1999 Kia Sportage Engine Problems

TL* THE CONTACT OWNS A 1999 KIA SPORTAGE. THE CONTACT STATED THAT THE VEHICLE EMITTED STRONG FUEL FUMES ON THE EXTERIOR AND THE INTERIOR. THE DEALER WAS NOTIFIED OF THE FAILURE AND STATED THAT THE VEHICLE WAS NOT INCLUDED IN A MANUFACTURER'S RECALL AND THE VEHICLE WAS NOT DIAGNOSED. THE CONTACT ALSO STATED THAT THE TIMING BELT FAILED THREE TIMES AND WAS REPLACED BY A MECHANIC. THE DRIVE TRAIN FAILED ONCE AND WAS REPLACED BY A MECHANIC. THE CRANK SHAFT WAS ALSO REPLACED ONCE. THE CONTACT ALSO WAS EXPERIENCING A TRANSMISSION FAILURE IN WHICH THE GEARS SLIPPED RANDOMLY AND WERE SLOW TO CHANGE OVER. THE VEHICLE WAS TAKEN TO THE DEALER MORE THAN THREE TIMES AND THEY WERE NOT ABLE TO REMEDY THE FAILURE. THE CONTACT REPLACED THE SEALS DUE TO THE TRANSMISSION FAILURE. THE FUEL LEAK CONTINUED AND WAS NOT REPAIRED. THE VIN WAS NOT AVAILABLE. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND PROVIDED NO REMEDY. THE FAILURE MILEAGE WAS 333,000.

NHTSA ID

10778236

Incident

Oct 6, 2014

Mileage

333,000 mi

TL* THE CONTACT OWNS A 1999 KIA SPORTAGE. THE CONTACT STATED THAT WHILE DRIVING 15 MPH, THE ENGINE STALLED WITHOUT WARNING. THE VEHICLE WAS TAKEN TO THE DEALER BUT THEY DID NOT INSPECT THE VEHICLE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 168,390. UPDATED 02/03/2014 *LJ UPDATED 02/24/14*LJ

NHTSA ID

10559564

Incident

Jan 2, 2014

Mileage

168,390 mi

KEYWAY ON CRANKSHAFT WHERE TIMING GEAR ATTACHES WEARS OUT PREMATURELY AND CAN RESULT IN HAVING TO REPLACE ENGINE! I HAVE REPLACE THROTTLE POSITION SENSOR, FUEL FILTER, AND KNOCK SENSOR ALSO THE MASS AIRFLOW SENSOR AND TIMING BELT WERE REPLACED AS THERE APPEARED TO BE A TIMING ISSUE COULD NOT FIND PROBLEM SO TOOK TO KIA DEALER TO FIND THE KEYWAY ON CRANKSHAFT TO BE SO WORN YOU COULD ALMOST TURN GEAR ALL THE WAY AROUND! IN ALL THE YEARS I HAVE BEEN WORKING ON VEHICLES THIS IS THE FIRST TIME I HAVE EVER SEEN THIS AND IS VERY OBVIOUSLY A MANUFACTURER DEFECT! *TR

NHTSA ID

10316796

Incident

Feb 25, 2010

Mileage

134,197 mi

TL*THE CONTACT OWNS A 1999 KIA SPORTAGE. THE CONTACT STATED THAT THE VEHICLE IS GRADUALLY LEAKING BRAKE FLUID AND HE IS CONSTANTLY HAVING TO ADD MORE FLUID. ALSO, THE VEHICLE STALLS INTERMITTENTLY WHILE DRIVING BETWEEN 30-50 MPH AND MERGING INTO TRAFFIC. HIS VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN ID NUMBERS 98V222000 (SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:HOSES, LINES/PIPING AND FITTINGS) AND 99V325000 (ELECTRICAL SYSTEM:WIRING); HOWEVER, THE DEALER WILL REPAIR THE VEHICLE ACCORDING TO NHTSA CAMPAIGN ID NUMBER 04V305000 (SEAT BELTS:FRONT:BUCKLE ASSEMBLY). THE CURRENT MILEAGE WAS 107,812 AND THE FAILURE MILEAGE WAS UNAVAILABLE.

NHTSA ID

10241352

Incident

Aug 15, 2008

TL*THE CONTACT OWNS A 1999 KIA SPORTAGE. THE SEAT BELT RETRACTOR ON THE DRIVERS SIDE HAS FAILED. THE AIR CONDITIONER IS ALSO LEAKING INTO THE PASSENGER SIDE OF THE VEHICLE. THE VEHICLE HAS NOT YET BEEN DIAGNOSED. THE PURCHASE DATE WAS UNKNOWN. THE CURRENT MILEAGE IS 80,000 AND FAILURE MILEAGE WAS 76,000.

NHTSA ID

10191567

Incident

Mar 5, 2007

Mileage

76,000 mi

THIS KIA WAS PURCHASED NEW AND IS A ONE OWNER CAR. IT HAS HAD 2 MASTER CYLINDERS, AND 4 SETS OF BRAKE PADS. THE CAR CURRENTLY HAS 50,000 MILES ON IT. THE CAR SLIDES TO THE RIGHT ON WET ROADS AND DOES NOT STOP UNTIL IT HITS SOMETHING OR SLOWS TO A STOP. I HAVE SLID 2 TIMES, REAR ENDED SOMEONE THE 3RD, AND MY SON HIT A LIGHT POLE. THE OTHER TIMES THE BRAKES MAY OR MAY NOT WORK. THE PROBLEM IS WORSE DURING RAINY WEATHER. THE BRAKES GO TO THE FLOOR AND THE CAR DOES NOT STOP. AT TIMES THE BRAKES VIBRATE. THIS CAR HAS HAD A NEW CLOTH TOP, NEW AIR CONDITIONING 2X, 5 CATALYTIC CONVERTERS, NEW CARPET FROM THE AIR LEAKING AND MOLDING, NEW SEAT COVERS AS THEY RIPPED, NEW BRAKES, ROTORS, PADS SEVERAL ITEMS I HAVE LOST COUNT, THE CHECK ENGINE LIGHT COMES ON, THE CAR HAS BEEN RE-WIRED, AT TIMES THE CAR WON'T ACCELERATE IF THE AIR CONDITIONER IS ON. LAST NIGHT THE HIGHWAY PATROL OFFICE WANTED TO KNOW WHY I WOULD ENDANGER MY SON'S LIFE IN A CAR THAT WON'T STOP OR SLIDES. THAT IS A GOOD QUESTION. WHY ARE ANY OF THESE MODELS STILL ON THE HIGHWAY WHEN THERE ARE SO MANY THINGS WRONG WITH THEM. IN LOOKING AT THE COMPLAINTS THERE WERE MANY THAT DEALT WITH THE BRAKES. AT THIS POINT IS THERE ANY RECOURSE WITH THE CAR? I DON'T FEEL THAT I CAN SELL IT OUTRIGHT HONESTLY AND PUT SOMEONES LIFE IN DANGER. THE HIGHWAY PATROL OFFICER MADE ME FEEL LIKE A NEGLECTFUL PARENT BY EVEN LETTING MY SON DRIVE THE CAR. WE EVEN PARKED IT FOR 6 MONTHS TRYING TO DECIDE WHAT TO DO WITH THE CAR. MY SON'S CAR WAS IN THE REPAIR SHOP, SO HE TOOK THE KIA. I FEEL THAT THE CAR IS A DEATH TRAP. *JB

NHTSA ID

10166674

Incident

Aug 24, 2006

DT*: THE CONTACT STATED THE VEHICLE STALLS AT VARIOUS SPEEDS AND INTERMITTENTLY WILL NOT START. AFTER SITTING FOR A WHILE THE VEHICLE WILL RESTART. THE DEALERSHIP HAS BEEN INFORMED. THERE ARE NO LIGHTS ILLUMINATED ON THE DASH PRIOR TO THE VEHICLE STALLING. THE TEMPERATURE GAUGE WAS ACTING ERRATIC. THE POWER STEERING BELT WAS REPLACED. UPDATED 09/13/06. *JB

NHTSA ID

10166087

Incident

Aug 21, 2006

Mileage

65,000 mi

I HAVE A 1999 KIA SPORTAGE WITH LESS THAN 35,000 MILES ON IT AS OF JULY 5, 2006. IN NOVEMBER OF 2005 I STARTED NOTICING A REALLY STRONG FUEL SMELL. SHORTLY THEREAFTER I NOTICED FLUID LEAKING FROM THE REAR OF MY VEHICLE. I TOOK IT IN AROUND THANKSGIVING TO FIND OUT THAT THE GAS TANK HAD TO BE REPLACED. I HAD TO PAY ALMOST $1,000 FOR THIS REPAIR. ALSO, IN MAY OF 2006 POWER STEERING FLUID LEAKED ALL OVER MY GARAGE WHILE THE CAR WAS IN SUMMER STORAGE. UPON FURTHER INVESTIGATION IT IS DUE TO THE POWER STEERING PRESSURE HOSE DAMPING PIPE RUSTING OUT. THIS CAR HAS ALSO ALREADY HAVE TO GET NEW FRONT BRAKE ROTORS (RUSTED/WARPED) AS WELL AS A NEW EXHAUST PIPE SINCE THE PREVIOUSLY ONE RUSTED OFF THE MUFFLER. WITHIN THE FIRST COUPLE YEARS ONE OF THE BEARINGS WENT BAD AND THEY ENDED UP REPLACING THE WHOLE FRONT AXLE UNIT. THIS CAR HAS HAD MANY PROBLEMS AND WITH LESS THAN 35,000 MILES ON IT BASICALLY MAKES ME SICK TO MY STOMACH. I AM REPORTING THIS TO YOU AFTER READING ON WWW.KIA.COM TECHNICAL/OWNERS SECTION ABOUT A "SERVICE CAMPAIGN" FOR THE LEAKING FUEL TANKS IN MAY 2006. NOBODY HAS NOTIFIED ME AND I JUST HAPPENED TO RUN INTO MYSELF AS I WAS RESEARCHING INFORMATION RELATED TO THE POWER STEERING SYSTEM SINCE THAT STARTED LEAKING IN MAY 2006. *JB

NHTSA ID

10161481

Incident

Nov 21, 2005

Mileage

28,000 mi

1999 KIA SPORTAGE HAS HAD TIMING BELT REPLACED THREE TIMES SINCE I BOUGHT CAR NEW IN 1999. WHILE TRAVELING ON NJ TURNPIKE, WHAT WE BELIEVED WAS THE TIMING BELT YET AGAIN WAS THE CRANK SHAFT AT THE HARMONIC BALANCE (WHICH HOLDS THE TIMING BELT IN PLACE) COMPLETELY SNAPPED INTO TWO PIECES INSIDE THE ENGINE. I SPOKE TO SEVERAL DIFFERENT KIA SERVICE DEPARTMENTS WHO ADVISED ME THAT THIS WAS NOT A NORMAL THING AND WAS IN NO WAY DUE TO SOMETHING WE COULD HAVE DONE. I WAS TOLD BY MY KIA DEALER THAT THE MANUFACTURERS WARRANTY HAD EXPIRED LAST YEAR AND THAT I WAS RESPONSIBLE FOR THE DEFECT IN THE KIA. THE FIRST THREE TIMES THAT THE TIMING BELT WAS REPLACED THE WARRANTY COVERED. NOW I AM TOLD I MUST PAY FOR A NEW ENGINE. BE ADVISED THAT EVERY TIME THIS HAPPENED THE CAR WAS GOING 55 M.P.H. OR OVER. IT IS MY BELIEF THAT WAS CAUSED BY A MANUFACTURING DEFECT AND THAT KIA SHOULD BE HELD ACCOUNTABLE. THERE HAS NEVER BEEN ANY COLLISION OR ANY OTHER EVENT THAT HAS TAKEN PLACE FOR THIS TO OCCUR. WE ARE JUST LUCKY THAT WE HAVE NEVER BEEN HURT OR KILLED IN THIS CAR!*JB

NHTSA ID

10134824

Incident

Aug 24, 2005

Mileage

62,500 mi

I AM THE OWNER OF A 99 KIA SPORTAGE WITH ONLY 60043 MILES. I BOUGHT THE VEHICLE BRAND NEW. THE VEHICLE STALLED AT 40 MPH, LUCKILY, IT DID NOT STALLED AT 75 MPH WHILE I WAS TAKING ONE OF MY DAILY TRIPS TO OK CITY BECAUSE IT WOULD HAVE BEEN DISASTROUS. THE CRANKSHAFT SHEARED OFF FLUSH WITH THE ENGINE HOUSING LEAVING THE MAIN AND TIMING BELT PULLEYS DISCONNECTED FROM THE ENGINE. AS CONSEQUENT, THE ENGINE STALLED LEAVING THE VEHICLE WITHOUT POWER IN THE MIDDLE OF TRAFFIC. NO ONE WAS HURT OR KILLED BECAUSE OF THIS. CONTACTED THE KIA DEALER AND THEY WILL NOT TAKE ANY RESPOSIBILITY FOR THIS DEFECTIVE PART. THIS IS THE KIND OF SAFE PRODUCT THAT MAKES KIA CUSTOMERS NOT TO BE REPEAT CUSTOMERS.

NHTSA ID

10111887

Incident

Feb 12, 2005

Mileage

60,043 mi

CONSUMER HAD THE SAME PROBLEMS AS MENTIONED IN NHTSA RECALL 99V325000. THE WIRES CONNECTED TO THE C123 AND C124 CONNECTORS CAN BE PUT UNDER TENSION BY MOVEMENT OF THE ENGINE, THUS PULLING THE WIRES AND CONNECTORS, AND LOOSENING THEM . THIS RESULTS IN A LOSS OF CIRCUIT CONTINUITY. DEALERSHIP INDICATED TO THE CONSUMER THIS VEHICLE WAS NOT COVERED UNDER THE RECALL DUE TO VIN. *AK

NHTSA ID

10087403

Incident

Aug 9, 2004

WHILE DRIVING AT 30 MPH VEHICLE STALLED WITHOUT WARNING. VEHICLE WAS TOWED TO THE DEALERSHIP, AND TECHNICIAN DETERMINED THAT WIRING AND CONNECTORS FAILED. *AK

NHTSA ID

10061584

Incident

Mar 8, 2004

\T\T\T\T 11/16/02\TGENERAL DIAGNOSTICS AFTER PURCHASE\T NO STORED CODES \T $75.50 \T\TTIMING CHECK - DISCONNECT BATTERY\T\T 11/29/02\TENGINE BUCKS ON ACCELERATION\T NO STORED CODES\T $87.26 \T BROKEN CENTER CONSOLE REPLACED\T\T 01/02/03\TENGINE STALLED - DIED AFTER ONE WEEK'S TIME, NO DIAGNOSIS\T $70.88 * TOWED *\T\T 01/05/03\TEMAIL SENT TO: KIA CONSUMER AFFAIRS ADVISED OF POOR RUNNING CONDITION AND \T INFERIOR KIA SERVICE RECEIVED RESPONSE AS TO FOUR \T \T\T MANUFACTURER RECALLS NOT PERFORMED TO\T \T\T DATE ON VEHICLE\T 01/13/03\T*SC014 RECALL - ENGINE WIRING HARNESS\T RECALL PERFORMED\T $102.44 *SC022 RECALL - MANIFOLD CATALYTIC CONVERTER\T RECALL PERFORMED\T \T\T*FRONT WHEEL BEARING SEALS LEAKING/LOOSE REPLACED FRONT HUB ASSEMBLIES\T \T\T*COOLANT LEAKING AT BYPASS HOSE\T R&R HOSE AND REPLACED SEALS\T \T\T*DETERMINED FRONT BUMPER REPLACED \T 01/17/03\T*EXHAUST MANIFOLD STUD BROKEN\T REMOVED MANIFOLD/DRILLED OUT BROKEN STUD\T AND REPLACED $77.77 \T\T*STUCK THERMOSTAT\T REPLACED THERMOSTAT\T 05/22/03\T52,500 MILE SERVICE\T\T$123.27 \T\T*WIPER BLADE CHECK - NOT OPERATING PROPERLY\T ADJUSTED WIPER ARMS/REPLACED BLADES\T \T\T\T OPERATING WORSE!\T \T\T*FRONT END SHAKING @ HIGH SPEEDS\T ROTATED TIRES - NO CHANGE!\T \T\T*REPLACE FRONT TURN SIGNAL ASSEMBLY\T COMPLETED SATISFACTORILY\T 05/23/03\TCAR DIED WHILE DRIVING - STALLED OUT AT IDLE\T WIRING HARNESS TO TCM SHORTING OUT\T $260.13 \T *TOWED* REMOVED TCM/CLEANED/REPAIRED\T TOTAL OUT OF POCKET REPAIRS (NOT INCLUDING WARRANTY ITEMS) $797.25

NHTSA ID

10069808

Incident

Dec 15, 2002

Mileage

50,280 mi

I AM THE OWNER OF A 99 KIA SPORTAGE WITH ONLY 19000 MILES ON IT BOUGHT NEW WITH ONLY 10 MILES ON IT BACK IN 99. THIS SUV HAS BEEN NOTHING BUT PROBLEMS FROM DAY ONE, WITH EVERYTHING FROM THE AC TO THE 4 WHEEL DRIVE NEEDING REPAIRED TWICE IN ONE DAY, TO THE MOST SERIOUS PROBLEM HAPPENING ON 8-19-02 WHEN MY RIGHT REAR ANTI SWAY BAR BRACKET BREAKS AWAY FROM WHERE IT WAS WELDED ON THE FRAME IN THE FACTORY ( THE ORG. WELDS JUST BROKE ) AS MY DAUGHTER AND I ARE DRIVING THIS SUV HOME ONE EVENING CAUSING THIS SUV TO BE ALL OVER THE ROAD AND UNCONTROLLABLE. LUCKILY NO ONE WAS HURT OR KILLED BECAUSE OF THIS. KIA ACCEPTS NO RESPONSIBILTY FOR THIS. BUT IT WAS THERE WELDS DONE IN THERE FACTORY WHEN THEY MADE THIS SUV. THIS IS THE KIND OF SAFE PRODUCTS THAT KIA MAKES AND THE PUBLIC NEEDS TO BE AWARE OF THIS FACT AND HOW MUCH THIS CO. VALUES A HUMAN LIFE.

NHTSA ID

10069532

Incident

Aug 15, 2002

CATALYTIC CONVERTER WAS RECALLED AND REPLACED BY THE DEALER IN 2001, RATTLING AND NOT WORKING CORRECTLY SINCE (ENGINE LIGHT ON - DIAGNOSTIC SAYS CONVERTER), RETURN TO DEALER APPROXIMATELY. 2 MONTHS LATER, THEY VERIFIED EVERYTHING WAS OK, WOULD NOT PASS SMOG THE NEXT YEAR, RETURNED TO DEALER THEY SAY IT IS THE CONVERTER AGAIN, WILL NOT PAY TO REPLACE AGAIN. CAR RUNS WITH NO POWER AND IS A DANGER ON THE ROAD. *LA

NHTSA ID

10043435

Incident

Nov 1, 2001

Mileage

40,000 mi

WHILE DRIVING AT ANY SPEED VEHICLE WILL INTERMITTENTLY STALL. AFTER A FEW MINUTES SITTING VEHICLE CAN BE RESTARTED. MANUFACTURER AND DEALER HAVE BEEN NOTIFIED OF THE PROBLEM.*AK

NHTSA ID

10042731

Incident

Sep 16, 2003

Mileage

56,000 mi

SMELL OF EXHAUST COMING FROM UNDER HOOD AGAIN. HAS BEEN IN SHOP NUMBER OF TIMES, CHECK ENGINE CAME ON 50 MILES AFTER LEAVING DEALERSHIP FOR REPAIRS.RUNS VERY BAD, SAME AS BEFORE REPAIRS. HAS BEEN OUT OF WARRNETY FOR WHILE, PAY FOR REPAIRS OUT OF POCKET. *AK

NHTSA ID

10036991

Incident

Aug 24, 2003

1999 KIA SPORTAGE 4DR ECM TROUBLE CODE 171 - LEFT BANK LEAN. DEALERSHIP HAS HAD VEHICLE FOR OVER A WEEK AND IS NOT ABLE TO FIX. *AK

NHTSA ID

10023829

Incident

Jun 17, 2003

DURING VEHICLE OPERATION EXHAUST FUMES ARE ENTERING THE PASSENGER CABIN.*AK

NHTSA ID

10024812

Mileage

43,000 mi

99 KIA SPORTAGE SURGES WHEN STARTING AND IDLES SO ROUGH WHEN STOPPED THAT YOU THINK THE CAR WILL DIE, HAS DIED A FEW TIMES. DEALER HAS NOT BEEN ABLE TO DETERMINE THE CAUSE TO REPAIR. ALL RECALL WORK WAS DONE, INCLUDING THE WIRING HARNESS FIX SC014, BUT THERE WAS NO SYMPTOM OF PROBLEM THEN. EXTENDED WARRANTY HAS EXPIRED, AND CONTINUALLY FINDING PROBLEM WITH CAR. ALSO TAIL PIPE RECENTLY BROKE OFF HAD TO BE REPLACED. I NOW HAVE A SPREADSHEET OF THE PROBLEMS AND REPAIRS. WOULD LIKE TO FIX THIS PROBLEM IF I KNEW WHAT IT WAS. HAD MASS AIR FLOW SENSOR, THROTTLE POSITION SENSOR, NUMEROUS OTHER PARTS REPLACED AS WELL AS A TUNE UP. ALSO THE EXHAUST SMELLS BAD. ENGINE DOESN'T HAVE MUCH PICK UP ON SMALL HILLS EITHER. *NLM

NHTSA ID

10023549

Incident

Jun 20, 2003

Mileage

36,000 mi

ENGINE BELT AND PULLEYS FAIL EVERY 3 MONTHS AND HAVE TO BE REPLACED. CAUSE UNKNOWN.*AK

NHTSA ID

10022684

Mileage

32,609 mi

EXHAUST IS SUCKED INTO THE PASSENGER COMPARTMENT WHEN THE REAR VINYL WINDOW RELEASES FROM THE TRACK THAT IS SUPPOSE TO KEEP IT SECURED AND CLOSED. THE EXHAUST CAUSES ILLNESS AND HEADACHES. THE DESIGN OF THE WINDOW AND EXHAUST PIPE DO NOT ALLOW FOR AN EXHAUST FREE PASSENGER COMPARTMENT. *JB

NHTSA ID

10013571

Incident

Aug 1, 1999

Mileage

10,000 mi

WE BOUGHT A 1999 KIA IN NOVEMBER OF 1999. SINCE THEN WE HAVE HAD NOTHING BUT TROUBLE WITH IT. EVERY SIX MONTHS THERE IS SOMETHING GONE WRONG WITH IT.

NHTSA ID

10000887

Incident

Nov 21, 1999

CONSUMER STATED THAT THE CATALYTIC CONVERTER FAILED CAUSING A DISTRACTION TO THE CONSUMER. DEALER NOTIFIED. TS

NHTSA ID

10001124

Incident

Nov 26, 2002

CONSUMER STATES THAT AFTER RECALL WAS DONE, DEFECT STATED IN RECALL HAPPENED SEVERAL TIMES. DEALERSHIP REFUSE TO FIX, CAUSE THEY CANNOT DUPLICATE THE PROBLEM. TS

NHTSA ID

8021782