2001 INFINITI I30

From 2000 through 2017, Takata produced millions of air bag inflators using two types of phase-stabilized ammonium nitrate ("PSAN") propellant -- propellant 2004 and propellant 2004L. After prolonged exposure to high temperature cycles and humidity, inflators using propellant 2004 can degrade, causing the propellant to burn too quickly when ignited. The rapid burning can cause the inflator to rupture during deployment, potentially causing serious or even fatal injury to vehicle occupants. See 2016 Blomquist Report at www.nhtsa.gov/sites/nhtsa.gov/files/documents/expert_report-hrblomquist.pdf.Consequently, all frontal inflators using propellant 2004 that do not contain a "desiccant" (a substance that traps and holds moisture) in US vehicles are under recall. These "non-desiccated" inflators either have been or are required to be replaced.In some cases, the remedy part for these recalled inflators was, or will be, an inflator using either propellant 2004 or 2004L that does contain a desiccant. None of these "desiccated" remedy parts (which were installed in older model year vehicles) are currently under recall for a degradation concern. Certain subsets of desiccated PSAN inflators using propellant 2004 for use as original equipment, however, have been recalled for a degradation concern. All Takata inflators produced with propellant 2004L contain desiccant, and none of these desiccated inflators using propellant 2004L are under recall for a degradation concern. There have been no reported field ruptures in any non-recalled desiccated PSAN inflators.It is understood that desiccants fully saturate at some threshold, at which point any additional moisture will not be captured. This means the degradation process observed in non-desiccated inflators using propellant 2004 may also occur in non-recalled desiccated inflators using propellant 2004, assuming additional moisture enters the inflator and high temperature cycling occurs. Based on available information, desiccant saturation can occur within the first five years in the worst environments, and the time required for full saturation is affected by multiple factors. While no present safety risk has been identified, further work is needed to evaluate the future risk of non-recalled desiccated inflators using propellant 2004.Three entities -- Takata (now known as TK Global), the Independent Testing Coalition, and Exponent -- have been studying the long-term behavior of Takata desiccated PSAN inflators using propellant 2004L (as well as 2004) in the presence of moisture and temperature cycling. The research efforts, which include development of predictive modeling techniques and field sample analysis, are ongoing. To date, none of the researchers have identified field evidence showing that propellant 2004L is undergoing a degradation process that leads to aggressive deployment and potential rupture. However, the time in service of such inflators remains short compared to that of the inflators using propellant 2004. Further study is needed to assess the long-term safety of desiccated inflators using propellant 2004L.The Office of Defects Investigation is opening this investigation to examine whether a safety defect related to propellant degradation exists in non-recalled desiccated PSAN frontal inflators manufactured by Takata. This investigation will require extensive information on Takata production processes and surveys of inflators in the field. Lists of recall actions that may have used desiccated PSAN inflators as remedy parts, as well as the makes and models originally manufactured with them, is available with the downloadable version of this document (see nhtsa.gov/recalls?nhtsaId=EA21002 -- note this information is subject to change/revision as the investigation proceeds). This investigation does not supersede EA15-001, which remains open.

In the last 2 months I have had the front passenger tire blow out 3 times. After this last tire repair the car started to shake, vibrate and make a knocking noise while driving. When driving faster the steering wheel would jerk me almost offthe road. It was so bad I pulled over and when I looked at the front passenger tire it was smoking and sitting sideways. I had to get my vehicle towed and now I have no way to work. I have included an estimate of the repairs as well as a written warranty that was given to the previous owner. I was told this was no longer valid since I am not the original owner of the vehicle. The way the steering jerked and how the tire went sideways I feel that is a safety issue.

NHTSA ID

11445735

Incident

Dec 27, 2021

I RECENTLY TOOK MY CAR IN FOR A REGULAR SMOG CHECK, AND THE TECHNICIAN REPORTED THAT THERE IS 1 OPEN RECALL FOR MY VEHICLE. I CALLED AND MADE AN APPOINTMENT WITH INFINITI OF ROSEVILLE. BROUGHT MY VEHICLE IN AND THE TECH TOLD ME THERES NO NEED TO REPLACE THE AFFECTED PARTS BEING AS THE CAR HAS 202K MILES.

NHTSA ID

11331996

Incident

Jul 1, 2020

TL* TAKATA AIR BAG RECALL. THE CONTACT'S HUSBAND OWNED A 2001 INFINITI I30. THE CONTACT STATED THAT WHILE HER DAUGHTER WAS IN LINE AT A DRIVE THRU, A SMELL EMITTED THROUGHOUT THE VEHICLE WITHOUT WARNING. AS THE BURNING SMELL PROGRESSED, SHE ALSO SAW WHITE SMOKE COMING FROM THE REAR END OF THE VEHICLE. THE DRIVER GOT OUT OF THE LINE AND CHECKED THE HOOD OF THE VEHICLE WHERE SHE SAW FLAMES COMING THE ENGINE. AUTHORITIES WERE CALLED TO THE SCENE OF THE FIRE; HOWEVER, BEFORE THEY ARRIVED, THE VEHICLE HAD EXPLODED. THE AIR BAGS DEPLOYED UPON EXPLOSION. NO INJURIES WERE REPORTED AT THE SCENE AND A POLICE REPORT AND FIRE REPORT WERE FILED. THE VEHICLE WAS DESTROYED DUE TO THE EXPLOSION AND WAS TOWED TO AN UNKNOWN LOCATION. UPON INVESTIGATION, THE CONTACT DISCOVERED THAT THERE WAS A TAKATA RECALL ON THE VEHICLE UNDER NHTSA CAMPAIGN NUMBER: 20V008000 (AIR BAGS) THE MANUFACTURER NOR THE DEALER HAD BEEN NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS UNKNOWN.

NHTSA ID

11324391

Incident

May 4, 2020

THERE IS VIBRATION AND A CLUNKING NOISE WHEN TURNING. IT IS HARD TO STEER STRAIGHT ON ROAD. THE REAR SUSPENSION INCLUDING IT'S PARTS HAVE FAILED MAKING IT IMPOSSIBLE TO PROPERLY ALIGN THE VEHICLE. THIS HAS CAUSED THE FRONT SUSPENSION TO DEGENERATE CONSIDERABLY CAUSING PERSISTANT VIBRATION AND A CLUNKING NOISE. THIS ALSO CREATES A PROBLEM WITH THE STEERING. IT CANNOT BE PROPERLY CENTERED. THE RIGHT REAR SEVERLY UNDER STEERS. THERE IS A DEFECTIVE TRANSVERSE LINK, SPRINGS AND STRUTS AND A DEFECTIVE RACK AND PINION.

NHTSA ID

11143371

Incident

Sep 15, 2018

Mileage

200,000 mi

TAKATA RECALL FOR FRONT SUSPENSION TRANSVERSE LINK. I THINK THIS VEHICLE BELONGS IN THE LIST AND OF THE I30T 2001 INFINITI AND SO DOES THE MECHANIC THAT INSPECTED THE VEHICLE

NHTSA ID

11142893

Incident

Aug 29, 2018

Mileage

20,000 mi

TAKERS RECALL WHEEL JERKS TO EITHER RIGHT OR LEFT AND CAUSES CARE TO JERK TO EITHER SIDE I WAS GOING 55 TO 60 MILES PER HOUR AND IT ALMOST THREW ME COMPLETELY OFF THE ROAD AND ANOTHER TIME IT JERKED ME TOWARDS A CAR COMING HEAD ON AT ME.

NHTSA ID

11142783

Incident

Aug 17, 2018

Mileage

232,000 mi

I WAS DRIVING THE CAR THE ENGINE WAS WARM AND RUNNING JUST FINE. THEN OUT OF NO WHERE THE CAR AT 40 MPH ENGINE BEGIN WILDLY REVVING THE RPMS WENT DIRECTLY HOME AND IN PARK IT WAS DOING THE SAME THING. TURNED IT OFF CALLED A TOW TRUCK HAD IT TOWED IN TO LOCAL SHOP. A CHECK ENGINE LIGHT CAME ON SHOWING A P0505 CODE. THE SHOP REPLACED THE IACM AND THEN THE ECU AT A COST OF OVER CAR WAS RETURNED SAME CODE AND CHECK ENGINE LIGHT ON THE MECHANIC SAID IT WOULD NOT RELEARN IDLE AND TO DRIVE IT AROUND AND SEE IF THAT WOULD HELP. I AM AN ELDERLY WOMAN AND I SPEND THE NEXT FEW DAYS RIDING THE BRAKE TO KEEP THE CAR IN CONTROL. IDLE WAS RUNNING HIGH IN PARK AND DRIVE. I WAS BECOMING AFRAID OF THE CAR AND DECIDED TO TAKE IT TO THE INFINITI DEALER FOR REPAIRS. WITH SAME P0505 CODE AND CHECK ENGINE LIGHT AND IN LESS THEN SEVEN DAYS THE IACM AND ECU ONCE AGAIN NEEDED TO BE REPLACED. THAT'S BECAUSE THE MOTOR MOUNTS FAILED AND SINCE THEY ARE FLUID FILLED THEY LEAKED CAUSING THE OTHER PARTS TO SHORT OUT. THE INFINITI DEALER SAID THE THREE PARTS ARE ALL ON THE SAME CIRCUIT BUT THIS IS ONLY KNOWN TO INFINITI MECHANICS. THE REPAIR IS NOW OVER $3000.00 PUS THE FIRST CHARGE. THIS IS WAY MORE THEN MY CAR VALUE. I RESEARCHED THIS CONDITION ON THE INTERNET. KIDS HAVE BEEN DRIVING THESE CARS WHEN THE FAILURE OCCURS AT 80 MPH WITH BOTH FEET ON THE BRAKE. I NEVER WRITE ANYTHING ON THE INTERNET BUT I AM CONCERNED THIS IS GOING TO CAUSE A CRASH AND SOMEONE MAY BE SERIOUSLY HURT. CAR HAS 110000. MILES I WILL PAY FOR THE REPAIRS OUT OF POCKET BUT I THINK THIS SHOULD BE A RECALL.

NHTSA ID

11072863

Incident

Jan 15, 2018

Mileage

110,000 mi

I WAS DRIVING ALONG THE MIDDLE LANE IN HEAVY TRAFFIC. AT THE INTERSECTION WITH TRAFFIC LIGHTS, THE LANE WAS STUCK IN FRONT OF ME AND THERE WAS NO SPACE TO GO. IN ORDER NOT TO BLOCK THE INTERSECTION, I HAD TO SLOW DOWN AND STOP AT THE TRAFFIC LIGHTS. WHILE I WAS WAITING AT THE LIGHTS, AFTER 10 SECONDS THE OTHER CAR CAME CLOSER WITHOUT SLOWING DOWN AND HIT MY CAR FROM THE BEHIND. I WAS REAR-ENDED ON THAT INCIDENT.

NHTSA ID

11071508

Incident

Jan 11, 2018

Mileage

128,543 mi

INTELLIGENT KEY NOT DETECTED / ENGINE WILL NOT START This bulletin has been amended. See AMENDMENT HISTORY on the last page. Please discard previous versions of this bulletin.

WINDOW GLASS WARRANTY INFORMATION This bulletin has been amended. See AMENDMENT HISTORY on the last page. Please discard previous versions of this bulletin.

REMOVING FOREIGN MATERIAL FROM THE WINDOW GLASS This bulletin has been amended. See AMENDMENT HISTORY on the last page. Please discard previous versions of this bulletin.

WINDSHIELD CRACKING This bulletin has been amended. See AMENDMENT HISTORY on the last page. Please discard previous versions of this bulletin.

WINDSHIELD CRACKING This bulletin has been amended. See AMENDMENT HISTORY on the last page. Please discard previous versions of this bulletin.

REMOVING FOREIGN MATERIAL FROM THE WINDOW GLASS This bulletin has been amended. See AMENDMENT HISTORY on the last page. Please discard previous versions of this bulletin.