2003 International 4300 Problems
Owner-reported complaints filed with NHTSA, grouped by component
Data refreshed
What this page shows
Everything below is an owner-reported complaint submitted to NHTSA about the 2003 International 4300, grouped by the component NHTSA recorded on the report. These are not confirmed defects, and they are not recalls. NHTSA does not verify most reports before publishing them, and a category with more reports in it is not evidence that a part is defective.
Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.
Reports by component
Ranked by how many owner reports name each component category
- Brakes562.5%
- Electrical112.5%
- Suspension112.5%
- Tires & wheels112.5%
Percentages are of component mentions. A single complaint can name more than one component, so these do not sum to the total complaint count.
Each component in detail
What the reports in each category say, in the owners' own words
Brakes
Reports naming service brakes, the antilock braking system, brake hoses, master cylinders or the parking brake.
From owner reports, verbatim
TL* THE CONTACT OWNS A 2003 INTERNATIONAL 4300. THE CONTACT STATED WHILE DRIVING 30 MPH, THE BRAKES WERE ENGAGED AND FAILED TO STOP THE VEHICLE. AS A RESULT, THE VEHICLE CRASHED INTO A SIGN. A POLICE REPORT WAS NOT FILED AND NO INJURIES WERE REPORTED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC. THE TECHNICIAN DIAGNOSED THAT THE BRAKE BOOSTER NEEDED TO BE REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 89,000.
REAR HYD. BRAKE ROTOR BROKE FROM HUB UNDER ROUTINE SERVICE. THIS HAS HAPPENED PREVIOUSLY TO ANOTHER TRUCK IN OUR FLEET. REPAIR SHOP REPORTS THEY HAVE SEEN SIX OTHER INTERNATIONAL 4300'S WITH THE SAME PROBLEM. THIS IS JUST ONE OF HUNDREDS OF REPAIR SHOPS IN THIS AREA, SAFE TO SAY THERE MUST BE HUNDREDS OF 4300'S SHEDDING ROTORS. OBVIOUSLY THIS CAUSES A COMPLETE LOSS OF BRAKING TO THE AFFECTED WHEEL(S). ADDITIONALLY, THIS CAUSES AN ABS FAULT CONDITION WHICH DISABLES THE EXHAUST BRAKE AND ALLOWS THE REMAINING BRAKING WHEELS TO LOCK CAUSING A LOSS OF CONTROL. AS OUR MECHANIC OBSERVED, THESE TRUCKS ARE GOING TO KILL SOMEBODY IF THESE BRAKES AND SOFTWARE ARE NOT REDESIGNED. THE ROTORS, CALIPERS, PADS, WHEEL SPEED SENSORS AND HARDWARE ON THE REAR AXLE HAVE BEEN REPLACED AS A RESULT OF THE FAILURE. THE DAMAGE HAS BEEN PHOTOGRAPHED. *JB
Too few reports in this category for a page of its own — they appear in the full complaint list.
Electrical
Reports naming the electrical system — wiring, battery, charging, control modules, infotainment and electrical accessories.
From owner reports, verbatim
TL*THE COMPANY OWNS A 2003 INTERNATIONAL 4300. THE CONTACT WAS WAITING FOR A TIRE MECHANIC TO ARRIVE WHEN HE NOTICED SMOKE UNDERNEATH THE WHEEL OF THE VEHICLE. THE VEHICLE CAUGHT FIRE ON JUNE 10, 2008 IN THE ENGINE COMPARTMENT, AND WAS DESTROYED. THE FIRE WAS EXTINGUISHED BY THE FIRE DEPARTMENT. THERE ARE NO PHOTOS OR FIRE REPORT AVAILABLE; HOWEVER, THE CAUSE OF FIRE WAS SUGGESTED TO BE ELECTRICAL. THERE WERE NO WARNING LIGHTS ILLUMINATED ON THE INSTRUMENT PANEL. THE CONTACT RECENTLY RECEIVED A RECALL NOTICE THAT WAS RELATED TO THE FIRE. THE RECALL NUMBER WAS UNKNOWN. THE FAILURE AND CURRENT MILEAGES WERE 345,000.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Suspension
Reports naming suspension components — springs, struts, shocks, control arms and related hardware.
From owner reports, verbatim
WHILE DRIVING AT HIGH SPEEDS THERE WAS HEAVY VIBRATION IN THE REAR AXLE. WHEN DRIVING LOW SPEEDS FRONT/REAR END WONDERED. DEALERSHIP WAS NOTIFIED, BUT DID NOT RESOLVE THE PROBLEM. *AK
Too few reports in this category for a page of its own — they appear in the full complaint list.
Tires & wheels
Reports naming tires, wheels, hubs, or the tire-pressure monitoring system.
From owner reports, verbatim
WHILE DRIVING 65 MPH THE DRIVERS SIDE REAR OUTSIDE DUAL TIRE BLEW OUT. WHEN THE CONSUMER EXITED THE VEHICLE HE ALSO NOTICED THAT THE DRIVERS SIDE INSIDE TIRE WAS FLAT. THE CONSUMER WENT TO CHECK THE PRESSURE OF THE OUTSIDE TIRE AND IT WAS ALRIGHT. WHEN THE CONSUMER ATTEMPTED TO CHECK THE PRESSURE OF THE INSIDE PASSENGER TIRE THE EXTENDER VALVE FELL OFF IN THE CONSUMERS HAND AND THE AIR ESCAPED FROM THE TIRE. IT APPEARED THAT THE EXTENDER VALVE HAD SHEARED OFF. THE CONSUMER WENT BACK TO THE FLAT TIRE AND NOTICED THAT THE EXTENDER VALVE ON THAT TIRE HAD ALSO SHEARED OFF THUS CAUSING THE TIRE TO GO FLAT. THE TIRE TECH INFORMED THE CONSUMER THAT THE EXTENDER VALVES WERE NOT INSTALLED PROPERLY AND THAT THEY WERE SUPPOSED TO BE BRACED. THE CONSUMER BELIEVES THE WEIGHT OF THE TRUCK CAUSED THE OUTSIDE DUAL TIRE TO BLOW OUT WHEN THE INSIDE TIRE WENT FLAT (INSIDE GOOD YEAR TIRE SIZE 265-70R 19.5 UNISTEEL G124). *AK * CB *NLM
Too few reports in this category for a page of its own — they appear in the full complaint list.
Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.
Elsewhere on this vehicle
Data sources
- NHTSA Office of Defects Investigation — owner-reported complaints and the components recorded on them
Data on this page last refreshed .