2002 Kia Rio Problems

I JUST GOT MY CAR FIXED ON MON. 8/25/14. I TOOK IT IN BECAUSE IT WAS IDLING ROUGH. THE SHOP PUT IN NEW SPARK PLUGS AND WIRES. IT COST ME $180. I DROVE IT HOME. IT WAS SMOOTH. THEN I DROVE TO DOWNTOWN AKRON, ABOUT 15 MILES, TO A HIKE. WHEN I WAS ALMOST THERE, MY CAR JUST WENT DEAD WHILE I WAS DRIVING. I PULLED OVER AND PARKED OFF THE BUSY ROAD ONTO A PARKING LOT (PART OF/BY AKRON UNIVERSITY). THE CAR WAS DEAD. IT MADE A CLICKING NOISE WHEN I TRIED TO START IT. I CALLED AAA AND THEY DIDN'T KNOW WHAT WAS WRONG (IT HAD A BRAND NEW 6 YEAR BATTERY IN IT). THEY TOWED ME BACK TO THE SHOP THAT HAD WORKED ON IT EARLIER THAT DAY - 15 MILES. THE NEXT DAY, 8/26/14, THE SHOP TOLD ME THE TIMING BELT BROKE AND IT RUINED THE ENGINE. THEY SAID KIA'S HAVE AN INTERFERENCE MOTOR. WHEN THE BELT BREAKS, IT BREAKS OFF ALL THE PISTONS (SOMETHING LIKE THAT) AND RUINS THE MOTOR. IT CAN'T BE FIXED. I HAVE TO BUY A NEW MOTOR $2000 APPRX, OR A NEW CAR. I LIVE ALONE AND DON'T HAVE THE MONEY FOR EITHER. I WAS COUNTING ON THIS CAR TO LAST ME 2-3 MORE YEARS. A COUPLE OF DIFFERENT GARAGES TOLD ME IT LOOKED GOOD AND SHOULD LAST THAT LONG AT LEAST. I WAS GOING TO START SAVING FOR A NEW CAR. THIS IS VERY UNETHICAL OF KIA. THEY SHOULD NOT BE ALLOWED TO MAKE/SELL A CAR THAT HAS A MOTOR THAT SELF-DESTRUCTS. I'VE HAD OTHER CARS AND THE TIMING BELT BROKE, BUT IT DID NOT RUIN THE MOTOR. THEY JUST REPLACED THE TIMING BELT. THIS IS HORRIBLE! I HAD NO IDEA, NO WARNING! ALL THE SHOP I TOOK IT TO NEVER SAID A THING! KIA SHOULD NOT BE ALLOWED TO DO THIS. THEY SHOULD AT LEAST HAVE TO WARN YOU ABOUT IT! I HAVE A MANUAL AND I NEVER SAW ANYTHING ABOUT IT IN THERE. MY CHEVY MANUAL HAD THE MILES AND WHAT YOU NEED TO DO AT THOSE MILES. THE KIA BOOK DOES NOT. I HAD NO IDEA!! THIS SHOULD BE ILLEGAL! TOTAL RIP OFF! *TR

2002 KIA RIO. CONSUMER STATES TIMING BELT FAILED *TGW THE CONSUMER STATED THE TIMING BELT FAILED FOR A SECOND TIME AT 59,059 AND DESTROYED THE SECOND ENGINE. THE CONSUMER WAS INFORMED THE VEHICLE WOULD NOT BE COVERED UNDER WARRANTY, BECAUSE THE ORIGINAL TIMING BELT WAS NOT REPLACED AT THE PROPER MILEAGE. THE CONSUMER STATED THE ORIGINAL TIMING BELT WAS REPLACED AT 53,668 AND THE REPLACEMENT BELT FAILED AT 59,059 BEFORE THE RECOMMENDED 60,000. A KIA REPRESENTATIVE INFORMED THE CONSUMER THE WARRANTY ONLY EXTENDED TO THE ORIGINAL ENGINE, NOT THE REPLACEMENT ENGINE. *JB

TL* THE CONTACT OWNED A 2002 KIA RIO. WHILE DRIVING 30 MPH, THE VEHICLE WAS INVOLVED IN A FRONT END CRASH. THE FRONT DRIVER SIDE AIR BAG DEPLOYED AGGRESSIVELY AND METAL FRAGMENTS STRUCK THE CONTACT'S FACE. A POLICE REPORT WAS FILED. THE CONTACT SUSTAINED A HEAD LACERATION THAT REQUIRED STITCHES, A BROKEN NOSE, AND A HAND INJURY. MEDICAL ATTENTION WAS REQUIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE VEHICLE WAS TOWED TO THE SALVAGE YARD AND DEEMED DESTROYED. THE FAILURE MILEAGE WAS UNKNOWN. ...UPDATED 7/19/16*BF *JS

GOING AT 80KM AN HOUR IN PEAK FRIDAY AFTERNOON TRAFFIC ON THE HIGHWAY I REAR ENDED ANOTHER CAR AND MY AIRBAG DID NOT DEPLOY. *TR

SLOWING TO TURN INTO GAS STATION, REAR AXLE BROKE DO TO EXCESSIVE RUST ROT. THE BODY ON THIS CAR HAD STATED TO RUST AT 8000 MILES, REAR FRAME HAS EXCESSIVE RUST ROT ALSO. NUMEROUS OTHER KIA RIO OWNERS ARE REPORTING THIS ISSUE THIS IS ALARMING I COULD HAVE SLAMMED INTO THE GAS PUMPS AS THE BRAKES LOCKED DO TO SEVERING A BRAKE LINE. *TR

T PROPORTIONING VALVE IS LEAKING ON MY 2002 KIA, LOOSING ALL BRAKE FLUID. KIA DEALER SAID THIS IS A COMMON PROBLEM THEY CAN REPAIR FOR $230.00. THE PROPORTIONING VALVE SHOULD NOT FAIL ON ANY CAR. HAS THIS BEEN REPORTED BEFORE? I FEEL THIS SHOULD BE A WARRANTY ITEM AND POSSIBLY A DEALER RECALL, WHAT CAN YOU TELL ME? *TR

TL* THE CONTACT OWNS A 2002 KIA RIO. THE CONTACT STATED THAT THE REAR DRIVER AND PASSENGER'S SIDE SEAT BELTS WOULD NOT RETRACT. THE CONTACT INSPECTED THE SEAT BELTS AND DISCOVERED THAT PART OF THE SEAT BELT WAS DISINTEGRATED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE ISSUE. THE APPROXIMATE FAILURE MILEAGE WAS 104,000.

TL* THE CONTACT OWNS A 2002 KIA RIO. THE CONTACT NOTICED THAT THE REAR SEAT BELT WAS FRACTURED. THE DEALER INFORMED THE CONTACT THAT IT WAS HER RESPONSIBILITY REPAIR THE VEHICLE. THE MANUFACTURER HAD NOT BEEN NOTIFIED. THE VEHICLE HAD NOT BEEN INSPECTED OR REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 93,458 AND THE CURRENT MILEAGE WAS UNKNOWN. THE VIN WAS UNAVAILABLE. UPDATED 09/01/2011 *LN

TL* THE CONTACT OWNS A 2002 KIA RIO. THE CONTACT STATED THAT WHEN REFUELING THE VEHICLE, FUEL WOULD SPEW BACK OUT FROM THE FILLER NECK. IN ADDITION, THE CONTACT STATED THAT A STRONG GASOLINE FUEL ODOR WAS CONSTANTLY PRESENT WITHIN THE VEHICLE AFTER REFUELING. THE CONTACT REFERENCED NHTSA CAMPAIGN ID NUMBER: 04V179000 (FUEL SYSTEM, GASOLINE: DELIVERY) BUT WAS ADVISED BY THE DEALER THAT THE VEHICLE WAS PREVIOUSLY REPAIRED UNDER THE RECALL PRIOR TO THE PURCHASE OF THE VEHICLE. THE VEHICLE WAS NOT FURTHER REPAIRED. THE FAILURE MILEAGE WAS UNKNOWN AND THE CURRENT MILEAGE WAS 107,000. UPDATED 03/16/12 *BF UPDATED 03/30/12

2002 KIA RIO, PURCHASED NEW AND MAINTAINED IN EXCELLENT CONDITION WITH REGULAR MAINTENANCE. HAD 61,000 MILES AND WHILE DRIVING, MY DAUGHTER SMELLED SOMETHING BURNING, ENGINE LIGHT CAME ON AND AT THE SAME TIME, SMOKE WAS COMING IN THROUGH THE AIR VENTS. SHE IMMEDIATELY PULLED OVER, STOPPED THE CAR AND REMOVED HER KEYS. THE IGNITION STARTED ON ITS OWN AND THE CAR ENGINE ERUPTED INTO FLAMES. THE CAR IS TOTALLY DESTROYED. FIRE AND HIGHWAY PATROL REPORTS WERE TAKEN AT THE SCENE AND CAR WAS TOWED TO KIA DEALERSHIP IN CLOVIS CA. SERVICE MANAGER STATED HE HAD TAKEN PICTURES AND BECAME INVESTIGATION. WHEN I WENT IN TO SEE THE CAR AND TAKE PICTURES, THE SERVICE TEAM WAS COMPLETELY APATHETIC AND RUDE. I MADE A CALL TO KIA CONSUMER AFFAIRS, AND FOUND THAT THE REPORT HAD NOT BEEN SUBMITTED. THE INDIVIDUAL AT KIA CONSUMER AFFAIRS WAS EXTREMELY HELPFUL AND ATTEMPTED TO CALL THE DEALERSHIP AS WELL. HER CALLS WERE NOT RETURNED. MY DAUGHTER WAS EXTREMELY LUCKY AND ONLY SUFFERED FIRST DEGREE BURNS TO THE FACE, AND SMOKE INHALATION THAT EXACERBATED HER ASTHMA. ACCORDING TO THE FIRE INVESTIGATOR, THE FIRE WAS CAUSED BY AN OVER-FILLING OF TRANSMISSION FLUID BY 1 QUART. THE CONSUMER STATED WHEN SHE SAW THE VEHICLE THE DAY AFTER, THERE WAS NO FLUID ANYWHERE. THE CONSUMER BELIEVED THERE WAS A DEFECT WITH THE VEHICLE POSSIBLY RELATED TO A RECALL, WHICH WAS SUPPOSEDLY HAD BEEN TAKEN CARE OF AT THE DEALERSHIP. *JB UPDATED 06/21/07. *JB

SLOWING TO TURN INTO GAS STATION, REAR AXLE BROKE DO TO EXCESSIVE RUST ROT. THE BODY ON THIS CAR HAD STATED TO RUST AT 8000 MILES, REAR FRAME HAS EXCESSIVE RUST ROT ALSO. NUMEROUS OTHER KIA RIO OWNERS ARE REPORTING THIS ISSUE THIS IS ALARMING I COULD HAVE SLAMMED INTO THE GAS PUMPS AS THE BRAKES LOCKED DO TO SEVERING A BRAKE LINE. *TR

MY CAR PULLS HARD TO THE RIGHT WHEN I PRESS THE GAS PEDAL AND I HAVE TO TURN THE STEERING WHEEL TO THE LEFT TO COMPENSATE FOR THAT. AS SOON AS I PULL MY FOOT FROM THE GAS PEDAL, THE CAR IMMEDIATELY GOES TO THE LEFT AND I HAVE TO BRING THE STEERING WHEEL TO THE NORMAL POSITION. THIS HAPPENS 100% OF THE TIME. I FEEL THIS IS A POTENTIALLY DANGEROUS SITUATION SINCE I HAVE TO PAY CLOSE ATTENTION TO THE TIMING IN ORDER TO KEEP THE CAR STRAIGHT AT HIGHER SPEEDS. I AM THE FIRST OWNER OF THE CAR AND THE CAR WAS PROPERLY MAINTAINED BY MY LOCAL MECHANIC (I HAVE RECORDS OF EVEN OIL CHANGES) AND EVEN AFTER ALIGNMENT AND TIRE CHANGE FOR THE PROBLEM BY A KIA DEALER, THE PROBLEM IS STILL THERE. I'VE BEEN TO 2 DIFFERENT KIA DEALERS AND I WAS TOLD THIS IS A "NORMAL" SITUATION IN THESE KINDS OF CARS AND IT HAPPENS TO "ALL OF THEM AT HIGH MILEAGE". I ALSO TRIED TO REACH THE REGIONAL OFFICE AND AFTER NUMEROUS PHONE CALLS I DIDN'T GET A RESPONSE FROM THERE YET. THE CAR IS AT 98,000 MILES AND I'VE HAD THE PROBLEM FOR ABOUT MORE THAN 3 MONTHS. I BELIEVE KIA EITHER SHOULD HONOR THEIR 100K MILE WARRANTY OR IF IT IS HAPPENING TO "ALL OF THEM" AND IT IS "NORMAL" THEY SHOULD MOVE THEIR OFFICIAL WARRANTY LOWER (FOR EXAMPLE 80K MILES ETC.) OR THEY SHOULD WARN THE CONSUMER ABOUT THIS "NORMAL" SITUATION WITH BIG LETTERS IN THEIR ADVERTISEMENTS AND MANUALS. *TR

2002 KIA RIO, PURCHASED NEW AND MAINTAINED IN EXCELLENT CONDITION WITH REGULAR MAINTENANCE. HAD 61,000 MILES AND WHILE DRIVING, MY DAUGHTER SMELLED SOMETHING BURNING, ENGINE LIGHT CAME ON AND AT THE SAME TIME, SMOKE WAS COMING IN THROUGH THE AIR VENTS. SHE IMMEDIATELY PULLED OVER, STOPPED THE CAR AND REMOVED HER KEYS. THE IGNITION STARTED ON ITS OWN AND THE CAR ENGINE ERUPTED INTO FLAMES. THE CAR IS TOTALLY DESTROYED. FIRE AND HIGHWAY PATROL REPORTS WERE TAKEN AT THE SCENE AND CAR WAS TOWED TO KIA DEALERSHIP IN CLOVIS CA. SERVICE MANAGER STATED HE HAD TAKEN PICTURES AND BECAME INVESTIGATION. WHEN I WENT IN TO SEE THE CAR AND TAKE PICTURES, THE SERVICE TEAM WAS COMPLETELY APATHETIC AND RUDE. I MADE A CALL TO KIA CONSUMER AFFAIRS, AND FOUND THAT THE REPORT HAD NOT BEEN SUBMITTED. THE INDIVIDUAL AT KIA CONSUMER AFFAIRS WAS EXTREMELY HELPFUL AND ATTEMPTED TO CALL THE DEALERSHIP AS WELL. HER CALLS WERE NOT RETURNED. MY DAUGHTER WAS EXTREMELY LUCKY AND ONLY SUFFERED FIRST DEGREE BURNS TO THE FACE, AND SMOKE INHALATION THAT EXACERBATED HER ASTHMA. ACCORDING TO THE FIRE INVESTIGATOR, THE FIRE WAS CAUSED BY AN OVER-FILLING OF TRANSMISSION FLUID BY 1 QUART. THE CONSUMER STATED WHEN SHE SAW THE VEHICLE THE DAY AFTER, THERE WAS NO FLUID ANYWHERE. THE CONSUMER BELIEVED THERE WAS A DEFECT WITH THE VEHICLE POSSIBLY RELATED TO A RECALL, WHICH WAS SUPPOSEDLY HAD BEEN TAKEN CARE OF AT THE DEALERSHIP. *JB UPDATED 06/21/07. *JB

TL*THE CONTACT OWNS A 2002 KIA RIO. THE CONTACT SMELLED SOMETHING BURNING AND NOTICED THE VEHICLE WAS ON FIRE WHILE PARKED. THE FIRE WAS CONTAINED TO UNDERNEATH THE HOOD AND WAS EXTINGUISHED BY THE CONTACT. THE VEHICLE WAS DESTROYED. NO POLICE REPORT WAS FILED. THE VEHICLE WAS NOT DIAGNOSED BY THE DEALER/MANUFACTURER. THE PURCHASE DATE AND ENGINE SIZE WERE UNKNOWN. THE CURRENT AND FAILURE MILEAGES WERE 60,000.

SLOWING TO TURN INTO GAS STATION, REAR AXLE BROKE DO TO EXCESSIVE RUST ROT. THE BODY ON THIS CAR HAD STATED TO RUST AT 8000 MILES, REAR FRAME HAS EXCESSIVE RUST ROT ALSO. NUMEROUS OTHER KIA RIO OWNERS ARE REPORTING THIS ISSUE THIS IS ALARMING I COULD HAVE SLAMMED INTO THE GAS PUMPS AS THE BRAKES LOCKED DO TO SEVERING A BRAKE LINE. *TR

DT: THE CONSUMER PURCHASED TWO 2002 KIA RIOS, THE FIRST VEHICLE WAS FINE. THE OTHER VEHICLE WITHIN 30 DAYS OF PURCHASE AT APPROXIMATELY 100 MILES, DIED. THIS DID NOT HAPPEN AT ANY CERTAIN SPEED. THE VEHICLE HAS BEEN TAKEN INTO THE DEALERSHIP OVER 14 TIMES AND THEY HAVE NOT REPLACED ANYTHING . THEY HAVE REPROGRAMMED THE COMPUTER NUMEROUS TIMES. THE VEHICLE WILL WORK FOR AWHILE, NO SPECIFIC TIME, AND THEN DIE AGAIN. CONSUMER'S DAUGHTER ACTUALLY DROVE VEHICLE WHICH WAS LOCATED IN SOUTH CAROLINA.*AK THE VISOR WAS REPLACED. THE INTERIOR LIGHT WOULD NOT GO OFF, THE DEALER STATED IT WAS A PINCHED WIRE. THE LIFTGATE LATCH WAS REPLACED AND THE PARKING BRAKE WAS ADJUSTED. *JB

SINCE APPROXIMATELY ONE YEAR AFTER PURCHASING MY 2002 KIA RIO, I HAVE HAD ON-GOING TRANSMISSION PROBLEMS. AT VARIOUS TIMES WHILE DRIVING THE TRANSMISSION 'SLAMS' INTO GEAR, OR SHUTTERS. ALTHOUGH I HAVE BROUGHT THIS ISSUE TO THE ATTENTION OF THREE DIFFERENT DEALERSHIPS, AND KIA CORPORATE, THEY CLAIM THAT THERE IS NO ISSUE OR THAT THEY CAN NOT IDENTIFY THE PROBLEM. THEY CLAIMED AT ONE POINT THAT THE TRANSMISSION FLUID WAS DIRTY (ALTHOUGH IT WAS WELL BELOW THE RECOMMENDED SERVICE MILEAGE), SO I HAD A THIRD PARTY SERVICE STATION PERFORM A COMPLETE TRANSMISSION FLUID/FILTER CHANGE. HOWEVER, THE PROBLEM HAS CONTINUED, AND NOW A YEAR LATER THE DEALERSHIP IS AGAIN TELLING ME THAT IT IS THE FLUID - WHICH I HAVE NEVER HEARD AN ISSUE LIKE THIS BEING CAUSED BY FLUID, BUT IF THIS IS TRUE, THERE IS ANOTHER ISSUE IN THAT THE TRANSMISSION FLUID SHOULD NOT HAVE TO BE CHANGED EVERY 6-12 MONTHS. I RECENTLY BROUGHT MY CAR TO A CERTIFIED MECHANIC, AND HE WAS ABLE TO IDENTIFY THE PROBLEM AS A TORQUE CONVERTER AND A TCC PREMATURELY ENGAGING, AS WELL AS A TRANSMISSION 'SHUTTER'. HE PROVIDED ME WITH WRITTEN DOCUMENTATION OF THE ISSUE, AND I RETURNED TO THE DEALERSHIP. AGAIN, THE DEALERSHIP SAID THERE WAS NO ISSUE AND THE SYMPTOMS ARE 'NORMAL'. THIS VEHICLE IS A LEMON, AND I AM UNABLE TO OBTAIN PROPER SERVICE FROM KIA, AND I AM VERY CONCERNED THAT THE VEHICLE COULD BECOME A SAFETY HAZARD SHOULD THE SYMPTOMS CONTINUE TO GET WORSE, OR THE TRANSMISSION COMPLETELY FAIL WHILE DRIVING. *JB

VEHICLE SHOOK UNCONTROLLABLY AND SWAYED FROM LEFT TO RIGHT WHILE DRIVING. DRIVER WAS ABLE TO MAINTAIN CONTROL OF THE VEHICLE, PULLED OVER, AND TURNED THE VEHICLE OFF. THEN, DRIVER RESTARTED THE VEHICLE, AND TRANSMISSION FAILED TO SHIFT OR MOVE ON ITS OWN. VEHICLE WAS TOWED TO THE DEALER, AND MECHANIC DETERMINED THAT THE FRAME WAS BEND, AND TRANSMISSION HAD BLOWN OUT, AND NEEDED TO BE REPLACED. *AK

DRIVE SIDE DOOR WILL NOT UNLOCK, AND THEREFORE, WILL NOT OPEN. *TR

TL*THE CONTACT OWNS A 2002 KIA RIO. THE CONTACT STATED THAT THE DRIVER SIDE FRONT SEAT BELT WOULD NOT BUCKLE AND THE PASSENGER SIDE FRONT SEAT BELT ANCHOR FELL APART. THE DRIVER SIDE FRONT DOOR LOCK WOULD NOT UNLOCK WITH THE KEY OR FROM THE INSIDE OF THE DOOR. KIA WAS CONTACTED AND STATED THAT THERE WAS NOTHING THEY COULD DO. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 175,000. THE CURRENT MILEAGE WAS APPROXIMATELY 182,000. THE VIN WAS UNKNOWN. UPDATED 11/05/10. *LJ

I HAVE HAD THE BERINGS REPLACED 2 TIMES IN THE PASSENGER SIDE TWO TIMES NOW AND ITS DOING IT AGAIN THE OTHER SIDE WAS DONE FIRST . THE CAR JUST STOPPED DEAD IN THE ROAD AND I COULD NOT GET IT TO MOVE BEFORE I GOT IT FIXED THE TIME BEFORE THIS . I DONT HAVE THE MONEY TO KEEP FIXING THIS SAME PROBLEM THE CAR HAS BEEN SITTING FOR MONTHS NOW . I GOT THE CAR TO FINALLY MOVE BACKWARDS SO I DROVE IT BACKWARDS TO THE SPOT ITS IN GOT IT FIXED . AND FOR THE THIRD TIME ITS HAPPENING AGAIN.

I PURCHASED MY KIA 02 IN 8/02, I HAD IT LESS THAN 5 MONTHS AND THE TRANSMISSION WENT OUT AT LESS THAN 20,000 MILES. A NEW TRANSMISSION WAS INSTALLED IN 1/03. IN 11/03 THE FIRST GEAR IN THE TRANSMISSION WAS GONE. MY KIA NEEDED TO BE TOWED TO AND WAS AGAIN REPAIRED WITH A NEW TRANSMISSION, SO I WAS TOLD. IT TOOK TWO AND A HALF WEEKS FOR MY CAR TO BE REPAIRED. I WAS NOT GIVEN THE PAPER WORK FROM THE REPAIR SHOP THEN AND WAS TOLD THAT IT WOULD BE MAILED TO ME. FEW WEEKS PASSED AND THE TRANSMISSION BEGAN TO GIVE PROBLEMS AGAIN, THIS TIME THE SHIFTING OF GEARS WERE COMPLETELY OFF AND MY OVER DRIVE DID NOT WORK AT ALL. I WAS TOLD TO TAKE THE CAR BACK TO THE SAME REPAIR SHOP OF WHICH I DID ON 1/07/04. I LEFT TWO MESSAGES ASKING FOR THE STATUS OF MY CAR AND HAVE NOT RECEIVED A CALL BACK. AS OF TODAY I DO NOT HAVE MY CAR.*AK

DT: THE CONSUMER STATESDTHE TIRES WERE PURCHASED ON APRIL 23, 2005. THEY SPLIT IN HALF AND CHUNKS WERECOMING OUT OF THE TIRES. ALL FOUR OF THE TIRES WERE HAVING THIS PROBLEM. WIRE WAS COMING OUT OF THE TIRES. THE AIR PRESSURE IWAS CHECKED. THE SHOCKS AND STRUTS HAVE BEEN CHECKED TO MAKE SURE THIS WAS NOT THE PROBLEM. THESE TIRES STARTED FALLING APART AT APPROXIMATELY 1,000 MILES.*AK

IF VEHICLE IS ON THE SLIGHTEST INCLINE THE TRUNK LID WILL COLLAPSE WHEN OPENED FULLY. ONCE WHEN THIS OCCURRED IT RENDERED THE CONSUMER UNCONSCIOUS. DEALERSHIP REPLACED THE TRUNK LID SPRING, BUT IT DIDN'T CORRECT THE PROBLEM. ALSO, AT 4000 MILES THE TRUCK IS HAVING PROBLEM WITH EXCESSIVE FRONT TIRE TREAD WEAR ON THE INSIDE ONLY. AT 6000 MILES THE FRONT TIRES WERE REPLACED, AND A FRONT ALIGNMENT WAS PERFORMED. FRONT TIRE TREAD WORE OUT AGAIN AT 12000 MILES. THE FACTORY REPRESENTATIVE WAS CONTACTED, BUT DIDN'T PROVIDE ANY ASSISTANCE. THE FRONT TIRES WERE REPLACED AGAIN AT 20000 MILES WITH BRAND NEW 60000 MILES WEAR TIRES BUT THEY HAVE WORN EXCESSIVELY AT 10,000 MILES. *AK

DT: THE CONSUMER PURCHASED TWO 2002 KIA RIOS, THE FIRST VEHICLE WAS FINE. THE OTHER VEHICLE WITHIN 30 DAYS OF PURCHASE AT APPROXIMATELY 100 MILES, DIED. THIS DID NOT HAPPEN AT ANY CERTAIN SPEED. THE VEHICLE HAS BEEN TAKEN INTO THE DEALERSHIP OVER 14 TIMES AND THEY HAVE NOT REPLACED ANYTHING . THEY HAVE REPROGRAMMED THE COMPUTER NUMEROUS TIMES. THE VEHICLE WILL WORK FOR AWHILE, NO SPECIFIC TIME, AND THEN DIE AGAIN. CONSUMER'S DAUGHTER ACTUALLY DROVE VEHICLE WHICH WAS LOCATED IN SOUTH CAROLINA.*AK THE VISOR WAS REPLACED. THE INTERIOR LIGHT WOULD NOT GO OFF, THE DEALER STATED IT WAS A PINCHED WIRE. THE LIFTGATE LATCH WAS REPLACED AND THE PARKING BRAKE WAS ADJUSTED. *JB

NO ACCIDENT YET ON THIS DEFECT. WE HAVE NOTICED OVER THE PAST 2 YEARS OF DRIVING THIS VEHICLE A SERIOUS DEFECT IN THE WAY THE DASH IS CONSTRUCTED THAT SERIOUSLY OBSTUCTS BOTH VIEWING OF THE ROAD THROUGH THE WINDSHIELD BY THE DRIVER AND VIEWING THE DASH INSTRUMENTATION (SPEEDOMETER, ETC) VIRTUALLY IMPOSSIBLE UNDER NORMAL DRIVING CONDITIONS. ON A SUNY DAY, THE BLACK PLASTIC MATERIAL USED IN THE DASH CONSTRUCTION AROUND THE INSTRUMENT PANEL IS SO REFLECTIVE, THAT OFTEN WITH THE SUN COMING IN THROUGH THE REAR OR A SIDE WINDOW, IT BECOMES IMPOSSIBLE TO SEE THE INSTRUMENTATION IN THE DASH DUE TO REFLECTIVE GLARE OFF THE BLACK PLASTIC IN FRONT OF THE CLEAR PLASTIC THAT COVERS THE SPEEDOMETER, ETC. IT IS SO BAD THAT OCCASIONALLY WE HAVE TO PUT A PIECE OF PAPER OR ANOTHER NON-REFLECTIVE OBJECT BEHIND THE STEERING WHEEL AND IN FRONT OF THE SPEEDOMETER IN ORDER TO READ THE INSTRUMENTATION. EVEN MORE DISTURBING IS THE SAME PHENOMENON WHEN THE SUN IS STREAMING INTO THE CAR, PARTICULARLY FROM THE FRONT OR A SIDE WINDOW, THAT THE REFLECTION OFF OF THE BLACK PLASTIC ONTO THE INSIDE OF THE WINDSHIELD IS SO BAD THAT WE OFTEN CANNOT SEE OUT OF THE WINDSHIELD WITHOUT PUTTING A PIECE OF PAPER OR SOME OTHER SUBSTANCE DOWN TO CUT THE GLARE DOWN. THIS IS AN EXTREMELY DANGEROUS SITUATION, AND IT'S ONLY A MATTER OF TIME BEFORE SOMETHING SERIOUS HAPPENS AS A RESULT OF BEING UNABLE TO SEE CLEARLY.

VEHICLE WAS IN A HEAD ON COLLISION AT 46 MPH. UPON IMPACT, PASSENGER SIDE AIR BAG DEPLOYED, BUT DRIVER SIDE AIR BAG DIDN'T DEPLOY. STEERING WHEEL CAME COMPLETELY OFF, AND THE DRIVER DIED AS A RESULT. *AK CONSUMER'S WIFE WAS HIT HEAD ON WHILE DRIVING AT 50 MPH BY A TOOTA TACOMA. THE DRIVIER OF THE TACOMA WAS ON DRUGS WHEN CROSSED OVER INTO PATH OF THE RIO. THE DRIVER OF THE RIO EXPERIENCED A SEVERED BRAIN STEM, PUNCTURED LUNG FROM THE STEERING COLUMN AND A SEVERED ARM. THE DRIVER OF THE RIO WAS WEARING THE SEAT BELT. DURING THE CRASH THE RIO'S DRIVER'S SEAT BROKE FROM THE MOUNTINGS AND THE STEERING WHEEL BROKE OFF. AFTER THE CRASH THE RIO'S DRIVER WAS FOUND UNDER THE INSTRUMENT PANEL. THE TACOMA WAS BENT IN HALF AND THE TRUCKS BED BROKE OFF FROM THE FRAME. RIO HAS BEEN NOTIFED OF THE CRASH. IT WAS ASSUMED THE DRIVER OF THE TACOMA WAS TRAVALING ATLEAST 45-50 MPH AT THE TIME OF THE CRASH. CW

WHILE DRIVING VEHICLE STOPS ABRUPTLY AND WILL NOT ACCELERATE GOING UP HILLS. DEALER CONTACTED. TS CONSUMER PROVIDED MORE INFORMATION WHICH IS IN SPANISH. *TT

VEHICLE STALLED AT HIGHWAY SPEED. DEALER WAS CONTACTED, AND DEALER REPLACED A MODULE. THREE MONTHS LATER, THE SAME PROBLEM OCCURRED. *AK VEHICLE STALLS AT ANY SPEED. AIR CONDITIONER EXHIBIT BAD SMELL. *LA

SINCE PURCHASING THIS CAR IN NOV. 2001, IT HAS GIVEN ME NUMEROUS PROBLEMS. I HAVE HAD THE STRUTS REPLACED UNDER WARRANTY FOR LEAKING OIL, IT HAS STALLED MORE TIMES THAN I CAN COUNT, CAUSING CONCERNS ABOUT MY AND MY FAMILY'S SAFETY,AND RECENTLY THE ENGINE CUT OFF WITHOUT WARNING WHILE EXITING THE FREEWAY. THE ENGINE IS NOW FROZEN AND SINCE I'VE REACHED MY 60,000 MILE MARK, THE DEALERSHIP IS HESITANT TO FIX IT UNDER WARRANTY. THIS IS TRULY AN EXPENSIVE LEMON.*AK