2010 Hyundai Veracruz

The Office of Defects Investigation (ODI) has received eight Hyundai Motor America (Hyundai) and eight Kia America, Inc. (Kia) Part 573 Recall Reports between 2016 and 2023. The combined 16 safety recalls all involve the antilock braking system (ABS) modules or Hydraulic Electronic Control Units (HECU) manufactured by the equipment supplier Mando. The Part 573 Recall Reports contain varying defect descriptions and differing remedy descriptions for the same or similar equipment supplied by Mando. Safety recalls included in this Audit Query (AQ) review include: Hyundai recalls 20V-520, 20V-543, 21V-161, 21V-160, 21V-303, 22V-056, 22V-810, and 23V-651. Kia recalls 16V-815, 20V-518, 20V-519, 21V-137, 21V-331, 22V-051, 22V-800, and 23V-652 The purpose of this AQ is to evaluate the timeliness and scoping of Hyundai and Kia’s defect decision making and adherence with reporting requirements; and understand the varying defect descriptions and remedies between these recalls.

The contact owns a 2010 Hyundai Veracruz. The contact stated that after starting the engine and shifting into drive(D), the engine immediately shut off. The vehicle could not be restarted, and the battery failed. The manufacturer and local dealer were notified of the failure. The cause of the failure was not determined. The contact stated that the vehicle had previously experienced the same failure and was serviced under the NHTSA Campaign Number: 14V415000(ENGINE AND ENGINE COOLING). The failure mileage was 114,000.

NHTSA ID

11743441

Incident

May 27, 2026

Mileage

114,000 mi

on 1/31/26 I replaced battery that was only a little over a year old. on 2/1/26 while driving myself and 2 of my kids to there grandparents we lost power and lights on dash started flickering. I was able to pull over the side barely. I was told by family after explaing what happend that it could be related to the recall. I called Larry H Miller Hyundai Albuquerque and they verified the recall and we set up appointment for 2/5/26. I was able to tow vehicle to the dealership on 2/3/26. I received a call later that day from Martin on why my vehicle was there I explained the issue of loss of power and lights and door locks flickering and I believed it to be related to the recall. I received a text/email with the dealership making recommedations. I refuse them as they were not urgent and not why my vehicle was there. I received a text message 2/4/26 that my vehicle was ready to be picked up and they had ordered the recall parts and was a week out but I was able to pick up. I called mutiple times for 2 weeks to find out more and was never called back. on 2/14/26 I drove to the dealer ship to find out what was going on. I was told they still were waiting for part and when I asked what part they ordered and why I never got a call back I was only told they ordered a "valve kit" which Martin had to call the parts dept becuse my vehicle was not in there current service since they were waiting on parts. I asked what about the alternator and they said since I denied any repairs out side of the recall and the battery was an item I declined they did not test the alternator. I asked why they could not charge it as I expressed to them several times it was a new battery. they never answered me. but they told be they had to charge it to get it in to look at it. I said well doesn't that mean the alternator is bad and it needs to be replaced under the recall. after going back and fourth I ended up taking my vehicle and ended up agian on the side of the road with my daughter.

NHTSA ID

11721789

Incident

Feb 1, 2026

They should not have closed/completed the prior recall that was open regarding the valve cover gasket leak - oil leaks onto the alternator when can cause the alternator to fail. I went to the dealership last year to get it fixed and even per the dealership, they told me this valve cover leak is going to still be a problem even if fixed. It will leak again - and they are right. It is currently leaking again and possibly causing the alternator to fail.....again. Just this weekend my battery and alternator are failing when I just got them replaced within this past year!

NHTSA ID

11695796

Incident

Oct 25, 2025

MY VEHICLE IS EXPERIENCING AN ISSUE WITH THE WINSHIELD WIPER MOTOR THE MOTOR HAS FAILED AND THE WIPERS DO NOT WORK THERW IS A RECALL I SEEN FOR 2000-2012 HYUNDAI VEHICLES UNFORTUNATELY MY VIN NUMBER IS NOT INCLUDED I SPOKE WITH HYUNDAI AND THEY TOLD MY VIN IS NOT A RECALL DEFECT THAT IT IS A JUST REGULAR PROBLEM THAT NEEDS REPAIRED. i AM VERY HARD PRESSED TO BELIEVE THAT MY YEAR MAKE AND MODEL HAS THIS RECALL JUST NOT MY VIN

NHTSA ID

11695017

Incident

Jun 1, 2023

The contact owns a 2010 Hyundai Veracruz. The contact stated that there was a hard knocking sound coming from the engine. While driving 45 MPH, the vehicle lost motive power. The battery power was low. The vehicle was previously taken to the local dealer for TSB Number: 21-01-047H-2. The contact stated that the failure was related to NHTSA Campaign Number: 20V705000 (Engine and Engine Cooling) and 14V415000 (Engine and Engine Cooling). The alternator was replaced; however, the failure recurred. The vehicle was taken back to the local dealer where it was diagnosed and determined that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was not contacted. The failure mileage was approximately 117,674.

NHTSA ID

11663033

Incident

May 10, 2025

Mileage

117,674 mi

The contact owns a 2010 Hyundai Veracruz. The contact stated while driving at approximately 35 MPH, there was an abnormal odor inside the vehicle. The contact stated that the odor was burning oil. The contact stated that the check engine warning light was illuminated. The contact had taken the vehicle to a local dealer, where it was diagnosed and determined that there was an oil leak from the T-Joint and that the repair was covered under Manufacturer Recall Number: 197 - Oil Leak on Alternator (Engine and Engine Cooling). The vehicle was repaired; however, the leak recently reoccurred. The contact took the vehicle back to the same dealer who diagnosed the failure and informed the contact that there was oil leaking onto the alternator. The contact was informed that the vehicle was no longer covered under the manufacturer’s recall. The vehicle was not repaired. The manufacturer was not informed of the failure. The failure mileage was unknown.

NHTSA ID

11618958

Incident

Feb 9, 2024

Driving at approximately 35 mph Check Engine Light came on P0331 Knock Sensor - light was cleared drove 14 miles CEL was back on. Called Hyundai about the code & knock sensor in reference to all the Hyundai models being recalled for the same problem and a warranty extension being granted. Hyundai advised me to take it to a local dealer for diagnosis and pay the fee of course. I did just that. The dealer clear the codes and sent me home. CEL was on again. Car was back at dealer confirmed knock sensor replacement needed. I inquired about extension of warranty on my car. I was told it's not on the list. Called Hyundai back advised of the confirmation of diagnosis just to be informed that my car isn't covered under the extension warranty. We established that already. I asked to be escalated & was given a supervisor who suggested while the problem is being investigated I could ask the dealer to request Goodwill from Hyundai. Denied. Called Hyundai to follow up on my claim, I was advised claim closed my car isn't covered under the extension warranty for the same problem as other models and out of original warranty. Which I already knew. I was trying to find out if my car should be added to the list covered. I was told once the claim is closed it is closed. Hyundai needs to protect the owners of all Hyundai vehicles not just the popular ones. Since they closed my claim that fast. I would love an explanation as to why I was advised to take it to the dealer pay the fee and 25x the price for repair vs an independent shop. This is the 3rd time I've been without my car while it sits at the dealer waiting on parts. I'm left with a large bill, an unsafe engine and no vehicle. Hyundai needs to be held accountable. We shouldn't fear for our safety while driving. Bought in 2011 & it currently has 106,350 miles. Still within the 15 year, 150,000 mile warranty extended to other Hyundai owners whether original or not. I'm the original owner. My vehicle needs to be safe to drive.

NHTSA ID

11587348

Incident

Apr 16, 2024

The contact owns a 2010 Hyundai Veracruz. The contact stated that while the vehicle was parked, she observed that the vehicle was leaking brake fluid. The ABS warning light was illuminated. The vehicle was not taken to the dealer or an independent mechanic. The vehicle was not repaired. After investigating the failure, the contact related the failure to NHTSA Campaign Number: 23V651000 (Service Brakes, Hydraulic). The VIN was included, but parts were not yet available. The manufacturer was notified of the failure but provided no assistance. The failure mileage was unknown. Parts distribution disconnect.

NHTSA ID

11586559

Incident

May 2, 2024

The National Highway Traffic Safety Administration (NHTSA) has issued an urgent safety advisory regarding dangerous, counterfeit driver‑side airbag inflators manufactured by Jilin Province Detiannuo Automobile Safety System Co., Ltd. (DTN), that have been identified in U.S. vehicles following prior crashes, theft, or non‑certified airbag replacements. These inflators are not approved for use, may rupture during deployment, and have caused serious injuries and fatalities. Please see attached announcement, provided by NHTSA, for more details.

The National Highway Traffic Safety Administration (NHTSA) has identified the presence of substandard and dangerous driver’s-side airbag inflators manufactured by Jilin Province Detiannuo Automobile Safety System Co., Ltd. (DTN). These inflators were not supplied, approved, or authorized by the vehicle manufacturers and have primarily been found in vehicles that previously experienced a crash and underwent airbag replacement using non-genuine parts. These dangerous inflators have ruptured during deployment, posing a serious risk of injury or death due to metal fragments entering the vehicle cabin. To date, Hyundai is aware of three people who have died while driving a Hyundai vehicle with one of these substandard replacement airbag inflators that deployed in what likely would have been a survivable crash. NHTSA has issued a public advisory urging vehicle owners and service professionals to have vehicles inspected if there is reason to believe that a non-genuine replacement airbag may have been installed. Vehicles with salvage or rebuilt titles, prior airbag deployments, or unknown repair histories may present a higher risk. NHTSA strongly cautions against self-inspection by vehicle owners and recommends inspection by trained technicians.

This bulletin provides information regarding condensation related to the accumulated moisture in the headlamp, rear combination lamp, daytime running lamp (DRL), or fog lamp. This TSB illustrates the various causes of condensation inside the lamp assembly. Lamp assembly replacement is NOT necessary in most cases. This condition can be eliminated by turning on the lamps with the engine running for several minutes or during normal driving operation.

This bulletin contains information about the proper removal of the windshield wiper blade protective cover on all models. If the protective cover is not removed correctly, there is a possibility of the rubber insert and rail spring becoming partially separated on the inner side of the wiper blade, which could lead to poor wiping performance and/or possible scratching of the windshield glass. Follow the procedure in this bulletin to properly remove the windshield wiper blade protective cover on all new wiper blades.

This bulletin provides important checkpoint guidelines when performing engine oil and filter change services.

Hyundai applies a Paint Protection Film (PPF) on new vehicles before delivery to dealerships. It provides a barrier between the paint and contaminants, such as rail dust, acid rain, and industrial fallout. In rare cases, the paint can become clouded under the PPF. These spots are the result of moisture trapped between the PPF and the paint.