2006 Jeep Wrangler Problems

Vehicle’s inlet check valve for gas tank does not work properly when tank is filled at fueling stations. Does not trigger gas pumps to stop causing overflow and spilling on person / clothing / vehicle and gas station property. This is a known issue for 2005-2006 Jeep Wranglers. The issue was repaired by manufacturer for newer Jeep Wranglers. Currently no manufacturer ownership on remediation issue and/or recall for 2005-2006 model year Jeep Wranglers.

WHEN FILLING UP THE GAS TANK WITH FUEL, THE FUEL SPLASHES OUT GOING OVER ME, MY FENDERS, SIDE OF JEEP AND THE GROUND. I BELIEVE THIS IS A MAJOR SAFETY ISSUE.AND JEEP SHOULD BE LIABLE. GOD FORBID IF THIS CAUSED A FATALITY.

DEATH WOBBLE. VEHICLE WILL SHAKE VIOLENTLY AT TIMES BETWEEN 50-53 MPH. CONDITION WILL RETURN TO NORMAL AFTER DECELERATING TO < 40 MPH, MOST TIMES. OCCASIONALLY WILL HAVE TO COME TO COMPLETE STOP.

2006 JEEP WRANGLER. CONSUMER WRITES IN REGARDS TO VEHICLE EXHIBITS SEVERE/ VIOLENT VIBRATION "JEEP DEATH WOBBLE" ISSUES. DEALERSHIP HAS NO SOLUTIONS OTHER THAN TIRE ROTATION AND ALIGNMENTS. *SMD THE CONSUMER STATED THE VIBRATION WAS SO SEVERE, HE HAD TO SLOW THE VEHICLE DOWN, BECAUSE IT FELT AS THOUGH THE VEHICLE WAS FALLING APART. *JB

EXPERIENCING THE "DEATH WOBBLE" AT 55 MPH. SLOWING DOWN OR SPEEDING UP WILL CAUSE IT TO GO AWAY.HAPPENS ABOUT 33% OF THE TIME WHILE ACCELERATING OR DECELERATING.

DEATH WOBBLE- BRAKING AT 55MPH, HITTING BUMP AT 55 + MPH. ON GOING. DANGEROUS SITUATION. THIS WAS ADDRESSED FOR 2015-2016 BUT THE COMPONENTS IN MY JEEP ARE THE SAME AS NEWER JEEPS AND IS A DANGER FOR OLDER JEEPS.

The transmission has been shifting very hard and erratic for years and if i hit a bump the steering wheel shakes violently. Has been doing these things since almost new the dealer would not fix any of it.

THE VEHICLE WHILE OPERATING UNDER NORMAL DRIVING CONDITIONS HAD A CHECK ENGINE LIGHT APPEAR. A CERTIFIED MECHANIC FOUND THE TCM WAS FAULTY. FINDINGS: P0218 HIGH TEMP OPERATION ACTIVATED. P0714 TRANSMISSION TEMP SENSOR INTERMITTENT. P0613 INTERNAL TCM PROBLEM. INSTRUMENT CLUSTER: 1 TCM/SINGLE BOARD ENGINE CONTROL MESSAGE NOT RECEIVED DATA LIST FOR TCM IS READING 1023 DEGREES FAHRENHEIT OR 1.10 VOLTS HAVING CODE P0613 TCM IS FAULTY.

The ECU/PCU has developed a failure to control the idle air intake valve due to an unrepairable defect on the computer. IT can shut the engine down without warning while running, especially when approaching stops. IT requires the operator to try to control the issue using the accelerator pedal to override it and prevent the engine from cutting out. It can happen without warning, and de[pending on the skill level of the driver, an accident can easily result. PLUS there are NO repair parts for the ECU/PCU in the parts system, resulting in an unsafe and unmaintainable vehicle on the highways. The ECU /PCU was used one year only, so the Chrysler engineers knew they had a defect. No older Jeep used this particular unit and no younger ones used it either!

WHILE PARKING MY 2006 JEEP WRANGLER UNLIMITED INTO A PARKING SPACE I PUT THE CAR INTO PARK AND IT CONTINUED TO DRIFT FORWARD. I HAD TO PULL THE EMERGENCY BRAKE UP TO STOP IT. I TURNED THE CAR OFF AND THEN IT WOULD NOT RESTART. I HAD THE CAR REPAIRED AND IT WAS THE TRANSMISSION SHIFTER CABLE.

THE VEHICLE WHILE OPERATING UNDER NORMAL DRIVING CONDITIONS HAD A CHECK ENGINE LIGHT APPEAR. A CERTIFIED MECHANIC FOUND THE TCM WAS FAULTY. FINDINGS: P0218 HIGH TEMP OPERATION ACTIVATED. P0714 TRANSMISSION TEMP SENSOR INTERMITTENT. P0613 INTERNAL TCM PROBLEM. INSTRUMENT CLUSTER: 1 TCM/SINGLE BOARD ENGINE CONTROL MESSAGE NOT RECEIVED DATA LIST FOR TCM IS READING 1023 DEGREES FAHRENHEIT OR 1.10 VOLTS HAVING CODE P0613 TCM IS FAULTY.

TL* THE CONTACT OWNS A 2006 JEEP WRANGLER. THE CONTACT WAS AN INDEPENDENT MECHANIC AND STATED THAT THE BATTERY ALMOST FAILED AND THE 02 OXYGEN HEAT SENSOR WAS NOT ABLE TO COMPLETE THE FINAL TEST OF REPROGRAMMING. ALSO, THE ACTION SENSOR HEAT MODULE COULD NOT BE REPROGRAMMED. THE CONTACT CALLED AUBURN CHRYSLER DODGE JEEP RAM (1901 GRASS VALLEY HWY, AUBURN, CA 95603, (888) 268-8026) AND WAS INFORMED THAT THE VEHICLE WAS NOT INCLUDED IN A RECALL. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND REFERRED THE CONTACT TO NHTSA. THE FAILURE MILEAGE WAS APPROXIMATELY 50,000.

LEFT REAR BRAKE LOCKS WHEEL WHEN EMERGENCY STOP OR WET PAVEMENT. NO VISIBLE DEFECT BY 2 BRAKE SHOPS. HAPPENS WHEN MOVING ON DRY OR WET CITY STREETS.

LOST BREAKS ON VEHICLE. TOOK VEHICLE TO GET FIXED...WAS INFORMED THE BREAK LINE WAS MOUNTED AGAINST BODY AND DUE TO THIS AND NORMAL BOUNCING OF THE VEHICLE THE METAL CUT THROUGH THE BREAK LINE.

2006 JEEP WRANGLER. CONSUMER STATES SHIFT CABLE BUSHING BROKE WHICH CAUSED THE AUTOMATIC TRANSMISSION SHIFT LEVER TO BE INOPERABLE. *TGW THE CONSUMER STATED THE SHIFT CABLE FAILED TWICE. *JB

2006 JEEP WRANGLER. CONSUMER STATES CLUTCH PEDAL SNAPPED. THE CONSUMER STATED WHEN HE ATTEMPTED TO START THE VEHICLE, THE CLUTCH SNAPPED AND DANGLED. THE CLUTCH HYDRAULIC UNIT ACTUATING ROD HAD SNAPPED IN TWO. THE VEHICLE HAD TO BE TOWED TO THE DEALER. THE CONSUMER STATED THE DEALER CONTACTED HIM AND STATED THE RECALL WAS PERFORMED IN AUGUST 2006. THE CONSUMER STATED HE FORGOT THE RECALL HAD ALREADY BEEN PERFORMED. BUT APPARENTLY, THE CLUTCH HYDRAULIC UNIT THAT WAS INSTALLED UNDER THE RECALL IS ALSO DEFECTIVE. *JB

TL* THE CONTACT OWNS A 2006 JEEP WRANGLER. WHILE DRIVING 60 MPH, THE STEERING WHEEL VIBRATED AND SHOOK WHEN THE VEHICLE DROVE OVER A BUMP. THE CONTACT HAD TO HOLD THE STEERING WHEEL AGGRESSIVELY, SLOW DOWN, AND STOP THE VEHICLE. THE DEALER DIAGNOSED THAT THE SHOCKS AND TIRES NEEDED TO BE REPLACED. THE PARTS WERE REPLACED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE VIN WAS UNKNOWN. THE APPROXIMATE FAILURE MILEAGE WAS 8,000.

I WAS DRIVING ON THE INTERSTATE AT A SPEED OF ABOUT 55-60 MILES PER HOUR. I DROVE INTO A CURVED PART OF THE INTERSTATE THAT VEERED TO THE LEFT AND WHEN I TRAVELED THROUGH IT, THE WHOLE JEEP BEGAN TO SHAKE VIOLENTLY. I SLOWED DOWN TO PULL OVER AND WHEN I REACHED ABOUT 40 MILES PER HOUR, THE SHAKING STOPPED. I ASKED A MECHANIC ABOUT IT AND HE SAID THAT THIS "DEATH RATTLE" IS A COMMON PROBLEM WITH JEEPS. WE CHANGED THE TIRES AND THE STEERING DAMPER. THIS SEEMED TO FIX THE PROBLEM FOR A WHILE BUT A YEAR LATER THE SHAKING CAME BACK. I DID SOME INVESTIGATING ON THE INTERNET ABOUT THE DEATH WOBBLE AND FOUND OUT THAT THE CAUSE CAN BE ONE OR MORE OF A NUMBER OF THINGS ON THE FRONT END. I HAD THE TRACK BAR CHANGED AND THAT HELPED ABOUT 80%. NOW, 8 MONTHS LATER THE SHAKING IS BACK. I UNDERSTAND FROM THE INTERNET THAT THIS DEATH WOBBLE PROBLEM IS RAMPANT ACROSS THE COUNTRY WITH DIFFERENT JEEP OWNERS. YET CHRYSLER WILL NOT ADMIT THAT THERE IS A PROBLEM. IS THERE ANY RECOURSE OTHER THAN ME SPENDING HUNDREDS TO THOUSANDS OF MY DOLLARS TO FIX A PROBLEM THAT IS OBVIOUSLY THE FAULT OF CHRYSLER?

MY JEEP EXPERIENCES WHAT'S KNOWN AS THE "DEATH WOBBLE." IT HAS HAPPENED FOR YEARS, BUT I HAD ALWAYS BEEN TOLD THAT MY TIRES WERE OUT OF BALANCE, OR THAT I NEEDED A FRONT WHEEL ALIGNMENT. THOSE FIXES WOULD HELP FOR A COUPLE OF MONTHS, AND THEN THE SHAKE WOULD RETURN. JUST IN THE LAST 6-8 MONTHS DID A MECHANIC ACTUALLY TELL ME ABOUT THE WOBBLE, WHAT REALLY SEEMS TO CAUSE IT, AND THAT IT'S A KNOWN ISSUE WITH JEEPS. MY JEEP IS STOCK, WITH NO MODIFICATIONS, BUT I STILL GET THE WOBBLE. IT OCCURRED 3 TIMES THIS MORNING ON THE 5 FREEWAY IN SAN DIEGO COUNTY, EACH TIME AT SPEEDS BETWEEN 55-68 MILES PER HOUR. THE FRONT END OF THE JEEP SHAKES VIOLENTLY, AND THE ONLY WAY TO STOP THE SHAKING IS TO COME TO A COMPLETE STOP. LUCKILY, I'VE ALWAYS BEEN ABLE TO PULL OVER SAFELY TO THE SHOULDER OF THE FREEWAY. A FEW MONTHS AGO IT HAPPENED, AND A CO-WORKER WAS FOLLOWING ME IN A DIFFERENT VEHICLE. HE SAID MY FRONT TIRES WERE ACTUALLY SMOKING BECAUSE OF THE WAY THE TIRES MOVED ON THE FREEWAY. *TR

I HAVE AN 06 JEEP WRANGLER WITH THE DEATH WOBBLE. THIS IS AN ONGOING PROBLEM. I HAVE REPLACED MY TIRES THREE TIMES. I TOOK MY JEEP AND HAD THREE MECHANICS LOOK IT OVER TODAY, EACH WITH THE SAME RESPONSE, " I DON'T KNOW WHAT IT COULD BE." I'VE CALLED JEEP SEVERAL TIMES, I REPLACED THE STEERING DAMPER AS THEY RECOMMENDED. THIS HAS BEEN GOING ON FOR YEARS AND I JUST DON'T KNOW WHAT ELSE TO DO. *TR

The frame of this vehicle has deteriorated to the point of becoming a safety hazard. The frame has rusted through over 50% of the thickness (internally) and has broken through to the outside in several areas around where the suspension and transmission attach. I recognize that this is an older vehicle, but it has larger percentage of rust than other vehicles I have owned and I do not believe it should be this deteriorated. I believe there must have been a manufacturing defect in the design (water/dirt) can get trapped in the frame or the material used was of insufficient corrosion resistance. Component Malfunction: Frame Structural Integrity Safety Risk: Drivetrain/Suspension could detach from vehicle causing safety risk to occupant of vehicle or nearby pedestrians/vehicles/structures. Inspected by dealership: Dealership did not mention it, probably because this is a 'known' issue that they don't have a fix for. (Frame replacement is expensive) Inspected by police: Indiana does not require inspections. (No) Warning Lamps: No. Symptoms appeared in 2020, seem to have accelerated over the last two years/5000 miles.

HELLO, I AM WRITING TO COMPLAIN ABOUT A LEAKING DOOR SEAL ON MY 2006 WRANGLER. THE SEAL HAS BEEN REPLACED THREE TIMES, BUT CONTINUES TO LEAK. WHEN IT RAINS, WATER COLLECTS ON THE FLOOR CREATING A WET AND SLIPPERY CONDITION THAT MAKES IT DANGEROUS TO DRIVE, AS THE HEEL SLIPS WHILE OPERATING THE PEDALS. FURTHERMORE, THE WATER LEAK CAUSES A MOLD CONDITION THAT IS HARMFUL TO HEALTH. PLEASE LET ME KNOW IF THERE IS ANYTHING YOU CAN DO. THANK YOU.

JEEP WRANGLER FAN SPEED SELECTOR SWITCH IS A KNOWN ISSUE FROM THE "TJ" YEARS. THEY TYPICALLY BURN OUT THE FIRST 2 SPEEDS AND THE LAST 2 WILL WORK FOR A WHILE, AND ALSO FAIL LEAVING NO METHOD TO DEFROST OR CLEAR YOUR WINDOW. *TR

OUR WRANGLER RUBICON WAS PURCHASED NEW FROM A DODGE/CHRYSLER/JEEP DEALERSHIP IN BULLHEAD CITY DURING MODEL YEAR, 2006. SINCE THAT TIME, THE JEEP HAS BEEN TAKEN INTO THE DEALERSHIP TO FIX THE WINDSHIELD RUBBER SEAL THAT CONTINUES TO SEPARATE FROM THE WINDSHIELD AND THE WINDOW FRAME. FIRST IT SHRANK IN THE LOWER LEFT CORNER. THIS CAUSED WIND NOISE AND EXCESSIVE DRAFTS. THEY PUSHED IT BACK INTO PLACE. SEVERAL MONTHS LATER, THE ENTIRE GASKET SEPARATED AND FELL ONTO THE DASH! GOOD VISTA GLASS CAME TO OUR HOME CHECKED THE SEAL AND TOLD US IT WAS DEFECTIVE AND THE WHOLE RUBBER GASKET WOULD HAVE TO BE REPLACED. IT WAS. NOW THIS WEEK, WHILE THE JEEP JUST SAT IN OUR DRIVEWAY, WE DISCOVERED THE ENTIRE RUBBER SEAL AGAIN HANGING FROM THE WINDOW FRAME ABOVE THE DASHBOARD. THIS MAKES DRIVING THE JEEP TO GET IT REPAIRED DANGEROUS. AS I TYPE THIS, GOOD VISTA GLASS AGAIN IS PLACING A NEW GASKET INTO PLACE. I AM NOT COMPLETELY SURE ABOUT THE INTEGRITY OF THE WINDSHIELD WHEN THIS CONTINUES TO HAPPEN BUT AT THE VERY LEAST, THERE IS A DANGER OF THIS GASKET FALLING INTO MY VIEW AND/OR LAP WHILE DRIVING. MY VEHICLE HISTORY IS IMPORTANT TOO. I, LIKE A LOT OF 4 X 4 OWNERS, DO NOT EVEN TAKE THE JEEP OFF ROAD. I "BABY" THE VEHICLE AND KEEP IN IMMACULATE CONDITION. ALSO, ALL OF THE FOLKS I HAVE DEALT WITH AT SWANTY'S JEEP AND GOOD VISTA GLASS HAVE BEEN POLITE AND HELPFUL. NOW, I WAS TOLD BY THE GOOD VISTA GLASS TECHNICIAN YESTERDAY, 10/01/06 THAT THIS WINDSHIELD GASKET SEPARATION IS A CONTINUING PROBLEM WITH JEEPS. MAYBE A RECALL SHOULD BE IN ORDER? ALL DOCUMENTATION HAS BEEN RETAINED. THANK YOU, JOHN L JENKINS FORT MOHAVE, AZ *TR

WAS DELIVERING MAIL STARTED TO SMELL SOMETHING GOT OUT TO CHECK PACKAGE GOT BACK IN SMOKE WAS COMING FROM VENTS AROUND DASH AREA WENT FOR HELP WHEN RETURNING TO VEHICLE IT WAS IN FLAME TRIED TO SALVAGE AS MUCH MAIL AS POSSIBLE AND IT BURNED COMPLETELY

MY 2006 JEEP WRANGLER HAS BEEN A PROBLEM SINCE I BOUGHT IT. THE VEHICLE HAS BEEN BACK TO THE DEALERSHIP FOR PART REPLACEMENT REPAIR OVER 7 TIMES, AND IT HAS ONLY 24,000 K. WON'T DETAIL EACH MECHANICAL ISSUE, BUT I HAVE BEEN VERY DISAPPOINTED IN THIS VEHICLE, AND GOT RID OF IT LAST WEEK. *TR

TL* THE CONTACT OWNS A 2006 JEEP WRANGLER 4X4. THE CONTACT STATED THAT AFTER PUTTING ON HER SEAT BELT AND TRYING TO TIGHTEN IT, THE METAL PART INSIDE THE CHAIR FAILED. THE VEHICLE WAS TAKEN TO A DEALER WHO WAS UNABLE TO DETERMINE WHAT CAUSED THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS CONTACTED AND THEY OFFERED NO ASSISTANCE. THE FAILURE AND CURRENT MILEAGE WAS 61,113.

TL* THE CONTACT OWNS A 2006 JEEP WRANGLER SPORT. THE CONTACT STATED THAT THE PASSENGER SIDE SEAT BELT WOULD NOT RETRACT, AND COULD NOT BE UTILIZED. THE DEALER AND THE MANUFACTURER WERE NOTIFIED OF THE FAILURE, BUT DENIED ANY ASSISTANCE WITH REPAIRS TO THE VEHICLE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 29,700 AND THE CURRENT MILEAGE WAS 29,828. THE VIN WAS UNAVAILABLE.

Unrecalled, unreplaced TAKATA air bags. This particular Jeep has been operated in high temperature/high humidity conditions and which was known to the manufacturers to cause potentially fatal injuries to the driver and front seat passenger. The truck was built by Daimler Chrysler (2006), and neither they, nor the successor companies Fiat/Chrysler and Stellantis have made no efforts whatsoever to contact the owners (I am the original owner from day 1) to effect repair or replacement of the defective air bags and initiator units. The unit was extensively operated in the Paris , Texas area for 2-1/2 years in extremely high humidity/hot temperatures in normal service. They should be considered compromised by your own tests done in the 2006-2012 period.

December 19th, 2022 Gentlemen/Ladies: This vehicle has been operated over five (5) of its sixteen (16) years in East and West Texas, in an extremely high heat and high humidity environment. It has been also in Central Illinois for about 9 years in a similar environment, and it is known to have the Takata air bag initiator units that are prone to an over 50% dangerous explosion failure rate when actuated. Given that this vehicle is soon to be exported to an equally high heat and humidity environment in service, may I ask why haven't you required Chrysler/Jeep to recall and repair the units in question? Given that there are no doubt several million Jeep Wranglers and Wrangler Unlimiteds with these Takata units in them, it is an unconscionable mistake to allow them to continue in daily service in an unrepaired or updated condition. When, not if these units fail, the results can result in serious injuries and deaths.

WAS DELIVERING MAIL STARTED TO SMELL SOMETHING GOT OUT TO CHECK PACKAGE GOT BACK IN SMOKE WAS COMING FROM VENTS AROUND DASH AREA WENT FOR HELP WHEN RETURNING TO VEHICLE IT WAS IN FLAME TRIED TO SALVAGE AS MUCH MAIL AS POSSIBLE AND IT BURNED COMPLETELY

FOR AT LEAST THE THIRD TIME, WHILE OFF ROAD JEEPING IN 4 WHEEL LOW, OUR JEEP 2006 LJ RUBICON SELF ACCELERATED ON ITS OWN. ONCE AGAIN, WE ROARED INTO A TREE BEFORE WE COULD PUT THE CAR IN NEUTRAL OR REMOVE THE KEY. (LINK TO VIDEO:) HTTPS://WWW.FACEBOOK.COM/VIDEO.PHP?V=10204011339395600&SET=O.261401957266994&TYPE=2&THEATER AFTER WE BOUGHT THE JEEP IN 2009, THE PREVIOUS OWNER TOLD US THAT HE HAD EXPERIENCED SOME SELF ACCELERATION. HE HAD IT INVESTIGATED BY THE ORIGINAL DEALERSHIP, THEN TOOK IT TO ANOTHER JEEP MECHANIC AND CONTACTED CHRYSLER, WHO DENIED THAT THERE WAS A PROBLEM. WE PARTICIPATE IN JEEP JAMBOREES AND HAVE EXPERIENCED THE PROBLEM AND HAVE TRIED TO ADDRESS IT AFTER RECEIVING ADVICE FROM VARIOUS GUIDES AND MECHANICS AT THE JAMBOREES. WE HAVE HAD TWO JEEP MECHANICS ATTEMPT SOLUTIONS AND WE HAVE EVEN REPLACED THE COMPUTER BUT THE PROBLEM PERSISTS. ONCE AGAIN, WE ROARED INTO A TREE. *TR