2003 International 4300 Owner Complaints

TL* THE CONTACT OWNS A 2003 INTERNATIONAL 4300. THE CONTACT STATED WHILE DRIVING 30 MPH, THE BRAKES WERE ENGAGED AND FAILED TO STOP THE VEHICLE. AS A RESULT, THE VEHICLE CRASHED INTO A SIGN. A POLICE REPORT WAS NOT FILED AND NO INJURIES WERE REPORTED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC. THE TECHNICIAN DIAGNOSED THAT THE BRAKE BOOSTER NEEDED TO BE REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 89,000.

NHTSA ID

10672677

Incident

Dec 11, 2014

Mileage

89,000 mi

TL*THE COMPANY OWNS A 2003 INTERNATIONAL 4300. THE CONTACT WAS WAITING FOR A TIRE MECHANIC TO ARRIVE WHEN HE NOTICED SMOKE UNDERNEATH THE WHEEL OF THE VEHICLE. THE VEHICLE CAUGHT FIRE ON JUNE 10, 2008 IN THE ENGINE COMPARTMENT, AND WAS DESTROYED. THE FIRE WAS EXTINGUISHED BY THE FIRE DEPARTMENT. THERE ARE NO PHOTOS OR FIRE REPORT AVAILABLE; HOWEVER, THE CAUSE OF FIRE WAS SUGGESTED TO BE ELECTRICAL. THERE WERE NO WARNING LIGHTS ILLUMINATED ON THE INSTRUMENT PANEL. THE CONTACT RECENTLY RECEIVED A RECALL NOTICE THAT WAS RELATED TO THE FIRE. THE RECALL NUMBER WAS UNKNOWN. THE FAILURE AND CURRENT MILEAGES WERE 345,000.

NHTSA ID

10234266

Incident

Jun 10, 2008

Mileage

345,000 mi

REAR HYD. BRAKE ROTOR BROKE FROM HUB UNDER ROUTINE SERVICE. THIS HAS HAPPENED PREVIOUSLY TO ANOTHER TRUCK IN OUR FLEET. REPAIR SHOP REPORTS THEY HAVE SEEN SIX OTHER INTERNATIONAL 4300'S WITH THE SAME PROBLEM. THIS IS JUST ONE OF HUNDREDS OF REPAIR SHOPS IN THIS AREA, SAFE TO SAY THERE MUST BE HUNDREDS OF 4300'S SHEDDING ROTORS. OBVIOUSLY THIS CAUSES A COMPLETE LOSS OF BRAKING TO THE AFFECTED WHEEL(S). ADDITIONALLY, THIS CAUSES AN ABS FAULT CONDITION WHICH DISABLES THE EXHAUST BRAKE AND ALLOWS THE REMAINING BRAKING WHEELS TO LOCK CAUSING A LOSS OF CONTROL. AS OUR MECHANIC OBSERVED, THESE TRUCKS ARE GOING TO KILL SOMEBODY IF THESE BRAKES AND SOFTWARE ARE NOT REDESIGNED. THE ROTORS, CALIPERS, PADS, WHEEL SPEED SENSORS AND HARDWARE ON THE REAR AXLE HAVE BEEN REPLACED AS A RESULT OF THE FAILURE. THE DAMAGE HAS BEEN PHOTOGRAPHED. *JB

NHTSA ID

10135756

Incident

Sep 2, 2005

Mileage

90,000 mi

WHILE DRIVING AT HIGH SPEEDS THERE WAS HEAVY VIBRATION IN THE REAR AXLE. WHEN DRIVING LOW SPEEDS FRONT/REAR END WONDERED. DEALERSHIP WAS NOTIFIED, BUT DID NOT RESOLVE THE PROBLEM. *AK

NHTSA ID

10089763

Incident

Jun 14, 2004

Mileage

40,000 mi

ABS LIGHT COMES ON AND OFF, ESPECIALLY WHEN IT IS RAINING.*AK

NHTSA ID

10033456

Incident

Jan 28, 2003

Mileage

5,140 mi

ABS LIGHT COMES ON AND OFF, ESPECIALLY WHEN RAINING.*AK

NHTSA ID

10033450

Incident

Jul 31, 2003

Mileage

42,007 mi

ABS LIGHT COMES ON AND OFF. ESPECIALLY WHEN IT IS RAINING. ACCORDING TO A MECHANIC AT MAUDLIN, IF MORE THAN ONE SENSOR GOES OUT THE WHOLE ABS BRAKE SYSTEM FAILS TO WORK CAUSING IT TO REVERT TO MANUAL BRAKES. THIS OCCURED ON JULY 28TH, CAUSING THE BRAKES TO LOCK UP DURING A RAIN STORM RESULTING IN AN ACCIDENT.*AK

NHTSA ID

10033446

Incident

Jul 28, 2003

Mileage

61,086 mi

WHILE DRIVING 65 MPH THE DRIVERS SIDE REAR OUTSIDE DUAL TIRE BLEW OUT. WHEN THE CONSUMER EXITED THE VEHICLE HE ALSO NOTICED THAT THE DRIVERS SIDE INSIDE TIRE WAS FLAT. THE CONSUMER WENT TO CHECK THE PRESSURE OF THE OUTSIDE TIRE AND IT WAS ALRIGHT. WHEN THE CONSUMER ATTEMPTED TO CHECK THE PRESSURE OF THE INSIDE PASSENGER TIRE THE EXTENDER VALVE FELL OFF IN THE CONSUMERS HAND AND THE AIR ESCAPED FROM THE TIRE. IT APPEARED THAT THE EXTENDER VALVE HAD SHEARED OFF. THE CONSUMER WENT BACK TO THE FLAT TIRE AND NOTICED THAT THE EXTENDER VALVE ON THAT TIRE HAD ALSO SHEARED OFF THUS CAUSING THE TIRE TO GO FLAT. THE TIRE TECH INFORMED THE CONSUMER THAT THE EXTENDER VALVES WERE NOT INSTALLED PROPERLY AND THAT THEY WERE SUPPOSED TO BE BRACED. THE CONSUMER BELIEVES THE WEIGHT OF THE TRUCK CAUSED THE OUTSIDE DUAL TIRE TO BLOW OUT WHEN THE INSIDE TIRE WENT FLAT (INSIDE GOOD YEAR TIRE SIZE 265-70R 19.5 UNISTEEL G124). *AK * CB *NLM

NHTSA ID

10024250

Incident

May 31, 2003

Mileage

11,000 mi