2016 Keystone Cougar Problems
Owner-reported complaints filed with NHTSA, grouped by component
Data refreshed
What this page shows
Everything below is an owner-reported complaint submitted to NHTSA about the 2016 Keystone Cougar, grouped by the component NHTSA recorded on the report. These are not confirmed defects, and they are not recalls. NHTSA does not verify most reports before publishing them, and a category with more reports in it is not evidence that a part is defective.
Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.
Reports by component
Ranked by how many owner reports name each component category
- Other / unspecified228.6%
- Suspension228.6%
- Brakes114.3%
- Electrical114.3%
- Fuel system114.3%
Percentages are of component mentions. A single complaint can name more than one component, so these do not sum to the total complaint count.
Each component in detail
What the reports in each category say, in the owners' own words
Other / unspecified
Reports whose component NHTSA recorded as unknown, or that do not map to one of the categories above.
From owner reports, verbatim
The domestic refrigerator on this 2016 KEYSTONE RV caught on fire while traveling.
TL* THE CONTACT OWNS A 2016 KEYSTONE COUGAR. WHILE DRIVING APPROXIMATELY 63 MPH, THE REAR DRIVER SIDE WHEEL FRACTURED WITHOUT WARNING. DUE TO THE FAILURE, THE FRONT PASSENGER SIDE TIRE FLATTENED. THE VEHICLE WAS TOWED AND HAD TO BE DRIVEN LESS THAN 20 MPH. THE VEHICLE WAS TAKEN TO THE REPAIR SHOP FOR INSPECTION. THE MANUFACTURER WAS NOT NOTIFIED. THE VIN AND FAILURE MILEAGE WERE UNKNOWN.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Suspension
Reports naming suspension components — springs, struts, shocks, control arms and related hardware.
From owner reports, verbatim
TL* THE CONTACT OWNS A 2016 KEYSTONE COUGAR RECREATIONAL VEHICLE. WHILE DRIVING VARIOUS SPEEDS, ALL FOUR TIRES STRUCK AGAINST THE FLOOR OF THE RV. THERE WERE NO WARNING INDICATORS ILLUMINATED. THE DEALER DIAGNOSED THAT THE VEHICLE NEEDED HEAVIER SPRINGS AND AXLES. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED. THE VIN WAS INVALID. THE APPROXIMATE FAILURE MILEAGE WAS 650. UPDATED 01/06/17*LJ UPDATED 6/29/18*JB
TL* THE CONTACT OWNS A 2016 KEYSTONE COUGAR. WHILE DRIVING APPROXIMATELY 63 MPH, THE REAR DRIVER SIDE WHEEL FRACTURED WITHOUT WARNING. DUE TO THE FAILURE, THE FRONT PASSENGER SIDE TIRE FLATTENED. THE VEHICLE WAS TOWED AND HAD TO BE DRIVEN LESS THAN 20 MPH. THE VEHICLE WAS TAKEN TO THE REPAIR SHOP FOR INSPECTION. THE MANUFACTURER WAS NOT NOTIFIED. THE VIN AND FAILURE MILEAGE WERE UNKNOWN.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Brakes
Reports naming service brakes, the antilock braking system, brake hoses, master cylinders or the parking brake.
From owner reports, verbatim
I PURCHASED A NEW TRAVEL TRAILER MANUFACTURED BY KEYSTONE IN MAY OF 2015. I TOOK IT BACK TO THE DEALER AFTER MY FIRST TRIP WHEN I REALIZED THE BRAKES BARELY FUNCTIONED. AFTER 4 MONTHS OF TRYING TO GET THE MANUFACTURE TO ACKNOWLEDGE THE BRAKES DID NOT WORK FROM THE FACTORY KEYSTONE STATED THAT THEY FELT THE BRAKES FUNCTIONED PROPERLY. THE DEALER, RCD SALES AGREED WITH ME THAT THE BRAKES DID NOT WORK AND THEY HAD A SECOND 2016 TRAILER ON THEIR LOT WHICH THE BRAKES DID NOT FUNCTION EITHER AND THEY WERE SCARED TO SALE IT. I REVIEWED THE BRAKES MYSELF THEY WEEKEND AND DISCOVERED THAT THE WIRING USED BY THE MANUFACTURE WAS TOO SMALL. THERE WAS NEARLY A 3 VOLT (25%) VOLTAGE DROP FROM THE WIRING HARNESS TO THE BRAKE DRUMS. AFTER REPLACING WHAT APPEARED TO BE 16 GAUGE WIRE WITH 12 GAUGE WIRE THE BRAKES NOW WORK PROPERLY. KEYSTONE HOWEVER IS STILL MANUFACTURING TRAILERS WITH INADEQUATE BRAKING CAUSED BY UNDERSIZED WIRING AND INSISTING THEY ARE SAFE.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Electrical
Reports naming the electrical system — wiring, battery, charging, control modules, infotainment and electrical accessories.
From owner reports, verbatim
I PURCHASED A NEW TRAVEL TRAILER MANUFACTURED BY KEYSTONE IN MAY OF 2015. I TOOK IT BACK TO THE DEALER AFTER MY FIRST TRIP WHEN I REALIZED THE BRAKES BARELY FUNCTIONED. AFTER 4 MONTHS OF TRYING TO GET THE MANUFACTURE TO ACKNOWLEDGE THE BRAKES DID NOT WORK FROM THE FACTORY KEYSTONE STATED THAT THEY FELT THE BRAKES FUNCTIONED PROPERLY. THE DEALER, RCD SALES AGREED WITH ME THAT THE BRAKES DID NOT WORK AND THEY HAD A SECOND 2016 TRAILER ON THEIR LOT WHICH THE BRAKES DID NOT FUNCTION EITHER AND THEY WERE SCARED TO SALE IT. I REVIEWED THE BRAKES MYSELF THEY WEEKEND AND DISCOVERED THAT THE WIRING USED BY THE MANUFACTURE WAS TOO SMALL. THERE WAS NEARLY A 3 VOLT (25%) VOLTAGE DROP FROM THE WIRING HARNESS TO THE BRAKE DRUMS. AFTER REPLACING WHAT APPEARED TO BE 16 GAUGE WIRE WITH 12 GAUGE WIRE THE BRAKES NOW WORK PROPERLY. KEYSTONE HOWEVER IS STILL MANUFACTURING TRAILERS WITH INADEQUATE BRAKING CAUSED BY UNDERSIZED WIRING AND INSISTING THEY ARE SAFE.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Fuel system
Reports naming fuel storage or delivery — tanks, pumps, lines, injectors and fuel leaks.
From owner reports, verbatim
2016 KEYSTONE COUGAR RV. CONSUMER WRITES IN REGARDS TO THREADED ROD THAT CLAMPS DOWN THE PROPANE TANKS BECAME UNSCREWED FROM TRAILER TONGUE WITH GAS REGULATOR STILL ATTACHED. *SMD UPDATED 06/26/2017*JS UPDATED 08/09/17*LJ *CN
Too few reports in this category for a page of its own — they appear in the full complaint list.
Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.
Elsewhere on this vehicle
Data sources
- NHTSA Office of Defects Investigation — owner-reported complaints and the components recorded on them
Data on this page last refreshed .