contact received notification of NHTSA Campaign Number: 22V627000 (Visibility) however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was made aware of the issue. The manufacturer was not made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.

NHTSA ID

11482677

Incident

Sep 2, 2022

Sunroof is not opening after inspecting I noticed the right side clip broke off it’s position leaving only the metal piece by itself

NHTSA ID

11481598

Incident

Aug 27, 2022

The contact owns a 2020 Hyundai Palisade. The contact stated that the front windshield had cracked without impact. The contact stated he had replaced the front windshield three times. The contact had taken the vehicle to a glass repair shop for the front windshield replacement. The vehicle was not diagnosed. A dealer was not contacted. The manufacturer had been informed of the failure. The failure mileage was approximately 10,000.

NHTSA ID

11475306

Incident

Oct 1, 2021

Mileage

10,000 mi