2006 Jeep Commander

Chrysler is conducting a safety recall of approximately 643,618 model year 2006-2007 Jeep Commander and model year 2005-2007 Jeep Grand Cherokee vehicles to address the problem of ignition turning off while driving (see NHTSA recall 14V-438 for more information).According to Chrysler, these vehicles may experience an unintended change in ignition switch position while driving, which may result in loss of engine power, power steering, and braking assist, increasing the risk of a crash and disabling one or more of the vehicle's safety features including the frontal air bags.Most of the reported incidents occurred as a result of driver interaction with the ignition key.Based on the recall action taken by Chrysler, this Preliminary Evaluation is closed.Additionalinformation on this closing resume, and the investigation are in the PE14-017 public file available online at SaferCar.gov.The ODI reports cited above can be reviewed online at http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers: 10101116 10103300 10106060 10112589 10116788 10126986 10128093 10130780 10145501 10146213 10153018 10155291 10156396 10158165 10162933 10166746 10178559 10183305 10186545 10189530 10192237 10193106 10194092 10199552 10199986 10221500 10222283 10227253 10231011 10328609 10358324 10392364 10577532 10585326 10585976 10599142 10604990 10605091 10605209 10606494 10606610 10607043 10607614 10607785 10608196 10615565 10615671 10615761 10616124 10633266 10633313 10633724 10639371 10640010 10644827 10652526 10653000 10653382 10654009 10654139 10654809 10655095 10659448 10662220 10662703

On November 18, 2010, NHTSA's Recall Management Division (RMD) opened an audit query (AQ10-001) to investigate recall remedy completion by rental car companies on safety recall campaigns.It was expected to provide the agency an indication of how completely and how quickly rental car fleets perform necessary recall-related remedies on the vehicles owned and then rented/leased for use on the roadways.RMD queried three (3) major motor vehicle manufacturers (Ford, Chrysler, and General Motors) and requested data regarding completion figures for fifteen (15) discreet safety recalls.Analysis of this data demonstrated that rental car recalls completion was neither complete nor consistent.The rental car companies representing the largest market share in the industry were then queried as to their respective policies for the rental, lease, and sale of vehicles with open recalls.The data and responses from the manufacturers and the rental car companies can be found in the document repository by accessing the ?Associated Documents link above.In December 2015, Congress enacted the Fixing America's Surface Transportation (FAST) Act.One section of the Act prohibits rental car companies from renting, leasing, or selling motor vehicles subject to open safety recalls.With the passage of the FAST Act and its prohibition, there is no continuing need for the agency to investigate rental car recall completions.Accordingly, this investigation is closed.The agency reserves the right to open any future investigations, including audits of individual recalls, or groups of recalls, or rental car companies, to examine more closely safety recalls performance and completion issues in this area.

ON MAY 5, 2008, CHRYSLER LLC (CHRYSLER) SUBMITTED A DEFECT INFORMATION REPORT TO NHTSA CONCERNING AN ENGINE CALIBRATION ISSUE THAT COULD RESULT IN ENGINE STALL IN APPROXIMATELY 24,461 MODEL YEAR (MY) 2006 JEEP COMMANDER VEHICLES EQUIPPED WITH THE 4.7L V-8 ENGINE AND BUILT FROM FEBRUARY 25, 2005 THROUGH JANUARY 11, 2006.ACCORDING TO CHRYSLER, THE POWERTRAIN CONTROL MODULE (PCM) WAS PROGRAMMED WITH SOFTWARE THAT MAY ALLOW THE ENGINE TO STALL DURING CERTAIN OPERATING CONDITIONS.CHRYSLER DEALERS WILL REPROGRAM THE PCM SOFTWARE IN THE RECALLED VEHICLES. INFORMATION PROVIDED BY CHRYSLER DURING PE07-009 AND EA07-007 INDICATED THAT A REVISED ENGINE CALIBRATION WAS IMPLEMENTED IN PRODUCTION EFFECTIVE JANUARY 12, 2006 FOR THE MY 2006 JEEP COMMANDER VEHICLES EQUIPPED WITH 4.7L V-8 ENGINES.ODI'S ANALYSIS OFCONSUMER COMPLAINTS, FIELD REPORTS AND OTHER DATA RELATED TO FIELD EXPERIENCE WITH ENGINE STALLING IN MY 2006 THROUGH 2007 JEEP COMMANDER VEHICLES EQUIPPED WITH 3.7L, 4.7L AND 5.7L ENGINES IDENTIFIED AN ELEVATED RATE OF STALLING INCIDENTS IN THE MY 2006 VEHICLES EQUIPPED WITH 4.7L ENGINES THAT WERE MANUFACTURED BEFORE THE CALIBRATION CHANGE.ODI INTERVIEWED OVER 70 CONSUMERS WHO REPORTED STALLING INCIDENTS IN EARLY PRODUCTION MY 2006 4.7L VEHICLES.INFORMATION GATHERED FROM THOSE INTERVIEWS INDICATED THAT THE STALLING INCIDENTS WERE OCCURRING AT VARIOUS SPEEDS, OFTEN OCCURRED DURING TURNS AND TYPICALLY OCCURRED MORE THAN ONCE.THE INTERVIEWS DID NOT IDENTIFY ANY CONCERNS WITH RESTARTABILITY. ALTHOUGH THE EARLY MY 2006 PRODUCTION VEHICLES WITH 4.7L ENGINES MAKE UP ONLY ABOUT 15 PERCENT OF ALL MY 2006 THROUGH 2007 JEEP COMMANDERS BUILT BY CHRYSLER, THEY WERE RESPONSIBLE FOR 465 OF THE 854 REPORTED STALLING INCIDENTS (54%), 6 OF THE 12 CRASH INCIDENTS (50%) AND THE ONLY INJURY CLAIM.THE STALLING RATE FOR THE RECALLED VEHICLES IS 1.90 PERCENT, ALMOST 7 TIMES GREATER THAN THE RATE IN THE REMAINING POPULATION (0.28 PERCENT).CHRYSLER'S RECALL COVERS THE VEHICLES WITH THE ELEVATED STALLING RATE.THE REMAINING VEHICLES HAVE RELATIVELY LOW RATES OF STALLING AND DO NOT EXHIBIT ANY SIGNS OF AGGRAVATING FACTORS SUCH AS PROBLEMS WITH RESTART. ODI ALSO ANALYZED COMPLAINTS ALLEGING CONCERNS WITH LOSS OF LIGHTING COINCIDENT TO STALLING INCIDENTS.THIS ANALYSIS IDENTIFIED SEVEN STALLING INCIDENTS WHERE LOSS OF EXTERIOR LIGHTING WAS ALLEGED.NO SPECIFIC CAUSE WAS IDENTIFIED IN THESE INCIDENTS AND THERE WAS NO DISCERNIBLE PATTERN REGARDING ENGINE, VEHICLE PRODUCTION OPTIONS, BUILD RANGE OR FAILURE TREND. THIS INVESTIGATION IS CLOSED WITH CHRYSLER'S RECALL.

ODI HAS RECEIVED 76 VEHICLE OWNER COMPLAINTS ALLEGING INCIDENTS OF ENGINE STALL WHILE DRIVING IN MODEL YEAR (MY) 2006 THROUGH 2007 JEEP COMMANDER VEHICLES (SUBJECT VEHICLES).SOME OF THE COMPLAINTS REPORTED ONE OR MORE INCIDENTS OF ENGINE STALL WITH A SIMULTANEOUS LOSS OF SOME OR ALL LIGHTING SYSTEMS, INCLUDING HEADLAMPS.TWO ENGINE STALLS RESULTED IN A VEHICLE CRASH.IN ITS RESPONSE TO A REQUEST FOR INFORMATION, DAIMLERCHRYSLER CORPORATION (DCC) INDICATED THAT IT HAS NOT DETERMINED THE CAUSE OF ENGINE STALLING IN THE SUBJECT VEHICLES AND THAT IT HASFORMED A MULTI-DISCIPLINARY TASK FORCE TO INVESTIGATE THE ISSUE. THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA07-007) TO FURTHER ASSESS THE FREQUENCY, SCOPE AND POTENTIAL SAFETY CONSEQUENCES OF THE ALLEGED DEFECT.

Brakes failed completely. 2-3 car lengths between be and car in front of me with plenty of time to stop. My jeep did not even slow down when brakes we applied.

NHTSA ID

11733742

Incident

Apr 23, 2026

My jeep will shut off unexpectedly, it will do a up and down idle increase and decrease while at a idle the abs will lock up my wheel tight to where itll drag while trying to move forward. The 4x4 low will not engage at all says service 4x4

NHTSA ID

11710463

Incident

Dec 31, 1969

The contact owns a 2006 Jeep Commander. The contact stated while driving approximately 10 MPH in a parking lot the vehicle stalled. There was no warning light illuminated. The contact stated the failure was intermittent but a recurring failure. The contact stated that the failure occurred at various speeds. The contact stated that the 12-Volt battery had been replaced approximately 2 years ago due to battery drainage issues. The contact stated that the failure with the 12-Volt battery being drained and had jumpstart the vehicle several times. The contact researched online and related the failure to NHTSA Campaign Number: 08V203000 (Power Train); however, the VIN was not included in the recall. The contact also replaced the ECM module independently. The contact had not taken the vehicle to a local dealer or independent mechanic. The manufacturer was not informed of the failure. The failure mileage was approximately 200,000.

NHTSA ID

11694039

Incident

Aug 16, 2024

Mileage

200,000 mi

Seat Belts/Rear. The integrated retractor bracket edge on the third row seat may contact the seat belt during certain operating conditions. In the event of a crash, the seat belt may not properly restrain thee third row occupant. Service Brakes. Hydraulic: Antilock/Traction Control/Electronic Limited.: Control Unit/Module. On certain sport utility vehicles, the software programmed into this ABS Electronic Control Module allow a momentary delay in breaking when coasting up a kill during certain conditions. This has happened while wet conditions occur some.

NHTSA ID

11687373

Incident

Sep 15, 2025

Power Train. The (TCM/PCM/TECM) Chrysler is recalling 24, 461 Jeep Commander vehicles equipped with 407 V8 engines. Th powertrain control module (PCM) was programmed with software that may allow the engine to stall under certain operating conditions. This could cause a crash without warning. ( My Jeep turns on, but it is not able to be moved, it is stalled indefinitely). I asked the dealer @Rockwall Dodge, Rockwall TX to check the PCM/TCM/TECM. They refused. Said they were not able to check this situation. Didn't have that equipment. Electrical System. This defect can affect the safe operation of the airbag system. The air bag lights comes on randomly. The engine will turn off, which will then depower various key safety systems. I am unable to unlock the ignition on several occasions. Suspension. Rock Krawler recalled 44 performance suspension systems sold as aftermarket equipment for use on the vehicle listed above. We have had suspension issues on our Jeep. No one can find the issue to fix it. The Jeep makes noise at the suspension system.

NHTSA ID

11687370

Incident

Sep 13, 2025

Radiator coolant system failed and caused the engine to overheat and loss of power while traveling on an interstate highway. Pulled over to side of highway. The vehicle was towed to a private mechanic shop. The shop evaluated the engine could not start as it had seized from overheating. It was determined that the radiator plastic end caps suddenly failed causing the engine to overheat and seize. The radiator temperature is very high and the plastic and aluminum materials expand and contract at different rates therefore weakening the connection between the two materials until the part fails. This is a bad design, application, and mix of materials in a part that does follow the basic principles of thermodynamics.

NHTSA ID

11668118

Incident

Jul 16, 2016

Abs, traction control, and another light come on and goes off intermittent. While reversing feels like brakes are locking up. Transmission shifts different intermittently. I have seen that there is recalls for other 06 commanders that reflect the issues I am having.

NHTSA ID

11656154

Incident

Mar 21, 2025

Vehicle randomly saying transmission over temp. Vehicle may or may not crank upon turning key Vehicle downshifts to second gear while driving and has caused me to run off the road/slam on brakes to stop Vehicle resets itself to where Jeep dealership cannot even trace wiring harness for shorts or check to see if transmission control module works properly after having my commander from August to December. Suspect faulty Transmission control module/short due to poorly designed wiring and parts on manufacturer's behalf. Other issues include random codes with each new code reader, stereo wiring issues, vehicle changing from v8 to v4 randomly while driving, consuming excessive gas amounts only receiving 9 miles per gal of fuel Extremely dangerous to drive and do not feel safe

NHTSA ID

11640684

Incident

Apr 11, 2024

Plate - Planetary

Security Module Lock Out After Entering the PIN to Unlock The Wireless Control Module (WCM)

Security Module Lock Out After Entering the PIN to Unlock The Wireless Control Module (WCM)

Transmission Kit with Torque Converter 1. All Promaster (VF) 3.6L/62TE equipped vehicles. If the transmission bracket to the transmission case fasteners are removed during servicing, the fasteners (Part Number 06511385A$) are one-time usage. Vehicles built prior to 10/23/2015 requires Service Kit PN 68461214AA; includes Transmission Isolator PN 68264483AA, and Adaptation Bracket 68264479AA and Fastener Service Kit PN 68329056AA Vehicles built after on or after 10/23/2015 will require only the Fastener Service Kit PN 68329056AA. 2. All 3.6L/62TE equipped vehicles. If the vehicle you are repairing has a crack in the flex plate or failed pump bushing inspect and confirm that both (2) dowel pins are present in the engine block, which align the transmission center line to the crank shaft centerline and visually inspect the dowel alignment holes in the transmission case. If the holes are damaged or elongated the transmission should be replaced to prevent further damage to the transmission/flexplate or pump bushing due to the inability to properly align the engine to the transmission during the repair. 3. All 62TE equipped vehicles. If pump bushing is scored or damaged and the dowel pin alignment holes are ok, replace the pump assembly as opposed to complete transmission. 4. All 62TE equipped vehicles. If vehicle is jerking/slipping with MIL code(s) P0740 or P2764, check TCC Solenoid operation. If TCC Solenoid is ok, the codes are indicative of a torque converter failure. Replace the torque converter.

Mechanical rocker arm, intake, 1.7 ratio.

Mechanical rocker arm, intake, 1.7 ratio.