2006 Isuzu I-280

ON JULY 28,2009, GM INITIATED A REGIONAL RECALL CAMPAIGN ON CERTAIN MODEL YEAR (MY) 2004-2009 CHEVROLET COLORADO AND GMC CANYON VEHICLES AND MY2006-2008 ISUZU I-SERIES VEHICLES.THE STATES AND U.S. TERRITORIES INVOLVED ARE AL, AZ, FL, GA, HI, LA, MS, NV, NM, PR, SC, TX, VI AND UT.A TOTAL OF 185,903 VEHICLES WILL BE RECALLED WITH 92,272 VEHICLES WITHIN THE SCOPE OF THIS INVESTIGATION.IN ADDITION, A SPECIAL COVERAGE/EXTENDED WARRANTY PROGRAM WILL BE INITIATED FORVEHICLES REGISTERED IN ALL OTHER STATES. GM DETERMINED THAT BRAKE LAMP SWITCH FAILURES ARE MORE LIKELY TO OCCUR IN VEHICLES IN WHICH CUSTOMERS USED INTERIOR CLEANERS CONTAINING SILICON AND THAT RESIDE IN HOT GEOGRAPHICAL LOCATIONS.BRAKE LAMP SWITCH CONTAMINATION FAILURE CAN CAUSE LOSS OF THE BRAKE LAMPS OR THE BRAKE LAMPS TO STAY ON CONTINUOUSLY, INCREASING THE RISK OF REAR-END CRASHES.GM HAS REPORTED NO CRASHES OR INJURIES DUE TO THE FAILURE OF THE BRAKE LAMP SWITCH.ODI INITIALLY REPORTED ONE CRASH INCIDENT, BUT LATER DOWNGRADED THE REPORT DUE TO THE ABSENCE OF ACTUAL PROPERTY DAMAGE OR COST INCURRED WHEN THE VEHICLE WAS LIGHTLY TAPPED FROM BEHIND AT LOW SPEED.THIS INVESTIGATION IS CLOSED (SEE RECALL CAMPAIGN 09V0310).

COUPLE OF WKS. AGO I HAD TO REPLACE FRONT LEFT HUB WHEEL ASSEMBLY WHICH AFFECTED DRIVE SHAFT, ABS, EMER. BRAKE. THAT WAS FIXED . NOW TONIGHT DRIVING FROM A FRIENDS I HEAR A CLICKING NOISE SOUNDS LIKE UNDERNEATH GEAR BOX OR BEHIND HEATER WHAT IS IT. ALSO INTERIOR LIGHTS TURN CONTROL & HAVE TO HIT AROUND LIGHT FOR IT TO TURN ON, AND AROUND FACING OF HEATER TO ILLUMINATE HEATER CONTROLS! WHAT'S GOING ON? THIS ONLY HAPPENED IN GEAR NOT IN NEUTRAL.HIGHWAY & CITY.

NHTSA ID

11171296

Incident

Jan 21, 2019

Mileage

181,000 mi

STRONG ODOR OF GASOLINE COMING FROM TRUCK. LEAK APPEARS TO BE COMING FROM THE TOP OF THE TANK. THERE ARE MANY COMPLAINTS OF THE SAME ISSUE WITH THE CHEVY COLORADO PICKUPS AND A FEW OF THE SAME ISSUE WITH THE ISUZU I280. I DID REPLACE THE GAS CAP, BUT THAT DID NOT SOLVE THE PROBLEM. MY NEXT STEP WILL BE REMOVING THE TANK AND REPAIRING THE FAULTY PART (LEAKING GASOLINE). WITH ALL THE ONLINE COMPLAINTS OF THE SAME ISSUE, I WOULD THINK THAT THERE SHOULD'VE BEEN A RECALL ISSUED. I DID CONTACT ISUZU, BUT THEY REPORT NO SUCH RECALL. I THEN CONTACTED CHEVY TO SEE IF THEY HAD A RECALL ON THE COLORADO (SAME TRUCK, DIFFERENT BADGE) BUT THEY WOULDN'T TELL ME IF THERE WAS A RECALL FOR THAT PROBLEM. CHEVY INFORMED ME THAT THEY CAN ONLY TRACE RECALLS THROUGH A VIN NUMBER AND DESPITE THE FACT THAT MY I280 IS A GM PRODUCT, THEIR LIST OF RECALLS COULDN'T BE SEARCHED USING MY VIN NUMBER. THE GASOLINE ODOR IS QUITE STRONG, BUT WILL DISSIPATE WHEN THE VEHICLE IS LEFT SITTING (NOT RUNNING) FOR A COUPLE OF DAYS. THE ODOR CAN STILL BE DETECTED AFTER SEVERAL DAYS OF NOT USING THE VEHICLE - IT'S JUST FAINT. I BELIEVE THIS ISSUE IS QUITE DANGEROUS AND POSSIBLY DUE TO EITHER FAULTY PARTS OR A FAULTY DESIGN. THE FACT THAT THERE ARE NUMEROUS COMPLAINTS, REGARDING THE EXACT SAME ISSUE, SUGGESTS THAT THE PROBLEM IS WIDESPREAD AND DUE TO A FAULTY PART OR DESIGN.

NHTSA ID

11019125

Incident

Jun 1, 2017

Mileage

100,000 mi

TL* THE CONTACT OWNS A 2006 ISUZU I-280. THE CONTACT STATED THAT THE BRAKE LIGHTS FAILED WITHOUT WARNING. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 196,000. THE VIN WAS NOT AVAILABLE.

NHTSA ID

10955015

Incident

Feb 6, 2017

Mileage

196,000 mi

DRIVERS SIDE AIR BAG WARNING LIGHT HAS TURNED ON AND REMAINS ON PERMANENTLY. QUESTIONABLE IF AIRBAGS WILL DEPLOY. NO ACCIDENTS IN VEHICLE OR ANY OTHER INCIDENT THAT MIGHT IN SOME WAY LEAD TO DAMAGE TO AIR BAGS, ELECTRICAL SYSTEM, SEAT BELT CONNECTIONS, ETC. *TR

NHTSA ID

10693741

Incident

Mar 1, 2011

TL* THE CONTACT OWNS A 2006 ISUZU I-280. THE CONTACT STATED THAT THE VEHICLE FAILED TO START AND THE SECURITY PASS LOCK WARNING INDICATOR ILLUMINATED ON THE INSTRUMENT PANEL. AFTER WAITING TEN MINUTES, THE ENGINE RESUMED NORMALLY. THE FAILURE RECURRED NUMEROUS TIMES. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER FOR DIAGNOSIS HOWEVER, THE DIAGNOSTIC COMPUTER WAS UNABLE TO GENERATE A FAILURE CODE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE DEFECT. THE APPROXIMATE FAILURE MILEAGE WAS 50,000.

NHTSA ID

10502108

Incident

Jun 1, 2011

Mileage

50,000 mi

TL*THE CONTACT OWNS A 2006 ISUZU I280. THE CONTACT STATED THAT THE ANTI THEFT LOCK DEVICE WOULD NOT ALLOW THE CONTACT TO START THE VEHICLE. THE CONTACT HAD TO WAIT OVER 20 MINUTES FOR THE ENGINE TO OPERATE, WHICH CAUSED THE INTERIOR LIGHTS TO DIM. THE DEALER WAS NOTIFIED OF THE ISSUE WHO OFFERED NO ASSISTANCE. THE MANUFACTURER WAS ALSO NOTIFIED WHO ADVISED THE CONTACT THAT THE VEHICLE WAS OUTSIDE OF WARRANTY AND PROVIDED NO ASSISTANCE. THE FAILURE MILEAGE WAS 49,600 AND THE CURRENT MILEAGE WAS 54,000. UPDATED 8/8/12 *CN THE CONSUMER STATED IN READ IN THE OWNERS MANUAL, WHERE THE PASSLOCK ANTI-THEFT DEVICE COULD CUT OFF THE FUEL AND NOT ALLOW THE ENGINE TO START, AS SOMETHING WAS TRIPPING IT. AFTER A MONTH OF CONSTANT PROBLEMS, HE DISCOVERED HIS WIFE'S CAR KEY TO HER NEW VEHICLE THAT HE WAS CARRYING IN HIS POCKET WAS TRIPPING IT. HE STATED HE STOPPED CARRYING THE KEY AND NOTICED THE PROBLEM LESSENED.

NHTSA ID

10463525

Incident

Dec 10, 2011

Mileage

49,600 mi

COMPLETE LOSS OF BRAKE LIGHTS / CRUISE CONTROL / KEEPS BLOWING FUSES. LEARNED OF RECALL ID # 52989 DATED 7/29/2009 - SO I TOOK VEHICLE TO DEALER ( COURTESY GMC - 205.836.2000 ) THEIR SERVICE MANAGER SENT ME AWAY - SAID TRUCK HAD RECALL #06030 PERFORMED ON 11/27/2006. I HAD A TRUSTED MECHANIC I KNOW CHECK BRAKE LIGHT SWITCH ( WHICH CHECKED OUT OK ) REPLACED IT ANYWAY WITH NEW ONE PURCHASED AT DEALER. BRAKE LIGHTS WORKED 5 MINUTES THEN BLEW FUSE AGAIN. MY MECHANIC TOLD ME THAT THE BRAKE LIGHT SWITCH WIRING FROM PREVIOUS RECALL WAS A BAD JOB - NOT DONE BY A PRO.

NHTSA ID

10418968

Incident

Aug 5, 2011

Mileage

47,600 mi

TL* THE CONTACT OWNS A 2006 ISUZU I280. WHILE DRIVING APPROXIMATELY 25 MPH, THE ABS WARNING INDICATOR ILLUMINATED AND A MESSAGE DISPLAYED FAULTY BRAKES ON THE INSTRUMENT PANEL. IN ADDITION, THE BRAKES WOULD MAKE A GRINDING NOISE WHEN DEPRESSED. THERE WAS A RECALL RELATED TO THE DEFECT UNDER NHTSA CAMPAIGN ID NUMBER 06V139000 (EXTERIOR LIGHTING: BRAKE LIGHTS: SWITCH); HOWEVER, THE VIN WAS NOT INCLUDED IN THE RECALL DEFECT. THE CONTACT WAS IN THE PROCESS OF NOTIFYING THE MANUFACTURER. THE FAILURE MILEAGE WAS UNAVAILABLE.

NHTSA ID

10411726

Incident

May 9, 2011

This bulletin outlines the procedures for using the Alpine Exchange Program (the "Exchange Program"). The Exchange Program must be used when any Alpine radio or other component covered by this bulletin is repaired under warranty and may also be used for radio and component repairs not covered under warranty. Contact Alpine directly for pricing and payment methods applicable to radio and component repairs not covered under warranty.

Isuzu Commercial Truck of America, Inc. (ICTA) is providing the following procedural recommendations to improve dealer efficiency when submitting Parts Warranty claims. We strongly recommend dealers follow these procedures in order to avoid delays in Parts Warranty claim payments and/or claim chargeback. This bulletin was revised to add a Parts Warranty Form

Isuzu Commercial Truck of America, Inc. (ICTA) is providing the following procedural recommendations to improve dealer efficiency when submitting Parts Warranty claims. We strongly recommend dealers follow these procedures in order to avoid delays in Parts Warranty claim payments and/or claim chargeback.

The Isuzu Commercial Truck of America (ICTA) Service Technical Assistance Center (TAC) provides diagnostic support to Isuzu dealer technicians repairing Isuzu vehicles in and out of vehicle warranty. A TAC case number will be issued solely for information tracking purposes and future contact reference.

The following is a list of the Isuzu-recommended Threebond product part numbers identified in the various Isuzu Workshop Manuals and bulletins. If a Threebond product is unavailable, we recommend that you utilize the chart below to find equivalent of similar products (when available) from Loctite and Permatex.

These SKUs are Exhaust Manifolds with Catalytic Converters. The customer communication requested return of unsold inventory due to a loss of CARB certification. These SKUs can no longer be sold as they do not meet CARB standards, but parts on vehicles are not effected.