2006 Jeep Liberty Suspension Problems

ball joint recall was issues and done on paper in August 2006 on the Jeep liberty. Both ball joint have failed on this vehicle at different times this year while driving the vehicle and Jeep has declined to take any responsibility in any way. This is a major safety concern as any kind of speed while this occurs would be catastrophic. I suspect that Jeep submitted that the recall was fixed when in fact it was not and documents were falsified.

NHTSA ID

11751878

Incident

Jul 15, 2026

Mileage

163,911 mi

The contact owns a 2006 Jeep Liberty. The contact stated that while driving at an undisclosed speed, the steering wheel was loose, with a clunking sound coming from the steering wheel. The vehicle was taken for inspection and failed the inspection. The vehicle was diagnosed by a certified mechanic, and the contact was informed that the driver's side ball joint was detaching and needed to be replaced. The vehicle was taken to another certified mechanic to be repaired. Two years later, the steering was loose again. The vehicle was taken for inspection, and it failed the inspection again. The vehicle was not repaired. The contact researched and found information about NHTSA Campaign Number: 06V288000 (Suspension); and associated the failure with the recall. The dealer was contacted and confirmed that the VIN was not included in the recall. The manufacturer was not made aware of the issue. The failure mileage was 87,803.

NHTSA ID

11730737

Incident

Apr 13, 2024

Mileage

87,803 mi

The front lower ball joints have repeatedly failed under recall. The dealer says I now have to pay to have it repaired properly, under recall

NHTSA ID

11716426

Incident

Jan 25, 2026

Vehicle: 2006 Jeep Liberty VIN: [XXX] Summary: The front lower ball joint on my 2006 Jeep Liberty failed while the vehicle was in normal use. This failure matches the defect described in NHTSA Recall 06V288000 (Chrysler F23), which involves corrosion and separation of the front lower ball joints. My VIN does not currently show this recall as open, but the failure occurred exactly as described in the recall documentation. Details: In November 2025, the front end of the vehicle collapsed due to a lower ball joint separation. The joint failed without warning, causing loss of steering control. The vehicle had to be towed home by AAA. The failure is consistent with the recall condition involving water intrusion, corrosion, and separation of the lower ball joint from the steering knuckle. The vehicle still has other open recalls (fuel tank and rear lower control arms), but the front lower ball joint recall does not appear as open in the NHTSA VIN lookup. I believe the recall may have been incorrectly marked as completed in the past, or the original repair was not performed or not performed correctly. The defect has clearly recurred. Safety Concern: This is a serious safety hazard. The ball joint separation caused sudden loss of steering and could have resulted in a crash. The defect is identical to the condition described in Recall 06V288000. Requested Action: I am requesting that NHTSA review this case and require Chrysler/Stellantis to perform the recall repair for the front lower ball joints, as the defect has reoccurred and the recall never expires. I also request verification of whether the recall was ever properly completed on this VIN. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ID

11713720

Incident

Nov 5, 2025

The contact owns a 2006 Jeep Liberty. The contact stated that while driving approximately 20-25 MPH, the front control arm fractured. The front wheel seized, and the vehicle drove into a driveway. There were no warning lights illuminated. The vehicle was towed to the residence. The local dealer was contacted and suggested an appointment, and that the rear control arm was not covered under warranty. The contact was informed about NHTSA Campaign Number: 13V252000 (Fuel System, Gasoline, Structure) and NHTSA Campaign Number: 18V278000 (Suspension). The vehicle was not diagnosed or repaired. The manufacturer was contacted and referred the contact to the local dealer for assistance. The approximate failure mileage was 180,000.

NHTSA ID

11699001

Incident

Nov 5, 2025

Mileage

180,000 mi

The contact owns a 2006 Jeep Liberty. The contact stated that while reversing, the contact noticed an abnormal sound before the vehicle stopped. The contact stated that upon inspecting the vehicle, the front of the vehicle had lowered unintendedly. The contact noticed that the front lower ball joint had detached and separated from the spindle. The vehicle was not diagnosed or repaired by an independent mechanic or the dealer. The dealer was made aware of the failure. The contact referenced an unknown recall; however, the VIN was not included in the recall. The manufacturer was not made aware of the failure. The failure mileage was approximately 214,564.

NHTSA ID

11681633

Incident

Aug 17, 2025

Mileage

214,564 mi

The contact owns a 2006 Jeep Liberty. The contact stated while driving on the highway at 55 MPH, there was an abnormal popping sound coming from the front passenger’s side, and the vehicle started to skid. There was no warning light illuminated. The contact pulled over onto the side of the road to park and inspect the vehicle and became aware that the front passenger’s side lower ball joint was fractured. The vehicle was towed to a local independent mechanic where the vehicle was diagnosed, and the contact was informed that the lower ball joint was fractured and needed to be replaced. The vehicle was repaired. The manufacturer was notified of the failure. The approximate failure mileage was 213,000.

NHTSA ID

11644146

Incident

Feb 20, 2025

Mileage

213,000 mi

I was driving down the freeway at 70 mph, and suddenly my car (2006 Jeep Liberty) felt as if the rear end was dragging and I began to lose control of my vehicle. The icy Michigan conditions were no help, but thankfully the drivers surrounding me were attentive and moved out of the way until i was able to regain control and pull onto the shoulder. I had my vehicle towed to a shop, where i was informed the rear control arm had fractured and in turn damaged the rear axle. I found out there was a recall for this EXACT problem on my car, a blessing because my family is struggling very badly financially. BUT, Chrysler says my vehicle's VIN is not listed on the recall and it is not their problem. Not only is this extremely dangerous for all drivers of these effected vehicles, but my kids missed school today because I don't have a functioning vehicle. Manufacturers need to be held accountable and publicly announce ALL VEHICLES THAT COULD BE EFFECTED, not whichever number of vehicles pleases public relations.

NHTSA ID

11638430

Incident

Jan 22, 2025

The contact owns a 2006 Jeep Liberty. The contact received notification of NHTSA Campaign Numbers: 13V252000 (Fuel System, Gasoline, Structure) and 18V278000 (Suspension) however, the parts to do the recall repairs were not yet available. The contact stated while driving at various speeds, there was an abnormal sound coming from underneath the vehicle. The vehicle was taken to the dealer, where it was diagnosed and determined that the abnormal sound was due to a lower control arm failure. The vehicle was not repaired. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recalls repairs. The manufacturer was made aware of the failure. The failure mileage was approximately 63,000. Parts distribution disconnect.

NHTSA ID

11574040

Incident

Jan 6, 2024

Mileage

63,000 mi

Driver Front Lower Ball joint failed. Recalled ball joints were replaced in 2006. Spoke to Chrysler in 2020 about both lower ball joint boots being deteriorating and ball joints worn and rusty due to failure of recall work but refused to redo recall due to age of vehicle. Vehicle has less than 100k miles. Ball joint failed when turning from stop sign. Loud pop was heard and grinding from drivers side wheel.

NHTSA ID

11513891

Incident

Mar 26, 2023

I have 2 recall on my 2006 jeep liberty dealer don’t want to fix please I need help.

NHTSA ID

11510994

Incident

Mar 9, 2023

The contact owns a 2006 Jeep Liberty. The contact stated while exiting a parking lot and going over a small speed bump, the vehicle inadvertently lowered to the floor. The contact noticed that the ball joint had detached from the wheel. The vehicle was towed to a tire repair shop where the vehicle was diagnosed and the mechanic stated that the front suspension lower ball joint had separated from the wheel. The dealer was contacted and stated that the vehicle was not included in Manufacturer Safety Recall: F23 (Lower Ball Joints). The vehicle was not repaired. The manufacturer was contacted and stated the vehicle was not included in Manufacturer Safety Recall: F23 (Lower Ball Joints) and advised to contact the NHTSA Hotline. The failure mileage was 118,000.

NHTSA ID

11483499

Incident

Sep 3, 2022

Mileage

118,000 mi

The front lower ball joint on the passenger side broke in half which caused my tire to completely separate from the car. Luckily it happened in my driveway, but I had just gotten off the interstate going 75 mph. After replacing it, a closer inspection was done on both upper front ball joints and the driver side lower ball joint. All need replacement. It was a near miss crash, but mine and others safety is still on jeopardy because I can't afford to replace all of them. I haven’t received any recall information in the mail from the manufacturer.

NHTSA ID

11479253

Incident

Aug 6, 2022

The rear lower control arms on my car are about to break. One has holes all the way through. At 40 mph, vehicle shakes in back. Issue also causes stability control to malfunction. No Jeep dealers that I can use will make appointments before 06/27 even after being shown the terrible condition of the parts. Nor do they offer a loaner car. I contacted Jeep themselves and was offered NO manner of accommodation or compensation. I drive for a living, so I can either risk my safety, or give up two weeks income, and job, waiting for Jeep and it's dealers to fix defective equipment. If Jeep and their dealers are unable/unwilling to fix dangerous recalls in a timely manner, they should either afford customer a rental car, or offer to buy the vehicle at market value. I would have accepted either, and not filed this complaint, had I been offered.

NHTSA ID

11469246

Incident

Jun 14, 2022

2006 JEEP LIBERTY. CONSUMER WRITES SEEKING REIMBURSEMENT FOR REPAIRS RELATED TO BALL JOINT SAFETY RECALL.

NHTSA ID

11461171

Incident

Apr 18, 2022

2017 passenger ball joint broke Driving about 25mph, no injuries No recalls were found, towed, repaired 2019 driver side ball joint broke Vehicle was stationary in a wait line at restaurant, no injuries No recalls found, towed, repaired 2021 Christmas night, passenger ball joint breaks again Speed was 60mph, minor injury occurred without medical attention. Haven't been towed or repaired yet.

NHTSA ID

11445423

Incident

Dec 25, 2021

My back rear control arms/suspension/alignment were recalled, I had them replaced. Now My front control arms/suspension/alignment are very unsafe to drive. Wobbly, unstable, loose, noises, screeching. It Feels like it’s going to break/snap/fall off. Yes my vehicle is available for inspection. I feel unsafe on turns especially. It could snap at any moment and my Jeep could roll injuring me or others. I had a tire/allignment center check the status. No warning lights or messages. The sound and issue has been going on since I got my jeep recall fixed. The dealership hit the front of my Jeep in the parking lot and still has not taken responsibility for their actions and damages done to my Jeep. It was evaluated from Jeep’s body/auto shop estimating at outer damage 1,500$ + and they have not inspected the damage caused to the control arm/suspension/alignment from the employee hitting me Jeep into something moments before returning my Jeep from a recall-fix. Jeeo still has yet to take responsibility for the damages caused. I have not felt safe since then. The steering has been wobbly, the turns make noise and shudder like the wheel is going to break off/fall off or worse snap. I have tried numerous attempts to get these issues resolved with Jeep Liberty of San Diego Camino del rio s. With no responsibility taken from them for the damages they have caused making me Jeep unsafe to drive.

NHTSA ID

11439944

Incident

Jul 25, 2018

The contact owns a 2006 Jeep Liberty. The contact stated that upon making turns in either direction, an abnormal squeaking noise would emit from the vehicle without warning. The contact was informed by an independent mechanic that the front lower ball joints were defective and needed to be repaired. The contact was informed of NHTSA Campaign Number: 06V288000 (Suspension) which the mechanic linked to the failure. The manufacturer was notified, and the contact was informed that her vehicle was not included in the recall. The vehicle had yet to be repaired. The failure mileage was approximately 157,000.

NHTSA ID

11437155

Incident

Jul 1, 2021

Mileage

157,000 mi

The contact owns a 2006 Jeep Liberty. The contact stated while driving at slow speeds, the driver's side front of vehicle lowered to the ground causing a tire blowout. The ABS and TPMS warning lights were illuminated. The contact called the local dealer however, the vehicle was not diagnosed or repaired. The manufacturer was notified however, no further assistance was provided. The contact stated that the failure was related to NHTSA Campaign Number: 18V278000 (Suspension). The failure mileage was 179,323.

NHTSA ID

11434464

Incident

Sep 26, 2021

Mileage

179,323 mi

2006 JEEP LIBERTY. CONSUMER IS SEEKING REIMBURSEMENT FOR REPAIRS MADE RELATED TO NHTSA SAFETY RECALL 18V-278. THE CONSUMER STATED THE MANUFACTURER DECLINED TO REIMBURSE THE COST OF REPAIRS DUE TO THE VEHICLE BEING OUT OF WARRANTY AND CREDIT CARD NOTICE NOT BEING SUBMITTED. *JS

NHTSA ID

11433759

Incident

Sep 21, 2021

ALREADY HAD RECALL REAR CONTROL ARMS THEN JEEP WAS MAKING NOISE FRONT DRIVER SIDE I WENT TO RUN CORNER ON CITY STREET CONTROL ARM IN FRONT BROKE BLEW OUT TIRE AND RIM HAD TO HAVE IT TOW THEN NOT EVEN 6 MONTHS LATER UPPER CONTROL ARM PASSENGERS IDENTIFIED SAME THING I WAS LUCKY ENOUGH TO NOT BE ON HIGHWAY ELECTRICAL PROBLEMS HAD CAR 3 1/2 YES REPLACE COMPRESSOR TWICE AND ALTERNATOR TWICE EVERY NOW RADIO GOES OFF AND ON LITES GO DANGEROUS CAR BUT CA N T AFFORD TO DO ANYTHING ABOUT IT

NHTSA ID

11413466

Incident

Apr 7, 2021

Mileage

250,000 mi

UNKNOWN - TESTING FOR ODI

NHTSA ID

11396657

Incident

Feb 4, 2021

THE CAR VIBRATES A LOT , THE CAR LOSES CONTROL ESPECIALLY WITH TURNS TO DANGEROUS, AND SLIDES FROM REAR

NHTSA ID

11395221

Incident

Jun 20, 2019

Mileage

145,000 mi

I'VE HAD LOWER BALL JOINTS, BUSHING AND CONTROL ARMS ALREADY REPLACED ONCE IN 2017 AND NOW THEY ARE OUT AGAIN. I'VE BEEN TOLD BY MOPAR THAT MY 2006 LIBERTY WAS MADE 5 WEEKS AFTER THE LAST ONE INVOLVED IN THE RECALL.THIS IS INEXCUSABLE. I'VE HAD 3 WINDOW REGULATORS REPLACED. THIS IS A FATALITY WAITING TO HAPPEN IF I DRIVE. I STARTED HEARING AND FEELING THE BALL JOINTS GOING BAD ABOUT 2 WEEKS AGO. I HARDLY HAVE DRIVEN IT SINCE I WORK FROM HOME NOW. CAN CHRYSLER SEE ALL THESE COMPLAINTS ABOUT THE BALL JOINTS AND STILL NOT ADD THESE 06 JEEP'S TO THAT RECALL. THIS IS NOT GOOD BUSINESS AT ALL. ALSO JUST HAD FRONT BRAKES DONE 1 YEAR AGO AND THEY NEED REPLACED ALREADY. IGNITION - MY KEY WILL NOT COME OUT OF THE IGNITION UNLESS I PUSH ON THE IGNITION CABLE. PLEASE HELP ME TO GET THESE PROBLEMS FIXED. THIS IS UNACCEPTABLE FROM CHRYSLER.

NHTSA ID

11376079

Incident

Nov 1, 2020

Mileage

165,000 mi

THERE IS AN ACTIVE RECALL ON SOME 2006 JEEP LIBERTY'S, HOWEVER MINE WAS NOT INCLUDED IN THE RECALL BUT IS HAVING THE ISSUES OF THE RECALL. I NEED MY VEHICLE INCLUDED IN THE RECALL SINCE IT IS A PROBLEM MY VEHICLE IS EXPERIENCING. I WAS TOLD BY THE DEALER THAT THE FRONT BALL JOINTS (CONTROL ARMS) ARE OUT AND THAT IS WHAT THE RECALL IS FOR. THERE WAS ALSO A RECALL FOR THE REAR CONTROL ARMS AND WE HAD THAT RECALL CORRECTED. PLEASE ADD MY CAR TO THE RECALL LIST SO THSI CAN BE CORRECTED.

NHTSA ID

11374133

Incident

Nov 6, 2020

Mileage

120,700 mi