1996 Jeep Cherokee Electrical Problems

The contact owns a 1996 Jeep Cherokee. The contact stated while driving at approximately 40 MPH, the vehicle was running rough and then stalled. The contact was unable to restart the vehicle. The contact stated no warning light was illuminated. The contact had the vehicle towed to the residence. The contact had a mobile mechanic diagnose the vehicle, and it was determined that there was a failure of the manifold. The vehicle was repaired. The contact stated that the vehicle was not running properly and called another mobile mechanic. The second mechanic diagnosed the vehicle and determined that an aftermarket distributor and aftermarket computer had both failed. The contact stated that the distributor and computer were installed previously by another independent mechanic. The contact had purchased the aftermarket parts, Cardone Distributor Part Number 84-4694, and Cardone Computer Part Number: 79-1199 Model Number: 04886961, online. The vehicle was not repaired. The manufacturer was informed of the failure and declined to stand behind the aftermarket computer and distributor parts. The failure mileage was approximately 223,000.

NHTSA ID

11626385

Incident

Oct 18, 2024

Mileage

223,000 mi

THE JEEP WILL START TO SHAKE WHENEVER YOU HIT A BUMP REALLY BAD SHAKING . ALSO WHENEVER YOU COME TO A STOP AFTER DRIVING 10 MILES THE MOST , THE CAR WILL NOT TURN ON AGAIN FOR ABOUT 20 MINUTES. AT SOME POINT I ROCKED THE CAR FROM SIDE TO SIDE AND AFTER THAT IT WILL START. ALSO TOO THE STEERING COLUMN SEEMS LOOSE . MY SHOCKS LIKE IT DON'T EVEN HAVE ANY

NHTSA ID

11317447

Incident

Jan 1, 2020

Mileage

16,665 mi

TL* THE CONTACT OWNS A 1996 JEEP CHEROKEE. WHILE DRIVING VARIOUS SPEEDS, THE SPEEDOMETER SEIZED WITHOUT WARNING AND THE VEHICLE BEGAN TO DECELERATE. THE VEHICLE WAS TAKEN TO A DEALER WHERE THE FAILURE COULD NOT BE DETERMINED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 120,000. THE VIN WAS NOT AVAILABLE.

NHTSA ID

10876502

Incident

Mar 25, 2016

Mileage

120,000 mi

WHILE DRIVING AT APROX. 40-45 MPH, THE JEEP WOULD START TO SHUDDER. EVENTUALLY IT WOULD SHUT OFF. THE JEEP WOULD THEN CRANK BUT NOT START. I HAD THIS PROBLEM HAPPEN FOR ABOUT FOUR TIMES. THREE OF THE TIMES THE JEEP WAS TOWED TO A REPAIR SHOP. TWICE THE PCM UNIT WAS REPLACED AND TWICE THE CRANK POSITION SENSOR WAS ALSO REPLACED. THE LAST REPAIR WAS 1 MONTH AND A HALF AGO. TWO DAYS AGO, THE JEEP STALLED AGAIN DOWN THE ROAD. I WAS TRAVELING WITH MY WIFE AND CHILDREN. WE ALMOST LOST OUR LIVES. A 16 WHEELER ALMOST COLLIDED WITH US DUE THAT I COULD BARELY MANIPULATE THE JEEP BECAUSE IT TURNED OFF ON ME. I TRIED TO DO SOME VISUAL INSPECTIONS UNDER THE HOOD. I HAD ONE OF MY SONS TO WIGGLE THE PCM (COMPUTER) WHILE I CRANKED THE STARTING SWITCH. AT ONE POINT THE JEEP MANAGED TO START AGAIN. THEN IT STALLED THE MOMENT MY SON STOPPED WIGGLING THE PCM. I HAD ANOTHER TOW TRUCK PICK UP THE JEEP AND SEND IT BACK TO THE MECHANIC. CHRYSLER HAS NOT CORRECTED THIS ISSUE ON THE PCM AND PERHAPS MIGHT NOT DO IT UNTIL ONE DAY SOMEONE GETS SERIOUSLY HURT. VIDEOS ON YOUTUBE SHOW OTHER JEEP CHEROKEE OWNERS HAVING THE SAME PROBLEM 1996-2001.

NHTSA ID

10721042

Incident

May 20, 2010

VEHICLE BEGAN STALLING WHEN COMING TO AN ABRUPT STOP OR BEING JARRED BY A BUMP OR POT HOLE. GRADUALLY PROGRESSED TO RANDOMLY STALLING WHEN APPLYING ANY PRESSURE TO BRAKES OR ANY SLIGHT JARRING. ALL POWER IS LOST AT THIS TIME ALONG WITH ANY CONTROL OF STEERING AND ACCELERATING UNTIL VEHICLE IS TURNED ON AGAIN. RECENTLY VEHICLE REPEATEDLY AND INTERMITTENTLY STALLS WITHOUT ANY PATTERN DURING ACCELERATION OR DECELERATION AT ANY SPEED WITHOUT ANY BRAKING OR JARRING. IT THEN CATCHES ON ITS OWN AND REGAINS POWER. *TR

NHTSA ID

10693765

Incident

Jan 16, 2012

Mileage

224,000 mi

WHILE LEAVING HOME FROM WORK, THE VEHICLE STARTED TO SHUTTER AND FAIL. I MANAGED TO GET HOME AT A SPEED OF 40MPH SINCE I NOTICED THAT AT A HIGHER SPEED, THE VEHICLE WOULD TRY TO STALL. THE NEXT DAY I TRIED TO TURN ON THE VEHICLE BUT IT WOULD NOT TURN ON. I CALLED A CERTIFIED MECHANIC AND RECEIVED INSTRUCTIONS THRU CELL PHONE TO SHAKE A BIT THE CABLES TO COMPUTER COMPONENTS AND CABLES TO DISTRIBUTOR COMPONENTS. THE VEHICLE TURNED ON BUT WITH PROBLEMS. I MANAGED TO DRIVE TO MECHANIC SHOP WHERE THE CHEROKEE WAS LEFT FOR TESTING AND REPAIRS. THE DIAGNOSTICS SHOWED A FAULTY COMPUTER. THE COMPUTER WAS REPLACED. ABOUT THREE MONTHS LATER, THE VEHICLE STALLED AGAIN AT A CROSS ROAD AND TURNED OFF. A TRUCK NEARLY STRUCK ME BECAUSE I COULDN'T GET OUT ON TIME. THE MECHANIC HAD TO SHOW UP AT THE SITE AND HAD SOME PROBLEMS STARTING THE CHEROKEE. THE DIAGNOSTICS, ANOTHER BLOWN COMPUTER. THE MECHANIC ORDERED ANOTHER COMPUTER WITH UPGRADE (HAD TO WAIT ABOUT A MONTH) ORIGINAL CRANK SHAFT SENSOR WAS ADDED. ALL SEEMED TO WORK WELL UNTIL YESTERDAY OCT/2/2013 WHEN I WENT OUT FOR A RIDE WITH MY SON AND THE CHEROKEE STALLED AND TURNED OFF. THE SAME SYMPTOMS AS BEFORE. I HAVE SPENT ABOUT $1,000.00 TRYING TO GET MY JEEP CHEROKEE TO RUN PROPERLY AND NOW I'M AFRAID TO TAKE IT OUT TO THE STREET. I HAVE A FAMILY OF 4 AND I WORRY THAT THE CHEROKEE WOULD FAIL ME BY STALLING AGAIN AT A CROSSROAD CAUSING A FATAL ACCIDENT TO ME OR MY FAMILY BECAUSE OF THIS ELECTRICAL FAILURE. ALL CABLES WERE CHECKED FOR SHORTS BUT NOTHING SOLVES THE PROBLEM. I DID SOME RECALL SEARCH BUT NOTHING OFFICIAL ALTHOUGH SOME JEEP GRAND CHEROKEE USERS REPORT THE SAME PROBLEMS FOR THEIR 4.0L ENGINE (MY JEEP CHEROKEE IS ALSO 4.0L) COINCIDENCE? I LOVE MY CHEROKEE BUT FEEL THAT I CAN'T RELY ANYMORE ON IT AS FOR SAFETY. HAD IT FOR ABOUT 6 YEARS WITHOUT PROBLEMS THE FIRST 5 YEARS. *TR

NHTSA ID

10546603

Incident

Mar 8, 2013

Mileage

151,950 mi

I WAS DRIVING DOWN THE HIGHWAY,AND ALL OF A SUDDEN I HEARD A LOUD NOISE. SO I PULLED OVER TO THE NEAREST GAS STATION AND REALIZED I WAS LEAKING OIL PROFUSELY. THEN I REALIZED THE DRIVER SIDE MOTOR MOUNT HAD BROKEN OFF OF THE ENGINE CAUSING A LARGE HOLE IN THE ENGINE BLOCK. I HAVE TAKEN GREAT CARE OF MY VEHICLE, CHANGED THE OIL EVERY 3,000 MILES, AND THEN THIS HAPPENS AT RANDOM. I DIDN'T HIT ANYTHING TO CAUSE THE MOTOR MOUNT TO BREAK, SO WHY WOULD IT BREAK FOR NO REASON? ANYWAYS, THE LEAKING OIL CAUSED A FIRE BENEATH MY VEHICLE, AND INSIDE THE ENGINE COMPARTMENT. BUT I QUICKLY PUT OUT THE FIRE BY A CONTAINER OF WATER I HAD IN MY VEHICLE. I HAD MY 13 YEAR OLD BROTHER WITH ME AND THANK GOD HE OR MYSELF WAS NOT INJURED. BUT IT CAUSED US GREAT FEAR AND STRESS. *TR

NHTSA ID

10487514

Incident

Aug 7, 2012

Mileage

131,862 mi

WITH TIME THE BLOWER MOTOR WIRING HARNESS (WHICH IS TOO SMALL FOR THE AMPERAGE) IN THESE VEHICLES INVARIABLY HEATS UP AND MELTS OR BURNS. THE MELTING OF THE HARNESS AND CONNECTOR BEHIND THE BLOWER SPEED SELECTOR SWITCH IN THE DASH AND THE BURNING OF THE SWITCH ITSELF OCCURED IN MY VEHICLE, ALLONG WITH THE FAILURE OF THE BLOWER MOTOR RESISTOR, BUT IN MANY VEHICLES THE RESISTOR IS THE FIRST TO BURN AND FAIL. I HAVE LOOKED AT OVER 20 OF THESE VEHICLES RANGING FROM 1991 TO 1996, AND 30000 TO 220000 MILES, AND EVERY SINGLE ONE ONE THEM HAD THESE COMPONENTS MELTED AND BURNED TO THE POINT OF NOT BEING USABLE, AND MAKING ONE WONDER HOW MANY OTHER VEHICLES HAVE CAUGHT FIRE AND BURNED BECAUSE OF THIS FAULT. SOME OF THESE VEHICLES ALSO SHOWED ASSOCIATED WIRES BURNED OR MELTED IN THE STEERING COLUMN. AN ASSOCIATED SYMPTOM IS THAT THE BLOWER MOTOR CEASES TO FUNCTION, OR (IN THE CASE OF RESISTOR FAILURE, WILL USUALLY WORK ONLY ON HIGH SPEED). THIS SHOWS A DEFECT THAT MAY TAKE TIME TO MANIFEST, BUT WILL ALWAYS OCCUR EVENTUALLY IN EVERY VEHICLE UNLESS THE BLOWER IS NEVER USED. THE BLOWER SWITCH TO RESISTOR WIRING HARNESS AND SWITCH CONNECTOR/PLUG ARE NOT EVEN AVAILABLE FROM DEALERS, BUT THE SWITCH ITSELF AND THE RESISTOR ARE AVAILABLE AS AFTERMARKET ITEMS. HOWEVER, IF REPLACED, THESE WILL FAIL TOO, UNLESS THE WIRING IN THIS CIRCUIT IS REPLACED WITH HEAVIER GUAGE WIRING OR SOMEHOW PROTECTED FROM HIGH AMPERAGE. AS EVIDENCED BY HUNDREDS OF RELATED COMPLAINTS ON INTERNET FORUMS, THIS IS A SERIOUS PROBLEM THAT COULD RESULT IN FIRES, AND POTENTIALLY LOSS OF LIFE. LUCKILY MY FIRE WAS MINOR, DID LITTLE DAMAGE AND WAS QUICKLY EXTINGUISHED. HOWEVER, I'M NOT SURE HOW TO RESOLVE THE ACTUAL PROBLEM PROPERLY, SINCE OEM REPLACEMENT PARTS WILL SOONER OR LATER DEVELOP THE SAME PROBLEMS, AND AVAILABLE AFTERMARKET PARTS ARE NOT IMPROVED OVER THE ORIGINALS. *TR

NHTSA ID

10456075

Incident

Feb 15, 2012

Mileage

176,010 mi

CAR STALLS WHILE DRIVING WITH NO WARNING. STALLS ON FREEWAY OR IN CITY DRIVING. THIS IS AN INFAMOUS MANUFACTURING DEFECT ON 96 JEEPS. VERY HAZARDOUS BECAUSE ENGINE CUTS OUT COMPLETELY WHILE IN MOTION. REQUIRES PULLING OVER WITH ENGINE NOT RUNNING TO RESTART ENGINE. JEEP THEN WILL REPEATEDLY DIE AFTER RE-STARTING. SINCE ENGINE DIES WHILE IN MOTION, CARS BEHIND ARE IN REAL DANGER OF COLLIDING WITH MY VEHICLE. THIS ISSUE IS ALMOST IMPOSSIBLE TO FIX WITH NORMAL MECHANICAL PROBLEM-SOLVING. ENGINE LIGHT DOES NOT COME ON. THIS ISSUE IS WELL DOCUMENTED IN ONLINE BLOGS FOR JEEPS WITH THIS PROBLEM. THIS PROBLEM WITH STALLING WHILE IN MOTION POSES A GREAT THREAT TO PUBLIC SAFETY. JEEP/CHRYSLER IS AWARE AND DOES NOT ACKNOWLEDGE THE PROBLEM. *TR

NHTSA ID

10453707

Incident

Feb 6, 2012

Mileage

125,005 mi

TL* THE CONTACT OWNS A 1996 JEEP CHEROKEE. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 30 MPH WITH THE AIR CONDITIONER ACTIVATED ON HIGH, SMOKE BEGAN TO EMIT FROM THE IGNITION SWITCH. THE AIR CONDITIONER WAS TURNED OFF IN ORDER TO STOP THE SMOKE FROM EMITTING. THE VEHICLE WAS NOT TAKEN TO THE DEALER FOR DIAGNOSTICS. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 61,015.

NHTSA ID

10417210

Incident

Aug 5, 2011

Mileage

61,015 mi

I HAVE A 1996 JEEP CHEROKEE. THE HEATER STARTED MAKING A FUNNY NOISE SO WE BOUGHT A NEW BLOWER MOTOR. THEN WE BOUGHT A NEW RESISTOR. WE STILL COULD NOT GET THE SPEEDS TO WORK IN THE HEATER. SO WE THEN BOUGHT A SWITCH. WELL WE COME TO FIND OUT THAT THE SWITCH HARNESS WAS BURNT TO A CRISP. I CALLED THE PARTS STORE AND THEY DON'T CARRY THEM, SO I THEN CALLED A DEALER. THE DEALER TOLD ME THEY DON'T JUST SELL THAT HARNESS I HAD TO BUY THE ENTIRE ONE FOR EVERYTHING IN THE JEEP. THEN TOLD ME TO GO CUT ONE OUT OF A JUNK YARD. I CALLED MY LOCAL JUNK YARD AND THE GUY WENT AND CUT THREE HARNESSES OUT. ONE THAT WAS A 1996, ONE THAT WAS A 1995, AND BOTH OF THE ENDS WERE BURNT JUST LIKE MINE. HE THEN CUT ONE OUT OF AN EVEN OLDER ONE, AND THE WIRES WERE THICKER THAN THE ONES ON MINE, AND DIFFERENT COLORS. I TRIED HOOKING IT UP AND IT DOESN'T WORK. I BELIEVE THAT SHOULD BE A RECALL AND IT SHOULD HAVE TO BE REPLACED BY THE COMPANY. THE COMPANY SHOULD ALSO SELL INDIVIDUAL HARNESSES. *TR

NHTSA ID

10301780

Incident

Jan 2, 2010

Mileage

183,000 mi

WHILE OPERATING THE VEHICLE I KEPT SMELLING BURNING PLASTIC. THE HEATER FAN QUIT AND WHEN I JIGGLED THE SWITCH IT STARTED TO OPERATE AT HIGH FAN ONLY AND WOULD NOT LET ME SET IT TO LOW. THEN IT QUIT WORKING AND I REMOVED THE SWITCH TO REPLACE IT. I FOUND THAT THE WIRING HARNESS WAS MELTED. I AM NOW CONCERNED ABOUT THE DANGER OF REPLACING THE SWITCH. I AM NOT SURE IF I CAN REPLACE THE MELTED PART OF THE WIRING HARNESS. I ALSO NOTICED THAT THE SWITCH HAS 5 CONNECTIONS BUT ONLY 4 WIRES WERE CONNECTED TO IT. *TR

NHTSA ID

10294997

Incident

Dec 8, 2009

Mileage

182,000 mi

MY MOTHER-N-LAW PURCHASED A 1996 CHEROKEE, AND THE CHECK ENGINE LIGHT WAS ON . SO SHE TOOK IT TO THE EMISSION PLACE TO GET IT CHECKED AND IT FAILED THE TEST, SO SHE TOOK THE EMISSION PAPERS AND THE VEHICLE TO THE AUTO SHOP , AND THE MECHANIC STATED THAT THE CAR SHOULD HAVE NEVER BEEN SOLD TO HER , SO WHAT SHOULD SHE DO AT THIS POINT. *TR

NHTSA ID

10261448

Incident

Feb 6, 2009

TL*- THE CONTACT STATED THAT WHILE DRIVING BEHIND THE 1996 JEEP CHEROKEE AT 60 MPH, SHE NOTICED SMOKE COMING FROM UNDER THE VEHICLE. THE CONTACT FLASHED THE LIGHTS TO GET THE ATTENTION OF THE DRIVER. THE DRIVER PULLED TO THE SHOULDER, GOT OUT OF THE VEHICLE AND BACKED AWAY. THE VEHICLE BEGAN TO BURN, AND HAD TO BE TOWED. THE CONTACT DID NOT KNOW THE CAUSE OF THE FIRE. THE FIRE DEPARTMENT WAS CALLED AND THEY EXTINGUISHED THE FIRE. THE CONTACT HAD NOT RECEIVED A POLICE OR FIRE DEPARTMENT REPORT. THERE WERE NO INJURIES. *AK

NHTSA ID

10180826

Incident

Nov 22, 2006

Mileage

120,000 mi

1996 JEEP CHEROKE WHILE DRIVING WITH BLOWER ON (AIR) , STEERING COLUMN STARTED SMOKING AND MELTING THE PLASTIC HOUSING. CAUSE WAS DETERMINED TO BE IGNITION SWITCH WAS NOT HEAVY DUTY ENOUGH TO HANDLE BLOWER MOTOR CURRENT AND THE WIRES IN THE HARNESS BURNED AND MELTED. WIRES AND SWITCH WAS REPLACED AND 1 YEAR LATER SAME THING HAPPENED AGAIN CAUSING THE INTERIOR TO FILL WITH SMOKE WHILE DRIVING AND THE WIRING HARNESS TO BURN UP AGAIN. A MECHANIC AT A DEALER TOLD ME THIS WAS A NOT UNCOMMON PROBLEM WITH THAT JEEP MODEL. I WAS TOLD THAT THE CHRYSLER VAN USED THE SAME SWITCH AND HARNESS AND THERE WAS A SAFETY RECALL FOR THEM BUT NOTHING WAS EVER DONE ABOUT THE JEEP CHEROKEE !!

NHTSA ID

10125541

Incident

Jun 18, 2001

Mileage

73,443 mi

THE VEHICLE IGNITED AFTER BEING PARKED FOR APPROXIMATELY 2 HOURS. FIRE INVESTIGATION PINPOINTED START IN THE MAIN HOUSING OF THE ELECTRICAL, IN THE FIREWALL.

NHTSA ID

10071261

Incident

Nov 15, 2003

Mileage

99,000 mi

1. ELECTRICAL SHORT UNDER LEFT SIDE DASH, MAIN WIRE BUNDLE GOING TO FUSE BOX RUBBED AGAINST BOLT AND WORE THROUGH WIRE CAUSING A SHORT. 2. NEUTRAL SAFETY SWITCH GONE BAD. 3. DRIVER'S SIDE SEAT RAIL BROKE SOMEWHERE AND SEAT ROCKS AROUND. 4. REAR LEAF SPRINGS HAVE A NEGATIVE ARCH IN THEM CAUSING REAR TO SAG AND WHEELS TO RUB WITH MINIMUM WEIGHT IN VEHICLE. DT

NHTSA ID

769266

Incident

Aug 15, 2002

A FIRE STARTED IN ENGINE COMPARTMENT WHILE DRIVING 15 MPH. DEALER AND MANUFACTURER WERE NOTIFIED. FEEL FREE TO PROVIDE ANY FURTHER INFORMATION.*AK

NHTSA ID

8008879

Incident

Apr 19, 2002

WHILE STARTING VEHICLE ENGINE WOULD NOT TURN. SERVICE TECHNICIAN STATED FUEL PUMP NEEDED TO BE REPLACED. ALSO, BATTERY WAS DRAINED. PROBLEMS HAD RETURN. *AK THE REPLACED FUEL PUMP FAILED AND HAD TO BE REPAIRED UNDER WARRANTY. *YH

NHTSA ID

8002560

Incident

Aug 24, 2001

VEHICLE BURSTED INTO FLAME AND EXPLODED WHILE PARKED OUTSIDE OF HOME. LOCAL FIRE DEPARTMENT ARRIVED AND EXTINGUISHED FIRE. ALSO, FIRE DEPARTMENT BELIEVED FIRE WAS DUE TO AN UNDER HOOD ELECTRICAL SHORT. DEALER / MANUFACTURER WERE NOTIFIED. FEEL FREE TO PROVIDE ANY FURTHER DETAILS ON THIS MATTER. *AK

NHTSA ID

887402

Incident

Apr 24, 2001

VEHICLE WAS PARKED IN GEAR WITH ENGINE TURNED OFF WHEN IT CAUGHT ON FIRE IN ENGINE CARPARTMENT AREA. CAUSE UNKNOWN. CONSUER WAS WAITING FOR FURTHER INFORMATION. PLEASE PROVIDE FURTHER INFORMATION.*AK

NHTSA ID

887154

WHILE VEHICLE WAS PARKED AND NOT RUNNING, A FIRE IGNITED IN THE ENGINE COMPARTMENT, THE ADJUSTER AND FIRE COMPANY BELIEVED THE FIRE WAS STARTED AT THE POWER DISTRIBUTION CENTER, CONSUMER ASKED DEALER ABOUT THE RECALL (95V193) THAT DEALT WITH THIS COMPONENT AND WAS TOLD THIS VEHICLE DOES NOT FALL UNDER THE RECALL, AFTER THE FIRE THE VEHICLE WAS A TOTAL LOSS. *SLC

NHTSA ID

557166

NO SUMMARY LISTED FOR ABOVE VEHICLE. *AK

NHTSA ID

734056

Incident

Sep 15, 2000

VEHICLE HAS EXPERIENCED FAILURE OF THE RECALL COMPONENT ON SEVERAL OCCASIONS, THE FAILURE HAS CAUSED OTHER BRAKE COMPONENTS TO WEAR EXCESSIVELY AS WELL. (00V-136) *MJS

NHTSA ID

552923

Incident

Mar 23, 1999

HAD PARKED VEHICLE. WAS INFORMED BY ANOTHER INDIVIDUAL THAT VEHICLE WAS ON FIRE. THE FIRE DEPT CALLED & EXTINGUISHED FLAMES. HAD INDICATED IT WAS FAULTY ELECTRICAL WIRING. [XXX] *AK INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

NHTSA ID

848276

Incident

Aug 12, 1999