2022 Jeep Wrangler Fuel system Problems

Today is 10/19/2026. I have a 2022 Jeep Wrangler 4Xe Rubicon that has completed all of its safety recalls and recall notices. Each recall notice has been completed and each was marked as having no issues found. After completion of recall notice 68C (NHTSA 25V-741), we began to experience a complete change in how the car operates based on the vehicle mode selected on the 3 button panel (Hybrid, Electric, E-Save). We are now experiencing a consistent inappropriate kicking in of the gasoline engine when selecting and driving in the "Electric" only mode. Our normal driving of this car has occurred on the same roadways since we purchased the car from dealer stock. Prior to the Safety recall notice referred to as "68C/NHTSA 25V-741), we could select the "Electric" mode button on the 3 button panel selection and our 4Xe would run exclusively in the electric mode until it approached or reached the 1% mark. Now, the vehicle will kick in the gasoline engine even when the electric charge is above 50% ( I have actually had it kick in at the 75% mark). In addition, when this happens, the engine will rev to the 3000-4000rpm range unlike when the selection mode is chosen for "Hybrid". Today, while driving in the "Electric" mode and with the battery in excess of 50%, the gasoline engine kicked in about 10x. I finally had to press the "E-save" button to prevent the excessive engine kicking in and revving. Please initiate an investigation on what Chrysler did to change the software that now is rendering my vehicle useless in some respects and in most respects defeats the exact purpose of wishing to run in electric mode if I KNOW my trips will be under 20 miles. The excessive wear, tear, and strain on the engine due to the high revving can NOT in any fathomable way be deemed normal behavior! A review of some Jeep forums and Youtube channels can confirm that other owners are experiencing the same exact issues.

NHTSA ID

11772044

Incident

Oct 19, 2026

i PURCHASED MY 2022 JEEP RUBICON 4XE USED ON MARCH 31, 2026. IN APRIL, I HAD A RECALL NOTICE FOR RECALL 68C. I TOOK IT TO MY JEEP DEALER AND HAD THE RECALL DONE. IMMEDATELY, I NOTICED THAT MY ACCELERATION IN ELECTRIC MODE & HYBRID MODE IS DRASTICALLY REDUCED TO THE POINT OF BEING UNSAFE. ATTEMPTING TO MERGE OR PULL OUT INTO TRAFFIC, THE VEHICLE NO LONGER ACCELERATES LIKE IT DID BEFORE THE RECALL 68C WAS DONE. IT FELLS LIKE I AM DRIVING WIHT MY EMERGENCY BREAK ENGAGED, AS THE VEHICLE WILL NOT ACCELERATE NORMALLY. THE DEALER ADVISED THAT EVERYTHING IS NORMAL, HOWEVER IT IS VERY DIFFERENT. I WOULD NOT HAVE BOUGHT THE VEHICLE IF IT HAD A HESITATION WHEN ACCELARATING. LOOKING ONLINE FOR SUGGESTIONS, I DISCOVERED THAT THOUSANDS OF JEEP WRANGLER 4XE OWNERS WHO HAD THE 68C RECALL DONE, HAVE EXPERIENCED THIS ISSUE. I AM SURPRISED THAT NO ONE HAS BEEN KILLED OR SERIOSLY INJURED DUE TO THE HESITATION, CAUSED BY THE RECAL. I WOULD RATHER DEAL WITH THE POSSIBLE RISK OF FIRE THAN HESITATION CAUSED BY THE RECALL "FIX", IN THIS CASE THE CURE IS FAR WORSE AND MORE DANERIOUS THAN THE DISEASE/ISSUE JEEP WAS TRYING TO FIX WITH 68C.

NHTSA ID

11770462

Incident

Apr 6, 2026

I own a 2022 Jeep Wrangler Sahara 4xe. My vehicle underwent Recall 68C and related high-voltage battery evaluation/software work. The high-voltage battery was later replaced by Jeep under warranty. Immediately after that battery replacement, I noticed a significant change in the vehicle’s propulsion behavior that I had not experienced before. Prior to the replacement, when Electric mode was selected and sufficient battery charge was available, the vehicle normally remained on electric propulsion. Since the warranty battery replacement, the gasoline engine can engage unexpectedly even though Electric mode is selected and usable battery charge remains. I have also experienced hesitation during acceleration, including a delay or change in propulsion response before the gasoline engine engages. This has occurred repeatedly since the battery replacement and was not characteristic of the vehicle beforehand. I am concerned that the battery replacement, Recall 68C-related software, or associated battery/propulsion-control calibration may have altered the vehicle’s electric-mode operation. I consider this a safety concern because predictable acceleration is important when entering traffic, crossing intersections, making turns, or merging. Unexpected hesitation or a sudden transition from electric to gasoline propulsion can cause the vehicle to respond differently or more slowly than the driver anticipates. I am requesting that NHTSA investigate whether Recall 68C, subsequent high-voltage battery replacements performed under warranty, or associated software/calibration changes have introduced hesitation or unpredictable propulsion behavior in Jeep Wrangler 4xe vehicles.

NHTSA ID

11768812

Incident

Jun 26, 2026

I would like to report a safety concern with my 2022 Jeep Wrangler 4xe that began after Recall 68C was performed in January 2026. Prior to this recall, my Jeep did not exhibit the behavior I am now experiencing. Since the recall was completed, the vehicle has repeatedly showed unpredictable transitions between the electric motor and gasoline engine, delayed acceleration, loss of expected power, and unusually high engine RPM immediately upon the gasoline engine starting. When driving in electric mode the gasoline engine will sometimes start unexpectedly without what appears to be any normal engine warm-up period. When this happens, the Jeep does not accelerate normally. There is a noticeable lag and loss of expected acceleration. Because I am concerned about both engine damage and the safety implications of the delayed acceleration, I have essentially stopped using Electric mode. Unfortunately, I have discovered that the problem can also occur while driving in Hybrid mode. When the battery charge is below approximately 50%, the gasoline engine may start unexpectedly. When this occurs, the vehicle can repeatedly switch between gasoline and electric propulsion several times within approximately one minute. The result is a jumpy, inconsistent driving experience along with hesitation and delayed acceleration. I have experienced situations where I press the accelerator, there is a noticeable delay before the vehicle accelerates. In an emergency situation such as attempting to avoid another vehicle or accelerate out of a dangerous situation that delay could contribute to a collision.The vehicle also does not perform the way it did before Recall 68C was completed. It has less responsive power, the gasoline engine operates more frequently, and the engine can be started immediately, without warmup. This is particularly frustrating because I owned and drove this vehicle before the recall and know how the 4xe powertrain previously behaved. I attached photos in electric mode.

NHTSA ID

11768554

Incident

Oct 2, 2026

While driving my Jeep 4xe, the vehicle suddenly loses motive power without warning. The vehicle emits a chime, the "D" gear indicator flashes on the shifter and instrument cluster, the check engine light illuminates, and a message displays instructing me to shift the vehicle into Park. At that point, the vehicle will no longer accelerate, forcing me to coast and maneuver across traffic lanes to reach a safe location. This failure has occurred multiple times, including at highway speeds, creating an immediate safety hazard and increasing the risk of a crash. During several incidents, I narrowly avoided being struck by surrounding vehicles due to the sudden and unexpected loss of propulsion. The vehicle is currently at the dealership, and the dealership has confirmed the condition. A sudden loss of motive power while driving is a serious safety defect that requires immediate corrective action.

NHTSA ID

11766900

Incident

Aug 22, 2026

2022 Wrangler 4xe plug-in hybrid. The hybrid high-voltage system failed the first time it was used, in April 2026 at about 35,000 miles. I had not charged or used hybrid mode before that because of the manufacturer's high-voltage battery fire-risk recall guidance (recalls 23V-787, 24V-720, 25V-741) not to charge and to park away from structures. The check engine light came on at first use and has not stayed off except when cleared by the dealer. The vehicle was taken to an authorized Jeep dealer for the same hybrid high-voltage system concern on 4/19/2026, 6/17/2026 and 7/5/2026 without a fix. On 8/4/2026 the vehicle would not start at all and had to be towed. It stayed at the dealer 29 days (8/6 to 9/4/2026). The dealer replaced the main battery and found DTC P0E15-00 (electric coolant heater performance) with the high-voltage coolant heater in a 'locked permanent' unrecoverable state, and replaced the HV heater. The three earlier visits never identified this high-voltage thermal-management failure. Safety risk: a sudden no-start / loss of propulsion, and a failed cooling component in the high-voltage system of a vehicle population already under repeated battery thermal-runaway / fire recalls, where the manufacturer has acknowledged fires in vehicles that had received earlier remedies. The failures were confirmed and documented by the dealer on repair orders. The manufacturer (Stellantis) has been notified in writing and has declined to repurchase the vehicle. Repair orders are available on request.

NHTSA ID

11766177

Incident

Aug 4, 2026

After the 68C software recall the vehicle no longer operates the same as prior update in electric mode! While driving in electric mode and on a flat to fairly flat road and with a 50% or less battery the gas engine suddenly starts!! Revs to 3000+rpms then drops to 1500, back up to 2500, back to 1500 then shuts off! The gas engine isn't needed at that time!! When this happens it sort of confuses the drive train and may experience a loss of power. This may happen one or two more times before the battery runs out and it switches to hybrid mode. Hybrid mode works normally! This abnormality only occurs in the electric mode! This is scary when it happens and it started right after the 68C recall. I talked to the Jeep dealership service department and they checked for fault codes and there were none. I asked if they would open a STAR report and they said they did Although it's next to impossible to duplicate it for them as there's no way to tell when it will happen and it doesn't last more than a minute or two. I don't know what to do about this and neither does the service department Calling Jeep Customer Support does nothing as there is no way to talk to the technical department. I'm at a loss other than to report it here. I have heard from other 4xe owners having the exact same issues after the 68C recall. Please help.

NHTSA ID

11765675

Incident

Jan 7, 2026

After recall 68C on this vehicle, my power output has noticeably altered. I did have a HV battery replaced due to failure as well. Yes, they have extended warranty for that HV battery, but also down scaled its original abilities so it is not the vehicle that we originally bought. It does not feel safe on the road, and is constantly under do not park in structures warnings from Stellantis.

NHTSA ID

11765644

Incident

Oct 30, 2025

Ever since the 68c recall I have had a multitude of safety related issues with my vehicle. It appears that in order to protect themselves from a known faulty hybrid battery pack Jeep has reprogramed the vehicle to reduce power. While driving in electric or hybrid mode the vehicle will suddenly lose power creating an unexpected power delivery (ie. one minute you have plenty of power to pass a slower vehicle for example then all of a sudden, you lose that power mid pass). Once power loss occurs the vehicle will start acting extremely erratic with the gas engine kicking on and off and revving high for no reason, constant gear changes etc. A substantial delay occurs between pushing the gas pedal and power delivery, dramatically increasing the vehicles response time to a necessary acceleration, etc. I have inquired to my local dealership about these issues multiple times but am always told by the service advisor that they are not aware of any problems which i know is not true as the online forums are filled with hundreds of stories of near crashes, etc and that Jeep has extended the battery warranty to "unlimited" acknowledging that there is an issue. The problem is that when these batteries fail (and mine has and has been replaced) they replace them with the same defective part.

NHTSA ID

11765432

Incident

Jun 15, 2026

My 4xe has experienced several recalls since it was purchased in 2022. The most recent recall, 68C was the latest attempt to mitigate the issue of thermal runaway with the High Voltage Battery, which could ultimately lead to a fire. While 68C may have been a partial success with the latter, I believe the software update has created other issues that have introduced potentially dangerous operating scenarios and will likely lead to premature failure of the 2.0L Turbo Gas Engine. The 68C recall software was applied to my 4xe on 12/26/2025 and since that date, the vehicle noticeably performs and behaves differently from the date of purchase on 5/31/2022. When in Electric Mode, the vehicle will inconsistently hesitate and is lacking in power, especially when exiting a full stop. When applying the accelerator to gain more power, the system will override the Electric Mode and will initiate the gas engine to compensate. This instantly loads the engine up to 4k+ RPMs and causes the vehicle to unexpectedly surge forward. The engine will also override the Electric Mode while the vehicle is in motion, again instantly loading the engine and creating a surge of power and additional unexpected forward motion. In addition, I am no longer able to traverse highways without assistance of the gas engine, due to the hinderance of electrical power available. While I do realize that this is a Hybrid/Electric vehicle and has certain safeguards and protocols, this vehicle no longer performs as it was initially delivered to me. Performance aside, I believe that the 68C recall software has created a driving situation that is inconsistent, potentially dangerous, and will be placing future financial burdens on anyone who owns a 4xe.

NHTSA ID

11765378

Incident

Dec 26, 2025

68C recall software update has caused some form of loss of power, doesn’t fully power off, it feels as if it is throttling the electric motor causing the engine to suddenly start and rev high (5-7k RPM) bypassing the warm up time that’s built into the software for the engine. Now on 09/14/2026 (Monday) the vehicle through a DTC code “P0BBE-00” High Voltage Battery Voltage Variation. It went into limp mode while attempting to drive up the roll back (flatbed tow truck). Currently awaiting Dealer diagnostic.

NHTSA ID

11765151

Incident

Sep 14, 2026

Post the 68c recall the acceleration profile of the vehicle is inconsistent and at times significantly delayed. To the point where when making left hand turns or merging into freeway traffic becomes dangerous. One specific instance while making a left I started to go but the accelerstion was extremely slow. Pressing the pedal nearly all the way down with traffic bearing down in me the enging finally kicked in at nearly full throttle. Causing a very chaotic turn. This is particularly noticeable while driving in electric mode, and usually shows up after driving for a little while. However I have had it happen very shortly after starting a drive. It does seem to be related to either battery or motor temperature, but it is very inconsistent. Typically when it does happen you try to accelerate and the normal response of acceleration doesn't occur. You keep pressing the pedal until it is nearly all the way to floor before the engine kicks in and suddenly is floored and you get more acceleration than you were trying to get. Not necessarily a safety issue, but further evidence that battery or electric power has been restricted. Since the 68c recall my fuel economy has reduced a out 8 mi/gal. I make the same road trips on a regular basis and the same trip prior to the 68c recall I got nearly 100mi more per tank of gas. It seems the battery charging and electric assist has been retarded from the original performance. Again this is more dramatic in all electric and causes precarious situations as described above. There are no warning lights or error messages, the dealer either can't reproduce the issue or calls it normal operation. I have over 90k miles on my vehicle and it is only the 10k or so since the 68c recall that I have noticed this issue. It is not performing "normally".

NHTSA ID

11765145

Incident

Aug 4, 2026

I believe this has to do with a Recall software update 68C that Jeep put out to resolve issues with the high voltage battery. This is a plug in hybrid Jeep Wrangler 4xe and since the software update the vehicle does not perform the way it did before and is a definite safety issue. When running in electric mode the vehicle sometimes does not respond as it should, like a hesitation, then the gas engine will suddenly start and accelerate much faster than was intended. You will be pressing on the pedal more and more then suddenly, zoom ! This is very dangerous when merging or pulling into traffic. The dealership will just tell you there are no fault codes and the vehicle is operating normally. There are no warning lamps or messages The only way to safely operate the vehicle now is gas engine mode (E-Save). There are certain conditions that bring this on but it can be random .

NHTSA ID

11765134

Incident

Sep 1, 2026

2022 Jeep Wrangler 4xe always had good power on electric mode as well as hybrid mode (electric/gas). There were no issues merging with traffic on highway, freeway, climbing hills, staying with the flow of traffic in electric mode. Was able to stay in Electric mode 99% of the time. When and if Jeep called for more power, engine came on smoothly with engine idling low having time to warm up and then kicking up revs to create stable propulsion. However, on 12/30/2025 Jeep Dealership performed the 68C recall with updates to the Jeep. Now the jeep has no power in electric mode and is constantly going into gas mode with an ice-cold engine revving at high revs to create propulsion. I am no longer able to safely merge with traffic on highway, freeway, climbing hills, staying with the flow of traffic in electric mode. I am concerned for my safety as well as the engine being asked to kick on in high rpm's not up to appropriate operating temperatures.

NHTSA ID

11765132

Incident

Dec 30, 2025

As I was driving the vehicle this afternoon my entire jeep smelled like gas. I felt like I was breathing in fresh gas coming from my ac vents. I did vent my windows as I started to get a headache & I had to go home and get my husband’s vehicle before picking up my children because I could not expose them to such toxic fumes. Even though my vin shows zero unrepaired recalls, my hybrid jeep was part of the national recall of being of a fire risk and had all kinds of service lights on. When I took it to the dealer they told me if the battery didn’t fail, the jeep was fine. They cleared the codes and replaced the heater and I am not sure how that fixes the national recall? Prior to going to the dealer, there was no fix for this recall and the notice told me not to plug it in. But now the recall is cleared? Now I have gas fumes filling my jeep and there is no leak outside the vehicle. I have a witness to that. I FaceTimed my mom when I got home and we looked under the vehicle together. At this point, it says my vehicle is not safe to drive,

NHTSA ID

11764842

Incident

Sep 16, 2026

I am reporting repeated premature failures of the factory charge air cooler (turbo intercooler) hoses on my 2022 Jeep Wrangler EcoDiesel (3.0L V6). Within 73,000 miles, both the primary and secondary turbo charge hoses have hardened, cracked, and failed under standard boost pressure. Safety Risk: When these turbo charge hoses split, the engine experiences an immediate and complete loss of boost pressure (limp mode / Code P0299), severely restricting acceleration and vehicle speed. This sudden, unannounced loss of engine power occurs while driving at highway speeds, creating a severe rear-end collision hazard in heavy traffic. Failure History & Repair Documentation: First Hose Failure: Replaced by an authorized Jeep dealership at under 60,000 miles (November 2025). Second Hose Failure: Replaced by an authorized Jeep dealership at 73,000 miles (August 2026). Stellantis/Jeep treats these recurring structural hose splits as non-warranty "wear and tear," forcing out-of-pocket repairs despite the severe highway safety hazard caused by sudden power loss. I am requesting NHTSA open a safety defect investigation into the material failure rate of 3.0L EcoDiesel charge air hoses.

NHTSA ID

11758720

Incident

Aug 20, 2026

RE: SAFETY COMPLAINT FOLLOWING RECALL 68C (NHTSA Recall Number 24V-111 / Mopar 68C) I am the owner of a 2022 Jeep Wrangler Rubicon 4xe. Prior to having safety recall 68C performed, the hybrid system functioned flawlessly. Immediately upon receiving the vehicle back from the dealership after the 68C software flash, a severe drivability and safety hazard emerged. When driving in standard Hybrid/Electric mode, the vehicle experiences a sudden loss of power, hesitation, and a physical 'bogging down' sensation. Following this lag, the vehicle violently surges into gasoline mode, causing a sudden and unpredictable acceleration lurch after the vehicle hesitates to accelerate. This behavior occurs randomly at both low neighborhood speeds and highway speeds, making it impossible to smoothly modulate throttle input. This creates an immediate safety hazard when attempting to pull out into cross-traffic, merge onto highways, or maintain a safe, predictable following distance. The vehicle hesitates when throttle is demanded, creating a risk of being rear-ended, followed by an uncommanded surge. The dealership states the vehicle is 'operating as designed' according to a regional Jeep field engineer, implying this dangerous lag-and-surge behavior was intentionally introduced into the vehicle's management software by the manufacturer to mitigate, the recall notice noted above, battery thermal risks at the expense of occupant driving safety. The manufacturer’s recall remedy has traded a fire risk for an active moving traffic hazard." Several forums and AI searches show this is a common problem the manufacturer has created to avoid a costly recall by addressing the real issue with the battery’s fire risk. Instead they have intentionally reduce the battery’s performance causing a safety issue with the vehicle’s acceleration and operation.

NHTSA ID

11746276

Incident

Apr 12, 2026

When driving down the road my jeep goes into an uncomfortable death wobble. It has already been to a dealer to fix this once but it isn’t . There is a weld defect in the driver side front and passenger door frame . When the electronics get hot from the summer heat they black out . The digital display is not calibrated to the odometer of the vehicle . The Jeep surges violently and almost caused a collision.

NHTSA ID

11745199

Incident

May 1, 2026

After the latest 68C recall fix, Jeep has adjusted the behavior of how the vehicle's electric mode operates. When the battery gets to a certain temperature when driving, the engine is supposed to turn on (to prevent the fire risk hazard). However, instead of the vehicle making the powertrain switch, the vehicle power will just stop. The pedal will go to the floor but no forward movement. It is dangerous in many driving situations, like the highway or among other vehicles when mine unexpectedly stops. Jeep has tried to fix this exact issue in 3 separate recalls, but it still occurs. They should buy back the vehicles as they seem to not be able to fix and they are not safe to drive.

NHTSA ID

11745048

Incident

Jun 16, 2026

My Jeep will not operate correctly in the electric mode after a software update that was required to resolve a recall. The vehicle loses power in the electric mode and surges into the gasoline mode suddenly. This occurs after the vehicle has been driven a while and when the battery level drops below 50%. See these forums for others experiencing the same issue. [XXX] [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ID

11744322

Incident

May 1, 2026

Multiple recalls on jeep 4xe starting with the hybrid system from charging to the battery. Ultimately not fixable per Stellantis. Now electrical components in steering that present possible fire hazard at anytime. Not to mention the fact that if it can cause a fire, then the steering could fail in some unexpected way while driving, leading/contributing to an accident with serious injury or death. These combined make the car generally unreliable, potentially unsafe, and increase depreciation.

NHTSA ID

11743720

Incident

Jun 10, 2026

While driving any speed most of the time slowing down "Performance limited service fuel system". Dealership looked at it 2 different times and said it was just the clamp of some sort..took it on again and they said it could be the high pressure fuel system. Nothing has been replaced as they do not know what is going on. The message pops up randomly and goes away very quickly. This Jeep currently have just over 19,000 for a 2022 model When we first noticed the message it had just over 12000 miles

NHTSA ID

11743097

Incident

Jan 30, 2026

The issues lies in the Hybrid systems electric only function. When climbing grades, the vehicle experiences severe power loss which can be felt by the driver and is displayed by the vehicle on the dashboard information cluster. Power output from the hybrid system drops to or below 50% output even when pressing the accelerator to maximum. This issue occurs almost every time climbing a steep grade regardless of exterior temps. After losing speed and power on a steep grade while working the accelerator to or near maximum application the engine is activated abruptly without warning and without the proper hybrid warm up sequence and causes startling shifting by the powertrain and jerks the vehicle. This behavior began after Recall 68C was performed and hybrid Battery replacement.

NHTSA ID

11726798

Incident

Mar 24, 2026

My 2022 Jeep Wrangler has an ongoing issue involving an oil and diesel leak, which creates a hazardous driving condition and poses a fire and safety risk. The vehicle has been taken in for repair multiple times (4 repair attempts) for the same issue, and the problem remains unresolved. Due to the severity of the leak, the vehicle is unsafe to operate and requires towing to the dealership. Despite repeated repair attempts, the manufacturer has failed to provide a permanent fix and has denied further assistance based on procedural reasons (vehicle not currently at dealership, mileage, and warranty concerns). I am concerned this is a broader safety defect that could affect other vehicles.

NHTSA ID

11725420

Incident

Nov 4, 2025

My 2022 Jeep Wrangler 4xe experienced a sudden loss of power while driving on Interstate 285 in Atlanta during rush hour traffic. The vehicle began shaking and lunging forward unpredictably while I attempted to exit the highway. With hazard lights on, I slowly crept the vehicle to the dealership because it could barely move. The vehicle is currently at the dealership for Recall 68C related to the hybrid battery system. This incident created a dangerous situation on a major interstate and could have caused a serious accident.

NHTSA ID

11723930

Incident

Jan 20, 2026